Kia Sorento Complaints (2016)

1,262 consumer complaints on file.

#11756972August 14, 2026
STRUCTURE:BODY
Vehicle: 2016 Kia Sorento EX VIN: [XXX] Current Mileage: Approximately 67,000 Component: Paint/Body (Exterior Finish) My 2016 Kia Sorento (Snow White Pearl / Pearl White) has developed premature, multi-panel paint failure. Flaking began appearing on the roof rail area above the front doors in late summer 2025, followed by flaking on the hood, and later bubbling on the rear driver-side door. Flakes recovered from the ground beneath the vehicle have consistently been approximately the size of a 50-cent piece. At the manufacturer's request, three independent, licensed California collision repair facilities inspected the vehicle. All three independently identified a paint adhesion or chemical bonding failure, not ordinary wear. One shop's written estimate states verbatim that "the sealer did not chemically bond when basecoat was applied." Another states it cannot warranty a repair unless affected panels are stripped to bare metal and fully refinished. Repair estimates to properly address the condition range from approximately $9,000 to $17,000. Kia has already acknowledged this as a defect meriting manufacturer assistance, having extended a goodwill offer covering partial repainting costs. I am filing this report to document a paint system manufacturing defect, consistent with a pattern reported by other Kia Sorento owners and referenced in at least one prior Kia service bulletin (SA166) addressing paint peeling on Sorento door panels. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752935July 26, 2026
ENGINE
While I was driving, my 3.3 V6 engine on my 2016 Kia Sorento seized up with no warning. There is no visible oil on the dip stick, although I have changed my oil routinely. There has never been visible oil outside of the engine or on the ground. I never had any warning light come on. I believe the engine burns an extreme amount of oil, which is putting people in a dangerous situation and financial hardship.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752340July 23, 2026
ENGINE
On Saturday the 18th of July, the car was fine, on Sunday 07/19/2026 got ready to take car to regular scheduled oil change and it was making a blown engine noise, the rod had failed, Safety issues where the people at oil change could have had a rod thrown out the bottom of the engine, or my car could have failed in the middle of the road causing an accident. No warning signs, no limp mode, no engine light, no noted metal in oil on previous oil changes. Inspected at Kia, does not meet any recall warranties, however service manager at West Hills Kia stated this is in an internal engine failure and should not have happened with our service records and care of vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751372July 19, 2026
POWER TRAIN
I have a 2016 kia sorento I was having a problem with the shifter it would not go into park and had to use the shift override button I contacted the dealer there was an active recall they refused to repair or replace the shifter because it was inspected by the dealer in 2022 and as far as they where concerned that satisfied the recall The recall is still valid, and does not have close date how can they refuse to repair . It is still a safety issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751409July 19, 2026
POWER TRAIN, ENGINE
I recently took my 2016 Kia Sorento L to the Kia dealership for the Emissions update recall. The next day when I started it up and put it in drive, it started jerking hard when I was trying to speed up (going from first to second gear). I had to stop and then slowly push the gas so it wouldn't jerk so hard, then it finally switched gears and was smooth. Ever since it's happening only at the first cold start up of the day, and have sluggish acceleration throughtout the day. No lights on or codes. I took back to dealership twice and they said they couldn't replicate it and so they aren't sure, but it definitely still does it (anyone riding with me notices before I even mention it).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749807July 12, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
I took my 2016 Kia Sorento to the dealership for an emissions service update as a result of a service bulliten (SC340) After recieving the car back, the transmission acts unpredictably and the throttle is erratic. This happens when started cold and continues until the engine reaches temperature. It did not do this previous to the update. It is a safetey hazard and almost caused a collision. The throttle response was sluggish, it hunted for gears and as a result I was unable to safely merge into traffic endangering myself and other drivers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748819July 7, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM, ENGINE
(Transmission and motor) I had taken my car to the dealership on XXX for recalls and all the signal were fine before going there. They took my car back to do the recalls and my son and I waited . Once they were done we left closer to closing time is noticed there was a burn mark on my dash board that wasn’t there before the recalls. Going forward on the way home. We were waved down by a man stating that my signal and brake light weren’t working . So that next day we took my car back to the dealership to see what happen, why all the sudden different alerts were coming up. They had the same mechanic relook at the car and a when finish 31/2 hour latter was told I needed a new transmission, costing $7384.94 which I don’t have . They charge me $179.00 just to confirm what they said about needing a new transmission. I was devastated and confused why I wasn’t told that the day before. So a few days later I took it to another machanic to see if the could see why the lights weren’t working and he ended up putting new bulbs in and got them working but also he put it in a diagnosis machine 2 of them and couldn’t get a reading at all and said I should take it back to find out why he couldn’t get a reading. I was so frustrated at that point I just was upset! I then had a friend of the family mechanic look at it and he said it wasn’t the transmission it was a knock sensor that I needed so I ordered it. When I called him to install the knock sensor he was too busy to do it and it had already been a whole month of waiting so I reached out to a place in Cumberland RI to see if he could install the knock sensor had it towed there and he kept it for three days and said it was a transmission computer and he tried two of them and neither of them worked and charged me $150 for that I was humiliated and crying , I went there to have my car towed home seen him while waiting for the tow truck to come he said I needed a new transmission and now a motor, crying again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747800July 1, 2026
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
Hello. I just started smelling gas fumes when my car has been running. I see no drips , etc. It happens everytime I drive it to the point where someone pointed it out to me. I had a new engine put in by KIA for my old engine "going to sleep" about 4 years ago. I have been told that this is a on going problem with the Model I have. I want to know what I should do at this point. Im [XXX] and [XXX] so I dont have the money to take it all over the place if this engine issue is covered. Could you please let me know and how to proceed? [XXX] [XXX] Cell [XXX] THANK YOU FOR ANY HELP ps....You should have record of KIA replacing the engine on file??? Is this a warranty issue since I do have a newer engine? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746729June 26, 2026
AIR BAGS, STRUCTURE:BODY, SERVICE BRAKES
The exterior paint on my 2016 Kia Sorento (Snow White Pearl, paint code SWP) is peeling off in large chunks across multiple panels. The clear coat is delaminating and lifting in sheets from the surface, exposing bare metal underneath which is now actively rusting. This is consistent with a known defect documented in hundreds of complaints about 2013-2016 Kia Sorentos in Snow White Pearl (SWP). I have photographic documentation showing significant progression of this damage over the past few months. The vehicle has not been inspected by a dealer or manufacturer regarding this issue. No warning was given prior to the paint failure — it began suddenly and has spread rapidly. The vehicle is available for inspection upon request. Additionally, the gear shift randomly locks in Park without warning, leaving me unable to operate the vehicle. This has occurred on multiple occasions and presents a direct safety risk as it strands me without notice. No warning lights or messages appeared prior to the shift lock engaging. The dashboard is also cracking in multiple locations, including near the airbag housing, which may present an additional safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746307June 24, 2026
ENGINE
Took 2016 kia sorento april 22nd to kia services eastgate batavia oh 45103 to have all recalls fixed, few weeks later engine blew, kia services replaced engine then had to replace my battery because they had to for a month and my good battery was now a total loss, replaced my battery then my car started jerking and won't start unless in neutral, now they say my inhibitor switch needs replaced when I NEVER had any issues in the past with shifting and they wont fix it because they claim its not their fault
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745845June 23, 2026
ENGINE, TRAILER HITCHES
The contact owns a 2016 Kia Sorento. The contact stated that after the vehicle was parked and turned off for approximately an hour, the vehicle was restarted and there was a knocking sound coming from the engine compartment. The contact continued driving and the knocking sound increasing in volume and frequency. There were no warning lights illuminated. The vehicle was taken to a certified mechanic and was diagnosed with engine failure. The contact was informed that the engine needed to be repaired. The mechanic referred the contact to the dealer for assistance. The vehicle was taken to the dealer and the contact was informed that since the vehicle was not repaired under NHTSA Campaign Number: 22V703000 (Trailer Hitches); the dealer was unable to repair the engine ffailure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745718June 22, 2026
ENGINE, ENGINE AND ENGINE COOLING
The contact owns a 2016 Kia Sorento. The contact stated that the vehicle was experiencing excessive oil consumption, and 3 quarts of oil were added every 1,000 miles. The Check Engine and Low Oil Pressure warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with excessive oil consumption. The mechanic determined that the valves in the engine or the engine needed to be replaced. The dealer and the manufacturer were notified of the failure and informed the contact that there was no recall or warranty coverage on the vehicle. The contact was provided an estimate for the repair. The vehicle was not repaired due to the cost. The failure mileage was approximately 98,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744546June 16, 2026
UNKNOWN OR OTHER
MY 2016 KIA SORENTO ROLLS OUT OF PARK; I APPARENTLY HAVE A SORENTO THAT IS "OUT OF THE DATE RANGE" OF THE 2016 KIA SORENTOS THAT HAD A RECALL. THIS IS NOT ACCEPTABLE!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742888June 9, 2026
ENGINE
The contact owns a 2016 Kia Sorento. The contact stated that while driving at various speeds, abnormal engine oil consumption was noticed. No warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed with engine oil consumption, but repairs could not be made until a knocking sound was heard. The contact stated that the vehicle was no longer experiencing the failure but was repaired under an unknown recall. The contact stated that occasionally, while driving at various speeds, the Check Engine warning light illuminated. The vehicle was taken back to the same local dealer, where it was diagnosed with a catalytic converter failure. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 74,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742930June 9, 2026
ENGINE
My husband and I got the oil changed at Walmart, one week later we took a trip to Cincinnati zoo with my children. On the way home we were driving on the interstate, car jolted and caught fire. something went through the oil pan and the oil dumped on the exhaust and caught flame. The car had to be towed to my parents and has been sitting since. We are paying on a car just for it to sit. No one will give us answers.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11741451June 2, 2026
UNKNOWN OR OTHER
Coolant empty, found overheating. Coolant refilled. No noticeable leaks. Mechanic found failure of thermostat. Replaced and car found to be overheating again. Coolant leaking into hood covering engine components.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741029May 30, 2026
FUEL/PROPULSION SYSTEM, ENGINE, STEERING
Car completely stalled while on the freeway with no warning, no engine lights, nothing….luckily we were going downhill and were able to pull over to the side safely. Still owe 6k to the finance company but mechanic claimed I needed a new waterpump…after being changed and charged the car still wouldn’t turn on despite the new waterpump….and a bunch of new obd codes showed up & now I need a new engine. After a lot of research I’ve learned this car is notoriously known for many recalls and overall complains…..I wish I had done research before buying it, now I’m in debt for a car I can’t even drive
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741030May 30, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Fire at the rear bumper of car
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11740766May 29, 2026
ENGINE, POWER TRAIN
Was in for service on recalls 2 weeks ago may 2026...dealer did not fix shift solenoid recall..stated bcu need replaced...driving may 28 26 without warning no lights anything lost power while driving and engine and or transmission failed..lost oil...metal shavings in dipstick oil.oil on skid plate cover..3.3L V6 2016 kia sorento LX was able to get off road without crashing
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739736May 23, 2026
ENGINE
At 116 miles, the engine blew and I was informed it would need to be replaced. I purchased a used engine from the same year of vehicle because Kia said it would not be covered since the vehicle had passed the 100,000 mile mark. I spend over $5,000 to get this engine and have it installed by a licensed mechanic. This second engine has now also blown leaving me without a vehicle as a single mom with a child who has a medical disability. Kia does not have a recall on this engine, which is clearly faulty. There is no way for me to come up with the funds to replace this engine for a second time and is something that should not even have to have to be figured out. I have been in touch with multiple mechanics who say the only way to repair is to replace as it would cost way more to try to rebuild. Kia should stand behind this as they know it is an issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento