Hyundai Santa Fe Complaints (2020)

218 consumer complaints on file.

#11592945June 6, 2024
ENGINE, ELECTRICAL SYSTEM
Prior to these occasions, the Hyundai Santa Fe was constantly needing oil added. On top of that, starting on [XXX], my 2020 Hyundai Santa Fe coded with a check engine light blinking in the upper right corner of the dashboard. I was on [XXX] in NW Indiana on my way to a meeting. The SUV would not accelerate past 2,000 rpm and bogged down on a national interstate sending me into a panic. I had my car towed back to my house. I called my brother in law, [XXX] , who sold me the vehicle in November 2020, to get advice on what to do next. I was told to have the vehicle towed to the nearest dealership. After having my car sit there for two weeks, Webb Hyundai finally looked at it. They upgraded the knock sensor software and had the knock sensor replaced. With the plethora of things that I asked to be repaired or looked at, they only fixed the knock sensor. Due to an extended warranty, I paid $100. Two days later, the SUV got a flat tire. The SUV sat for a week or week and a half due to a flat tire and the place not having it in stock. [XXX] driving back from getting my new tire put on in Valparaiso, Indiana, the vehicle coded again on [XXX]. It caused another very dangerous situation as the vehicle slows to 2,000 rpms. Once again, I had the SUV towed back to my home in Cedar Lake, Indiana. It sat for a few days while I was deciding my next move. This time, I had the vehicle towed to Gerald Hyundai, where my brother in law works and where the vehicle was originally purchased. The vehicle arrived [XXX], 2024. The SUV only sat for one day before telling me all the work that needed to be done. Some of the charges were covered by the extended warranty. Total bill was $540. The work was done on May 13, 2024. I could not pick up the vehicle until the weekend. However, my other car was in an accident, so I did not make it until [XXX] 2024. Shortly after picking up my vehicle, the SUV coded again on [XXX] going back to Indiana. More to follow.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11589505May 19, 2024
WHEELS
Front drivers side wheelwell cover come off on the highway, I could have had a wreck
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11586490May 2, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
On Interstate 95 in Virginia, multiple times, going ~68-70 MPH the vehicle automatically applied the brakes causing an unsafe situation with a momentary loss of control. Multiple times this has happened with no other vehicle or obstacle in front of, or beside me. It has happened now for no reason causing the loss of control of the vehicle. We have reported this to Hyundai and they cannot find any fault code, or record of the incident. Our understanding is that this is a widespread problem with this vehicle and system, but also includes other vehicles with the same technology. We are afraid this may end up causing serious damage, injuries or fatality(ies). We have asked Hyundai to turn the system off, and they have refused. They have no solution, and we have spent time and money on this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574032February 26, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle suddenly lost motive power. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that one bolt on the fuel pump was sheared off and another was extremely loose. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 63,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11571294February 11, 2024
UNKNOWN OR OTHER, VISIBILITY:SUN/MOON ROOF ASSEMBLY
Sunroof spontaneously exploded while driving on the highway. There were no other vehicles around and nothing visibly seen that hit the roof.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11563531January 4, 2024
UNKNOWN OR OTHER
I purchased this vehicle in early 2023. I was driving on the interstate and received a TINY rock chip that immediately cracked across my entire windshield in April of 2023 resulting in my replacing the windshield. I have since received two TINY rock chips one on 11/25/23 and one on 01/03/24 resulting in immediate cracks. the rock chips are barely visible and as soon as it was heard each time, the windshield cracked considerably. The windshield is faulty and defective. I have driven the same interstate for the last 10 years and have never had this issue with any other vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11559501December 11, 2023
SUSPENSION, STEERING, POWER TRAIN
La guagua a tenido problemas con el tren delantero. Comenzó con un sonido en el Guía. La Hyundai le reparo esa pieza y luego continuó con el mismo ruido. Ahora tienen que cambiarle el Rack and Piñogn. Mi guagua tiene solo 19,750 millas creo que vino mala de fábrica.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557881December 1, 2023
POWER TRAIN
The contact owns a 2020 Hyundai Santa Fe. The contact stated while attempting to drive from a complete stop, the accelerator pedal was depressed, but the vehicle failed to respond. The contact stated that he shifted to park(P), turned off, and restarted the vehicle, and the vehicle responded as needed. The contact stated that the failure had recurred 5 times while driving. Additionally, the contact stated that the immobilizer warning light was illuminated. The vehicle was taken to the dealer three times; however, the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 30,595.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557052November 27, 2023
ENGINE
The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the check engine warning light flashed on the instrument panel, prompting her to pull into a parking area and contact Roadside Assistance. The vehicle was towed to the dealer, who diagnosed a failure with the knock sensor. The vehicle was repaired, but the failure reoccurred. The vehicle was again towed to the dealer, who diagnosed a general failure with the engine, requiring a replacement engine. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 14,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11556600November 23, 2023
ENGINE
My engine light came on December of 2022. I took it to Autozone and had them to a diagnostic text to read the code. They stated it was a misfire on 3. My vehicle was also burning oil. I took it to the dealer(Napleton). They changed the spark plug. That didn’t fix the issue. I took it back because the check engine light came back on. Napleton Downtown Chicago, IL, kept the vehicle for 5 months because they stated they had to replace the engine. About 2 weeks ago my check engine light came back on. I made an appointment to take it into to Napleton Downtown Chicago on November 27, 2023. Yesterday November 22, 2023, my vehicle cut off, started smoking and didn’t cut back on, I had to have it towed to Napleton in Urbana, IL. Clearly this vehicle is having engine problems. I been telling Napleton Downtown Chicago that there’s a defect with this vehicle and to replace it. Please look into for me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11555742November 17, 2023
ENGINE
On 01/21/2023 after exiting thr highway and pulling into a shopping center signals started popping up on my dashboard and ny car lost speed. I tried making it down the rd to a tire discounters but ny car lost complete power and would not turn on. A tow truck toad it to the tire discounters and once on the flat bed it was a puddle of oil and a trail of oil coming from my car. Once there tire discounters states that my car needed to go to a dealership. It set at kerry hyundai Alexandria until may 2023 waiting to be diagnosed. Once diagnosed it stated that ny car was missing the drain plug and that I needed a brand new engine. I had a oil change at car x on 12/10/2023 and hyundai blamed car x stating that they didn't tighten my plug. But car x denied. I got a lawyer n began to sue car x when car x lawyer responded stating that there were other people having the same problem and hyundai was being investigated. My car is currently still sitting at hyundsi because I don't have 7800 for a engine and hyundai will not cover the engine under warranty
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11554372November 9, 2023
UNKNOWN OR OTHER
The metal cable that holds the spare tire snapped off while the car was driving out of our driveway. And the tire flew off the car nearly causing it to crash.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11553828November 6, 2023
ENGINE
After having a warranty repair for a valve cover gasket' at CENTEREACHHYUNDAI, I picked up my car. Only 8 minutes into my drive home the engine light went on and engine error code appeared. At that piont smoke was coming from the hood when I heard a pop and flames appeared at my passenger side window. I turned the car off removed my phone and exited the vehicle. No one else was in the car but within minutes the fire was totally involved. I also noted it took the fire department very long to arrive. If anyone was trapped in the car they would have peristed.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11553683November 5, 2023
ENGINE, ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:SUMP/TANK:DRAIN PLUG
Oil leak from oil pan area. Took the car to the dealer twice to get it fix and the problem temporarily stop but now is continuing to leak again. All they did was retighten the oil plug the first time and then the second time replaced the oil plug with a new one. They said it was a bad oil plug washer and now it should stop the leak, but now it’s leaking again. Took notice of the leak when the car was parked in garage overnight and a pool of oil formed under the car again. This is scary because losing oil like this is not normal and if it continue it could seize the engine while the driver is driving it risking the safety of the driver and car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11550736October 18, 2023
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS
Numerous different occasions since I bought the vehicle this year in March 2023 when on highway, side streets and even in parking lots with nothing, no cars no objects or humans in front or behind the vehicle my forward collision warning and rear end collision warning has came on which caused the car to break on its own and it is a safety concern. I have been to the dealer numerous times since I’ve bought the vehicle and currently have reached out to Hyundai Motors of America and pretty much got told to suck it up nothing they can do for me as the computer isn’t showing any codes or issues my car has now been at dealership where I bought it for 2 weeks now and no resolution besides come get the car and figure it out on my own and as a single mother with a child with disabilies I don’t know what else to do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11549580October 12, 2023
FUEL/PROPULSION SYSTEM, LANE DEPARTURE: WARNING
Catalytic converter is failing Lane collision warning failing driver side rear view mirror
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11548273October 4, 2023
UNKNOWN OR OTHER
Sitting in parked vehicle. Opened the rarely-opened panoramic sunroof. Heard unusual sound,. Looked next day and noticed a stationary glass panel forward of the sunroof had shattered all the way around but had not collapsed (yet--have tape on it to keep it intact until repairs can be made). Hyundai does not consider this to be a warranty issue. The warranty states in the "What is not covered" section: "- Action of road elements (sand, gravel, dust or road debris) which result in stone chipping of paint and glass." Dealer documented it and basically said "too bad". Since the issue being reported was NOT caused by road debris etc., This should be a warranty coverage matter. Similar instances have happened to others (entire sunroof) and has been reported. This glass should be LAMINATED--not tempered--but is not. This could be a major safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11548093October 3, 2023
EXTERIOR LIGHTING
Intermittently when you turn the left turn signal, it will be a delay of 2-3 seconds to actually turn on the lights. Usually it happens in the morning when cold.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11545572September 20, 2023
ENGINE
Oil pan cracked leaking oil
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11544448September 14, 2023
VISIBILITY/WIPER
I had been driving my vehicle for about 5 minutes when I heard what sounded like a loud bang or gunshot followed by the sound debris falling. I realized the front piece of my panoramic sun roof had literally exploded. When I got out to look at it the glass around the hole was pointed upwards so it looked like it exploded from the inside out. The glass had no prior damage and nothing hit it before the explosion. I was on a paved road by myself.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe