Kia Sorento Complaints (2016)

1,262 consumer complaints on file.

#11676374July 26, 2025
EXTERIOR LIGHTING
Not recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675852July 24, 2025
POWER TRAIN
The contact owns a 2016 Kia Sorento. The contact stated that while driving at 15 MPH, she attempted to park the vehicle in her driveway. As the contact tapped on the brake pedal, the vehicle independently accelerated as the contact slammed on the brake pedal and steered the vehicle out of the way of her home. The contact ran over a gutter and a bird feeder before applying the emergency brake, which stopped the vehicle. The contact was uncertain if any warning lights had appeared on the instrument panel prior to the failure. The contact was not injured, the air bags did not deploy, and a police report was not filed. The next day, the contact had the vehicle towed to a dealer. The contact was informed that rust was discovered on the vehicle's brake rotors; however, they had yet to determine the cause of the failure. The contact stated that the engine had been replaced almost a month prior to the failure. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 83,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11675603July 23, 2025
ENGINE, STRUCTURE:BODY, UNKNOWN OR OTHER
Paint peeling everywhere an innocent burning excessive oil.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674599July 18, 2025
ENGINE
Driving in traffic at night. Engine suddenly began running erratically, lost power and died. Upon opening the hood I found oily coolant all over the engine compartment that had shorted out the engine electrical systems. I determined that it has shorted out from coolant because after sitting for about 30 minutes the coolant apparently evaporated and the engine started again. This could have been life threatening to my wife, me and others if the engine had died on the very curvy road we'd just gotten off of. I have since found out that there is a TSB (WTY035) that extends the warranty due to faulty head bolts. But this is also a safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672522July 10, 2025
EXTERIOR LIGHTING
I have now replaced the headlight bulbs in my 2016 KIA Sorento 6 times and it's getting worse as it gets older. I believe it is a safety issue since the last time I was out of town, traveling in the middle of the night when it went out. I had to wait until morning to find an auto parts store to buy and replace the bulb. No inspections have been done by anyone. Yes, the warning lamp comes on and stays until reset.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672161July 9, 2025
ENGINE
My Sorento burned oil excessively, without warning, and now has a damaged engine, requiring replacement. This is a serious problem and common. There are two other Kia vehicles with the 3.3L Lambda engine in Weston Kia for the same problem - low/no oil and no “low oil” light. Those two vehicles and mine now require new engines. When my car experienced the problem, the car shook and the engine vibrated with a significant loss of power. This would’ve been extremely dangerous if towing anything or driving uphill. This is a common problem among Kia forums and Kia is unwilling to assist.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671966July 8, 2025
ELECTRICAL SYSTEM
The specific issue I’ve encountered is that the vehicle intermittently becomes stuck in “Park” and cannot be shifted into “Drive” or any other gear using normal methods. The only workaround has been to manually engage the shift lock override by inserting a screwdriver or similar tool into the override slot near the gear shifter. This is not a normal or acceptable method of operating the vehicle and clearly indicates a failure of a system that should function reliably. Upon further investigation, I discovered that this problem is not isolated. Hundreds of Kia Sorento owners from various forums and complaint boards (including Reddit, Kia owner groups, [XXX] , and even other reports on NHTSA.gov) have documented the same problem with identical symptoms: the gear shifter becomes stuck in Park, the brake lights do not illuminate, and in many cases, this is traced back to a faulty Body Control Module (BCM). Many owners have noted that when they contacted Kia corporate or their dealerships, the representatives either acknowledged the issue was known but not recalled, or simply claimed there was no current recall to address it. This is disappointing and raises serious questions about Kia’s willingness to take accountability for systemic flaws in their vehicles. I respectfully request that NHTSA: 1.Initiate an investigation into the prevalence and root cause of BCM-related failures in the 2016 Kia Sorento, particularly those that result in gear shift locking and/or brake light malfunction. 2.Evaluate whether this issue meets the criteria for a safety-related recall. 3.Require Kia Motors to issue a recall and provide cost-free repairs or replacements of the affected components to all impacted vehicle owners. 4.Monitor any further consumer complaints to determine the full extent of the issue across other model years, trims, or vehicles using the same BCM design. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671204July 4, 2025
