Ford Maverick Complaints (2023)

348 consumer complaints on file.

#11626562November 21, 2024
ELECTRICAL SYSTEM
Factory Wireless charging station drops charging continuously and fails to charge phone.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625995November 18, 2024
ENGINE, POWER TRAIN
Loss of motive control ongoing issue. This is documented problem being investigated by NTHSA, R2Q4014. Functional issue: • Engine flips into Neutral unexpectedly. Vehicle coasts to a stop, where it flips into Park on its own. • Vehicle requires a restart to move gear out of Neutral. After restarting vehicle, vehicle can operate on limited power that maxes out at about 35 mph. Acceleration is dramatically reduced, gradually ramping up as the vehicle continues to drive — the acceleration pedal does not control speed. Coming to a complete stop while driving with the vehicle in this reduced power mode requires another gradual ramp up to speed, making typical street driving difficult because it may take 30-45 seconds for the vehicle to ramp up to adequate speed (ramp from zero to 35mph), frustrating other drivers behind he vehicle who may think the slow speed is intentional. • After the vehicle has sat powered down for a number of minutes, it can be started up again at full power. I have seen this refractory period as low as 15 minutes and as high at 45-ish minutes. This issue has happened to me multiple times, 9 as of last count. Ford has attempted a fix twice now, and the issue persists. I would be happy to discuss full experience and how Ford has responded, or rather not responded, with your investigative team. Thank you for looking into this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625620November 15, 2024
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
The wiring harness on this vehicle is made of a soy based material, I had a rodent chew through this coating and my wiring harness, it caused my rear turn signal to go out, I have a 3 year 36,000 mile bumper to bumper warranty on the vehicle but Ford does not cover this, you have to pay to have it fixed yourself and they replace it with the same material, I am worried that it will happen again and again I will have to pay to have it fixed, I feel that Ford should be responsible for this and have it fixed. I found out that Ford is not the only manufacturer that uses this product.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625172November 14, 2024
ELECTRICAL SYSTEM
The contact owns a 2023 Ford Maverick. The contact stated that on some occasions when the vehicle was started, there was an abnormal odor of overcharged battery in the cabin of the vehicle. The contact also stated on several occasions, the odor made his eyes swell with tears, especially in the hotter months of the year. The vehicle was taken to a dealer however, the failure could not be replicated; however, the mechanic observed the same odor of the overcharged battery. The dealer contacted the manufacturer and was advised that the odor was normal. The contact stated that manufacturer had stated that only two instances were reported and there would be no assistance. The failure mileage was approximately 24,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625202November 14, 2024
POWER TRAIN
Upon accelerating from about 40 to 50 mph violent shaking was occurring , took to dealership CV axels were found to be the problem and were replaced at 17,000 miles now at 29,000 miles they are doing the same thing and need to be replaced again took to dealership waiting on new CV axels to be replaced again
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623426November 4, 2024
SEATS
My wife and I were involved in an accident where we were stopped and a vehicle rear-ended us at approximately 45mph, centered on the rear of the truck. My wife was in the passenger seat and I was driving. My seat collapsed backwards completely, and my wife's seat collapsed within about 2 inches of the rear seat. When mine collapsed, the headrest came out most of the way, and I slid backwards, hitting the top, back of my head on the rear seat just below the head rest, breaking the skin and leaving a mark of blood visible in the photos.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11623206November 1, 2024
ENGINE, POWER TRAIN, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
On 1028/24, driving at approximately 55 mph in the right lane of a local highway, the front collision braking system engaged almost totally stopping my vehicle. There were no vehicles, animals, nor pedestrians in front of my vehicle. I was able to pull to the shoulder. The collection detection icon appeared on the screen, as well as the check engine light, and the wrench. Then a message saying collision warning system unavailable, then service vehicle immediately. The drive gear dial remained in drive (D) position and was flashing. From there, with my warning light activated, I was able to get the vehicle to go up to 25 mph in order to drive to the Ford dealership nearby. I was told by the service department that they operate on appointments only, I would "try to look at it soon." The Ford Pass App states a powertrain malfunction, pre-collision assist not available, and service engine soon warning. Even if the system resets itself when vehicle turned back on, it is totally unsafe to drive in traffic not knowing if these systems will unexpected fail again, causing an accident and injury. I understand that this problem has occurred with other drivers on this model in the recent past.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622853October 30, 2024
POWER TRAIN
CV axles failed prematurely, at 20,000 miles. Wheels and steering column vibration at highway speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622745October 30, 2024
SUSPENSION
The contact owns a 2023 Ford Maverick. The contact stated while driving approximately 65 MPH, there was a loud clucking sound coming from the front end of the vehicle. There were no warning lights illuminated. The vehicle was taken to the dealer and was diagnosed with a fractured front stabilizer and stabilizer link. The front stabilizer and stabilizer link were replaced, and the vehicle was repaired. The manufacturer had not been made aware of the failure. The failure mileage was 8,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620702October 18, 2024
FUEL/PROPULSION SYSTEM
This vehicle will reduce or cut throttle application/response relative to how many degrees the steering wheel is turning. When trying to pull out in traffic if you have the wheel turned beyond a set angle the throttle doesn't respond as expected and acceleration is greatly reduced. It will also cut the throttle if you pull out and then turn only to fully accelerate as the wheel is straightened out again. Two very dangerous examples I've experienced are 1: pulling onto a "freeway" that has a few side roads with perpendicular access. With the wheel turned the truck is very slow to accelerate when first pulling onto the expressway but suddenly will as the wheel is straightened. 2: When going across 2 lanes of traffic and making a turn to join traffic the truck will accelerate as expected across the first lanes, loose power as you turn, and then accelerate fully again as the wheel is straightened. While an argument could be made to just sit and wait until there is more time to join traffic, there are moments when being able to accelerate hard are necessary. This vehicle will either not accelerate or will reduce acceleration based on angles of steering. I believe this is a dangerous situation that most experienced drivers are not going to be expecting when they have to join fast moving traffic. Following web forums this is an issue other owners have experienced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619385October 11, 2024
ENGINE
The plastic cooling system overflow expansion tank sign is stress cracking in the inlet tubing at approximately 8K miles. It has gotten worse with my odometer at 12K now. I have not contacted Ford regarding a warranty replacement because they would just replace it with the same defective part. I have further investigated this issue and found several documented cases with complete failure of the tank at a little as 20 K miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617656October 2, 2024
BACK OVER PREVENTION
The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616612September 26, 2024
ELECTRICAL SYSTEM, LANE DEPARTURE: ASSIST, VEHICLE SPEED CONTROL
Vehicle was travelling on freeway at freeway speeds suddenly without notable cause the vehicle electrical stopped, giving multiple warning in succession, cutting speed rapidly to 35 mph, with no acceleration pedal response and an automatic speed of 35 on battery power with the ability to break, but with no control of speed and only regulated by break pedal. Pulled vehicle to side of road and put in park, parking break automatically engaged. Vehicle had alarms on all automatic systems being off. Turning vehicle on and off did not effect response. After checking engine visually, was able to turn vehicle on with no alarms or issues. This has happened in both my Mavericks and almost led to a fatal collision in the 2022 Maverick.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616721September 26, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I started the Car and it made loud boom boom sounds like as if I was at a loud concert for about 10 seconds. That stopped but then loud static or electrical sound continued even after car was turned off. Re started and the sound continued. The initial sound shook me and wife. Where wife refuses to get back in. Also the initial sound wife said she smelt smoke. I faintly smelled a burnt wire smell. The next day while driving the system made more of the static/ electrical noise and didn’t stop until I parked and shut off system for about 10 min. I will be taking truck into dealer ship tomorrow.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616308September 24, 2024
POWER TRAIN
The vehicle shakes during acceleration, specifically in the 40mph-65mph range. The shaking is worst around 55-60mph, especially—but not exclusively—when accelerating from a stop. The shaking does not occur at these speeds while coasting; acceleration prompts the issue. This is a known problem among 2022 Maverick owners, according to online forums including Maverick Truck Club, Reddit, and influencers on YouTube. Drivers widely report that the CV Axle is the culprit here, and report that replacing the CV Axle alleviates the shaking.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615969September 23, 2024
SERVICE BRAKES, BACK OVER PREVENTION: WARNINGS
pre collision assist stops working or false alert when driving around 25-35 miles i had the truck for about 15 months and had many issues with the pre - collision sensor / camera. i took the truck to the dealer and could not duplicate the issue or fix it the sensor show and sound the alarm about crash and no car close in the front of the truck. some times the alert sound when a car is parked on the side and i am driving in a small street i have the alert recorded in the ford mobile App also rear brake locks without pressing the pedal on highway driving
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614783September 16, 2024
POWER TRAIN
The contact owns a 2023 Ford Maverick. The contact stated while driving at an undisclosed speed, the transmission inadvertently shifted into neutral(N). There was no warning light illuminated. The failure recurred the next day while driving 70-75 MPH, and the vehicle lost motive power. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 12,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613769September 10, 2024
ENGINE
2023 Ford Maverick 2.0L engine current mileage 5300 Noticed oil leak on top of engine valve cover. Ford Mechanic stated there are (3) current service related engine leak issues with Maverick. (1) Plastic valve cover cracked (2) Turbo Oil leak (3) Timing Cover Leak. Mechanic stated a die test will need to be performed. After review of online forums, this appears to be a more common issue and can cause engine fire, especially since High Pressure fuel pump is also located on top of the engine. With Ford spreading repairs across three known issues, A recall investigation should be opened. Repair Sevice schedule for 9/19/24. Can provide repair invoices if desired after service. From research the valve cover, most likely culprit based on oil leak location, is a 2 week repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612721September 5, 2024
VISIBILITY/WIPER
Shortly after startup the infotainment screen on my Maverick froze. After shifting into reverse it was unable to display the reverse camera image. I attempted several shifts between Drive, Park, and Reverse and it remained frozen. I attempted a short key cycle, powering the truck down, including opening the drivers door in an attempt to cycle power to the infotainment and upon restart it remained frozen. After arriving at my destination and leaving the power off for 10-15 minutes it returned to normal behavior on the next key cycle. I have video of the failure occurring, including attempted solutions noted above.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612646September 4, 2024
ENGINE, UNKNOWN OR OTHER
I have just recently bought a brand new truck, a hybrid model. Not a single mile on it when I purchased it, and I strongly feel that I almost died or caused an accident, completely not my fault but the truck’s fault. This has happened on 3 separate occasions. The first two times, as I was driving up the highway on a mountain road, I lost power, but just kind of chalked it up to maybe the fuel sloshing around, and no other vehicles were around me. The third time, I was returning home from work, on a busy 4-lane highway that goes across the pass and over the mountains, I was in the left lane, a semi truck was to my right, and a semi truck was behind me, we were passing the slower truck that was on the right, and I was traveling at around 55 mph, the truck completely shut off and was flashing red at me to pull to the side of the road. I lost all power, the steering, gas, and everything was not working. I need to mention that I was in front of semi truck, a larger truck that cannot stop on a dime, so he had to swerve to miss me, as I did not have control of the truck. The slower truck went by me and there was a another pickup truck behind him, and there was a little bit of a gap between them, so I jerked the wheel over and drove into the ditch. It was absolutely frightening, and kind of switched something in my head that I was very close to causing a large crash and maybe a death, of myself or someone else. I was in the ditch and the truck would not start back up. Nothing worked. To add to that, I was in a spot of the mountains that I do not get cell phone service. So I popped the hood and just sat there trying to turn the ignition and start the vehicle. 30 minutes passed and I slammed the hood and got back inside the truck and this time the truck turned over, but it said it was running on electric only, and the check engine light was, so I was able to limp home which was about 30 miles away, driving 20-30 mph. It sent the codes to my phone and I contacted the dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick