Kia Sorento Complaints (2023)

167 consumer complaints on file.

#11726760March 24, 2026
POWER TRAIN
Transmission went out while driving on highway. Dealership said they need to replace the entire transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725220March 18, 2026
UNKNOWN OR OTHER
February 23 2026: Discoverd the rear window had imploded on its own overnight. investigated with the neighbor's Ring camera to see if there was suspicious activity overnight and found there was none. I had the glass replaced. I thought this was bizarre to have a window implode but didn't think anything else. March 17, 2026: Driving home from an errand the rear window imploded again with the most impressive sound-like a gunshot- and the window bits sprayed inside the vehicle. The sound was so loud my ears rang for approx 2 hours afterwards. I have the repair people coming out again, but am working with the local Kia Dealership to source the reason for the issue. This is no longer a one-off problem, but a particular car defect. There have been no warnings or extreme weather temperature changes that could factor into the problem. The incidents are sudden and without warning or reason. I have photographs from both incidents.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723449March 10, 2026
ELECTRICAL SYSTEM
I am writing to report a mechanical failure with my Kia vehicle that occurred on January 19, 2026. While stopped at a red light, my vehicle suddenly shut off and would not restart. Although the electrical lights came on, the engine would not turn over. Because my car was stuck in the middle of the intersection blocking traffic, I had to call 911 for assistance. When the police arrived, the officer attempted to jump-start the vehicle, but it still would not start. A tow truck was then called to remove the vehicle from the roadway. I paid $290 out of pocket to have the vehicle towed to a nearby repair shop. After diagnosing the issue, the shop determined that the starter had completely failed. I purchased the vehicle on May 15, 2023. At the time of the failure, the vehicle had just exceeded the 60,000-mile warranty, leaving me responsible for the repair. I paid approximately $500 out of pocket to replace the starter. Given the short time between purchasing the vehicle and the failure of the starter, I believe this may indicate a defective component.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722647March 7, 2026
SERVICE BRAKES, ENGINE, UNKNOWN OR OTHER
UNKNOWN However multiple times the front end of the vehicle starts shaking when I try to break up especially on the highway. The dealership claimed to have repaired it once and shortly after it happened again. When I took it in they first looked and said the parts was ordered but nothing was done then came back and said oh yes it was done then refused to fix it without a charge so I had to pay to repair it since I feared that the brake would give out if I drive it. The other issue was the check engine light just popped up check engine while driving on the highway, when I take it in they are stating that I may have left the gas tank open which is absolutely false. They cleared it but could not or neglect to explain why it was on. All these incidents occur while on highways never in the general local areas.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721357March 2, 2026
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2023 Kia Sorento. The contact stated that while his wife was driving 10 MPH, after making a left turn, the sunroof shattered with the sunroof cover closed. The vehicle was steered to the side of the road and inspected, but the contact was unaware that the sunroof had exploded. The vehicle was taken to the residence, where the contact’s husband became aware that the sunroof had shattered. The contact had not sustained any injuries. The vehicle was then taken to a dealer, where it was diagnosed that the sunroof had exploded and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was approximately 39,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720822February 26, 2026
VISIBILITY/WIPER, UNKNOWN OR OTHER
While driving on the interstate at 70 mph the front part of the panoramic sunroof exploded. There was no debris or road hazards that caused it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720064February 24, 2026
UNKNOWN OR OTHER
What component or system failed or malfunctioned, and is it available for inspection upon request? —-The radiator How was your safety or the safety of others put at risk? ——possible fire and engine damage Has the problem been reproduced or confirmed by a dealer or independent service center? —— dealer stated rock chip damage. Contesting as manufacturer defect. They should be a plate to protect from this. Advertisement show vehicles off road so how can a normal highway driving cause this type of alleged damage. Is there No manufacturer design to prevent this flaw. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? ——no Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? —— yes, warning message on 3/21/26
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718445February 17, 2026
ELECTRICAL SYSTEM
The contact owns a 2023 Kia Sorento. The contact stated that while driving approximately 40 MPH on several occasions, the vehicle stalled after the battery became drained. The vehicle was able to restart each time after waiting for the battery to recharge. The vehicle was taken to two different dealers on three occasions. During the first two visits, the dealer was unable to duplicate the failure. On the third visit, the failure was duplicated, but the dealer was unable to provide a cause for the failure. During a visit to the dealer, the vehicle stalled while a mechanic was driving it, and the vehicle was towed back to the dealer. The manufacturer was not notified of the failure. The failure mileage was 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717191February 11, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2023 Kia Sorento. The contact stated that while driving at 40 MPH, the "Low Oil" message was displayed on the instrument panel. The contact immediately pulled over and called for assistance. A service technician arrived at the scene and added engine oil, and the vehicle was driven to an independent mechanic to be inspected. The vehicle was inspected, and the contact was informed that the bolts on the oil pan were loose, causing oil to leak from the engine. The bolts were tightened. The mechanic then informed the contact that certain Kia vehicles were under investigation for failures with the oil pan and that the vehicle was possibly affected. The contact stated that approximately 4 hours after the oil service, the "Low Oil" message returned. Due to the failure, the vehicle was towed to a dealer for inspection. The dealer was unaware of any investigations regarding the engine oil pan, and the vehicle remained with the dealer. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716868February 9, 2026
ENGINE, VEHICLE SPEED CONTROL, POWER TRAIN
While driving hybrid battery depletes and car stops accelerating. With pedal to the floor, it may get to 60 MPH, other times 15 MPH. Car doesn't sound great while this is happening. 3/4 times an error showed up stating "Check Hybrid System-Stop Safely". The 4th time the error didn't appear , but was driving on hilly road where battery charged when it was going down a hill. The problem occurred on back roads and Highways. It is VERY unsafe when you suddenly can't accelerate. The car was towed to a kia dealer twice. 1st time I was told it was "bad gas." $1,500 later, it happened again. The 3rd time I had it again towed to a Kia Dealer. 6 weeks later, I was told they couldn't find anything wrong, and Kia released the car. 1 week later, it happened again on the Highway. Dates of occurrence: November 17, 2025 November 25, 2025 December 11, 2025 February 9, 2026 (car was at the dealer from Dec 11-January 29th)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714643January 31, 2026
ELECTRICAL SYSTEM
Screen not responding properly
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709869January 9, 2026
UNKNOWN OR OTHER
I am reporting a vehicle fire that occurred in June 2025 involving my Kia vehicle. On the day of the incident, I started my car and immediately noticed excessive smoke coming out of the air vents, along with a strong burning smell. I drove only a short distance and pulled into a gas station across the street to stop and check what was wrong. While stopped, my children in the back seat alerted me that there was a fire coming from the rear AC vent area. I known it was fire because I saw flames inside the AC vent located in the back seat area of the vehicle. I immediately got my children out of the car and ran inside the store to ask for help. When I walked back outside moments later, my entire vehicle was engulfed in flames. The vehicle was a total loss. At the time of the incident, there was no recall issued for my vehicle. However, in November 2025, I received a recall notice from Kia by mail that appears to be related to the cause of the fire. I purchased this vehicle from Toyota Cavender in October 2024. Since the fire, I have contacted Kia multiple times seeking assistance and resolution, but I am still waiting for a response. This fire occurred without warning and put my children and me in immediate danger.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11709219January 6, 2026
ELECTRICAL SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL
I purchased a new 2023 Kia Sorento in February 2023 from Ken Garff Kia Avondale. Since shortly after purchase, the vehicle has experienced repeated electrical and mechanical failures that substantially impair safety. In July 2023, the vehicle began displaying flashing lights, dashboard error messages, and system malfunctions while driving, despite no collision or visible damage. The air conditioning system malfunctioned and blew hot air even when turned off. The dealership stated a front sensor was “damaged” and not warranty-covered, despite no visible damage, and verbally indicated that many other customers were experiencing similar issues. Repairs took nearly four months, during which Kia Corporate engineers were involved. The issue persisted despite repairs. In December 2024, the vehicle began displaying repeated transmission system error warnings, often within the first 5–10 minutes of driving, causing significant loss of speed and drivability. After multiple service visits, the vehicle required a full transmission replacement in July/August 2025 under warranty. Despite this repair, the same transmission errors returned in December 2025. More critically, the vehicle then experienced multiple sudden and complete electrical shutdowns without warning, including: Shutting off entirely while stopped at a red light, requiring a jump start All screens going black and the vehicle failing to restart Restarting only after being left parked for several minutes These events occurred without any battery or system warning indicators and created a serious safety risk, including risk of being stranded or disabled in traffic. The issues have been documented with photos, videos, repair records, and written communications. Due to the ongoing and dangerous nature of these failures, I am reporting this as a vehicle safety defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708689January 4, 2026
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
Upon starting the vehicle, it flashed several warning lights that were not on the day before. Including popping codes up on the infotainment system and urging me to schedule a service with KIA. Upon looking up the codes it states HVAC issue, when calling to dealership to schedule a service for it (while it is still barely under warranty) they let me know it might not be covered. That’s when I found out there is a recall only for certain VIN #’s for the exact same issue. My car won’t even drive because the electrical system is being affected. Windshield wipers going crazy, lights not working, AC/heat not working, the emergency braking system braking out of nowhere, the lane departure pulling the wheel while driving without cause. I don’t even feel safe driving the vehicle anymore. Kia needs to have a recall on this that alerts the vehicles owners because I had no clue that there was a potential fire hazard due to faulty wiring.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708410January 2, 2026
ENGINE, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Was driving on Dallas North Toll way when my vehicle lost acceleration. Had to pull over and engine started smoking and lit a flame under the hood. Car is now at Clay Cooley Kia in Irving, TX. Car has been there for over two weeks and I still have no answers or information regarding the plan to fix it. Major dealership delay and all they keep saying is “Waiting on a Kia Engineer to come out but we don't have a date.”
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11704792December 12, 2025
ELECTRICAL SYSTEM
I have been calling the nearest Kia dealership to have this recall fixed since September 2025 and there has been no remedy since. We do not feel safe using the vehicle due to the recall involving a fire hazard due to HVAC wiring. We have a family that needs the vehicle and its been 3 months with no remedy and no estimated date of when remedy will be available, so remedy for recall is indefinite. We would like Kia to repurchase the vehicle or assist in auto monthly payments, as we are paying for a vehicle that we cannot use. We have kids and do not feel comfortable driving in this vehicle. We use this vehicle to help work and recall has impacted us financially. Below are details of the recall as we are trying to get Kia to help with: Manufacturer Recall Number SC351 There is no remedy for this safety recall ***REMEDY IS NOT AVAILABLE YET*** KIA AMERICA, INC. IS RECALLING CERTAIN 2021-2023 SORENTO VEHICLES. THE HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) BLOWER MOTOR WIRING HARNESS MAY BE INADEQUATE, WHICH CAN RESULT IN A FIRE. Safety Risk A FIRE INCREASES THE RISK OF INJURY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703565December 7, 2025
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Incident #1: [XXX] The vehicle would not accelerate after coming to a stop at an intersection. The vehicle would not exceed 20 MPH with oncoming traffic from both the East and West as I was turning West from a North Bound Road. On coming traffic was traveling between 45 and 50 MPH. I was clearly nearly broadsided. The car displayed flashing lights on the dash as I was attempting to accelerate. Depressing the accelerator did not increase my speed. The car kept at a 20 MPH speed for the 1/2 mile I traveled to pull off the road in a safe location, causing traffic to be disrupted until I could pull off the highway I had the car towed to the Kia of Round Rock dealership November 17th. The car remained at Kia until December 3rd where they were unable to duplicate the problem. I requested the problem be referred to Kia in California. Kia of CA was totally unresponsive when the problem could not be duplicated. Incident #2 [XXX] Vehicle failed to respond to accelerate after stopping before attempting to enter a four lane highway. (No traffic was visible.) The car would not accelerate more than 20 MPR, the speed limit was 55 MPH. For the 1.5 mile trip home, I turned on my hazard lights, kept to the right and flagged traffic around me. The car never exceeded 20 MPH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703072December 4, 2025
UNKNOWN OR OTHER
I was Driving the car and the sunroof exploded out of the blue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702926December 4, 2025
ELECTRICAL SYSTEM, VISIBILITY
The contact owns a 2023 Kia Sorento. The contact stated that while attempting to activate the HVAC system, there was an abnormal burning plastic odor inside the vehicle. There was no warning light illuminated. The vehicle was to an independent mechanic who diagnosed the vehicle and determined that the blower motor relay had short circuited and needed to be replaced. The vehicle was not repaired; however, the contact performed a repair based on guidance from the mechanic. The contact stated that the vehicle was repaired, but the failure with the blower motor relay reoccurred. The contact recently received notification of NHTSA Campaign Number: 25V649000 (Electrical System, Visibility). The contact related the failures to the recall. The contact called a local dealer and was advised that the remedy was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 48,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702648December 3, 2025
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
While driving my 2023 Sorento plug-in hybrid a msg appeared that Charging Stopped Check Cable. When you stop the car and try to drive it will not go into any gear, msg says Shifting Conditions Not Met and Unplug Vehicle to Start and the wheels are locked up (E-brake) and needs a tow truck with dollies in order to load. This happened in the middle of the Highway and it’s happened FOUR times. By the time the dealer looks at it, the problem has cleared and does not show any codes. It’s not easy to reproduce since it just happens sometimes with the warning and sometimes no warning. The dealer tells me nothing is wrong with the car yet someone could get killed by being rear ended. I’ve tried for 4 months to get a Kia Field Tech out to diagnose but just keep getting lip service from Kia Customer “I don’t “ Care. I feel the car is to dangerous to drive and have refused to pick up from dealer until they fix it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento