Kia Niro Complaints

531 consumer complaints on file.

#11731378April 15, 2026
ENGINE AND ENGINE COOLING, POWER TRAIN, STEERING
The contact owns a 2017 Kia Niro. The contact stated that while driving approximately 60 MPH, there was smoke coming from the rear of the vehicle. The message, "Turn Off the Vehicle and Stop" was displayed, and the transmission failure warning light was illuminated. The contact pulled over and turned off the vehicle. Once the vehicle was turned off, the smoke dissipated. The vehicle was towed to the dealer, who diagnosed that there were holes in the engine, power steering, and there was an engine oil leak. The engine, transmission, and battery were replaced. However, 2 months later, the contact attempted to start the vehicle; however, the vehicle failed to start. The vehicle was scheduled to be towed to another dealer, Buster Miles Kia (1401 S Quintard Ave, Anniston, AL 36201). The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure, and it was determined that the repair was not covered under warranty or recall. The failure mileage was approximately 50,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731185April 14, 2026
STRUCTURE:BODY
I am making a complaint in reference to my 2017 Kia Niro. On or about June 2025 I attempted to open my back driver side door and the handle broke off the car in my hand. We had this replaced at our cost. Since this repair, the back passenger door handle has done the same thing. I have notified KIA headquarters of this and they say they cannot help with this. I am concerned of the safety concerns with the inability to access the back seat quickly in case of emergency because this is where my grandchildren ride. I saw there was a bulletin that when one handle breaks, all door handles with the exception of the drivers door, must be replaced at the same time. I notified the Kia dealership of this and they denied it and told me they had no indication this was required and advised me to take it to my nearest Kia dealership. (3 hour drive).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731040April 14, 2026
POWER TRAIN
I am reporting a safety issue involving my 2018 Kia Niro hybrid related to the Hydraulic Clutch Actuator (HCA), which is currently subject to a recall addressing fire risk. My vehicle has already had the recall remedy performed, which consisted of inspection and installation of a lower-amperage fuse. The dealer confirmed that the actuator is leaking fluid but did not replace it because there was no evidence of PCB contamination, which is the condition required under the recall. However, the vehicle is now experiencing significant drivability issues that create a safety hazard: Intermittent hesitation when accelerating from a stop Failure to properly engage the transmission, especially on inclines Engine revving without corresponding vehicle movement Delayed or inconsistent clutch engagement In one recent instance, the vehicle would not properly engage while attempting to move from a stopped position on an uphill incline, creating a hazardous situation where the vehicle could not reliably move when needed. This condition appears to be caused by loss of hydraulic pressure due to the leaking actuator, even though it has not yet reached the stage of PCB contamination described in the recall. The current recall remedy does not address this failure mode. Instead, it allows a known defective component to remain in service until it reaches a condition that presents a fire risk. In the meantime, the vehicle can experience loss of propulsion under normal driving conditions. I believe this represents a separate safety defect or an incomplete remedy, as loss of propulsion, especially during acceleration from a stop or on an incline, can significantly increase the risk of a crash. I am requesting that NHTSA investigate whether the current recall adequately addresses all safety risks associated with the defective Hydraulic Clutch Actuator, including drivability and loss-of-propulsion conditions that occur prior to PCB contamination.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730887April 13, 2026
UNKNOWN OR OTHER
I own a 2021 Kia Niro. The rear backup camera intermittently fails to operate. When shifting into reverse, the display screen will either go completely black or the camera will not activate at all. This issue occurs unpredictably and without warning. As a result, I am unable to see behind the vehicle when reversing, which creates a significant safety concern. The lack of rear visibility increases the risk of a collision, especially in areas with pedestrians, children, or low-visibility obstacles. I am aware that similar rearview camera failures have led to recalls for certain Kia Niro EV models; however, my vehicle is not included in those recalls. Despite this, my vehicle is experiencing the same or a very similar issue. The problem has occurred multiple times from 2023-now and does not appear to be related to specific weather, lighting, or driving conditions. This defect poses a serious safety risk and should be investigated for potential inclusion in a broader recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730504April 10, 2026
POWER TRAIN
This is a hybrid vehicle. It has Dual clutch transmission. Since I have owned it, intermittently the clutch does not disengage completely. This causes the vehicle to try to pull ahead but my foot is on the brake. The vehicle does not stall. Somehow it figures out it can't pull ahead and somehow fully releases. I have brought it to kia at least 3 times. In each case they tell me they cNt get the car to fail and since there are no codes produced they can't fix it. They even held onto the car several days. I asked them to please replace SOMETHING but the say Kia policy will not allow them to do that. So I am stuck with a car that keeps misbehaving. It is embarrassing because problems occur while a passenger is in the car and it seems to them that I am not driving correctly. I don't know what to do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729706April 7, 2026
ENGINE, ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
The contact owns a 2017 Kia Niro. The contact stated that while driving 60 MPH on the highway, the vehicle jolted and shook abnormally. The electrical system warning light illuminated, and the vehicle lost partial power. The engine and hybrid warning lights were illuminated. The vehicle was coasted off the roadway to a gas station. The vehicle was towed to the local dealer, where it was diagnosed with a blown high-voltage fuse. The vehicle was repaired with a higher voltage fuse. The manufacturer was contacted and opened a case. The approximate failure mileage was 101,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728259March 31, 2026
POWER TRAIN
The contact owns a 2018 Kia Niro. The contact stated that when the vehicle was shifted into reverse(R), the vehicle failed to respond. The vehicle was turned off and restarted to reset the transmission, but the vehicle failed to respond while in reverse(R). The vehicle was shifted to drive(D) but failed to respond. The vehicle was shifted into park(P). The vehicle was towed to a local dealer. The dealer diagnosed the vehicle and determined that the transmission fuse and the hydraulic clutch actuator had failed and that the transmission needed to be replaced. The contact researched online and related the failure to NHTSA Campaign Number: 23V534000 (Power Train). The manufacturer was contacted and the contact was informed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 175,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728234March 31, 2026
ENGINE
The vehicle has a recurring P0420 code (“Catalyst System Efficiency Below Threshold Bank 1”). A boroscope inspection at Ricardo Caballero Kia Santa Isabel (invoice #[XXX] dated December 5, 2025) confirmed internal disintegration of the catalytic converter, with physical pieces of the catalyst falling out when the exhaust pipe was removed. This failure appears related to Recall 23V534 (SC276) and TSB PS709 (overheating / coolant boiling issues in 2017-2022 Niro Hybrid models). Motorambar, Inc. (official Kia distributor in Puerto Rico) has ignored my warranty claim since December 2 and December 22, 2025 (more than four months). Motorambar is now refusing to authorize a courtesy loaner vehicle at the dealer Ricardo Caballero Kia Santa Isabel, claiming the tests will take less than 5 days. This leaves me without transportation. The catalytic converter is fully covered under the Federal Emissions Warranty (8 years / 80,000 miles). I request that NHTSA investigate this as a potential safety and emissions defect and require Kia / Motorambar to: 1. Immediately repair or replace the catalytic converter under warranty at no cost. 2. Provide a courtesy loaner vehicle during the repair. 3. Reimburse previous diagnostic costs of $449.17. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727300March 26, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2019 Kia Niro. The contact stated that while driving at an undisclosed speed, the vehicle stalled in the middle of the road. The vehicle was successfully restarted and moved over to the side of the road. The vehicle was towed to an independent mechanic, where it was diagnosed with a blown head gasket, a misfire in the engine, and coolant mixing with the engine oil; however, the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 118,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727309March 26, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
I own a 2020 Kia Niro PHEV. In October 2024, my dealership performed Technical Service Bulletin SA512 on my vehicle addressing the inverter coolant system. I was not informed at that time that the issue was likely to recur or that periodic maintenance would be required. In March 2026, the inverter coolant warning light returned. I brought the vehicle back to the dealership, where I was told the coolant had crystallized. The dealer confirmed this is a known recurring issue with this vehicle and stated it would need to be flushed approximately every two years since we drive relatively low miles per year (despite driving every day). I was not warned of this at any point. Furthermore, many owners likely drive it short distances every day since it is a plug-in electric vehicle. Kia denied goodwill coverage and I paid out of pocket for the repair. When I contacted Kia Customer Care, representatives gave conflicting information. One confirmed SA512 was performed as a service campaign, another stated it was only a TSB and declined coverage since my car is out of warranty (even though the warranty should still cover the battery and this is an electrical issue). A total case specialist I was assigned to said she would talk to the dealer and call me back but never did. The inverter cooling system is safety-relevant as it prevents the battery from overheating. The problem was confirmed and repaired by the dealership. The component is no longer available for inspection as the repair has been completed. Kia's issuance of SA512 suggests this is a known design issue affecting multiple owners of this model, and they informed the dealership that they could not cover the cost because if they did so, they would have to cover everyone with the same problem (again implying that the issue is quite widespread.)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726377March 23, 2026
ENGINE
Engine Seized at 79,000 miles on Kia Niro Hybrid on 3/8/2025. Oil was changed at 78,225 miles on 12/16/2025. No issues with vehicle until approx. 1,000 miles later and just a month and a half later when car suddenly lost power on a highway forcing me to try to safely and quickly navigate off the road. This could have caused risk to my life and other lives. The car could not be restarted. Kia said the drain plug was not screwed on and is refusing to honor warranty despite no issues with the oil change. Notably, in October 2022, the National Highway Traffic Safety Administration (NHTSA) announced it had launched an investigation into Hyundai Motor Company and Kia Motor Company for problems with their oil pans and oil drain plugs. Specifically, consumers and aftermarket service facilities have filed complaints their engine’s oil drain plug falls out, causing all the oil to drain out of their engine while driving. In multiple tests the oil drain plug was tightened according to factory torque specifications and the tightening was well documented. Yet, testing shows in multiple cases that while driving, the oil drain plug falls within a few thousand miles after the service. In those cases, the crankcase drained completely. [XXX] This issue should be investigated for potential recall to keep drivers, passengers safe on our highways. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725753March 20, 2026
ENGINE, POWER TRAIN
EV motor and drive train have a clattering noise, much like a playing card attached to a bicycle clattering against the wheel spokes. it speeds up and slows down with the acceleration of the motor.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725337March 18, 2026
ENGINE
-Car was leaking or burning coolant causing engine to overheat. -Car was diagnosed with: Exhaust heat exchanger is leaking coolant and needs to be replaced. After costly repair, car continued to leak coolant and overheated. -Car was taken back to the dealership and diagnosed with: Engine Assembly - Long Block - Replace | Engine long block needs replacement due to coolant in the oil. This was at a certified Kia Dealership. No insurance reps or police were involved. An engine light has come on a couple of times over the years that was interpreted to mean replacing the gas cap. After replacing the gas cap, the engine light didn't come back on. My safety was impacted as a person living in a cold, rural state to have a sudden mechanical failure where I couldn't run the heat and had to stop the car immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725424March 18, 2026
UNKNOWN OR OTHER
I believe the issue is related to something connected to the AC system or a component underneath the hood. The exact part that malfunctioned has not been confirmed. The vehicle is available for inspection upon request. My safety and the safety of others were put at risk because some kind of leak or fumes were being sent into the car through the AC vents, causing myself and others in the vehicle to feel sick. I have taken the car to 3 Kia Dealerships. All of which have been extremely dishonest (have tons of proof) and say they cannot verify problem. I took it to an outside independent shop and they verified it instantly and wrote a very detailed invoice about the problem. They couldnt pin point where it was coming from though. The vehicle has only been inspected by the 3 Kia Dealerships and the independant shop Brake Busters I purchased the car in November of 2025 and had no problems until February 22nd 2026. No warnihg lights or messages came on prior. The symtoms that started were Nausea, Headaches, light headedness, vision blurry, and almost caused me to pass out at wheel several times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724729March 16, 2026
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Kia Niro. The contact stated that while driving at an undisclosed speed, the message "Check Hybrid System" was displayed. The vehicle was towed to the dealer, where it was diagnosed, and determined that the hydraulic clutch actuator and power assembly had failed. The dealer related the failure to Kia Safety Recall Campaign Number: SC163 (Hydraulic Clutch Actuator (HCA) Inspection, Repair or Replacement). The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, where the part was replaced a second time; however, the failure persisted. The contact stated that while attempting to drive out of a parking space, the vehicle stalled and became undrivable. The vehicle was towed to Executive Kia (1164 N Colony Rd, Wallingford, CT 06492), where it was diagnosed and determined that the HCA needed to be replaced. The contact stated that the HCA failure had caused a hole in the bottom of the vehicle. The vehicle was not repaired. The contact stated that the recall repair failed to correct the failure. The manufacturer was notified of the failure, and the case was escalated to a case manager, who informed the contact that the case would fall under Goodwill assistance. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724340March 14, 2026
FUEL/PROPULSION SYSTEM, ENGINE, ELECTRICAL SYSTEM
While traveling from upstate New York, the vehicle displayed an engine overheating warning shortly after startup while the engine was still cold. Because I was away from home, I stayed overnight and the next morning took the vehicle to a Kia dealership for inspection. The dealership inspected the vehicle and diagnosed a problem with the exhaust heat recovery system pipe. According to the service department, coolant is leaking internally through this component and is being burned in the exhaust system. The cooling system was pressure tested and held pressure externally, indicating the coolant loss is occurring internally through the exhaust heat recovery system rather than from an external leak. This condition can cause coolant loss and overheating while driving. If the engine overheats while the vehicle is in operation, it could create a safety risk due to sudden loss of power or engine damage. The dealership confirmed the diagnosis after inspection and testing and provided a repair estimate to replace the affected exhaust heat recovery system component. The overheating warning message was the first symptom observed prior to diagnosis. The problem was confirmed by the dealership after inspection and testing. This issue may indicate a defect in the exhaust heat recovery or thermal management system used in this hybrid vehicle, as coolant is entering the exhaust stream internally rather than leaking externally. If this type of failure occurs in other vehicles, it could lead to overheating while driving and potential engine damage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722498March 6, 2026
STRUCTURE:BODY
The push-button locks (the plastic button that covers the electronic components) on the exterior of the driver's door and passenger's door fell off. The problem was confirmed by the Kia dealership, and attempting to push the buttons back on did not work (the buttons promptly fell back off). There was no warning that the buttons were loose before they fell off. The dealership stated that the only solution would be to replace the entire door handle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722316March 5, 2026
POWER TRAIN
I previously had major issues and recall 23V534000 fixed on my 2017 Kia Niro. I had issues again and took it to the local Kia dealership in Wichita, KS. They found a leak in a seal causing fluid to leak on to the clutch actuator. The service tech indicated it is related to the recall. I have spoken with Kia customer service escalations on multiple occasions. Originally they stated it was related to the recall. When I spoke when them today, on the phone they said all the parts that are affected are what were changed out previously. When they called back, they changed the story and said it is not related and they would not pay for it to be fixed, even though they previously said it was the exact thing related to the recall. When I emailed and asked for it in writing as to why it was denied, she changed the reasoning. It was nothing the same that she had told me on the phone. This is a safety issue that should be fixed by the manufacturer and they are refusing to fix it and telling me I have to pay over $5000 to fix it. Completely unacceptable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722353March 5, 2026
POWER TRAIN, ENGINE
The contact owns a 2019 Kia Niro. The contact stated while driving at an undisclosed speed, the vehicle jerked. The check engine warning light and the hybrid battery warning light were illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the clutch actuator was leaking, and the dual clutch and slave cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The contact stated that the engine and dual clutch were replaced two years ago. The contact related the failure to NHTSA Campaign Number: 23V534000 (POWER TRAIN); however, the VIN was not included. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721626March 3, 2026
VISIBILITY/WIPER
The interior surface of the windshield freezes during cold weather operation, beginning at the edges of the windshield and progressing toward the center directly into the driver’s line of sight. This significantly impairs visibility and requires approximately 20–30 minutes of vehicle warming before safe operation is possible. The condition has occurred repeatedly since November under normal winter temperatures. No warning lights or system messages appear prior to the event. The vehicle has fewer than 8,000 miles. The vehicle has been inspected multiple times by authorized dealerships. Three separate dealerships performed diagnostics and preventative service, including cleaning A/C drains and ventilation components; however, the condition persists. Dealership personnel advised they could not open a technical case unless the freezing could be observed in person, which has prevented further escalation because the condition is temperature-dependent. Photos and videos documenting the freezing have been provided to the manufacturer and dealerships. The issue has not been resolved and continues to present a safety concern because driver visibility is obstructed during normal winter driving conditions. The suspected cause is improper windshield installation or sealing allowing moisture intrusion, although the exact failure mechanism remains unconfirmed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Niro