Freightliner · Model Report
Showing safety data for the 2004 model year only.
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.
DAIMLER TRUCKS IS RECALLING MODEL YEAR 2004-2010 TRUCKS EQUIPPED WITH CATERPILLAR C15 ENGINE. THE VARIABLE VALVE ACTUATION OIL LINE MAY RUB AGAINST THE P-CLIPS RETAINING THE OIL LINE, CAUSING AN OIL LEAK.
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE VARIABLE VALVE ACTUATION OIL LINE MAY WEAR AGAINST THE SHARP EDGE OF THE CYLINDER HEAD IF NOT POSITIONED CORRECTLY.
PERSONAL FRIEND/TRUCK DRIVER WAS DRIVING 2004 FREIGHTLINER COLUMBIA WITH MERCEDES ENGINE ON INTERSTATE HIGHWAY. OTHER MOTORIST SAW HIM DRIVING ERRATICALLY, AND CALLED POLICE. DASH CAMERA RECORDS HIM WEAVING IN THE ROAD AND FINALLY VEERING INTO ONCOMING LANE, CRASHING INTO CONCRETE BARRIER. IMPACT WITH THE WALL CAUSES FUEL TANK TO SEPARATE FROM CAB, CAUSING SMALL FIRE WHICH DID NOT BURN DRIVER OR CAB. DRIVER WAS PRONOUNCED DEAD AT THE SCENE. AUTOPSY REVEALED SIGNIFICANTLY HIGH LEVEL OF CO IN BLOOD (61-65 %), BUT NO HEART ATTACK OR STROKE OR ANY OTHER NATURAL CAUSE. DEATH IS RULED ACCIDENTAL. FORTUNATELY, THERE WERE NO OTHER SERIOUS INJURIES, BUT MANY OTHERS COULD HAVE BEEN KILLED. THERE IS APPARENTLY A PROBLEM WITH THE EXHAUST SYSTEM ON THIS VEHICLE, AND OTHERS WILL DIE UNLESS THIS PROBLEM IS CORRECTED. *TR
2004 FREIGHTLINER COLUMBIA CONVENTIONAL TIRE BLOW OUT. CONSUMER STATED THAT WHEN THE TIRE BLEW OUT IT CAUSED THE SECOND TRAILER TO HIT A GUARDRAIL IN TWO LOCATIONS. *KB OHIO TRAFFIC CRASH REPORT # 10-0013-89. *JB
2004 FREIGHTLINER COLUMBIA CAUGHT FIRE UNDER THE HOOD. *KB ACCORDING TO THE REPORT, THE FIRE STARTED DUE TO A POSSIBLE SHORT IN THE WRING. OHIO TRAFFIC CRASH REPORT *JB
I HAVE A FREIGHTLINER COLUMBIA WITH A MBE 4000 MERCEDES ENGINE. THIS IS THE SECOND TIME I HAD TO PUT THE TRUCK IN A SHOP FOR AN EXHAUST LEAK. THIS TIME THE EXHAUST MANIFOLD WAS LEAKING FUMES INTO THE CAB AND MADE ME SICK WITH CARBON MONOXIDE. TOOK TRUCK TO PENN DETROIT DIESEL IN YORK HAVEN,PA. THEY FOUND THAT THE EXHAUST MANIFOLD WAS OFF ON PORT #1 AND #2 BY 1/16 INCH THERE BY ALLOWING EXHAUST FUMES TO ESCAPE AND ENTER THE CAB THROUGH THE FRESH AIR VENT THAT IS UNDER THE HOOD OF THE TRUCK. THEY CHECKED FOR EXHAUST LEAKS AFTER THE WORK WAS DONE AND SAID IT WAS FIXED. I THEN HOOKED UP TO MY TRAILER AND DID MY WALK AROUND AND SMELLED A STRONG ODOR OF EXHAUST COMING FROM THE FRONT OF THE TRUCK. I WHEN BACK IN AND REPORTED THIS AND THEY SAID THAT IT WAS THE OIL BURNING OFF THE MANIFOLD. I AM STILL GETTING CO IN THE TRUCK. WILL THIS END WHEN I DIE OR KILL SOMEONE ELSE??ANY HELP ON THIS MATTER WOULD BE GRATEFUL!!!! *NM
HAVE FREIGHTLINER COLUMBIA WITH AN MBE 4000 MERCEDES. HAD FLEX PIPE THAT WAS CRACKED LETTING IN CO FUMES. HAD THIS REPLACED BUT AM STILL GETTING LOW LEVELS OF CARBON MONOXIDE IN TRUCK. IT SEAMS TO BE COMING IN THROUGH THE AIR CONDITIONING AND HEATER VENTS. JFB. *NM
No injuries · No fire · No crash