ENGINE, UNKNOWN OR OTHER
Driving on the frwy when car started loosing power/acceleration, no warning lights or indicators on dashboard. Safely able to merge off the frwy. Turned off vehicle, engine would not turn back on. But all the dash lights came up as warning including engine light. Started to smell like burnt. Open the hood and it smelled like burning oil. Towed my vehicle & under the vehicle a pool of engine oil. Dealer confirmed engine seized. When repairs began water pump was damaged & engine mounts due to engine seizing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671177July 3, 2025
ENGINE
I’m driving down the road my engine started knocking like head gasket lifter and rod was knocking
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670747July 2, 2025
ELECTRICAL SYSTEM, ENGINE
While I am driving it can be jerking anytime and also the slippery light come on the dashboard.Sometimes the engine light come on too.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670873July 2, 2025
ENGINE
While driving on the highway, the vehicle engine began to shake violently. The check engine light came on. The car was driving normally prior to this moment. The car has been well maintained and is in excellent condition. I looked it up and found tons of cases that reference a judgement directive from the Theta II Engine Class Action Settlement (Case No. 8:17-cv-00838-JLS-JDE), where the warranty coverage has been extended due to known engine issues. The KSDS software update (SC260) was installed in 2023, by Kia of Orange Park. The vehicle now has approximately 127,121 miles. We towed the vehicle to Daytona Kia who diagnosed the engine as failed, but declined to initiate a warranty claim or submit the case to Kia Corporate because diagnostic trouble code P1326 was not present. I purchased this diagnostic for nearly $200 from Daytona Kia and they verified the second cylinder failed. They blamed it on a sticking fuel injector, but did not verify that this was the issue. Only stating that they believed this to be the case in their review. They did not conduct testing to rule out rod bearing failure or to verify fuel injectors were to blame for the issue. I asked for that. They checked to see if the service manager would be willing to do a BCS test on the vehicle. It was denied. I asked for definitive verification of the cause of the failure. They said I would have to pay for additional diagnostics to start that process. I contacted Kia corporate and asked them to intervene. Kia has denied my warranty claim, stating that the failure either doesn’t qualify under their extended warranty or that the lack of formal documentation disqualifies my case. In a recent interaction with the dealership, they also cited the lack of a specific diagnostic trouble code (DTC) as a reason not to proceed with warranty repairs…despite the fact that many vehicles with this engine fail without triggering that code, and the software update (SC260) was already applied.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670647July 1, 2025
ELECTRICAL SYSTEM
Vehicle stuck in park. Able to use emergency procedure to drive. Repair of fault would have cost 1600.00 if not covered by my extended warranty. There is a similar recall for not requiring brake to be applied before the shifter can select a gear. This is caused by the BCM body control module. I believe that most of these units are failure prone and they control a number of functions that are related to safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670648July 1, 2025
POWER TRAIN, ENGINE
My 2016 Kia Sorento (VIN: [XXX] ) has suffered a head gasket failure due to a known manufacturing defect identified in a Kia Technical Service Bulletin (TSB WTY035). The defect causes head gasket failure, which in my case has resulted in external oil leakage. While Kia issued a TSB acknowledging this defect, they are denying warranty repair on a technicality — stating that the failure must involve coolant entering the combustion chamber to qualify, despite acknowledging the underlying part defect. The vehicle’s engine is losing oil through the failed gasket, and the issue poses increasing risk of engine damage or sudden performance loss. Kia’s denial is inconsistent with the intent of the warranty and the federal Magnuson-Moss Warranty Act. This problem affects vehicle function and reliability. It is also being experienced by other owners of the same model and engine. I am filing this complaint so NHTSA is aware of this known defect and the manufacturer's refusal to take accountability unless the failure meets arbitrarily narrow criteria. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670650July 1, 2025
SERVICE BRAKES
The electric power brake (EPB) on my vehicle had a fault three separate times. The first time, the rear brakes were engaged by the EPB for approximately a half an hour. The second time a few weeks later, they stayed locked for approximately one hour. A few weeks after that, the brake locked up while the car was parked, and would not release for almost 7 days. It isn’t the fault itself that is of the greatest concern. It is the fact that there is no apparent emergency release for the parking break. I’m grateful I did not need to use the car to drive my kids to the emergency room, for example. I’m very surprised and disappointed that Kia, throughout all of their other innovations, does not have an emergency EPB/brake release handle. One could easily be put in the back of the car, near the spare tire, with a cable and set of release pins, which when pulled, would release the EPB and the car could be driven.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670204June 30, 2025
FUEL/PROPULSION SYSTEM
Fuel pump is leaking, unsafe to drive vehicle, no check engine light just really bad smell of gas
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670306June 30, 2025
ELECTRICAL SYSTEM
I own a Kia Sorento with a recurring electrical wiring failure that affects the passenger-side blinker and hazard lights. The issue has been “repaired” multiple times, but it returns within a day. This prevents me from safely signaling lane changes or using hazard lights in dangerous situations. The wiring becomes loose or faulty repeatedly, creating a persistent safety hazard. This defect has not been permanently resolved despite multiple service visits. I am concerned for my safety and the safety of others on the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669361June 25, 2025
ENGINE
he component that failed was the engine. Specifically, the engine block burst while the vehicle was traveling on the highway at over 50 miles per hour. The explosion of the engine block during driving posed a serious risk to my safety and that of other drivers. The sudden failure could have caused a loss of vehicle control, a collision, or even a fire. Fortunately, I was able to stop in the emergency lane in time without causing an accident. The issue was confirmed by an independent mechanic, who verified the structural damage to the engine block and its complete loss of functionality. At no time before the incident did any warning lights—oil or engine—come on. There were no messages on the dashboard indicating a potential imminent failure. The engine is available for inspection if necessary.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668040June 20, 2025
ENGINE, UNKNOWN OR OTHER
I was driving my Sorento SXL on a highway, at approximately 50 mph. With no warning, the engine began to run rough. The check engine light immediately began flashing. I was able to drive the car approximately three more miles to an auto service center. The engine ran very rough the entire time, wanting to stall when slowing down. The mechanic determined that my car’s oil reservoir was 4 quarts low, yet no engine oil light ever illuminated on the dashboard. It holds 6.2 quarts, and had only 2.2 quarts in it. Again, there was no illuminated light whatsoever telling me my car was dangerously low on oil. Because of this low oil condition, one of my timing chains skipped, and the cam rotated approximately 62° out of center. That’s what caused it to run rough. It appears my only options now are to have the engine apart, and hope no real damage was done, or replace it entirely. The engine for my car has been discontinued, with seemingly no suitable replacement from Kia. This could have been completely avoided if my car had alerted me to a low oil condition sometime before. This is very dangerous and it seems it is a common ailment among some Kia cars like mine. A low oil light would have informed me immediately that my car was in need of oil, a critical fluid for proper and safe operation. If I were towing a trailer when this happened, or on a winding stretch of road in snow or ice, this could have been catastrophic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667829June 18, 2025
ENGINE
My wife was taking my granddaughter to her dance recital on 06/14/2025 she went to pass a car and the Sorento started missing out then died. She had to get to the side of the road and call for help. Once I arrived, I noticed oil on the ground under the vehicle. After I had my mechanic look at the car it was determined that it threw a rod out bottom of motor and the car was towed home. This is a 2016 kia sorento LX with the 3.3 motor. We have had no issues with this car and it has had regular maintenance perforemd since we purchased it at 27000 mikes. It now has 11000 miles warranty ran out at 100000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667387June 17, 2025
ENGINE
The contact owns a 2016 Kia Sorento. The contact stated while driving approximately 65 MPH, the vehicle experienced a loss of automotive power. The contact was able to pull over to the shoulder of the road. However, upon further inspection, the engine oil dipstick had an abnormal fuel odor. No warning lights were illuminated. The vehicle was towed to a local dealer; however, the vehicle was not diagnosed or repaired due to a lack of maintenance records and the costs. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento