Filing as a proactive data point for the ongoing NHTSA Office of Defects Investigation Engineering Analysis (EA26005) regarding GM 6.2L L87 engine failures. Vehicle is a 2026 GMC Yukon XL AT4 equipped with the 6.2L V8 and 10-speed transmission. The vehicle currently has approximately 2,800 miles and operates perfectly with no mechanical symptoms, ticking, or loss of propulsion. As an active preventive measure against internal component contamination, early engine oil changes were performed at 700 miles and 1,700 miles by a certified franchise dealer (Alpine Buick GMC). The engine continues to use the factory-specified 0W-20 oil viscosity. A magnetic oil drain plug has been installed to monitor for premature ferrous bearing and crankshaft debris at future service intervals. This report is submitted to ensure 2026 model year data running 0W-20 oil is officially documented within the federal investigation scope.
No injuries · No fire · No crash
Engine blew at 8,762 miles in the middle of the night with 3 small kids in the car. Currently 41 days waiting for a new engine. We were driving and it started making a clapping sound like something was caught underneath. We had to drive a could miles to find a safe place to pull over. If we increased speed, the clapping increased and it slowed when we slowed. Hauled it to the local dealership and they said it was the engine. The dealership it was purchased at says the same thing. There was no warning. After a couple of miles of the clicking/clamping sound, the car started to shake and then died. There were no warnings or light on the dash of any signs of distress until it died. It was a couple of miles before we even had a safe place to pull over on the side of the highway. Going 70mph on a highway that is posted to be 70mph with 3 kids in the car, in the middle of the night, put my family’s life in danger along with other cars behind us. Clearly safety and quality isn’t GM’s top priority. This is our 5th Yukon. Our 13th General Motors vehicle. To say we are disappointed is an understatement when we have been devoted to GM for over a decade.
No injuries · No fire · No crash
I purchased my vehicle from GMC on April 13th and had approximately 4,500 miles on it. It was sold as new and drove it for about a week at 4,994 miles on the highway. During this time, it shifted from drive to neutral , but the vehicle was towed back to the dealership. Upon inspection, it was diagnosed with a seized engine.
No injuries · No fire · No crash
This is a follow-up to my previous complaint - 11716917. My second engine, which was installed after my first engine failed after approximately 5,000 miles, also failed. It failed after approximately 5,200 miles on it. I picked up the vehicle after the first engine replacement on 2/19/26 and the second engine failed on 5/18/26. It failed as I was driving to work - I was able to exit the highway and pull into a parking lot. From there I had the vehicle towed to a dealership and they confirmed that the engine had failed and needed a total replacement. This is a 2026 Yukon XL Denali Ultimate with the 6.2 L87 engine. I want to make sure the NHTSA is aware that I’ve now had two complete engine failures and am on my third. I have no confidence in the vehicle and have no reason to believe that my third engine will last. GM has refused to do anything about this vis-a-vis extending my warranty or replacing my vehicle or buying it back.
No injuries · No fire · No crash
9 months into ownership, with 24,000 miles I had complete engine failure pulling into an intersection. Slamming into park while moving and shutting down. This is a known issue with the GM 6.2 liter engines but I specifically waited to order a 2026 as this was far outside the recall window GM had in place for this known issue and was led to believe the issue was fixed going forward. The car was towed to a GM dealer and sat for 39 days for a complete engine replacement. Now, a week after it has been returned it has sputtered and shut off as I am coming to a stop requiring a restart, not unlike stalling a manual transmission car. I think your agency needs to expand the investigation far further to include 2026 models. This is a 90,000 dollar brand new family hauler that I am supposed to trust my wife and kids are safe in. Now I cannot even trust it will safely take her through an intersection. Thank you for your time.
No injuries · No fire · No crash