Kia Sorento Complaints (2016)

1,262 consumer complaints on file.

#11566027January 17, 2024
ENGINE
My car was overheating and no coolant was leaking. Took it to a Kia dealership and they said that it was due to failed head bolts warping the heads and damaging the block. They said they need to replace the engine and that this is an issue with 2016-2017 Kia Sorento.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565586January 15, 2024
ENGINE
Engine replacement needed due to faulty engine. Dealer confirmed faulty bolts in head gasket causing leaks. No signs of critical issue. The vehicle was taken in for a regularly scheduled oil change when the dealership discovered the leak and subsequent issue with the head gasket threads being striped requiring a full engine replacement. The manufacturer(KIA/Hyundai) should in good faith provide restitution for this issue as it has devalued the vehicle in the public market and is a public safety issue to have the potential for engines to fail without warning. The manufacturer, should also extend and fully cover future engine issues, not just the boilerplate 12k mile warranty on "new" engine replacements. Replacing one faulty engine with another does not negate the root issue and does not provide a good faith solution. The contact stated after being assured by the service department that the new engine would be free of defects the vehicle was driven roughly 300 miles when the warning lights for electronic steering, ABS, and traction control which was immediately followed by a burning smell in the cabin. When safely pulled over there was smoke coming from under the hood. Upon inspection there was almost no coolant left.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565293January 13, 2024
STRUCTURE:BODY
Delamination -peeling paint
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565352January 13, 2024
ENGINE, ELECTRICAL SYSTEM
My engine blew with no light to indicate there was even a problem with the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565232January 12, 2024
POWER TRAIN
My vehicle has 111k miles on it and is burning so much oil I have to spend 8 thousand dollars to replace the motor. This doesn’t seem like it should be burning this much oil. Now the motor has a horrible knock on the inside of the motor. Garage says the whole motor has to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11564937January 11, 2024
ENGINE
The car continues to have burning smell last few days and temperature Gauge past the H. Kia will not diagnose or look at for over 2 weeks and asks me to drive it with my young children. There are no rentals or loaner available while I wait to get my vehicle looked at. I do not want to be the next statistic with my vehicle burning on the side of the road. Please help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11564105January 8, 2024
ENGINE
When taking 2016 Kia Sorento in for oil changes, I'm being told vehicle is low on oil. On Nov 6, check engine light came on, with code P0010 Camshaft position Sensor, so my mechanic replaced both Camshaft position sensors. December 3, check engine light came back on, same code, when mechanic did a further diagnostic he said it is the variable valve timing actuator which happens to be causing the oil consumption. Indicated to take to Kia dealer because they are well aware of the issues with the Gamma motors. I haven't taken it yet to the dealership, I have done some research and seen where there are thousands of Kias and Hyundais with the same issues and it seems the corporations are not doing anything about this.I am really scared to drive now not knowing if I am going to be in the middle of the interstate and my vehicle just quits and then I am in an accident. I am waiting for all documentation of all oil changes and repairs from the shop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11563887January 6, 2024
STEERING
When in motion and at higher rates of speed, the vehicle’s steering wheel gets stuck and requires additional force to turn which causes an over correction. This is a consistent problem that happens.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11563827January 5, 2024
ENGINE, ENGINE AND ENGINE COOLING
Engine stalled while driving on highway. Took it to a Kia dealer and had it diagnosed as an engine block/head gasket failure. I have documentation of service. Service document reads “owner states vehicle runs rough when first started and a/c doesnt cool properly, started vehicle, a/c is currently working normally, upon inspection, found coolant about 3/4 gallon low and has bubbles coming up in reservoir tank, topped coolant, performed engine block test, photo of yellow fluid in tester indicates combustion gases are getting into cooling system and not going out exhaust as it is supposed to, took video of bubbles coming up into tank, advise more than likely due to overheating of engine either has crack in block or warped heads or a combination of the 2, advised recommended long block replacement as tear down is not cost effective , gave estimate, owner declined repairs at this time”. I have been made aware of other customers and people experiencing exact same issue with their Kia sorento models. We have only had this car for over a year from a reputable dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11563201January 3, 2024
ENGINE
The engine failed and stopped while driving on the highway going about 50 mph. Fortunately was able to pull off to side of the road without crashing. Took the vehicle to the kia dealer it was determined that the engine failed due to rod bearing failure. It stopped without any warning. It also appears that there is a current recall and class action lawsuit on v4 2.4 engines identifying the same problem. This needs to be checked into
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11563401January 3, 2024
ENGINE
To whom it may concern, I recently came across an article stating the NHTSA is investigating KIA about the faulty engine. I personally found out the hard way when my family vehicle, a 2016 KIA Sorento EX V6 3.3L V6 lost power on I75 while driving back from a trip to Disney World Orlando. I was able to pull aside but almost got hit by a speeding car. I looked in the engine bay and the coolant was overflowing from the reservoir and was very hot. I towed it back home and then followed up with my mechanic who said the head gasket was blown and that it needed to be replaced. The car is only shy of 50,000 miles and I got it with 4000 miles. I tried to get the engine replaced but KIA doesn’t have any engines for replacement. I have been looking to buy a car to get the engine from a newer KIA because I’m 100% sure this is a factory defect that they won’t fix on their own. I just received a letter stating to take the car to the dealer for a diagnostic on this exact issue and that they would fix it if they found the fault. Well, they said the issue was not about the head gasket and that the motor of the cooling fan was at fault. Yet I talked in person to the tech that diagnosed the car and only VERBALLY they would acknowledge the issue is the head gasket but not only that, they even said the entire engine needed replacing. Are they trying to get away from taking responsibility? Why they wouldn't state it in the paperwork? But if I send you the diagnostic they produced it would only say yellowing tires and wiper replacement to be necessary. This confirms there is a “cat in the bag.” But what they don’t know is that there was a prior inspection at another dealer that stated the head gasket was indeed blown. You are welcome to contact me at any time. My name is [XXX] . The vehicle is under my wife’s name [XXX] . My direct number is [XXX] . Thank you for your help and I hope you make KIA accountable for this really bad experience. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11562809December 31, 2023
STEERING
Has a steering control issue. I am now on my 3rd steering columm replacement. They do not correct the sticky on center steering control issues. Kia has not come up with a workable solution for this. I have had it to 3 dealers so far. They all say the steering column needs to be replaced. Now out of warranty. This car is difficult to drive and control . I have had this problem since I bought it brand new. It now has 118000 miles on it with a lot of misery driving it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11562400December 28, 2023
LATCHES/LOCKS/LINKAGES
The contact owns a 2016 Kia Sorento. The contact stated that while driving at 20 MPH, the front passenger’s side door was unintendedly unlocked, causing the door to open independently. The contact stated that the failure had occurred on several occasions. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was provided. The manufacturer has not yet contacted. The failure mileage was 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11561977December 27, 2023
ENGINE
Oil Consumption issue in which the oil is burning in in the engine. It's a known issue KIA acknowledges however; will not recall to replace the engine. My car has gone through the oil consumption test which they acknowledged it is consuming oil but would cost 1600 to correct a 92% success rate. I don't have the money to fix. Solution from the service dealer was to wait for the engine to go so it can be replaced in its entirety. I am having to check my oil every 1000 miles to top the oil off-quart low and change the oil every 3k. So unsafe to say wait for the engine to go. I am scared to drive my car any further than in the city limits. Is there anything that can be done. Where is the accountability on their end?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11562023December 27, 2023
ENGINE
I purchased this car in august of this year 2023. Since purchasing it has spent about half of the time I’ve had it at the dealership being repaired (all listed in carfax) Things that have been fixed are thermostat, car has been pressure tested multiple times due to hidden coolant leaks, Oring replaced, thermal module where coolant pipe connects & now it is having oil consumption issues & im in the process of testing. This car only has 60k miles and I’ve only put about 3500 of them on it. It has a good carfax showing it has been maintained properly. The dealership has told me that they are unsure if approval would be given for oil consumption. However this hadn’t been happening before all the coolant issues occured which leads me to believe this is somehow related. & now it is a huge concern to me as the idea that my engine could blow or catch on fire with two little kids in the car is extremely scary. Also there was no engine light on when car started having oil loss, luckily I was just checking fluids regularly and noticed & when we started this process the dealership had to put 3 qts of oil in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11561324December 21, 2023
ENGINE
Daughter was traveling at highway speeds (60 mph) when engine loss all power and hard to merge over in lanes due to loss of speed and other traffic. Once to side of road found coolant blowing out of reservoir under hood. Towed to service station where they said head gasket blown on back cylinder bank. Replacement motor needed to make repairs as 7 of 8 head bolts found loose and 3 threads striped from aluminum block which they said is common issue with Kia engines.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11561111December 20, 2023
ENGINE
On the morning of October 31st, 2022 I used my remote starter to warm the engine in my driveway for approximately 10 minutes, when I got into the car I noticed the air blowing was ice cold and when looked at the temperature gauge the needle was in the red. I allowed the engine to cool down for about an hour, checked the coolant level and found it empty. I looked all around and under the engine for signs of leaks, none were found. I purchased a gallon of coolant, topped off the system and brought the car to my local garage to check the problem. They replaced the thermostat and bled the cooling system. About a week later it started overheating again so I topped off the coolant again and took the car to the nearest Kia dealer. After keeping my car for a week they concluded that the head gaskets were leaking and the repairs would be more than the value of the car and they'd be happy to trade what's left of my car for a new Kia. I had my car towed to a reputable independent shop and ended up paying a total of $12, 274.84 for a re-manufactured engine and for labor involved in stripping down the old engine for the extended warranty who inspected the engine and denied the claim. I purchased this vehicle on 1/9/2021 with extended warranty from and authorized Kia Dealer for $20,522.78. I have since found out that this is an ongoing issue with the Kia/Huyndai V6 engines from 2016-2019. As a Mercedes-Benz employee for 30 plus years I am appalled at Kia for their unwillingness to stand by their products.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11560803December 18, 2023
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Car when into a low power mode,could not keep it running ,took 5 times to go thru a very busy intersection and motor was making a knocking noise,smells like burnt oil-motor ,misses out..The car was towed into a KIA dealership,3 weeks later they said it was fixed,drove off and didn’t even make it a mile until it started knocking and having the same smell like burnt motor,went into a reduce power.now it’s been 3 more weeks or more and still nothing is getting resolved. Yes the dealership knows about this issue. Yes warning messages came on when it went into low power mode. This is motor number two as the motor was replaced less than 12 months ago.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11560576December 17, 2023
ENGINE
There is a common issue with these year model Sorentos that poses a dangerous safety hazard for those in the car as well as others on the road. This model has a manufacturers defect that causes the head bolts to strip from the block, causing overheating engine, power loss, and other symptoms. A car that overheats and has these symptoms while on the road could cause a fire, cause hot steam or coolant to burn skin, and risks lives if it happens while on a fast paced roadway. The issue is common and pretty much guaranteed to happen to these model Sorentos. There are thousands of people complaining and report the issue. KIA is aware and not concerned of the issue. The only solution offered is an engine replacement, which most people can’t afford so will more than likely keep driving the vehicle regardless of the risks. My Sorento has been at the dealership already. I’ve contacted KIA corporate as well as attorneys seeking litigation of the issue. My insurance completed a full investigation by U.S. Forensic and determined the cause to be two of my head bolts stripped the threads out of the block. I have the final report from the investigation. We had no early warnings of the issue. We first noticed something was wrong when the car started over heating. You could, then, smell coolant and there was white smoke from the exhaust. There was a loss of power and bubbling in the coolant reservoir. The car would drive without overheating as long as you kept the radiator full of coolant. In summary, this is a common issue that has been ignored by KIA. It is clearly a safety concern and could pose life threatening risks. KIA won’t care and will never do anything about this unless they are forced to.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11560577December 17, 2023
ENGINE
Been dealing with oil issues for over a year. With a closely monitored oil level the car engine blew a hole and is now not drivable. There was never a low oil light or any warning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento