Ford Mustang Complaints (2006)

575 consumer complaints on file.

#10158279May 25, 2006
SUSPENSION
AFTER VEHICLE SPENT NEARLY TWO MONTHS IN THE SHOP DUE TO BALL JOINT ASSEMBLY FAILURE THE CAR WAS PUT BACK INTO MY POSSESSION. I DROVE THE CAR FROM THE DEALER THAT IT WAS PURCHASED FROM TO HOME, APPROXIMATELY 300 MILES. I NOTICED A RUBBING NOISE STILL COMING FROM THE FRONT END OF THE VEHICLE. AFTER 1 DAY OF THE CAR BEING IN MY POSSESSION I HEARD A RATTLING SOUND COMING FROM THE REAR END OF THE CAR. MOSTLY GOING OVER SMALL BUMPS AT LOW SPEEDS. NEEDLESS TO SAY I HAVE HAD THE VEHICLE FOR 5 MONTHS AND I HAVE SPENT MORE TIME DRIVING MY 2001 ESCORT THAN I HAVE MY 2006 GT. SAD BUT TRUE THE ESCORT NEARLY $20,000 LESS THAN THE GT IS SAFER AND MORE RELIABLE THAN MY BRAND NEW OFF THE LINE VEHICLE HAS BEEN. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10157818May 18, 2006
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
MY BRAND NEW 2006 FORD MUSTANG GAS TANK IS DIFFICULT AND IMPOSSIBLE TO FILL FULL. I TOOK CAR TO DEALER AND THEY SAID THEY CAN NOT REPAIR IT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10157493May 13, 2006
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY, FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
POTENTIAL FIRE HAZARD. CAN NOT FUEL VEHICLE. AFTER APPROXIMATELY 1/2 TANK, GAS STATION FUEL NOZZLE SHUT OFF. TRIED SLIGHTLY ENGAGING NOZZLE, AND CONTINUED TO SHUT OFF. AFTER MULTIPLE TRIES AND MULTIPLE GAS STATIONS, COULD FILL TANK TO 3/4 TANK, THEN SHUT OFF RECURRED. WILL NO LONGER ACCEPT FUEL. FUEL SPILLAGE OCCURRED ON ALMOST ALL SHUT OFF INCIDENTS, NO MATTER WHAT PRESSURE FUEL WAS TRANSFERRED AT (BY REGULATING HANDLE). AFTER RESEARCH ON INTERNET, FOUND MANY OTHER OWNERS COMPLAINING OF SAME ISSUE (SEE ALLFORDMUSTANG.COM'S 2005+ FORUMS) WITH SOME HAVING RESOLVE AFTER TANK AND / OR FILLER TUBE /VENT REPLACEMENT. TRIED THEIR SUGGESTION OF PLACING NOZZLE IN DIFFERENT DIRECTIONS DID NOT HELP. ALSO REFERENCE FORD SERVICE BULLETIN 06313 (NHTSA ITEM NUMBER 10019387) TAKING TO DEALERSHIP TOMORROW. NOT THE FIRST OCCURRENCE ON THIS VEHICLE. HAS SHUT OFF BEFORE PREMATURELY, BUT HAS ALWAYS RESTARTED WITH NO SPILLAGE / RECURRING. VEHICLE ONLY HAS 1200 MILES ON IT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155529April 17, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
TOOK DELIVERY OF MUSTANG PREMIUM CONVERTIBLE (V6) ON 1/6/2006. DROVE HOME 17 MILES. WHILE ACCELERATING FROM A FULL STOP AND TURNING ONTO SIDE STREET, THE ENGINE APPEARED TO ACCELERATE AND THEN STOPPED IN THE MIDDLE OF THE TURN IN THE MIDDLE OF ONCOMING TRAFFIC. FORTUNATELY NO ACCIDENT OCCURRED. DURING SUBSEQUENT DRIVES, ENGINE APPEARS TO ACCELERATE FROM A FULL STOP BUT THEN STALLS. IF ACCELERATOR IS PRESSED QUICKLY ENOUGH, THE ENGINE DOES NOT STOP; HOWEVER, IT MAY EXHIBIT THE STALL A SECOND TIME. DEALER INDICATES THAT NO INFORMATION IS RECORDED ON COMPUTER INDICATING REASON FOR FAILURE. THEY CANNOT DUPLICATE THE FAILURE. NEXT STEP IS TO INSTALL A "BLACK BOX" TO RECORD EVENT ACTIVITY DURING THE STALL. THIS DOES NOT OCCUR WHEN THE ENGINE IS COLD. IT ALSO IS VERY INTERMITTENT BUT, IF IT IS GOING TO HAPPEN, IT WILL BE FOLLOWING A FULL STOP. I DO NOT FEEL SAFE IN THIS VEHICLE. THE FAILURE CAN OCCUR DURING A TURN ACROSS TRAFFIC OR WHILE MOVING STRAIGHT AHEAD FROM THE STOP - EITHER OF WHICH COULD RESULT IN AN ACCIDENT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155537April 17, 2006
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
WHEN FILING GAS TANK WITH THE FUEL NOZZLE SET FOR FAST DELIVERY, THE GAS OVERFLOWS ONTO THE CAR. IT DOES NOT TRIGGER THE AUTOMATIC SHUTOFF ON THE FUEL NOZZLE. DEALER INDICATED THAT THIS IS THE "NEW" TANK DESIGN WHICH CONSISTS OF TWO CHAMBERS. THE RIGHTMOST CHAMBER FILLS FIRST AND THEN OVERFLOWS INTO THE SECOND CHAMBER. THIS HAS OCCURRED AT SEVERAL DIFFERENT GAS SUPPLIERS, DIFFERENT BRANDS, AND EVEN DIFFERENT STATES. THE ONLY WAY TO GUARANTEE THAT THERE WILL NOT BE OVERFLOW ONTO THE CAR IS TO CHECK THE GALLONS USED AND SLOW DOWN THE FLOW SO THAT THE NOZZLE TRIGGER GETS TRIPPED. DEALER HAS NO FIX FOR THE PROBLEM AT THIS TIME. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155364April 14, 2006
SERVICE BRAKES, HYDRAULIC
DT*: THE CONTACT STATED THE BRAKES HAVE NOT STOPPED THE VEHICLE ON THREE SEPARATE OCCASIONS. THIS OCCURRED AT NO PARTICULAR SPEED AND WITH NO WARNING. THE DEALERSHIP WAS UNABLE TO DETERMINE A PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155220April 12, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED WHILE EXITING THE INTERSTATE, AFTER DECELERATING, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE LOST POWER. THE VEHICLE HESITATED THEN SUDDENLY SURGED FORWARD. THIS OCCURRED ON THREE OCCASIONS, THE DEALERSHIP WAS UNABLE TO DETERMINE A PROBLEM. UPDATED 5/2/2006 - EACH TIME THIS PROBLEM OCCURRED THE VEHICLE HAD BEEN DRIVING AT HIGHWAY SPEED FOR OVER 2 HOURS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10153664March 24, 2006
STRUCTURE:BODY:TRUNK LID, STRUCTURE
STRESS FRACTURES ON FORWARD FACE OF REAR SPOILER ATTACH STRUTS (BOTH MOUNTS). VEHICLE LESS THEN A MONTH OLD WITH LESS THEN 600 MILES. 2006 FORD MUSTANG GT. NO APPARENT REASON FOR CRACKS IN COMPOSITE SPOILER. CRACKS ARE NOT SURFACE CRACKS (VERY DEEP) AND DO AFFECT SPOILER MOUNT INTEGRITY. FRACTURES ARE LOCATED ON THE FORWARD FACE / BOTTOM OF THE STRUTS, CENTERED AND STARTING AT FORWARD MOUNT BOLTS AND EXTENDING UPWARD. SUSPECT SPOILER ATTACH NUTS ON STUDS, OVER TORQUED DURING FACTORY INSTALLATION. MULTIPLE FISSURES EXTEND OVER TWO INCHES ON EACH STRUT AND MAY RESULT IN SPOILER DETACHING FROM TRUNK DECK LID. FORD DECLINED WARRANTY REPAIR, STATING CRACKS WERE CAUSED FROM "AN OUTSIDE SOURCE." FROM PERSONAL EXPERIENCE IN COMPOSITES, AS AN AIRCRAFT MECHANIC, SUSPECT STRESS FRACTURES FROM MOUNTING ERROR, EXPOSED VIA AIRFLOW OVER SPOILER, CREATING A DOWN FORCE AND OVER LOADING STRUT MOUNTS. TWO SEPARATE DEALER SERVICE DEPARTMENTS AGREED THAT FAILURE WAS CAUSED BY IMPROPER MOUNTING OF SPOILER AND NOT CAUSED BY OWNER. FORD WARRANTY DOES NOT AGREE, BUT DOES AGREE THAT SPOILER MUST BE REPLACED IF EXHIBITING THESE CRACKS AS THIS MAY CAUSE INJURY / DAMAGE TO OTHER PERSONS / VEHICLES AS SPOILER MAY DETACH WHILE VEHICLE IN MOTION. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10152927March 17, 2006
STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM
WHILE DRIVING AT 20-25 MPH GOING INTO A RIGHT HAND TURN THE CAR MADE A LOUD POP. THE LEFT REAR TIRE LOST CONTROL. THE REAR END WITH POWER ONLY ON THE GOOD WHEEL WAS LOSING CONTROL AND WITHIN A SECOND THE LEFT FRONT TIRE WAS OFF THE WHEEL. THE CAR WAS DRIVEN 1 CITY BLOCK TO THE CLOSEST PLACE TO PULL OFF THE ROAD. BOTH LEFT FRONT AND REAR WHEELS ARE DESTROYED FROM CRUNCHING ON THE CONCRETE THE ONE BLOCK OF DRIVING TO GET SAFELY OUT OF THE WAY OF TRAFFIC. ONCE STOPPED THE CAR COULD NOT BE DRIVEN. HAD TO CALL 24 HR ROADSIDE ASSISTANCE TO TOW THE VEHICLE. A PRELIMINARY LOOK AT A FORD SERVICE GARAGE FOUND THE FRONT LOWER CONTROL ARM TOTALLY SEPARATED FROM IT'S ATTACHMENT POINT. THE REAR SWAY BAR AND THE REAR AXLE HAD BEEN SHIFTED OUT OF POSITION ACCORDING TO THE MECHANIC. THIS CAR HAS BEEN DRIVEN UNDER NORMAL CONDITIONS, AVERAGING 33 OR SO MILES A DAY ON HIGHWAY, AND STATE MAINTAINED ROADS ONLY. THERE IS NO REASON I KNOW OF FOR THIS OUTSIDE OF A MANUFACTURER DEFECT IN THE ASSEMBLY OF THE VEHICLE. LOOKS LIKE A RECALL OF 2006 MUSTANG GT'S WOULD BE APPROPRIATE. HAD I BEEN ON THE INTERSTATE DRIVING AT HIGHWAY SPEEDS, I MAY NOT HAVE BEEN ALIVE TO FILE THIS COMPLAINT. I'M OUTRAGED TO SAY THE LEAST, BUT ALSO DISAPPOINTED. AGAIN, THE FACT THAT THE LEFT WHEELS WERE DESTROYED ALONG WITH THE TIRES WHILE MAKING A RIGHT HAND TURN HAS INDICATED TO ME THE VEHICLE PRESENTS A SAFETY HAZARD. THE CAR DID HAVE FACTORY INSTALLED TRACTION CONTROL WHICH I ASSUME MAY HAVE HELPED KEEP THE CAR FROM CRASHING INTO A HOUSE WHEN THE REAR END LOST CONTROL IN THE TURN. NEVERTHELESS IT IS A SAFETY HAZARD THAT I THINK ALL MUSTANG OWNERS OF THE 2006 GT SHOULD BE AWARE OF. FORD SHOULD BE MADE AWARE OF IT ALSO. THE FINAL ASSEMBLY LOCATION IS SHOWN AS FLATROCK MICHIGAN. I CAN'T SAY I HAVE ANY DESIRE TO DRIVE A MUSTANG EVER AGAIN, EVEN THOUGH THIS WAS THE FIRST ONE I HAVE BOUGHT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150461February 16, 2006
FUEL SYSTEM, GASOLINE:STORAGE
DT*: THE CONTACT STATED WHILE PUTTING FUEL IN THE VEHICLE THE FUEL NOZZLE MUST BE HELD IN A CERTAIN POSITION TO OBTAIN A CORRECT READING FROM THE FUEL GAUGE. BEFORE PUTTING FUEL INTO THE VEHICLE THE FUEL GAUGE READ HALF A TANK, WHILE ATTEMPTING TO PUT FUEL INTO THE VEHICLE IT SHOWED FULL. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, THEY REPLACED THE STORAGE TANK. HOWEVER, THIS DID NOT CORRECT THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150456February 16, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
2006 FORD MUSTANG EXHIBITING HESITATION UPON ACCELERATION ON FOUR DIFFERENT OCCASIONS WHILE PULLING OUT INTO TRAFFIC. FEELS AS IF CAR HAS STALLED THEN SLING SHOTS CAR INTO TRAFFIC. EACH INCIDENT NEARLY RESULTING IN ACCIDENTS. DEALERSHIP CAN'T DUPLICATE PROBLEM AND THEREFORE CAN'T MAKE ANY REPAIRS TO CAR. NO SENSOR ERRORS OR MESSAGES WHEN CHECKED, BUT OBVIOUSLY THERE IS A MALFUNCTION WITH ELECTRONIC &/OR SENSORS FROM GAS PEDAL TO ENGINE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150185February 13, 2006
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
I RECENTLY PURCHASED A 2006 MUSTANG AND ON THE TWO OCCASIONS I HAVE HAD TO PUT GAS IN THE TANK, BOTH TIMES PRIOR TO THE PUMP DISCHARGE SHUTTING OFF, FUEL HAS SPEWED OUT OF THE FILLER NECK AND DOWN THE SIDE OF THE CAR. I HAVE USED TWO DIFFERENT STATIONS WITH THE SAME RESULTS. I ALSO TALKED TO A COWORKER WHO OWNS A 2005 MUSTANG AND HE HAS THE SAME PROBLEM, AND ONLY AVOIDS THE PROBLEM BY PUTTING IN A FEW DOLLARS WORTH OF GAS AT A TIME. NEVER FILLING UP. I'M WORRIED THAT MY DAUGHTER WHO FREQUENTLY DRIVES THE CAR, COULD BE PLACED IN A BAD SITUATION SHOULD A FIRE BREAK OUT. ESPECIALLY WHEN IT GETS WARMER OUTSIDE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150066February 12, 2006
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
ON 2006 MUSTANG GT, EXPERIENCED ERRATIC FUEL GAUGE READING ONCE FUEL LEVEL DROPPED BELOW 1/2 TANK. EXPERIENCED FAILURE DURING INITIAL START OF VEHICLE FOR THE DAY. APPROX. 3/8 TANK AVAILABLE WHEN VEHICLE TURNED OFF PREVIOUS NIGHT. GAUGE READ "E" WITH "0 MILES TO EMPTY" ON DIGITAL DISPLAY. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10149691February 8, 2006
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
TRAVELING ON SATURDAY EVENING ON 2/4/06, ROADS SOMEWHAT SLICK, SNOW TURNING TO BLACK ICE ON ROAD. LOST CONTROL OF VEHICLE ON BLACK ICE DOING 30-35 MPH ON RESIDENTIAL STREET. CAR FISH TAILED HIT CURB WITH RIGHT REAR, WHICH SPUN CAR INTO ROADWAY, HIT RIGHT FRONT ON OPPOSITE CURB. CAR UNDER CONTROL AFTER THAT. LOST RIGHT REAR TIRE / WHEEL ASSEMBLY BROKE OFF THE AXLE-AT INITIAL IMPACT- HOWEVER NO DAMAGE TO TIRE, RIM SLIGHT DENT. AFTER ACCIDENT LOOKED AT AXLE-SEEMED POROUS, CONCERNED...POOR QUALITY, POOR MANUFACTURING. CONTACTED INSURANCE, TOWED VEHICLE TO DEALER. WAITING FOR ADJUSTER TO LOOK AT VEHICLE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147344January 10, 2006
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
DT*: THE CONTACT STATED WHEN ATTEMPTING TO FILL THE GAS TANK WITH GASOLINE, AND ONCE THE TANK IS HALF FULL, THE GAS WILL BACK UP THROUGH THE FILLER NECK AND SPILL OUT OF THE SPOUT ONTO THE VEHICLE. THIS IS INTERMITTENT IN NATURE. THE VEHICLE HAS BEEN SEEN BY A DEALER. THE DEALER DETERMINED THE FILLER NECK WAS FUNCTIONING NORMAL. HOWEVER, THE SERVICE DEPARTMENT INSTRUCTED THE CONTACT TO USE A DIFFERENT GAS STATION THAT OFFERED A DIFFERENT TYPE OF GAS PUMP NOZZLE. THE DEALER'S SERVICE DEPARTMENT SUSPECTED THE GAS PUMP WAS FORCING THE GASOLINE INTO THE TANK AT A HIGH RATE WHICH RESULTED IN THE LEAK. THE CONTACT DID AS INSTRUCTED BY THE DEALER, BUT WHEN ATTEMPTING TO FILL THE TANK, THE SAME PROBLEM OCCURRED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Mustang