Kia EV6 Complaints (2022)

275 consumer complaints on file.

#11660751May 13, 2025
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
My 2022 Kia EV6 has repeatedly shut off while parked and while in motion, placing myself, my [XXX] child, and other drivers at serious risk. The vehicle’s Integrated Charging Control Unit (ICCU) failed and was replaced, but the replacement ICCU also malfunctioned. This second failure caused a near-collision involving three vehicles. A Ford F-150 had to swerve off the road to avoid hitting me. The most recent incident occurred while dropping off my son, when the vehicle lost all power in traffic. Kia later confirmed that they could not guarantee this issue would not happen again. This statement came after I notified them of the near-accident and the ongoing shutdowns. Despite this, Kia has refused to buy back the vehicle or provide a safe resolution. The vehicle has been out of service for over 30 cumulative days and has undergone two ICCU replacements and one 12V battery replacement. Kia issued a recall notice for the ICCU in December 2024, but the issue persisted even after recall servicing. The defect has been inspected and confirmed by Kia dealerships, and all repair documentation is available. There were no warning lights or alerts before shutdowns. The system fails randomly and without warning, making the car unpredictable and unsafe to operate. This is an ongoing, unresolved issue that poses a danger to myself, my child, and the general public. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657856April 30, 2025
ELECTRICAL SYSTEM, POWER TRAIN
While driving a warning about battery and electrical sysytem failure. Vehicle would not drive more thsn 10mph. I was able to limp home about 1 mile away where the car died. Could not restart with a jumper battery.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657592April 29, 2025
LANE DEPARTURE: ASSIST, LANE DEPARTURE: WARNING, FORWARD COLLISION AVOIDANCE: WARNINGS
After driving the car for a while, when the car is parked and the car is still ON, the car began displaying - Check Lane Assist warning. From that point, the Smart cruise is not working. The warning displayed for more than 20 days. It happened to me more than 5 times. I reached out to Kia and their engineer is unable to resolve it. The warnings get erased after 20+ days. In the recent visit, Kia engineer asked me to change all 4 tires, which I did along with the Wheel balancing and alignment, still I got the same issue last week.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657207April 28, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Once again, the ICCU on the car failed requiring intervention / towing. This is the second outage of the ICCU. This issue happened in early April 2025 (April 8th I believe). My car was parked at work. I entered my car after work and turned on the car. I heard a pop from the rear passenger side identical to the issue as it had happened last January (2024). Shortly thereafter, the check electrical system warning came on. I briefly attempted to drive car to move it to where would likely be an easier spot for the purposes of towing (one parking lot over that is not gated). During that brief drive (roughly 1/4 of a mile), the car immediately began issuing warnings requesting that I pull over and stop. I entered the nearby parking lot and parked the car where it was towed the next day to the dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655093April 16, 2025
FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, AIR BAGS
I was involved in a fatal head-on collision with a pedestrian while driving my Kia EV6. What component or system failed or malfunctioned, and is it available for inspection upon request? Forward Collision-Avoidance Assist : The FCA system appears to have completely failed. It did not detect the pedestrian, did not provide any audible or visual warnings, and did not initiate automatic emergency braking prior to the collision. Airbag System: The system failed to deploy despite a severe head-on collision. Regarding availability for inspection: The car was impounded by the SDPD and was inspected by both the police and State Farm before being sold to SF after being rendered a total loss. How was your safety or the safety of others put at risk? My Safety: The failure of the airbags to deploy put me at significant risk of serious injury or death in the severe head-on collision. The Safety of Others: While the primary consequence of the FCA failure was the tragic impact with the pedestrian, the malfunction of a safety system designed to prevent or mitigate collisions inherently puts all potential road users at risk. Had the FCA functioned correctly, the collision might have been avoided entirely or the impact speed significantly reduced, potentially altering the outcome for the pedestrian. Has the problem been reproduced or confirmed by a dealer or independent service center? No not to my knowledge. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? As mentioned above, the car was impounded by the SDPD and was fully inspected by both the police and State Farm. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? None.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
1
#11653565April 8, 2025
ELECTRICAL SYSTEM
24V200 KIA recall is not being upheld by the manufacturer. they are only performing recall in a small subset of customers - hundreds if not thousands are being fobbed off (by JUST doing software updates) even when having to be towed in 4 or 5 times. In my case i have been towed 4 times. one of the times by power failed with little warning - the other 3 times it would not start in the morning - the car does not give many minutes/miles of wanring as recommended by NHTSA to allow driver to pull over safely. THIS WILL CAUSE AN ACCIDENT CRASH - it is just a matter of time. in my case kia is refusing to replace ICCU even though my vehicel is covered by the recall and has lost power 4 times - this is a scandal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652450April 3, 2025
ELECTRICAL SYSTEM, POWER TRAIN, FUEL/PROPULSION SYSTEM
ICCU failure, no time line for replacement Car at dealer for over a month
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651778March 31, 2025
POWER TRAIN
The ICCU failed causing the vehicle to shut down in the middle of the road with no warning at all. Shutting down in the middle of the road with no warning is a major safety issue. Kia is aware of this fault with the EV6 and all other EGMP platform vehicles, and has made no effort to fix the issue. They just replace the faulty ICCU with another faulty ICCU and hope it doesn't fail before the warranty runs out. They are putting lives at risk, and all EGMP vehicles are unfit for purpose. Kia has the vehicle, has confirmed they will "repair" it under warranty. There is no timeframe for the "repair" and the repair doesn't fix the issue, it just puts the vehicle back on the road in the same unsafe condition in which it is likely to shut down in the middle of the road again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650421March 25, 2025
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
After charging vehicle using L2 charger, (max 7kw) vehicle threw two error messages on screen. 1) “check electrical system” & 2) “stop vehicle and check power supply” Using an OBDII reader, the car provided error code P1A9096. I also noticed the car stopped charging the 12V battery as the 12V state of charge was down to 22%. I towed it to the dealer and they are currently working on diagnosing the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649163March 19, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
Regarding NHTSA Recall No. \/ MFR Recall No. : 24V-867 \/ SC327, I have contacted Kia America by email who is avoiding to take action in rectifying the SC327 defect. From March 11th to March 15th 2025 I have emailed Kia several times to address the issue of my Kia EV6 car, the lack of response from their side compels me to lodge a complaint with you. Please intervene in my case with Kia. Below is the latest correspondence from Kia.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648957March 18, 2025
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
Vehicle went into limp mode and was unable to exceed 20 mph on a 45 mph street. Was told by the dealership the the ICCU unit, which was under recall, would need to be replaced. The dealership has had my vehicle for over a month and is becoming increasingly unresponsive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646948March 7, 2025
ELECTRICAL SYSTEM, POWER TRAIN
I was leaving a parking space when I heard a pop in the right rear of the vehicle. I merged in to traffic and drove stop and go for about three blocks when a warnning message appeared on the dash saying that there was an electrical issue. I've been following this issue on various model specific forums so I was sure what had happened and knew that I had to get off the road quickly. I was able to find an open parking lot and immediately called for KIA roadside assistance. By the time the tow truck arrived all electrical systems were dead. It was towed to the dealer and the next day I was informed that diagnostics determined that the vehicle had a failed ICCU (Integrated Charge Control Unit). This vehicle has had the recalls that addressed this issue with software updates.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645746March 1, 2025
ELECTRICAL SYSTEM, POWER TRAIN
My wife was driving my vehicle and it alerted her that she needed to pull over while driving. She managed to get out of traffic but was stranded on the side of the road while waiting for a tow truck. I completed the recall SC327 and it was performed but still had an ICCU failure. Dealer has not repaired it and is waiting on a part but they say it is on back order and has not given me a timeline for repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645083February 26, 2025
ELECTRICAL SYSTEM
ICCU failed for a second time in 18 months, and the car has been waiting at the dealership for the replacement ICCU to arrive for 4 weeks - as Kia says the part is backordered. The recalls (of which they are now on their third, I believe) were supposed to have addressed this issue and prevented ICCU failure. Car was backing out of the garage on the morning of January 30th when the dashboard began showing alerts - "Stop vehicle and check power supply". Had the vehicle towed to the dealership where ICCU failure was confirmed. As mentioned, this is the SECOND time the ICCU has failed in our Kia EV6 - it was replaced once before already in July of 2023. This tells me that the issue is either far more common than the reported 1% failure rate or that there's some connection between how one uses or charges the car and the likelihood of failure. Either way, Kia doesn't seem to have any idea how to solve for it. First time our ICCU failed, the part was also backordered then and it took six weeks. How they can not have these parts readily available in the midst of an ongoing recall related to said part is truly frustrating.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644624February 24, 2025
UNKNOWN OR OTHER, BACK OVER PREVENTION: WARNINGS, FORWARD COLLISION AVOIDANCE: WARNINGS
On [XXX], I pulled into a parking space, and the car suddenly accelerated, jumped the curb, and hit the building. This is the second time this happened. It happened when I was parking in May 2022; the car suddenly accelerated and struck a fence. In all my time driving this car, I have never had an issue breaking or parking. There was an immediate surge in both cases, and I am confident that my foot was on the break. In both cases, I did not get any collision warning from the car or emergency braking. I know from experience driving this car that when the vehicle /system determined I was too close to something of danger, I would get a collision warning and an immediate breaking by the vehicle. I reported the issue to the KIA dealership for the first time and wrote a report; they said they had not heard of the problem but would note it. If there had been a person walking when this happened, I am sure serious, if not fatal injuries would be occur. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11644000February 20, 2025
POWER TRAIN, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
My EV6 lost power while driving on a busy street. It went into 'Turtle Mode' which allowed me to pull off onto a side road and then all power to the car went out and the car stopped on the side road. I was honked at a couple of times while trying to get off the busy street. The tow truck driver put a power pack on the car and shifted it into neutral and was able to move the car. The dealer diagnosed this as an ICCU failure. The part required is on national backorder with no delivery specified.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643971February 20, 2025
ELECTRICAL SYSTEM
Once the car was turned on, multiple electrical system warnings appeared. My battery was charged to 82%. Once brought to the Kia dealership, I was told that my ICCU needed to be replaced. My ICCU was already replaced once in 2023, so this is the second replacement. I had brought this car into the dealership on Oct. 11, 2024, for a maintenance check up, and this included software updates.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643774February 19, 2025
FUEL/PROPULSION SYSTEM
On 01/19/2025, after charging my vehicle to 100% using a Level 2 Charger, while driving, my vehicle displayed several warning notifications on the driver display, including "12 Volt Battery Low. Stop safely", "Stop vehicle and check power supply" and "Check electric vehicle system", shortly after I heard and felt a loud thump/pop. I returned home and powered the vehicle off. I and was able to drive the vehicle to the local Kia dealer the next day, less than 1 mile away. The vehicle had reduced power and multiple warnings advising to slow or stop the vehicle. On 01/20/2025, Geweke Kia advised the ICCU had failed and thet it was placed on order, with no ETA for the part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643450February 18, 2025
ELECTRICAL SYSTEM
I took my 2022 Wind AWD EV6 into Bob Johnson Kia for the required SC327 recall service on Feb 17. I was informed that the service would not be performed because they were having too many problems with critical failures after performing the service on other cars. Specifically, they said they had 7 EV6s that died within weeks of performing the SC327 update, 4 of which were still in their back lot waiting for new ICCU assemblies. They recommended to wait until Kia sorted out the quality issues surrounding the SC327 update. This seems highly suspicious since it's a required recall service. I'm aware that Kia has a design problem with the ICCU and has mishandled service support from the beginning, but I need to understand my course of action and how you recommend I handle this situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11642822February 14, 2025
UNKNOWN OR OTHER
The ICCU failed, causing the battery to die which left me unable to drive the car further. The car needed to be towed to the Kia dealership, who confirmed that the ICCU had failed. A warning saying check electrical system showed on the dash when the part failed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia EV6