Kia Soul Complaints

5,626 consumer complaints on file.

#11727757March 29, 2026
ENGINE
NHTSA SAFETY COMPLAINT: RECALL SC336 (CAMPAIGN 21V-301) NON-COMPLIANCE VIN: [XXX] I. PATTERN OF RECALL EVASION Vehicle (2021 Kia Soul) was towed to Classic Kia [XXX] ) on 3/13 with documented engine stalling, knocking, and codes P0014/P0017 (VVT/Timing failure). The dealership withheld this data from Kia Techline for 13 days (3/13–3/26), delaying the safety remedy until state authorities intervened. II. MECHANICAL IMPOSSIBILITY & REMEDY VIOLATION On Saturday 3/28, the dealer claimed a full engine swap was "installed and tested" in only 6.5 hours (7:30 AM–2:15 PM). Per the SC336 mandate, a compliant Long Block assembly (Part # ending in QQK) requires extensive fluid flushes, software reflashing, and safety recalibrations that cannot be performed correctly in this window. I suspect a "Short Block" shortcut was taken, reusing contaminated components in violation of the federal safety remedy. III. FRAUD BY OMISSION & UNIFIED SAFETY HAZARD The dealership is demanding a $99 "diagnostic fee" for an exhaust back-pressure test. Under SC336, testing for "consequential damage" (clogged catalytic converter) caused by the recall defect must be covered by the manufacturer. By omitting the stalling/timing symptoms from the initial Techline report, the dealer bypassed the mandatory exhaust safety testing. Reusing oil-contaminated VVT solenoids, camshafts, and valves from the failed engine poses an immediate fire and safety hazard. IV. DEMAND FOR INVESTIGATION I request NHTSA oversight to ensure Classic Kia provides: 1. Proof of Long Block (21101-QQK) installation vs. unauthorized Short Block (21102). 2. Time-stamped DEVT and GDS Full System Scan logs from 3/28. 3. Verification that all contaminated components were replaced, as a partial remedy leaves the vehicle in a hazardous state. Reusing oil-soaked VVT/cams & skipping exhaust tests creates a fire risk. An incomplete remedy violates SC336, leaving the car a high-risk liability for fire & stalling. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727424March 27, 2026
ENGINE, ENGINE AND ENGINE COOLING
The contact owns a 2015 Kia Soul. The contact stated that upon purchasing the vehicle and driving to the residence, the check engine warning light illuminated. The contact used a code reader and retrieved DTC: P0420 (Catalytic Converter). The contact called the dealer and was informed that the vehicle was included in NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling); and four other recalls. The vehicle remained with the dealer for approximately 4 days before the contact was informed that the VIN was not under recall. The contact was provided with an estimate for the repairs. The manufacturer was notified of the failure but offered no assistance; however, the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 145,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727449March 27, 2026
FIRERELATED, ENGINE, ENGINE AND ENGINE COOLING
The contact owned a 2016 Kia Soul. The contact received notification of NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and the engine made an abnormal sound. The contact turned off the vehicle to let it cool down. The vehicle was restarted and taken to an independent mechanic, who determined that the catalytic converter and exhaust pipe had caught fire and melted. The mechanic performed an oil change and drilled a hole in the catalytic converter, and advised the contact to take the vehicle to the dealer for the recall repair. The vehicle was taken to the dealer, who determined that the spark plugs were saturated in engine oil. The dealer flushed the radiator and performed a second oil change; however, the dealer refused to perform the recall repair. The vehicle was taken back to the independent mechanic, who replaced the spark plugs but refused to repair the engine until the recall was repaired. The contact stated that later while coasting downhill in neutral (N) after adding a quart of engine oil due to no oil in the engine, he heard an implosion coming from behind the driver's side front seat. No warning light was illuminated. The contact unbuckled his seat belt and jumped out of the vehicle, fracturing his ribs. The contact suffered burns to his right hand, legs, left side of face, nose, and eyebrows. The contact stated that the vehicle rolled downhill, and there were flames underneath the vehicle on the passenger's side. The contact ran after the vehicle. The vehicle drove into the bushes and came to a stop. Two bystanders alerted the contact that there were flames inside the vehicle. The police were called and arrived, attempting to extinguish the fire with an extinguisher until it was empty, and the fire had restarted. The firefighters arrived and extinguished the fire. A police report was filed and included with the fire department. The contact was transported to the hospital via ambulance an
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#11727579March 27, 2026
ENGINE
When I drive in alloys mode the system jerky and engine makes noise or hangs and I have to turn it off and on to start it back up to drive. When I drive without alloys on it thugs sporadically as if it is going to drive backward. Per the dealer the engine oil is slugs even thought it had oil change. But this vehicle is scary, I need it but scare of driving it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727196March 26, 2026
ENGINE
The contact owns a 2014 Kia Soul. The contact received notification of NHTSA Campaign Number: 20V750000 (Engine). The contact stated that while the vehicle was parked, the contact observed a leak underneath the engine compartment. The vehicle was taken to a dealer, where it was determined that the master seal was leaking and needed to be replaced. The vehicle was not repaired. The repairs were denied due to the failure not being covered under the recall. The vehicle was then taken to an independent mechanic, where it was diagnosed and it was determined that the master seal needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was approximately 90,140.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727306March 26, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2022 Kia Soul. The contact stated that the vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). After retrieving the vehicle, there was an audible tinging sound coming from the vehicle. No warning lights were illuminated. The vehicle was taken back to the dealer, and the contact was informed that the tires needed to be replaced. The vehicle was taken back to the local dealer for an extensive overhaul, and it was determined that the engine needed to be replaced. The oil level was approximately ¾ of a quart low. The manufacturer was contacted, but no assistance was provided. The manufacturer suggested driving the vehicle for 1,000 miles and having an oil consumption test performed. The failure mileage was approximately 69,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726716March 24, 2026
UNKNOWN OR OTHER
Car only goes 20 mph Engine knock Unsafe to drive I have multiple service repair documentation regarding engine knocking, oil consumption, unable to go above 20 mph. Car frequently goes into limp mode
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726782March 24, 2026
ENGINE
The engine burnt through all the oil in it, many miles before an oil change was needed for it.I have taken it to the dealership and the dealership submitted an extended warranty claim for it and despite the fact that the issue is mechanical and covered by the extented owarranty, the claim is being denied.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726767March 24, 2026
AIR BAGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Hit a deer. Airbag did not deploy or emergency braking system didn't come on. Police took pictures of car. The car is at the repair shop now. Insurance company hasn't stated if it will be totaled. There were no other problems prior to incident.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11726351March 23, 2026
ENGINE
Excessive Oil Consumption/Burning Catalytic Converter Clogging Check Engine Light/Misfires My engine has all of these issues. It has been determined as known KIA issues not driver/owner related. My car has 94,000 miles but none of what's going on is any cause other than KIA issues/problems. I work a full time job and have missed work due to car not being able to be driven at random times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726474March 23, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2021 Kia Soul. The contact stated that while driving approximately 40 MPH, the vehicle started losing automotive power. The message that the engine was overheating warning was flashing on the instrument panel with an audible chime. The contact pulled over but was unable to restart the vehicle. The vehicle was towed to a local dealer and was diagnosed with engine failure. The contact stated that the VIN was included in NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling); and was advised by the dealer that the engine failure was not related to the recall, and the dealer refused to perform the recall repair. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726314March 23, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2021 Kia Soul. The contact stated that while driving at an undisclosed speed, there was an abnormally loud sound coming from the vehicle with the check engine warning light illuminated. The vehicle idled abnormally rough, and the engine was pulsing. The oil level was checked and was noticeably low. The contact added oil to the engine. The vehicle was taken to Precision Auto Care for an oil change. The contact was informed that the oil level was low. The contact informed the technician that the oil had been recently topped off. The contact was informed of the excessive oil consumption. The contact was provided with information on NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced or repaired before the recall repair could be performed. The vehicle was not yet repaired. The manufacturer was made aware of the failure, and a case was filed. In addition, the contact was informed that the vehicle had to be repaired before the recall repair was performed. The failure mileage was approximately 134,431.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726069March 21, 2026
ENGINE
Driving on busy highway with one passenger. Vehicle began losing power and acceleration, but no warning lights came on. Kept driving for 20 miles and oil warning light came on, but temp vuage registered fine. I parked, checked fluid amounts, and oil was extremely low (even though it had been checked the week prior and was full). Put 2 quarts in, started vehicle and warning lights went off. Proceeded back on to highway, drove 5 miles and engine lost acceleration and started knocking loudly, and all the warning gauges lit up. I pulled into parking lot, turned off the vehicle. Checked oil level and it was fine. Got towed home. Fairly certain it's the rod bearing. Engine has about 103,000 miles on it and has been well maintained. I see so many of this exact complaint, but our year model seemed to be ignored with a recall. Have loved our Kia's until now. Watchable got Hyundai?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725829March 20, 2026
UNKNOWN OR OTHER, ENGINE
Anti theft ignition protector and another recall that makes the car have engine compartment fires. My car is at risk of being stolen as well as catching fire. Yes the problem has been confirmed from by Kia dealer. Yes the check engine light keeps coming on. It first appeared 02/10/2026. I purchased the car from b&g auto sales located at 3922 W Indian School Rd, Phoenix, AZ 85019 and they installed an aftermarket ignition cylinder so the recalls that needed to be done couldn’t be done.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725880March 20, 2026
ENGINE
On Feb. 11, 2026, while driving, the vehicle displayed a flashing check engine light and entered limp mode with major loss of power. A code reader recorded P1326. The vehicle was taken to an authorized Kia dealership for diagnosis and repair. After the dealership returned the vehicle to me, the same problem happened again within about 30 miles. The last repair order listed 142,352 miles, and the vehicle re-entered limp mode by 142,382 miles. I captured video of the flashing check engine light and a code-reader screenshot showing P1326 as the last trouble code. The malfunction appears related to the engine/engine management system and the vehicle is available for inspection. The safety risk is sudden reduced power and limp-mode operation while driving, which can make it difficult to maintain normal traffic speed or safely continue in traffic. This creates a safety concern if the event happens in traffic, during a turn, or while crossing an intersection. The problem has been reproduced more than once. A Kia dealership previously inspected the vehicle and returned it to me, but the problem recurred almost immediately after pickup. Kia corporate was notified in writing. The warning symptom was a flashing check engine light with limp mode. I am not continuing to drive the vehicle in this condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725778March 20, 2026
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2023 Kia Soul. The contact stated that while driving at an undisclosed speed, the instrument panel became inoperable. The instrument panel went blank while operating the vehicle. The vehicle was taken to a dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725761March 20, 2026
ENGINE
I am filing a safety complaint regarding my 2022 Kia Soul LX with approximately 97,500 miles. The vehicle has experienced sudden and excessive oil consumption despite regular maintenance and a recent oil change about 1,500 miles prior to failure. While driving in normal traffic conditions, the vehicle suddenly began running rough, lost power, and entered limp mode. Shortly after, the engine stalled while I was actively driving, creating a dangerous situation and safety concern for myself and other drivers. A mechanic inspection found diagnostic trouble codes related to camshaft timing issues and determined that the timing chain tensioner likely failed due to oil starvation. The mechanic also found internal engine damage including piston ring failure caused by abnormal oil consumption. I was advised the engine is not repairable and requires replacement. I understand there have been widespread reports, recalls, and class action litigation involving Kia engines experiencing similar oil consumption and catastrophic failure issues. However, I was informed my specific VIN is not currently included. Because this failure caused a sudden stall while driving and poses a significant safety risk, I am requesting that this complaint be investigated. I believe this defect could affect additional vehicles beyond those currently included in recalls or service campaigns. This vehicle was properly maintained and the failure occurred unexpectedly and prematurely for a modern engine. Before the stall that happened going at least 35 mph with my [XXX] daughter In the rear seat, there was no prior warning oil lights or engine lights. Causing severe safety concerns for myself and child. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725401March 18, 2026
ENGINE
The engine seems to be stalling, more than likely being caused by the piston rings being defective. With the piston rings being defective, this can cause oil to be lost, and then in turn causing damage to the vehicle. This can put others at risk as this will stall the vehicle, and in any form of traffic, can cause an accident. The problem has been confirmed by a dealer, but they claim it is another issue. The vehicle has been inspected by the manufacturer. The engine light turned on shortly before this happened.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724827March 17, 2026
ENGINE, POWER TRAIN
Safety defect P1326 code is a known indicator of rod bearing wear. When it triggered, the vehicle immediately went into Limp Mode, creating a significant safety hazard. The behavior aligns with the documented defect affecting NU GDI Engines and is not consistent with normal Engine wear. I have confirmed the KSDS software update was performed. I have taken the vehicle to Clay Cooley Kia of Plano and my service advisor has confirmed that the engine is defected per the NU GDI Engine Settlement and related federal safety actions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725093March 17, 2026
ENGINE
My car experienced engine stall, fire risk, and piston ring failure while returning from a family road trip. Myself, my son, [XXX] old, and [XXX] pup was left in a ditch on a very busy road as the car stalled while driving. My VIN is excluded, however car experienced exact symptoms of recall SC2091. Codes P0300 P0304 P0302 P219D P0303 with no pressure in cylinder 2 and 4.This happened in 0ct 2025 and dealership and corporate do not want to exend goodwill to replace the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Soul