Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Hyundai Motor America (Hyundai) is recalling certain 2013-2015 Santa Fe Sport vehicles. Brake fluid may leak inside the Anti-lock Brake System (ABS) module, possibly resulting in an electrical short.
Hyundai Motor America (Hyundai) is recalling certain 2013-2015 Santa Fe Sport vehicles. Brake fluid may leak inside the Anti-lock Brake System (ABS) module, possibly resulting in an electrical short.
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Vehicle: 2013 Hyundai Santa Fe Sport 2.0T Limited, VIN [XXX]. Registered and titled in Georgia, USA since July 2022. Built in the USA (VIN begins with 5); originally retailed in Canada. The vehicle has an unremedied ABS module defect that can cause an engine-compartment fire even when parked and turned off. Hyundai Canada lists it as open safety recall R0246-1 (41D013, Transport Canada 2024-080), remedy available since 2024-05-27. The same defect and the same remedy (ABS fuse replacement) are covered in the US by NHTSA recall 23V651 / Hyundai Recall 251, which includes 2013 Santa Fe Sport vehicles produced 7/12/2012 to 6/15/2013. A second Canadian fire-risk recall is also open: R0212 (21DG01, TC 2022-659, rear park-assist sensors). The NHTSA recall lookup for my VIN shows 0 open recalls (checked 10/26/2026), apparently because the vehicle was first sold in Canada. Georgia Hyundai dealers refuse to perform the recalls, telling me they do not do recalls on Canadian vehicles. As a result, a US-registered vehicle with a known fire defect that Hyundai Motor America has recalled in the US cannot get the remedy anywhere in the US. I have asked Hyundai Auto Canada (10/26/2026) to authorize a US dealer. I ask NHTSA to ask Hyundai Motor America (1) why US-registered vehicles that are the same as those in recall 23V651 are excluded from the remedy because of their original market, and (2) to authorize its dealers to perform the remedy on my vehicle. I am parking outdoors away from structures in the meantime. My family, including three young children, rides in this vehicle. No fire, crash or injury has occurred. Documents available: Hyundai Canada recall lookup and NHTSA lookup for this VIN, both dated 10/26/2026. [XXX], [XXX], [XXX], [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
FORMAL VEHICLE SAFETY AND WARRANTY COMPLAINT Date: [XXX] From: [XXX] Vehicle: 2013 Hyundai Santa Fe Sport, 2.4L Theta II engine Mileage: Approximately 150,000 miles (exact current reading to be confirmed) Subject: Recurrent Check-Engine Warning Following Repeated Repairs; Request for Theta II Engine Investigation I am submitting this complaint to formally document recurring engine-related symptoms affecting my 2013 Hyundai Santa Fe Sport, and my repeated requests for investigation of a possible connection to the known Theta II engine defects and related warranty programs. On [XXX], the check-engine light illuminated again. Previously, on three separate occasions, the vehicle experienced a flashing check-engine light and a light ticking noise while idling. I was advised each time that the knock sensor was responsible, and the sensor was replaced. The vehicle returned to normal operation after those repairs, but similar symptoms subsequently recurred. While my vehicle was still below the 150,000-mile threshold, I repeatedly expressed concern that the symptoms could relate to the Theta II engine issue. During the most recent dealership visit, resulting in repairs on September 10, 2026, I emphasized that the recommended valve-cover gasket and spark-plug work might address a secondary issue without resolving the primary recurring problem. The check-engine light has now returned approximately five weeks after that repair. I am not claiming that a connecting-rod-bearing defect has been conclusively diagnosed. I am asking that the possibility be properly evaluated and that my earlier reports, repair attempts, and the mileage at which I first raised these concerns be preserved and considered when warranty eligibility is reviewed. I am sending this as a record of contact and communication.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The vehicle suddenly stopped and suddenly smoke appear in the front part of vehicle. Firemen appeared and when the front of the car was opened the flames of the fire were all over the engine of the car. The front glass broke and the hood has visible signs of the fire. Police were everywhere while firemen worked to stop the fire in the car. The car was towed to our home.
The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that the front driver’s side door failed to unlatch as intended using either the interior or exterior door handles or the locking mechanism. In addition, the contact exited the vehicle using the front passenger’s side door to exit the vehicle. An appointment was scheduled with the local dealer. Upon further investigation, the contact associated the failure with TSB: 14-01-004-1. The contact stated that it might be a potential safety risk for passengers in an emergency. The manufacturer was made aware of the failure by telephone. The failure mileage was approximately 142,622.
No injuries · No fire · No crash
In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17th 2023 to replace the failed ABS module. Hyundai Corporate has twice denied reimbursement, arguing that Recall 251 only covers a multi-fuse replacement and claiming internal fluid leaks are not covered. This contradicts NHTSA 23V-651 documentation, which explicitly identifies internal ABS module fluid leaks and electrical shorts as the core safety defect. Installing a fuse current-limiter cannot repair an already-ruined ABS circuit board or resolve a safety-mandated Limp Mode. I am reporting this to document on the official public record that Hyundai is actively denying reimbursement for the exact root-cause failure identified in NHTSA Campaign 23V-651. PLEASE NOTE: This report is submitted solely to document Hyundai Motor America's non-compliance and improper reimbursement denial for official record-keeping under Campaign 23V-651. I do not require follow-up contact from NHTSA regarding this submission.
No injuries · No fire · No crash