Hyundai Ioniq Service Bulletins

124 manufacturer communications on file.

November 7, 2019•Document ID: 10169373
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM
Mfr Comm. #:
19-01-036H
Date Added:
December 16, 2019
Manufacturer:
HYUNDAI
Summary
Certain vehicles may incur dash warning light(s) On with DTC(s) stored including either of the following DTC: ? U1116 - Lost Communication With Motor Electronics Coolant Pump (C-CAN) ? U1118 - Lost Communication With Hybrid/EV Battery Electronic Coolant Pump (P-CAN) The vehicle may operate in limp home at a reduced power. The above DTC(s) may occur due to coolant leaking into the Electric Water Pump (EWP) Can Case and may have an intermittent electrical connection. This bulletin provides instructions to inspect the vehicle?s EWP assembly. The Can Case of the EWP or the full EWP Assembly will be replaced depending on the EWP inspection result. The EWP?s connector may also need to be replaced with a wiring harness kit if contamination is confirmed. Perform the inspection procedure as outlined on page-7.
Associated Products (2)
2019 Hyundai Ioniq 2019 Hyundai Kona
Associated Documents
- Download MC-10169373-0001.pdf↗
November 4, 2019•Document ID: 10169370
Service Bulletin/Repair Instructions
BACK OVER PREVENTION; LANE DEPARTURE
Mfr Comm. #:
19-BE-011H-1
Date Added:
December 16, 2019
Manufacturer:
HYUNDAI
Summary
The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects vehicles within the blind spot zone and gives off an alarm (visual and audible). The two magnetic radar sensors provide these functions for BSD/BCW: ? Senses other vehicles in the BSD/BCW zone and turns on the BSD/BCW warning lamp for the driver. The warning lamp starts blinking, along with an audible sound, when the driver turns on the turn signal lamp to enter the lane where another vehicle is driving.
Associated Products (246)
2020 Hyundai Elantra 2020 Hyundai Palisade 2020 Hyundai Veloster 2020 Hyundai Venue 2019 Genesis G70 2019 Genesis G80 2019 Genesis G90 2019 Hyundai Accent 2019 Hyundai Elantra 2019 Hyundai Elantra GT 2019 Hyundai Ioniq 2019 Hyundai Kona 2019 Hyundai Nexo 2019 Hyundai Santa Fe 2019 Hyundai Sonata 2019 Hyundai Tucson 2019 Hyundai Veloster 2018 Genesis G80 2018 Genesis G90 2018 Hyundai Accent+ 226 more
Associated Documents
- Download MC-10169370-0001.pdf↗
October 28, 2019•Document ID: 10167770
Service Bulletin/Repair Instructions
EQUIPMENT ADAPTIVE/MOBILITY; ENGINE; EQUIPMENT
Mfr Comm. #:
Campaign T4C Dea
Date Added:
November 18, 2019
Manufacturer:
HYUNDAI
Summary
Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
Associated Products (3)
2019 Hyundai Ioniq 2018 Hyundai Ioniq 2017 Hyundai Ioniq
Associated Documents
- Download MC-10167770-0001.pdf↗
October 28, 2019•Document ID: 10167766
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM; EQUIPMENT ADAPTIVE/MOBILITY; ENGINE
Mfr Comm. #:
19-01-030H
Date Added:
November 18, 2019
Manufacturer:
HYUNDAI
Summary
Certain 2017-2019 vehicles may experience check engine light ?ON? with the following DTC stored: ? DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are subject to marine layer cloud cover. Salt particulate deposit can form inside the Natural Vacuum Leak Detection (NVLD) which may cause intermittent operation prompting the DTC P0456 and the check engine light ?ON?. This bulletin provides the procedure to install a new Air Filter Kit with an updated filter to help prevent entry of the salt particulates. In addition, vehicles with check engine light ?ON? and DTC P0456 found stored in the Engine Control Module (ECM) must also replace the NVLD part.
Associated Products (3)
2019 Hyundai Ioniq 2018 Hyundai Ioniq 2017 Hyundai Ioniq
Associated Documents
- Download MC-10167766-0001.pdf↗
October 28, 2019•Document ID: 10167270
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING
Mfr Comm. #:
Campaign T4C Dea
Date Added:
November 6, 2019
Manufacturer:
HYUNDAI
Summary
Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
Associated Products (3)
2019 Hyundai Ioniq 2018 Hyundai Ioniq 2017 Hyundai Ioniq
Associated Documents
- Download MC-10167270-0001.pdf↗
October 28, 2019•Document ID: 10167262
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING
Mfr Comm. #:
19-01-030H
Date Added:
November 6, 2019
Manufacturer:
HYUNDAI
Summary
"Certain 2017-2019 vehicles may experience check engine light Ã¢ÂÂONÃ¢ÂÂ with the following DTC stored: DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are subject to marine layer cloud cover. Salt particulate deposit can form inside the Natural Vacuum Leak Detection (NVLD) which may cause intermittent operation prompting the DTC P0456 and the check engine light Ã¢ÂÂONÃ¢ÂÂ. This bulletin provides the procedure to install a new Air Filter Kit with an updated filter to help prevent entry of the salt particulates. In addition, vehicles with check engine light Ã¢ÂÂONÃ¢ÂÂ and DTC P0456 found stored in the Engine Control Module (ECM) must also replace the NVLD part."
Associated Products (3)
2019 Hyundai Ioniq 2018 Hyundai Ioniq 2017 Hyundai Ioniq
Associated Documents
- Download MC-10167262-0001.pdf↗
October 18, 2019•Document ID: 10167763
Service Bulletin/Repair Instructions
EQUIPMENT:ELECTRICAL; EQUIPMENT
Mfr Comm. #:
19-BE-015H-1
Date Added:
November 18, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin contains information regarding the clock display on certain Navigation (AVN 4.0) head units. This procedure is specifically for the clock date and time not displaying which started appearing around August 17, 2019. Other similar concerns which were opened before this date are a different root cause and will not be resolved by this information. An example of the clock concern is shown in the screenshot below:
Associated Products (21)
2018 Hyundai Elantra 2018 Hyundai Ioniq 2018 Hyundai Santa Fe 2018 Hyundai Santa Fe Sport 2017 Hyundai Azera 2017 Hyundai Elantra 2017 Hyundai Elantra GT 2017 Hyundai Santa Fe 2017 Hyundai Santa Fe Sport 2017 Hyundai Sonata 2017 Hyundai Tucson 2017 Hyundai Veloster 2016 Hyundai Azera 2016 Hyundai Elantra GT 2016 Hyundai Genesis 2016 Hyundai Sonata 2016 Hyundai Tucson 2016 Hyundai Veloster 2015 Hyundai Azera 2015 Hyundai Genesis+ 1 more
Associated Documents
- Download MC-10167763-0001.pdf↗
October 18, 2019•Document ID: 10167257
Service Bulletin/Repair Instructions
EQUIPMENT ADAPTIVE/MOBILITY
Mfr Comm. #:
19-BE-015H-1
Date Added:
November 6, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin contains information regarding the clock display on certain Navigation (AVN 4.0) head units. This procedure is specifically for the clock date and time not displaying which started appearing around August 17, 2019. Other similar concerns which were opened before this date are a different root cause and will not be resolved by this information. An example of the clock concern is shown in the screenshot below:
Associated Products (19)
2018 Hyundai Elantra 2018 Hyundai Ioniq 2018 Hyundai Santa Fe 2018 Hyundai Santa Fe Sport 2017 Hyundai Azera 2017 Hyundai Elantra 2017 Hyundai Elantra GT 2017 Hyundai Santa Fe 2017 Hyundai Santa Fe Sport 2017 Hyundai Sonata 2017 Hyundai Tucson 2016 Hyundai Azera 2016 Hyundai Elantra GT 2016 Hyundai Genesis 2016 Hyundai Sonata 2016 Hyundai Tucson 2015 Hyundai Azera 2015 Hyundai Genesis 2015 Hyundai Sonata
Associated Documents
- Download MC-10167257-0001.pdf↗
October 14, 2019•Document ID: 10167253
Service Bulletin/Repair Instructions
EQUIPMENT ADAPTIVE/MOBILITY
Mfr Comm. #:
19-GI-006H
Date Added:
November 6, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and matched with a Techline Case number.
Associated Products (226)
2020 Hyundai Elantra 2020 Hyundai Palisade 2019 Genesis G70 2019 Genesis G80 2019 Genesis G90 2019 Hyundai Accent 2019 Hyundai Elantra 2019 Hyundai Elantra GT 2019 Hyundai Ioniq 2019 Hyundai Kona 2019 Hyundai Nexo 2019 Hyundai Santa Fe 2019 Hyundai Sonata 2019 Hyundai Tucson 2019 Hyundai Veloster 2018 Genesis G80 2018 Genesis G90 2018 Hyundai Accent 2018 Hyundai Elantra 2018 Hyundai Elantra GT+ 206 more
Associated Documents
- Download MC-10167253-0001.pdf↗
August 13, 2019•Document ID: 10165461
Service Bulletin/Repair Instructions
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Mfr Comm. #:
Campaign T3U Dea
Date Added:
September 30, 2019
Manufacturer:
HYUNDAI
Summary
This service campaign provides information related to a BMS software update to the diagnostic logic for DTC P1B77 ? ?High Voltage Battery Pre-charging Fault?.
Associated Products (1)
2019 Hyundai Ioniq
Associated Documents
- Download MC-10165461-0001.pdf↗
August 13, 2019•Document ID: 10165457
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Mfr Comm. #:
19-01-023H
Date Added:
September 30, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin provides information related to a BMS (Battery Management System) software update to the diagnostic logic for DTC P1B77 ? ?High Voltage Battery Precharging Fault?.
Associated Products (1)
2019 Hyundai Ioniq
Associated Documents
- Download MC-10165457-0001.pdf↗
July 10, 2019•Document ID: 10163863
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM; EQUIPMENT
Mfr Comm. #:
19-EE-001H-1
Date Added:
August 19, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin provides information on how to return a Hyundai HEV/PHEV/EV/Fuel Cell Lithium Battery for proper disposal and safe environmental recycling using Hyundai?s authorized vendor Kinsbursky Brothers Intl. (KBI).
Associated Products (17)
2019 Hyundai Ioniq 2019 Hyundai Kona 2019 Hyundai Nexo 2019 Hyundai Sonata 2018 Hyundai Ioniq 2018 Hyundai Sonata 2017 Hyundai Ioniq 2017 Hyundai Sonata 2017 Hyundai Tucson 2016 Hyundai Sonata 2016 Hyundai Tucson 2015 Hyundai Sonata 2015 Hyundai Tucson 2014 Hyundai Sonata 2013 Hyundai Sonata 2012 Hyundai Sonata 2011 Hyundai Sonata
Associated Documents
- Download MC-10163863-0001.pdf↗
May 16, 2019•Document ID: 10161751
Service Bulletin/Repair Instructions
LANE DEPARTURE; FORWARD COLLISION AVOIDANCE
Mfr Comm. #:
19-BE-009H
Date Added:
July 1, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin provides information for troubleshooting of the Blind-Spot Collision Warning (BCW/BSD) system whenever it exhibits Diagnostic Trouble Code (DTC) C120B/D or C160A.
Associated Products (23)
2019 Hyundai Ioniq 2019 Hyundai Sonata 2019 Hyundai Tucson 2018 Hyundai Ioniq 2018 Hyundai Santa Fe 2018 Hyundai Santa Fe Sport 2018 Hyundai Sonata 2018 Hyundai Tucson 2017 Hyundai Ioniq 2017 Hyundai Santa Fe 2017 Hyundai Santa Fe Sport 2017 Hyundai Sonata 2017 Hyundai Tucson 2016 Hyundai Santa Fe 2016 Hyundai Santa Fe Sport 2016 Hyundai Sonata 2016 Hyundai Tucson 2015 Hyundai Santa Fe 2015 Hyundai Santa Fe Sport 2014 Hyundai Santa Fe+ 3 more
Associated Documents
- Download MC-10161751-0001.pdf↗
April 23, 2019•Document ID: 10160149
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Mfr Comm. #:
19-EE-002H
Date Added:
May 20, 2019
Manufacturer:
HYUNDAI
Summary
The following summarizes the service procedure for EV battery replacement:
Associated Products (4)
2019 Hyundai Ioniq 2019 Hyundai Kona 2018 Hyundai Ioniq 2017 Hyundai Ioniq
Associated Documents
- Download MC-10160149-0001.pdf↗
April 23, 2019•Document ID: 10160148
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Mfr Comm. #:
19-EE-003H
Date Added:
May 20, 2019
Manufacturer:
HYUNDAI
Summary
The following summarizes the service procedures for Lithium Battery replacement:
Associated Products (13)
2019 Hyundai Ioniq 2019 Hyundai Nexo 2019 Hyundai Sonata 2018 Hyundai Ioniq 2018 Hyundai Sonata 2017 Hyundai Ioniq 2017 Hyundai Sonata 2016 Hyundai Sonata 2015 Hyundai Sonata 2014 Hyundai Sonata 2013 Hyundai Sonata 2012 Hyundai Sonata 2011 Hyundai Sonata
Associated Documents
- Download MC-10160148-0001.pdf↗
April 22, 2019•Document ID: 10160106
Service Bulletin/Repair Instructions
STEERING
Mfr Comm. #:
19-ST-001H
Date Added:
May 20, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
Associated Products (67)
2019 Hyundai Elantra 2019 Hyundai Elantra GT 2019 Hyundai Ioniq 2019 Hyundai Kona 2019 Hyundai Santa Fe 2019 Hyundai Sonata 2019 Hyundai Tucson 2019 Hyundai Veloster 2018 Hyundai Elantra 2018 Hyundai Elantra GT 2018 Hyundai Ioniq 2018 Hyundai Kona 2018 Hyundai Santa Fe 2018 Hyundai Santa Fe Sport 2018 Hyundai Sonata 2018 Hyundai Tucson 2017 Hyundai Accent 2017 Hyundai Azera 2017 Hyundai Elantra 2017 Hyundai Ioniq+ 47 more
Associated Documents
- Download MC-10160106-0001.pdf↗
April 19, 2019•Document ID: 10160102
Service Bulletin/Repair Instructions
ENGINE; ENGINE AND ENGINE COOLING
Mfr Comm. #:
19-HA-001H
Date Added:
May 20, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin provides additional service diagnostic information and repair procedures related to electric A/C compressors equipped in hybrid electric vehicles, plug-in hybrid electric vehicles, and electric vehicles.
Associated Products (17)
2019 Hyundai Ioniq 2019 Hyundai Kona 2019 Hyundai Nexo 2019 Hyundai Sonata 2018 Hyundai Ioniq 2018 Hyundai Sonata 2017 Hyundai Ioniq 2017 Hyundai Sonata 2017 Hyundai Tucson 2016 Hyundai Sonata 2016 Hyundai Tucson 2015 Hyundai Sonata 2015 Hyundai Tucson 2014 Hyundai Sonata 2013 Hyundai Sonata 2012 Hyundai Sonata 2011 Hyundai Sonata
Associated Documents
- Download MC-10160102-0001.pdf↗
April 15, 2019•Document ID: 10160098
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM; POWER TRAIN
Mfr Comm. #:
19-FL-003H
Date Added:
May 20, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Once the VIN has been programmed to the ECM/PCM, it cannot be removed or overwritten.
Associated Products (166)
2019 Genesis G70 2019 Genesis G80 2019 Genesis G90 2019 Hyundai Accent 2019 Hyundai Elantra 2019 Hyundai Elantra GT 2019 Hyundai Ioniq 2019 Hyundai Kona 2019 Hyundai Nexo 2019 Hyundai Santa Fe 2019 Hyundai Sonata 2019 Hyundai Tucson 2019 Hyundai Veloster 2018 Genesis G80 2018 Genesis G90 2018 Hyundai Accent 2018 Hyundai Elantra 2018 Hyundai Elantra GT 2018 Hyundai Ioniq 2018 Hyundai Kona+ 146 more
Associated Documents
- Download MC-10160098-0001.pdf↗
March 13, 2019•Document ID: 10158803
Service Bulletin/Repair Instructions
VISIBILITY:REARVIEW MIRRORS/DEVICES; VISIBILITY
Mfr Comm. #:
19-BE-004H
Date Added:
April 22, 2019
Manufacturer:
HYUNDAI
Summary
This bulletin provides information on the serviceable parts for the outside mirror assembly. When diagnosing and repairing the outside mirror, do not replace the entire assembly. Refer to page 2 of this TSB for replacement of individual parts.
Associated Products (71)
2019 Hyundai Elantra 2019 Hyundai Elantra GT 2019 Hyundai Ioniq 2019 Hyundai Kona 2019 Hyundai Santa Fe 2019 Hyundai Veloster 2018 Hyundai Elantra 2018 Hyundai Elantra GT 2018 Hyundai Ioniq 2018 Hyundai Kona 2018 Hyundai Santa Fe 2018 Hyundai Santa Fe Sport 2018 Hyundai Sonata 2018 Hyundai Tucson 2017 Hyundai Accent 2017 Hyundai Azera 2017 Hyundai Elantra 2017 Hyundai Ioniq 2017 Hyundai Santa Fe 2017 Hyundai Santa Fe Sport+ 51 more
Associated Documents
- Download MC-10158803-0001.pdf↗
February 12, 2019•Document ID: 10154676
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM
Mfr Comm. #:
19-BE-003H
Date Added:
March 18, 2019
Manufacturer:
HYUNDAI
Summary
Some vehicles equipped with the wireless charging pad may experience a no charging condition. This bulletin provides information of how to diagnose the no charging condition.
Associated Products (14)
2019 Hyundai Elantra 2019 Hyundai Elantra GT 2019 Hyundai Ioniq 2019 Hyundai Kona 2019 Hyundai Sonata 2019 Hyundai Veloster 2018 Genesis G80 2018 Genesis G90 2018 Hyundai Elantra GT 2018 Hyundai Ioniq 2018 Hyundai Kona 2018 Hyundai Sonata 2017 Genesis G90 2017 Hyundai Ioniq
Associated Documents
- Download MC-10154676-0001.pdf↗

← Back to Hyundai Ioniq