Hyundai · Model Report
Showing safety data for the 2010 model year only.
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
CURT MANUFACTURING IS RECALLING CERTAIN TOW PACKAGE WIRING HARNESSES, PART NUMBER 55538, THAT CONNECT TOW VEHICLE LIGHTING CIRCUITS TO TRAILER LIGHTING CIRCUITS SOLD FOR USE ON CERTAIN MODEL YEAR 2009 THROUGH 2011 HYUNDAI SANTA FE VEHICLES. THE UNITS ARE NOT WATER-TIGHT AND MOISTURE CAN SEEP INTO THE CONVERTER MODULE AND DEFEAT THE MODULE'S INTERNAL CIRCUIT PROTECTION.
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2010 SANTA FE 2WD VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND 2.4L ENGINES MANUFACTURED FROM OCTOBER 15, 2009 THROUGH MARCH 5, 2010. THE INTERMEDIATE SHAFT MAY SUFFER FROM NOISE AND EXCESSIVE WEAR DUE TO A MISALIGNMENT OF THE INTERMEDIATE SHAFT WITH THE RIGHT SIDE OUTPUT GEAR. CONTINUING TO DRIVE THE VEHICLE IN THIS CONDITION LEADS TO THE DEVELOPMENT OF A WHIRRING/WHINING NOISE AND CAN EVENTUALLY CAUSE DAMAGE TO THE AUTOMATIC TRANSMISSION.
The vehicle is a 2010 Hyundai Santa Fe with about 157,000 miles. Hyundai issued Service Campaign 947 (TSB 17-01-005) for underbody corrosion on 2007–2010 Santa Fe models, but the campaign was never performed on this vehicle. When the vehicle was taken to an authorized Hyundai dealer, the dealer inspected it and found the frame rusted out in multiple places, with extensive holes. The dealer also told me that some of the main parts listed in the campaign bulletin need to be replaced. A separate independent inspection found a hole in the unibody and noted it would fail a state safety inspection. I am concerned that corrosion this severe in the frame and unibody could compromise the vehicle’s structural integrity and the safety of its occupants and others on the road. I do not know whether other vehicles are similarly affected, but the campaign covers a large population of this model. The problem has been confirmed by an authorized dealer and by an independent shop, and both have photos. The vehicle is at the dealer now and is available for inspection. The dealer is submitting its findings to Hyundai Motor America for review, and I have a case open with Hyundai Customer Care. I received no warning lights or messages before this was found. The rust was found during inspection.
No injuries · No fire · No crash
The Radiator fan remains on when the vehicle is turned off and requires the fan to be unplugged to disengage. If it is not unplugged it will continue to run until the battery is dead. If not caught at the time exiting the vehicle then I am left stranded until I can get the vehicle jumped but even with a dead battery if you plug up the fan again will continue running nonstop. The vehicle does not run hot. There are no known issues that present before this happens and no error codes when hooked up to diagnostics.
No injuries · No fire · No crash
The vehicle’s transmission slips while driving on the highway at approximately 65–75 mph. The slipping occurs at highway speeds and appears to affect the vehicle’s ability to maintain consistent power and acceleration. Problem The vehicle’s transmission slips while driving on the highway at approximately 65–75 mph. The slipping occurs at highway speeds and appears to affect the vehicle’s ability to maintain consistent power and acceleration. Safety Concerns This creates a safety concern because unexpected transmission slipping at highway speeds could result in a sudden loss or interruption of power. This may make it difficult to maintain speed, merge, pass, or respond safely to changing traffic conditions. The issue could increase the risk of an accident, particularly in heavy or fast-moving traffic.
No injuries · No fire · No crash
On XXX I was waiting at a light and the check engine light was blinking. When I started up, the car was very sluggish. It continued to be sluggish on my trip home - 5 miles. I brought it to Meineke [XXX] [XXX]. They ascertained that the engine was shot. They flushed out the oil in the engine and there was lots of metal in the oil. They instructed me to go to Hyundai immediately. There was a engine recall and their research showed that I was included under the recall warrenty. I've included their assessment. Both the drives to the Meineke from my house and to Hyundai from Meineke were scary. I didn't feel safe in the car. I went directly to [XXX], manager of Larry Miller Hyundai at [XXX], Phone [XXX]. He said that he needed to clear the recall with Hyundai. He called me back in a few days and told me that all the test diagnostics were made and that a censor malfunction was the cause of the problem and the front breaks needed work. I gave him the go-head. The cost was $1,319. I wasn't convince that was the primary problem. I use my car for short trips. I was driving to the gym on XXX - having driven less than 50 mile since the recent repair - once again I stopped at a light and the check engine light lit up permanently - not flashing. The engine started to shake when it was idle and there was an unusual sound coming from it. I finished my drive to the gym although the drive just didn't feel normal or safe. Right now (XXX) I am having my car towed to Hyundai. It is not safe to drive. My belief is that corporate Hyundai refused to fix the engine repair part of a class action lawsuit which includes replacing the engine. They had to see that my recall warrenty ends in September and they figured they'd stall until the warrenty was no longer valid. This is just a guess, but a very educated guess. They had to know that the engine was no longer safe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
Engine fire