Kia Optima Complaints (2015)

1,022 consumer complaints on file.

#11773169October 23, 2026
ENGINE
There is a known issue with this vehicle and the fix by KIA is not safe nor fair to the consumer. Kia's knock sensor recall centers on the Knock Sensor Detection System (KSDS) software update for Theta II GDI engines. The update listens for rod bearing wear, triggers a check engine light and limp mode via Code P1326, and extends the engine warranty up to a lifetime or 15 years/150,000 miles. My problem is that we had to car in on May of 2026 after in went into limp mode. They updated the software. The car again went into limp mode on 10/21/2026, they updated the software again. My focus here is the fact that it is a known issue and they say it still does not meet the parameters for an engine replacement. It is a severe issue that is dangerous and inconvenient to the driver. You are afraid to take it on a trip or even take it on a highway. My 20 year old daughter drives this to college. Can you imagine a car going into limp mode on a majory US highway? Limp mode essentially does not allow a vehicle to go above 2K RPM. You cant go up a hill over 35 and on a highway, on a flat road you "might" be able to go 55 MPH. My daughter goes to college 4 hours away. This creates a very unsafe, dangerous and inconvenient environment. KIA is hoping that they can buy time until these vehicles fail for some other reason and they dont have to pay the cost for a new engine.... ALL at the consumers peril. To put this in perspective, if you have a vehicle with a "low tire pressure" warning, does lowering the sensors parameters fix the problem.... No, it just turns off the warning and you are driving a car with low tire pressure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767775September 29, 2026
SERVICE BRAKES, HYDRAULIC
The contact owns a 2015 Kia Optima. The contact stated that while pulling into the driveway, the ABS warning light remained illuminated after the vehicle was powered off. The contact stated that the parking brake warning light unexpectedly illuminated while the vehicle was being operated. The contact stated that the brake lights illuminated while the vehicle was turned on or off. The contact's son inspected the vehicle and became aware that the rear of the vehicle near the brake pedal was extremely hot and that the area under the hood was extremely hot. The vehicle was taken to the dealer but was not diagnosed. The dealer informed the contact that the failure could be associated with a light switch failure; however, the contact stated that the failure was not related to the light switch and that the vehicle needed to be diagnosed to determine the cause of the failure. The approximate failure mileage was 231,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765682September 20, 2026
ENGINE, VEHICLE SPEED CONTROL
My energy in my car started messing up with only 150,000 miles it had a long knocking sound and it would not got over 20 miles while driving
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759158August 24, 2026
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
My 2015 KIA optima experienced a catastrophic engine fire while I was driving. There was no warning, I just heard a boom in the engine bay the breaks stopped working and all electrical cut out. As I'm coasting, because I'm unable to stop, flames started to come in through under the dash. I couldn't turn the car off, nor put it in park so the doors stayed locked. The driver window was opened just enough for me to grab the top and break it, allowing me to crawl out. The car coasted itself to the shoulder then blew up (I had a full tank of gas.). All this happened in the manner of 30 to 35 seconds. It's important to note that KIA just replaced the engine 2 months prior to this incident.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11758211August 20, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2015 Kia Optima. The contact stated that for over 8 years, the vehicle was experiencing excessive oil consumption. There was no warning light illuminated. The contact became aware that there was an oil leak on the ground underneath the vehicle. The vehicle was taken to the dealer on several occasions for the oil consumption failure; however, the dealer was unable to find a fault with the vehicle. The dealer had not yet provided a cause for the oil leak. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758113August 19, 2026
ENGINE
The engine in my vehicle failed while putting the car into reverse to back into my garage. I thank God I wasn't on the road when this happened. I took the car into a mechanic who confirmed that the engine was locked and that the car was very low on oil(even though I had my oil changed by him a few months prior). There was an undetected oil leak that led to the engine failure. The warning indicators didn't appear on my dash until after my engine failed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756632August 13, 2026
ENGINE, FUEL/PROPULSION SYSTEM, STEERING
This is a formal vehicle safety complaint regarding a manufacturer's active refusal to remedy a known safety defect under an active recall campaign guidelines.My 2015 Kia Optima Turbo experienced an active internal mechanical engine knock, violent sputtering, and a complete engine seizure. The vehicle is currently sitting un-driveable at an authorized Kia dealership.The required Knock Sensor Detection System (KSDS) software update was successfully completed on this vehicle prior to the incident, legally qualifying it for a 100% free long-block engine replacement under the manufacturer's active Lifetime Warranty extension. However, the dealership service department is actively withholding the safety warranty paperwork and refusing to submit the diagnostic photos and engine seizure data to corporate for warranty approval unless I agree to pay an additional $800 out of pocket for an external throttle body and O2 sensor.I have explicitly declined the retail accessory charges five separate times. I only authorize the replacement of my front sway bar links. Instead of separating the ticket and processing the free engine block safety remedy, the dealer is holding my safety warranty hostage to force a retail sale. Furthermore, a manufacturer consumer care representative recently refused to listen to my request on this matter and dropped the call.The manufacturer is using internal technical advice to block a court-ordered safety remedy and is allowing a dealership to use unauthorized retail accessory charges to deny me a safe, operating vehicle. I request immediate federal intervention to force the manufacturer to release the free engine block safety replacement order to the dealer and halt these predatory dealer practices.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753610July 29, 2026
ELECTRICAL SYSTEM
The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the rear taillight socket wiring harness failed to function as intended. The contact was informed that the brake lights were inoperable. The contact stated that the failure had occurred every 6–7 months. The contact stated that the repair was completed by the contact. The dealer was not made aware of the failure but provided no assistance. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752336July 23, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle stalled. During the failure, several unknown warning lights flashed on the instrument panel and there was smoke coming from under the hood of the vehicle. The contact exited the vehicle, and there were flames coming from underneath the hood. The Fire Department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A Police report was filed, and the vehicle was towed to a tow lot. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The contact stated that the original engine was previously replaced by the local dealer due to a previous recall. No further information was available. The failure mileage was 140,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11751632July 20, 2026
ENGINE
My girlfriend was driving on interstate 95 to pick me up from the metro. The engine suddenly cut off in a manner that appears to have melted the wiring harness of the vehicle, risking fire. She was able to safely get to the side of the road and call a tow. After taking it to a local repair shop, they diagnosed the issue as related to the KSDS recall. We had it towed to the dealership that has also confirmed it is related to the recall. The engine is completely seized following this incident and it's worth noting that Kia is completely denying the engine repair claim as the KSDS update was not installed prior.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750184July 14, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM
I would say that the time this incident happened I was driving and me and me nephew were in car at time taking to shop to see why it was making a sound like air and all of sudden the car started swerving and slowing down and then it made a pop sound and smoke started coming from the car and I was thankful that I didn’t get hit but affraid and also hit my head in car due to the sudden jerk car mad and then it popped sound a d smoke came from good. The next day I have to pay to get back on the other side and also tow it home which it been parked since but I see a recall on my vin and want to find out how to get it to the nearest Kia to fix the recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750336July 14, 2026
ENGINE AND ENGINE COOLING
The contact owned a 2015 Kia Optima. The contact stated that while driving to the residence, the vehicle caught on fire. The contact stated that while at a traffic light, the vehicle suddenly shut off. After exiting the vehicle, the hood was opened, and there was smoke coming from the engine compartment. The contact called an independent mechanic and, within two minutes, became aware of the fire. The contact called 911 for the Emergency Services. The Fire Department arrived and extinguished the fire. There was no injury sustained. There were no warning lights illuminated. The vehicle was previously taken to an unknown local dealer, where it was diagnosed that the engine was leaking with a blown head gasket. The engine was replaced. The vehicle was towed from the scene and was deemed a total loss by the insurance company. The manufacturer was contacted and opened a case. The failure mileage was approximately 212,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11748405July 5, 2026
STRUCTURE:BODY
My 2015 white Kia Optima is having terrible paint peeling problems. It is peeling and chipping on the hood, along the sides of the windshield, above the wind shield, on my back bumper, above my back tires, and just about every place in between. PLEASE HELP!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745917June 23, 2026
ENGINE
While driving my 2015 Kia Optima, the engine failed completely without warning. The vehicle lost power while in motion approximately 300 miles away from my home. All warning lights illuminated and the car shut down during driving conditions, creating a serious safety hazard. The vehicle was towed to a Kia dealership where it was inspected. I was informed the engine has failed and may be related to the known 2.4L engine defect and prior recall campaign involving this engine type. This vehicle has a history of multiple recalls, including engine-related recalls issued in 2018 for the same engine family. The failure occurred suddenly and without prior adequate warning, and the vehicle is now inoperable. I purchased the vehicle in May 2023, and at the time of failure it had approximately 133,000 miles. The engine began knocking loudly prior to failure, then stalled and shut off completely while driving. This incident placed me and others at risk because the vehicle lost propulsion while in traffic. I believe this may be related to a known manufacturing defect in Kia 2.4L engines that has been the subject of recall and/or investigation. I am requesting that this complaint be documented as a safety-related engine failure potentially associated with the existing recall and that it be reviewed for further investigation and manufacturer accountability
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745534June 22, 2026
ELECTRICAL SYSTEM, ENGINE
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The primary failure involved the engine. The vehicle experienced a major engine failure that resulted in an engine replacement under a manufacturer recall. After the replacement engine was installed, the vehicle later developed additional engine-related problems. An independent mechanic advised that the vehicle would require another engine replacement or extensive engine repairs. Additional defects included a malfunctioning moonroof that would no longer close properly and other mechanical issues affecting the vehicle's operation. The vehicle may be available for inspection depending on its current status and location. 2. How was your safety or the safety of others put at risk? The repeated engine problems created concerns about the reliability and safe operation of the vehicle. Sudden engine failure while driving resulted in loss of power, inability to maintain speed in traffic, and being stranded in unsafe conditions. The ongoing mechanical failures caused significant concern regarding the vehicle's dependability and safety. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The original engine issue was confirmed by authorized service personnel and resulted in an engine replacement under a manufacturer recall. The subsequent engine-related problem was evaluated by an independent mechanic, who advised that the vehicle required another engine replacement or significant repairs. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle was inspected in connection with the original engine recall and replacement. It was also inspected by an independent mechanic regarding the subsequent engine issues. At this time, I am not aware of any inspection by police or insurance representatives related to these mechanical failures. 5. yes, right away
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742779June 8, 2026
ENGINE, POWER TRAIN
P1326 code flashing engine light knock sensor went out 3 times in 6 months and just replaced it again and this time engine light didn't go off I was reading that there was a recall on this but apparently mine doesn't state it. Car cannot pass emissions if engine light is on and the 15th of June is approaching. The car doesn't make any sounds or nothing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742315June 5, 2026
SERVICE BRAKES, HYDRAULIC, ENGINE
The contact owns a 2015 Kia Optima. The contact received notification of NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while starting the vehicle, the check engine warning light illuminated. The vehicle was take to O'Reilly's to be diagnosed. The DTC: P1326; was retrieved. The contact attempted to start the vehicle, but the vehicle failed to start. The contact researched online and found NHTSA Campaign Number: 20V543000 (Service Brakes, Hydraulic). The dealer was contacted, and it was confirmed that the vehicle was included in NHTSA Campaign Number: 20V543000 (Service Brakes, Hydraulic); however, the dealer refused to repair the vehicle because the vehicle was not currently registered and additional repairs were needed before a recall repair could be performed. The vehicle was being towed to the dealer. The vehicle was not yet repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 137,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740785May 29, 2026
ENGINE AND ENGINE COOLING, ENGINE
The contact owns a 2015 Kia Optima. The contact stated that while accelerating at 55 MPH, there was an abnormal burning smell detected. While driving, she was alerted by another driver who informed her that the vehicle was on fire. The passengers were able to exit the vehicle safely. The vehicle was engulfed in flames. There were no reported injuries. The vehicle was towed to a tow lot. The vehicle was previously taken to an independent mechanic, who said the engine was bad. The engine was previously replaced at 147,000 miles. The fire department was able to extinguish the fire. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 60,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11738851May 19, 2026
ENGINE
The contact owned a 2015 Kia Optima. The contact stated that while driving at 65 mph and slowing down to enter a parking garage, she observed black smoke emanating from under the hood, and the vehicle stalled. The contact then observed flames near the windshield wipers coming from under the hood of the vehicle. The contact exited the vehicle and called 911. She observed flames coming from under the hood and under the vehicle, and the vehicle became engulfed in flames. The contact stated that the garage manager attempted to extinguish the fire but was unsuccessful. The police and fire department arrived shortly after the attempt, and the fire department extinguished the fire. The contact did not sustain any injuries. A police report was not taken, and she was not aware of any fire department report being filed. The vehicle was bulldozed out of the parking garage and towed to a tow yard. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 75,309.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11738230May 16, 2026
VEHICLE SPEED CONTROL
They were speeding with their phone in a phone stand watching a show while on the freeway
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Optima