Hyundai Santa Fe Complaints (2014)

493 consumer complaints on file.

#11473192July 10, 2022
ENGINE
We were driving in the highway and all of a sudden the engine started making a loud knocking noise. After safely pulling over, we checked the oil and there was none. There was no low oil light indicating a problem as well as no oil leaks or smoke. The oil just disappeared. We were lucky to get off the highway before the engine seized. The dealership confirmed the engine is blown and needs a replacement. The cost is $17,000 but Hyundai will only cover 50%. We are going the cut our losses and get a new car instead of repairing. To me this is a factory defect that should have been covered event though it’s beyond the warranty: we have service records showing an oil change every 5,000 miles. We are the original owner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472617July 6, 2022
ENGINE
Driving on interstate when car went into limp mode and started ticking and knocking. Again. Flashing engine light. P1326 knock sensor code, again. Another $250 for towing to dealership and life without a car again As a single mom of a disabled child
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472639July 6, 2022
STEERING
Steering column coupler is failing. If it breaks completely, I could lose control of steering and it could lead to a crash. It is available for inspection and has been inspected by Hyundai and confirmed that it is a coupler failing. The only known problem, that I didn't realize was a problem, was vibration upon braking (I thought that was the rotors needing attention) and vibration when hitting speeds between 65-75 (which I thought was an alignment issue). It was when I tool it in for an alignment that I was asked if there was any "play" or clicking in the steering column and there was, but it was so slight, I had not thought anything of it. I was told there was a recall on this part for two models in 2014, but my Santa Fe was not part of that. There was also a recall for this part on a Santa Fe 2016 forward; again, it excluded my vehicle. The job is expensive, for a $24.00 part replacement. I am told the entire steering column needs to be replaced at a cost of $2800.00 and that was from the Hyundai dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472643July 6, 2022
ENGINE, UNKNOWN OR OTHER, ELECTRICAL SYSTEM
When entering a busy intersection, the car seized with no power and would not restart.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472433July 5, 2022
ELECTRICAL SYSTEM
Drivers side rear passenger door lock became inoperable. Door will not lock or unlock with key fob or from the drivers door arm rest door lock/unlock switch. Door lock on the door panel does not move positions when fob or door lock switch is operated. Door lock within the door handle on the inside is in between the locked and unlocked position. If the silver lock on the door is either pushed or pulled, the door lock will function. Power lock does not work.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472194July 3, 2022
FUEL/PROPULSION SYSTEM, POWER TRAIN, UNKNOWN OR OTHER
While driving normally, suddenly the vehicle will jolt and the RPMs go down to zero despite the vehicle still moving. Even with the gas pedal pushed down to the floor, and being able to hear the engine 'vrooming', the vehicle will not increase speed. It is extremely dangerous to not be able to speed up when on a highway or interstate. The check engine light does not come on, the diagnostic at the dealership does not throw any codes and the issue is intermittent so no one knows how to fix it since they can't duplicate the problem on demand. Usually turning the car off and on will 'fix' the problem until it happens again out of nowhere. The vehicle is extremely unsafe; this has been happening on and off for months. We do have videos of this occurring; no one at the dealership or any friends who are mechanics have any idea of what is wrong.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471721June 30, 2022
ENGINE
On June 1, 2022, the vehicle was towed into the dealership. Customer complained it stopped while running and wouldn't start. Initial engine Dx was completed. The battery and starter were replaced. Upon replacing both, the engine started, but was making a "clicking" sound. On June 20, 2022, another engine Dx was performed. Dx revealed DTC P1326 - Knock Signal Range/Performance and DTC B1688 - Cluster Ionizer Fault. Engine was under an extended warranty. Given known engine issues with these vehicles, Dealership planned to request Hyundai replace the customer's engine. Customer was the original owner and routinely serviced vehicle at the dealership. The vehicle was moved to the back of the storage lot. Several minutes after parking same, they observed smoke coming from the engine compartment. Three fire extinguishers were used in an effort to suppress the engine fire. The Fire Dept. was ultimately called to extinguish the blaze.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11471797June 30, 2022
FUEL/PROPULSION SYSTEM
Car caught fire while driving.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11469972June 19, 2022
ENGINE
While driving to an appointment on 6/16/22, i went to pass someone in the left lane. I was able to accelerate enough to pass the vehicle. After that, my vehicle lost power and I was able to coast to the side of the road safely. I was stuck on the side of the road for a few hours and was finally able to be rescued. Got the car home, took it to the local maintenance shop where they couldnt find anything wrong with it. I got my car back the next day, only to have the engine start a tick noise in the engine. I checked the oil level and it was below the L on the dipstick. No low oil light or check engine light ever came on. I put 2 quarts of oil in. Started the car up to now have a loud knocking noise when i accelerate. Since this just happened over the weekend, i havent made it to a shop to have the car inspected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469225June 14, 2022
STEERING
I have a Steering Coupler failure on a 2014 Santa Fe with 67k miles. Hyundai has already recalled the Steering Coupler in the Elantra and Sonata models, however this same part is used across multiple models including the Santa Fe and Azera. My family is forced to replace this on a 2014 Santa Fe and 2013 Azera. The defective part causes a heavy clunking in the steering column which could lead to an accident. Below is the recall notice. https://autoservice.hyundaiusa.com/TXX7/MicroSiteTemplate/MicroSiteTemplateVINValidate/2687 The part being replaced is below, which as you can see is across multiple models. MDPS Flexible Coupling Replacement 56315- 2K000-FFF Applicable Vehicles: 2010~2014 Sonata (YFa), 2011~2014 Sonata Hybrid (YF HEV) 2007~2017 Elantra (HD, MD/UD), 2009~2012 Elantra Touring (FD), 2013~2014 Elantra GT (GD), 2013~2014 Elantra Coupe (JK) 2013~2018 Santa Fe (NC) 2012~2017 Azera (HG) 2012~2017 Veloster (FS) I wanted to report this to ensure that the government agency responsible knows that this part is used in more than 2 models. This is a common complaint against Hyundai if you read online about their complaints. It is unsafe and unfair for other models to not be included in this recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468694June 10, 2022
ENGINE
The engine began to knock when accelerating from stop signs and green lights then engine quit entirely. Check engine light came on but did not flash. Vehicle was towed to Hyundai dealer service department. Service department says engine needs to be replaced. THE CONSUMER REQUESTED THE MANUFACTURER HONOR THE WARRANTY DESPITE IT BEING EXPIRED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467802June 6, 2022
ENGINE
We were not advised that the vehicle was burning oil when serviced and there were no signs of leakage in the garage where kept. On an extended road trip the engine began to make a rattling noise that got worse as we drove. I stopped at an automotive store and checked the oil just to be surprised that no oil was in the engine. Again, no external damage or leaks. I serviced the vehicle with oil and continued driving home. On the interstate in traffic the vehicle stalled and I coasted the vehicle to the side of the road. The engine would not turn over and we had to be towed. Hyundai says they don't have parts to fix the vehicle, but that when they do it will cost $14,000 to replace the engine. This engine model needs to be put on re-call just like the other engines that Hyundai has been penalized for bad and unsafe engineering.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467670June 5, 2022
ENGINE
A worn connecting rod bearing which produced a knocking noise from the engine and engine warning light. Engine had 80 thousand miles with routine oil changes using 100% synthetic oil
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466451May 27, 2022
ELECTRICAL SYSTEM, ENGINE, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I was driving to pickup my dog from daycare centre and when I arrive to house, put my car in Park then a huge amount of smoke came out from the front hood of car. The smoke got bigger and bigger within 30 seconds I couldn't see anything from front of car and around driver's seat. There was no Hazard alerts or signs on my car that my car was overheating. There was no signal or emergency shut off on the car when the overheating began. My boyfriend was in car at time. My dog was walking outside with daycare caretaker when a flame started on Driver's side engine. The flame lit and sparked into a huge flame. I ran out of car while my boyfriend yelled for everyone to back away from car before it explodes. The flame grew and engine bursted into flames, a loud explosion followed. I did not have any time to even gather what was going on before my eyes, I was trembling in shock and could not speak clearly. Immediately, I called police to come put out the fire. The fire department was transferred into my phone call. I was able to give address and they arrived on scene within 3-4 minutes. Fire department put out the flames with a water hose. The car was completely damaged, falling apart into pieces, front hood was on fire to the back seats, doors were on fire, steering wheel was gone, entire front dashboard and chairs were melted and gone in pieces. I started feeling sick and overwhelming stressed.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11466331May 27, 2022
ENGINE
Bearing wearing that resulted in engine seizing. The vehicle started to make an engine noise without any light bulb on the dash or any signal of damage or oil leak. Due to the increment in noise I opted to stop the vehicle and tow it to the Hyundai dealer. Consumer's vehicle (2014 Santa Fe xl) started to sound bad out of nowhere on December 2021 and decided to stop it and take it to the Hyundai. The vehicle never light any bulb or lack any power, just the noise. Consumer was told by Hyundai engine needed replacement but they won’t cover because consumer is the second owner. The vehicle have 97,000 miles and all the oil changes had been made according to the recommended time by the manufacturer. There is a recall due to the same issues for the Santa Fe sport but consumer's wasn't included.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465939May 24, 2022
SEAT BELTS
Front seat passenger seat belt retractor is locked. Dealer says seat belt and retractor needs to be replaced at a cost of $900. How many owners are going to spend that much money to replace the most important safety device in the vehicle? Soon after I purchased the vehicle in 2014, the same thing happened to a rear passenger seat belt.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465105May 18, 2022
AIR BAGS, SERVICE BRAKES, SEAT BELTS
The contact owned a 2014 Hyundai Santa Fe. The contact stated that while driving approximately at 75-80 mph when another vehicle driving at high speeds crashed into the rear of the vehicle causing the vehicle to sway. The contact attempted to avoid crashing into another vehicle but crashed into a concrete divider. When the contact depressed the brake pedal, it failed to respond. As a result, the vehicle flipped over. During the incident, the seat let's failed to retract and secure the contact therefore he collided with the windshield during the impact. The air bags failed to deploy. The contact sustained injuries to his back, ribs, and shoulder that required medical attention. The vehicle was towed and deemed totaled. A police report was not filed. The manufacturer was made aware of the failure. The approximate failure mileage was 70,100.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11463516May 5, 2022
ENGINE
At highway speed during moving to exit ramp car stalled and luckily coasted to safety without an accident but was very scary and could have ended badly. Restarted car and all seems to be working fine currently but worried it will happen again, this is the first time. No engine codes and had it checked with a odb2 scanner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463094May 2, 2022
ENGINE, VEHICLE SPEED CONTROL
While driving on the MA Route 90 on April 29, 2022, the vehicle stopped accelerating and became unsafe drive. I brought the car to Midas and was told that the car needed a new engine. I contacted a Hyundai dealer and was told that they could not look at the car as they had over a hundred Hyundai engines to replace. Prior to this incident, there were no warning lights or messages. I have learned that there seems to be significant problems with many Hyundai models. I believe this was extremely dangerous as the car would not accelerate whileI was in the fastlane of the highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11462445April 27, 2022
ENGINE
While driving on the interstate the engine completely seized. I managed to quickly get to the side of the road by coasting. I was traveling in the left passing lane at a speed of 65-70 mph and had to cut into the right lane in order to safely make it to the side of the road. Luckily I did not have any of my three children in the car with me. Prior to this, there were no waring lights, i.e. check engine, low oil etc. and no signs of any oil leaks, no smell of burning oil and no blue smoke from the exhaust. The independent service center confirmed that the engine did not have any oil in it causing the seizure and ultimately blowing the engine. I take the vehicle in for regular maintenance for oil changes, tire rotations etc. as well as having it inspected per state emissions requirements.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe