Hyundai Santa Fe Complaints (2002)

165 consumer complaints on file.

#10342270July 13, 2010
SUSPENSION:REAR
2002 HYUNDAI SANTA FE. CONSUMER EXPRESS DISCONTENT REGARDING RECALL REPAIR *TGW THE CONSUMER STATED SHE IS STILL WAITING FOR THE REPAIR TO BE MADE TO HER VEHICLE. THE CONSUMER ATTEMPTED TO MAKE TWO APPOINTMENTS, AND BOTH TIMES SHE WAS TOLD THE PARTS WERE NOT AVAILABLE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10342639July 12, 2010
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
TL*THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED SHE AND THE PASSENGERS, INCLUDING A CHILD, WOULD DEVELOP HEADACHES AFTER DRIVING SHORT DISTANCES. THE VEHICLE TESTED POSITIVE FOR CARBON MONOXIDE; YET, THE DEALER WAS UNABLE TO LOCATE A LEAK OR DETERMINE WHERE THE GAS WAS EMITTING FROM. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE TOXICITY OF THE GAS AND ITS AFFECTS ON HER AND THE PASSENGERS IN THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 130,000 AND THE FAILURE MILEAGE WAS 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10339866June 24, 2010
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
MY 2002 HYUNDAI 2002 SANTE FE HAS A 2-PART CATALYTIC CONVERTER. HYUNDAI HAS A WARRANTY--REQUIRED BY FEDERAL LAW, I UNDERSTAND--THAT COVERS THIS FOR 8 YEARS, 80,000 MILES. MY CAR IS WITHIN THAT CRITERIA. THE SECOND CONVERTER BROKE OFF, AND NEITHER NOW WORK. HYUNDAI AND ITS DEALER, MARHOFER HYUNDAI OF CUYAHOGA FALLS, OHIO, REFUSE TO HONOR THE WARRANTY, BECAUSE THE MAIN CONVERTER WOULD WORK IF THE SECOND, AND AN ENTIRELY NEW EXHAUST SYSTEM, WERE INSTALLED. THE CAR IS UNDRIVEABLE, SOUNDING LIKE A TRUCK AND SPEWING EXHAUST. ANOTHER SHOP IS REPLACING THIS, AND THE OWNER TOLD ME HIS VENDOR HAS JUST SOLD FIVE OF THESE CONVERTERS/EXHAUST SYSTEMS. THE SHOP JUST PUT ONE IN ON A HYUNDAI SANTE FE, AND MINE WILL MAKE SEVEN IN A SMALL CITY (AKRON) IN A VERY SHORT PERIOD OF TIME. YET HYUNDAI WILL DO NOTHING, AND MARHOFER WANTS $2,000 FOR THE WORK. THIS PROBLEM IS A SAFETY ISSUE BECAUSE EXHAUST FROM THE BROKEN CONVERTER COULD ENTER THE VEHICLE AND CAUSE INJURY TO THE DRIVER AND PASSENGER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10339151June 19, 2010
ELECTRICAL SYSTEM:STARTER ASSEMBLY
ENGINE STALLED SUDDENLY ON SEVERAL OCCASIONS WHILE DURING LOW SPEED, AT IDLING OR AT A CONSTANT SPEED AS A RESULT WITH FULL LOSS OF POWER, BRAKING, AND STEERING. CAR DID START BACK UP FINE, BUT WOULD EVENTUALLY EXHIBIT SAME BEHAVIOR AGAIN ALONG WITH ERRATIC RPM SURGES. MY LOCAL MECHANIC ATTRIBUTED THE PROBLEM TO A BAD CRANK SHAFT POSITION SENSOR CPS. HE ADVISED I CONTACT THE DEALER SINCE THERE IS AN OPEN RECALL ON THIS EXACT PART AND SAME ISSUE REGARDING 2.7 V6 ENGINE RECALL #03V030000 I CONTACTED THE DEALER TO DISCUSS AND PROVIDED MY VIN NUMBER, HOWEVER THEY INDICATED MY VEHICLE WAS NOT PART OF THE RECALL. MY LOCAL MECHANIC REPLACED THE CPS SENSOR AS PER RECALL, AND CONFIRMED THE DAMAGED CPS SENSOR WAS THE ORIGINAL PART, AND THE ISSUE WAS ULTIMATELY RESOLVED. THIS OPEN RECALL 03V030000 AFFECTS APPROXIMATELY 25,000 VEHICLES, I BELIEVE THIS SAFETY ISSUE IS MUCH LARGER AND SEVERAL COMPLAINTS EXIST WHERE CONSUMERS ARE BEING TOLD BY THE DEALER THAT THERE VIN NUMBER IS NOT PART OF RECALL 03V030000, YET EXHIBITING THE SAME ISSUES WITH THE DEFECTIVE CPS AND ULTIMATELY PAYING FOR THIS PART THEMSELVES. THIS RECALL SHOULD BE EXPANDED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10336159June 14, 2010
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING AT SPEEDS OF 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE TACHOMETER READ ZERO AND THE VEHICLE VIOLENTLY JERKED AND THEN RESTARTED ITSELF. THE FAILURE WOULD OCCUR INTERMITTENTLY AND OFTEN TIMES, THE CHECK ENGINE LIGHT WOULD ILLUMINATE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE HE WAS INFORMED THAT THE CRANKSHAFT POSITION SENSOR HAD FAILED AND WOULD NEED TO BE REPLACED. THE MANUFACTURER ADVISED THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 132,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10335067June 7, 2010
STEERING
POWER STEERING FAILED DUE TO RUSTED FLUID LINES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328511May 3, 2010
SUSPENSION:REAR, SUSPENSION
2002 HYUNDAI SANTA FE RECALL *GR IN LATE FEBRUARY, PRIOR TO RECEIVING THE RECALL NOTICE, THE SUB FRAME FAILED WHILE THE VEHICLE WAS BEING SERVICED FOR AN UNRELATED ISSUE. THE CONSUMER HAD TO PAY TO HAVE THE SUB FRAME REPLACED. THE CONSUMER STATED THE BALL JOINT WAS BEING REPLACED AT THE TIME OF THE FAILURE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10325887April 15, 2010
SUSPENSION:REAR
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS OF 25 MPH, SHE HEARD A SQUEAKING NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC TEST WAS PERFORMED. THE FAILURE WAS CONTRIBUTED TO CORROSION ON THE REAR SUSPENSION ARM. THE CONTACT VERIFIED THAT SHE HAD PREVIOUSLY RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER 09V123000 (SUSPENSION: REAR) AND WAS ADVISED BY THE DEALER THAT THE FAILURE WAS DIRECTLY RELATED TO THE RECALL. THE DEALER STATED THAT THE PARTS NEEDED TO MAKE THE RECALL REPAIRS WERE NOT AVAILABLE AND THAT THE VEHICLE WAS DEEMED AS UNSAFE TO OPERATE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10325146April 12, 2010
ELECTRICAL SYSTEM, SUSPENSION
TL*THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STARTED THE IGNITION AND EXPERIENCED ELECTRICAL FAILURE. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE FIRST FAILURE ALSO OCCURRED ON THE DATE THAT THE VEHICLE WAS PURCHASED. ADDITIONALLY, THERE WERE FAILURES WITH THE LOWER CONTROL ARM AND THE FILLER IN THE FUEL TANK. THE VEHICLE WAS REPAIRED FOR THE MALFUNCTIONS; HOWEVER, THE FAILURES CONTINUED TO OCCUR WITH THE ELECTRICAL SYSTEM AND SUSPENSION. THE CONTACT STATED THAT THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE REPAIR EXPENSE. THE FAILURE MILEAGE WAS 92,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10319780April 9, 2010
SUSPENSION:REAR
2002 HYUNDAI SANTA FE. CONSUMER WRITES TO EXPRESS THOUGHTS THAT RECALLS WERE NOT HANDLED PROPERLY AND THAT FURTHER ACTION IS NECESSARY. *TGW THE CONSUMER STATED THERE WAS A LOUD CREAKING NOISE COMING FROM THE REAR OF THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10322915March 30, 2010
SUSPENSION:REAR
TL*THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE WOULD PULL TO THE RIGHT WHILE DRIVING AT VARIOUS SPEEDS UNDER 25 MPH. HE RECEIVED A RECALL NOTICE AFTER THE FAILURE OCCURRED, NHTSA CAMPAIGN ID NUMBER 09V123000, SUSPENSION REAR. UPON CONTACTING THE DEALER, HE WAS ADVISED THAT THEY WOULD NOT BE ABLE TO PERFORM THE RECALL REPAIRS UNTIL MAY 28, 2010. THIS WOULD BE TWO MONTHS AFTER RECEIVING THE RECALL LETTER. THE CONTACT STATED THAT TWO MONTHS AFTER THE RECALL NOTICE WAS RECEIVED WAS NOT WITHIN A REASONABLE AMOUNT OF TIME WHEN DEALING WITH A SAFETY ISSUE. NO REPAIRS WERE MADE TO THE VEHICLE. HE ATTEMPTED TO CONTACT THE MANUFACTURER; HOWEVER, THERE WAS A TWO-HOUR WAIT BEFORE HE COULD SPEAK WITH SOMEONE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10319920March 15, 2010
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. WHILE DRIVING AT 15 MPH THE CONTACT NOTICED A BANGING NOISE COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE LOWER BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS THEN TAKEN TO THE DEALERSHIP WHERE THE LOWER BALL JOINTS WERE REPAIRED UNDER WARRANTY. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP ON THREE PRIOR OCCASIONS AND THE LOWER BALL JOINTS WERE REPLACED EACH TIME. THE FAILURE MILEAGE WAS 15000 AND THE CURRENT MILEAGE WAS 118000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10315237March 1, 2010
STRUCTURE
MY 2002 SANTE FE HAS BEEN RECALLED FOR REAR TRAILING ARM REPAIR AND I'VE BEEN INFORMED BY THE DEALER THAT THEY WILL NOT PAY FOR A LOANER CAR. THE DEALER IS FAR FROM BOTH MY HOME AND WORK AND THIS WILL REQUIRE ME TO RENT A CAR AT MY EXPENSE. REPAIRING THE DEFECT IS THE VERY LEAST HYUNDAI SHOULD DO. TO TRULY BE AT NO COST TO THE CONSUMER, THE RECALL SHOULD INCLUDE A LOANER CAR, AS IT WOULD WITH ANY WARRANTY REPAIR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10314613February 26, 2010
VEHICLE SPEED CONTROL
I DRIVE A 2002 HYUNDAID SANTA FE (ENGINE 2.7L 6 CYL. THIS MORNING I PULLED INTO A PARKING SPACE AND SUDDENLY MY CAR ACCELERATED FORWARD. I HIT THE BRAKE YANKED THE EMERGENCY BRAKE UP AND IT STOPPED. I THEN BACKED IT UP SINCE IT WAS WAY OVERSHOT IN THE SPACE. I CALLED THE DEALER AND THEY SAID TO BRING IT IN ,BUT EXPLAINED IN GREAT LENGTH THAT HYUNDAI'S HAVE A DIFFERENT THROTTLE CONTROL SYSTEM THAN TOYOTA'S AND BMWS. I DON'T REALLY CARE THAT MY SYSTEM IS CONFIGURED DIFFERENTLY. THE FACT THAT MY PROBLEM OCCURRED DURING THE TOYOTA CRISIS IS CIRCUMSTANTIAL. MY PROBLEM DID OCCUR THOUGH. AND SOMEONE COULD'VE BEEN HURT. THE FIRST TIME IT HAPPENED WAS ABOUT 3 MONTHS AGO, I WAS DRIVING ON A SIDE ROAD AND GOING FAIRLY SLOW (ABOUT 25 MPH) WHEN IT ALL OF A SUDDEN ACCELERATED. SINCE THIS WAS THE FIRST TIME, I WAS DISORIENTED AND UNSURE IF I HAD DONE SOMETHING. I HIT THE BRAKE, PULLED OVER AND STOPPED. NOW THAT IT HAS HAPPENED AGAIN, I AM VERY CLEAR THAT IT WAS AN UNINTENDED SUDDEN ACCELERATION. I CHECKED MY FLOOR MAT AND IT IS COMPLETELY FLAT AND SECURE. I'M HAVING MY HUSBAND DRIVE IT TO THE DEALER. WE'LL SEE WHAT THEY CAN FIND. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10303546February 1, 2010
SUSPENSION:REAR
TL*THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. WHILE DRIVING, THE REAR END BEGAN TO SLIP AS IF IT WERE ON ICE. HE WAS UNABLE TO CONTROL THE VEHICLE WHILE DRIVING 20 MPH. THE VEHICLE WAS TOWED TO A REPAIR FACILITY. THE MECHANIC TOLD HIM THAT THE REAR TRAILING ARM WAS CORRODED. THE ENTIRE REAR END FELL DOWN DUE TO THE RUST. HE CALLED THE MANUFACTURER TO FIND OUT IF THERE WERE ANY RELATED RECALLS; HE WAS INFORMED OF RECALL 09V123000. THE VEHICLE HAS NOT BEEN REPAIRED TO-DATE. THE CONTACT WANTED THE MANUFACTURER TO PAY THE TOWING FEE SO THAT THE VEHICLE COULD BE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 137,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10299043January 11, 2010
VEHICLE SPEED CONTROL
IN JULY 2009 AND AGAIN IN DEC 2009 I EXPERIENCE "SUDDEN ACCELERATION" IN MY 2002 SANTA FE WITH THE 2.7 V6 ENGINE. I HAD ABOUT 92,000 MILES ON THE ODOMETER IN JULY AND ABOUT 95,000 IN DECEMBER. BOTH TIMES THE "SUDDEN ACCELERATION" OCCURRED WHILE I WAS IN "MANUAL MODE". SOME REFER TO THIS AS "SPORT MODE". I WAS DRIVING IN THE MOUNTAINS ON PENNSYLVANNIA WHEN THESE INCIDENCES OCCURRED. THE FIRST TIME I WAS COMPLETELY STOPPED IN 1ST GEAR. THE CAR STARTED TO DRIFTED INTO THE ONGOING TRAFFIC BEFORE I REALIZED THAT THE ENGINE WAS ACCELERATING. ALL THIS TIME I WAS PRESSING ON THE BRAKE PEDAL AS HARD AS I COULD AND FINALLY STOPPED ABOUT 10-15 INTO THE ONCOMING TRAFFIC. LUCKILY, NO TRAFFIC APPROACHED DURING THIS INCIDENT. IT HADN'T HAPPENED AGAIN UNTIL I WAS IN THE MOUNTAINS OF PA AGAIN IN DEC 2009 IN "MANUAL MODE" BECAUSE OF THE HILLY, ICY ROAD CONDITIONS AT THE TIME. THE INCIDENT OCCURRED WHILE I WAS SHIFTING BETWEEN GEARS. MY WIFE DRIVES THE CAR ALMOST EXCLUSIVELY BUT NEVER USES THE "MANUAL MODE" HOWEVER, WHEN I DROVE IN THESE TWO SPECIFIC AFOREMENTIONED INCIDENCES I WAS IN "MANUAL MODE" ON VERY HILLY AND WINDY ROAD CONDITIONS. I AM PRESENTLY WORKING WITH MY HYUNDAI SERVICE MANAGER ON SEVERAL POTENTIAL FIXES TO THE PROBLEM. THEY ARE TAKING THIS SERIOUSLY BUT HAVE NO DEFINITIVE FIX FOR THE PROBLEM AS YET. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10296870December 24, 2009
STEERING, POWER TRAIN:AUTOMATIC TRANSMISSION, SERVICE BRAKES, HYDRAULIC, TRACTION CONTROL SYSTEM
PREMATURE RUSTING OF POWERSTERING 2 (5 YEAR), & TRANSMISSION 2 (6 YEAR ), & BRAKE (7 YEAR), STEEL LINES . AND ABS, TRACTION CONTROL SENSOR RING ON FRONT DRIVE WHEELS SHAFT, RUST & SPLIT, NEEDED TO REPLACE AXLES AS THE ONLY FIX. RIGHT FRONT AXLE TO TRANSMISSION CASE SEAL SLIPS OUT AND LEAKS OIL HAS BEEN REPAIRED 5 TIMES UNDER WARRANTY & STILL NEED TO BE PUT BACK IN A OIL CHANGES (3000MILES) ON 2002 HYUNDAI SANTA FE . *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10295592December 14, 2009
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. WHILE ATTEMPTING TO DECELERATE THE BRAKE PEDAL FELL TO THE FLOOR. HE HAD USED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THE TECHNICIAN STATED THAT THE BRAKE LINE HAD RUPTURED. NO REPAIRS WERE MADE. THE CURRENT AND FAILURE MILEAGES WERE 56000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10293387November 24, 2009
FUEL SYSTEM, GASOLINE
I AM THE ORIGINAL OWNER OF A 2002 SANTA FE. FRED ZINK WE HAVE 149,000 MILES ON THE VEHICLE I JUST DISCOVERED A PERFORATION ON THE METAL FUEL FILL SPOUT JUST BELOW WHERE YOU INSERT THE FUEL SPOUT THIS CAUSED FUEL TO SPILL ALL OVER THE BOTTOM OF THE CAR AND ON TO THE GROUND THIS IS A VERY SERIOUS SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10292891November 19, 2009
POWER TRAIN:AXLE ASSEMBLY
TL*THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. WHILE DRIVING HE HEARD NOISES COMING FROM THE FRONT OF THE VEHICLE. THE DEALER REPAIRED THE LEFT JOINT AXLE ACCORDING TO THE WARRANTY. THE BOOT ON THE LEFT SIDE OF THE AXLE WAS ALSO TORN; HOWEVER, THE DEALER REFUSED TO REPAIR IT SINCE THAT PART WAS NOT COVERED BY THE WARRANTY. THE CONTACT STATED THAT HE PURCHASED AN EXTENDED WARRANTY AND THAT THE DEALER SHOULD REPAIR IT ACCORDINGLY. THE CONTACT REFUSED TO PAY FOR THE BOOT REPAIR. THE FAILURE MILEAGE WAS 80000 AND THE CURRENT MILEAGE WAS 81000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe