Kia Motors America (Kia) is recalling certain 2020-2021 Soul, and 2021 Seltos vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which may result in engine damage.
Reason for Dispute & Desired Resolution: I am filing an executive escalation regarding a catastrophic engine failure on my 2020 Kia Soul, which is actively included in the Piston Oil Ring Safety Recall (Campaign SC209). The engine suffered a total structural failure where a rod broke and punctured a hole directly through the engine oil pan. The vehicle is completely undrivable and presents an environmental hazard due to active fluid leakage. Standard Kia Customer Care and Roadside Support lines have officially denied emergency towing assistance and rental car coverage, stating they cannot help. The closest authorized dealership, Kia of Columbia, has an appointment backlog delaying an official inspection until October 29th. I cannot afford the out-of-pocket costs for an hour-long flatbed tow from my home or weeks of upfront rental car fees. As a consumer, I am being penalized and left stranded by a severe manufacturing defect that Kia has legally acknowledged. I demand that Kia’s Executive Resolution Team immediately issue a direct digital dispatch code to authorize a free flatbed tow to the dealership, and establish a direct-billed loaner or rental vehicle (via Enterprise) so that my livelihood is not disrupted while waiting for the scheduled recall repair and engine replacement.
No injuries · No fire · No crash
The car stalled at red light. After a few minutes cranked back up.
No injuries · No fire · No crash
On [XXX], my 2020 Kia Soul (2.0L Nu MPI, VIN [XXX], approximately 102,420 miles) suffered total engine failure: complete loss of motive power, stalled and would not restart. This is the exact defect covered by federal recall 21V259000 / Kia SC209 (piston oil rings causing engine damage and stalling). The SC209 recall remedy had already been performed on this vehicle at Kia of Daphne (Daphne, AL) in June 2026. The recall did not prevent the failure. Symptom history matches the defect: the vehicle has burned oil excessively its entire life (oil changed every 3,000 miles; oil like sludge by approximately 2,000 miles) - the textbook piston-ring symptom. Sputtering began June 2026; a spark-plug replacement bought two to three months before total failure. Diagnostic codes at failure: P0304 (cylinder 4 misfire), P219F (cylinder imbalance), P0014 and P0017 (camshaft/crankshaft timing correlation), P1327 (knock sensor) - internal engine and timing damage consistent with the recalled defect. On [XXX], Kia of Daphne inspected the vehicle ([XXX]). The technician found low compression and wrote the failure 'does not have to do with recall campaign sc209A' and is 'not covered under Kia warranty or recall,' quoting $5,855.28 for an engine long block. I dispute this: low compression plus lifelong excessive oil consumption is the classic signature of worn piston oil rings - the exact SC209 defect. The one-sentence dismissal does not address the documented symptom history. Kia corporate cases [XXX] (opened 09/30/2026) and [XXX]; rebuttal submitted 10/07/2026 requesting field-engineer review; no response as of 10/15/2026, cases now closed. Safety: total loss of motive power AFTER the remedy was performed. This post-remedy SC209 failure belongs in NHTSA's investigation of Kia recall remedy effectiveness. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
On XXX my 2020 Kia Soul while on the freeway, would not accelerate and silently stalled. The check engine, oil, and battery light all came on. Putting it into Park and then Drive again, the vehicle began shifting backwards. The vehicle could not be safely driven and was towed to Kearny Mesa Kia in [XXX]. The dealer diagnosed code P0017 (crankshaft position and camshaft position correlation). The technician found the exhaust camshaft out of sync because the pin on the CVVD gear had broken, which allowed the gear to spin on the camshaft. The recommended repair is replacement of the exhaust camshaft, CVVD gear and bolt, timing chain tensioner, and valve cover gasket, quoted at $3,285.34. A borescope inspection found no valve damage. The service advisor told me this is a common problem on these vehicles. An internal engine part failing like this at about 99,000 miles is a premature failure, not normal wear. A sudden loss of camshaft timing can cause stalling or a loss of power while driving, which is a safety risk. I am the third owner and bought the car used through Carvana at about 55,000 miles, so the powertrain warranty does not cover this repair. Kia America denied my request for goodwill assistance. I ask NHTSA to look into CVVD gear and camshaft timing failures on the 2020 Kia Soul 2.0L engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
2nd failed motor due to code P1327, was replaced last year for same issue, less than a year later and same issue again.
No injuries · No fire · No crash