Ford Maverick Complaints (2023)

348 consumer complaints on file.

#11717948February 13, 2026
POWER TRAIN
While driving highway speeds the vehicle suddenly lost power. Had to immediately pull to the shoulder of the highway with heavy traffic that got very close to my rear bumper due to the sudden decrease in speed. There was no advance warning of power loss. Upon stopping on the shoulder the vehicle was put in park and the key turned to the off position. After a short wait the ignition key was turned to the on position and was able to resume trip at highway speeds. Notified Ford close to my location and it was checked for fault codes and road tested with no defect found., Now concerned that the vehicle might fail again day or night leaving us stranded or causing a vehicle accident due to the sudden reduction in speed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717861February 13, 2026
ELECTRICAL SYSTEM
"2023 Ford Maverick Hybrid (VIN: [XXX] ). The vehicle has a chronic 12V parasitic drain defect. Authorized dealer Champaign Ford City provided false information, stating software was current when it was not. This led to a 100% discharge in freezing temperatures, requiring multiple jump-starts to reach the dealer. This discharge destroyed a high-quality owner-purchased AGM battery. Despite Safety Recall 25S02 mandating no-cost battery replacements for these vehicles, the dealer charged me for a Ford battery. Safety concern: Vehicle unreliability in sub-zero temperatures and dealer failure to adhere to federal recall reimbursement guidelines." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717721February 13, 2026
SUSPENSION, POWER TRAIN, VISIBILITY/WIPER
Vehicle "shakes and vibrates" when accelerating along with odd clicking noises when turning. The sunroof also leaks during car washes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716244February 6, 2026
STRUCTURE:BODY
Found Drivers door hard to open and close. Took vehicle to Body shop. Had to replace door.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716241February 6, 2026
STRUCTURE:BODY
Drivers door became hard to open and close. Found driver front door stop damaged / welds broken and separated from door interior.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713788January 27, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, UNKNOWN OR OTHER
Battery is constantly in battery saving mode. It use to do it only when I was on vacation for a week or so. Now it has been doing this every single day for about the last two month.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713754January 27, 2026
ENGINE
The throttle body component of the vehicle failed at approximately 40,000 miles. While this is an engine component that experiences normal wear and tear, throttle body valves fail anywhere between 75,000 and 100,000 miles. I have owned previous vehicles, each crossing the 100,000-mile mark, with no replacement or concern with the throttle body. My concern with this vehicle's throttle body relates to the outdoor weather conditions when the vehicle reported an issue. The outside air temperature was 3 degrees Fahrenheit with moderate winds and a wind chill of approximately -10 degrees Fahrenheit. Researching online, this appears to be a recurrent issue among other owners of this particular vehicle. When started, the vehicle appeared to misfire, potentially entering limp mode. An amber wrench light illuminated, indicating to have the vehicle serviced, and the engine light illuminated, indicating a problem with the emissions system. Additionally, the vehicle pushed a notification to my smartphone that stated the following: "The engine control system has detected the electronic throttle body is not responding as commanded and requires service." The vehicle was turned off and sat for 15 minutes. When the vehicle was restarted, the wrench light turned off, but the engine light remained on, not flashing. The vehicle operated normally, with no misfire. The failure of the throttle body in adversely cold conditions may cause the engine to stall or misfire, decreasing driver control and increasing the potential of a crash. It is of concern that this component seems to have failed early compared to other vehicles currently on the market. I believe the weather to be a contributing factor. The servicing dealership has confirmed that the throttle body must be replaced and has the appropriate part on back order. As this vehicle was not involved in an accident, no police reports or insurance claims have been filed. I plan on reaching out to the manufacturer to address these concerns.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713200January 25, 2026
POWER TRAIN, UNKNOWN OR OTHER
Battery goes into deep sleep truck will not crank this the 3rd time for this truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708934January 5, 2026
POWER TRAIN
I am reporting a premature and dangerous failure of the front CV (Constant Velocity) axle assembly on my 2023 Ford Maverick. While driving at 50 mph the vehicle began experiencing violent, uncontrollable shaking and shuddering in the front end, particularly under acceleration. This is an issue which affects all Mavericks for this model year. Ford has recalled/reimbursed replacements for the 2022 model year but not other ones yet. This failure causes significant instability and compromises steering control, creating a high risk of a crash when merging into traffic or maintaining highway speeds. The vibration is severe enough to distract the driver and could lead to a total loss of motive power if the axle snaps or the joint fully separates.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708485January 3, 2026
ELECTRICAL SYSTEM
I had a problem once with the interface module, and since it was still under warranty, the Ford dealership in Fairfield, California replaced it and at 3:32 AM today January 3, 2026. The interface module turned off for a couple seconds and then turned back on which was basically the same problem as it was when I complained and had them replace it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706253December 20, 2025
POWER TRAIN
When driving at higher speeds (60-70mph) and needing to pass another vehicle the clutch slips which triggers the accelerator to shut down. Leaving you helpless in the passing lane. All you can do is hope there is space to safely pull off the road and shut the engine off. This puts it in limp mode.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705141December 15, 2025
ELECTRICAL SYSTEM
I believe the OEM 12v battery that is used in the Ford Maverick hybrid is underpowered and has issues that seem to plague the vehicle. I’ve owned the truck for almost two years now and started getting “battery saver” alerts when the truck would sit for a few days over the week or during a vacation. But recently I’ve been getting the warning far more frequently and not even siting for more than 24 hours. Last month I had a warning that the power could turn off at any moment and need to pull over immediately. The warning went away after powering the vehicle down and turning back on. Last weekend the car was completely dead after using it all week and only letting it sit Saturday evening to Monday morning. The battery seems to be an issue that plagues the vehicle and I think an investigation needs to be conducted to have this corrected. I even see new 2025 models having similar issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702611December 2, 2025
VEHICLE SPEED CONTROL, ENGINE, POWER TRAIN
AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and issue seemed to be resolved. No check engine lights or other codes were showing on the dash cluster. AUTOMATIC REVVING INCIDENT 2 & 3 DATE: December 2, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Clear, around 27º F VEHICLE STATUS: In drive, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. Heat was on. Immediately turned dial to “D,” and engine proceeded to again rev all the way up. However, this time, full power was transferred to wheels, causing vehicle to attempt to lunge forward. Luckily, I was on an icy patch of the road, and the tires spun instead of gaining traction. I immediately slammed the brakes and turned the car off. Waited about 2 minutes and then turned key to on position, and the exact same thing happened again. No check engine lights or other codes were showing on the dash cluster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702163December 1, 2025
POWER TRAIN
The 2023 Ford Maverick Hybrid is experiencing a recurring safety failure of the Front CV Axle Shafts. The vehicle exhibits violent, uncontrollable shaking of the front end during acceleration at highway speeds (40–65 MPH). This severe vibration compromises vehicle stability and steering control, creating a significant safety risk during merging or overtaking maneuvers. The vehicle was previously repaired for this exact issue by an authorized Ford dealer on May 30, 2024 (at ~32,000 miles). However, the failure has recurred 18 months and 33,000 miles later. Inspection of the current failed parts reveals that during the 2024 warranty repair, the dealership installed obsolete, superseded part numbers (Series "NZ", specifically NZ67-3B436) instead of the updated, corrected design (Series "SZ") released by Ford to fix this known defect. Because the dealership replaced defective parts with the same defective/superseded design, the safety hazard has returned prematurely. The defect was previously confirmed by a dealer technician. The current failure is confirmed by visual inspection of the part labels showing the obsolete "NZ" code. No warning lights appeared prior to failure; the symptom is immediate mechanical vibration under load.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697663November 5, 2025
ENGINE, POWER TRAIN, ELECTRICAL SYSTEM
This exact situation has occurred twice in the past 6000 miles driven. Both occurred while driving at highway speeds, once on I85N and once on I75N in GA. Our 2023 Ford Maverick XLT Hybrid suddenly and unexpectedly loss power and shutdown. This forced us to make an emergency stop and attempt to pull over in high speed, heavy traffic in both instances. The vehicle eventually restarted and was drivable with a check engine light illuminated. The DTCs were read with an OBDII scanner and were recorded as P0811, P0E71 and P1920. The first time this occur the vehicle was taken back to Ford under warranty and they said they reprogrammed the PCM and another control module and assured us it was repaired. Obviously that is not the case. The vehicle is currently with Ford being diagnosed. Please follow up on this one. We're not the only Maverick Hybrid owners to have this unfortunate and very unsafe experience. This situation of a vehicle suddenly dying in heavy traffic is going to get someone killed. Thanks in advance for your consideration in this matter. We would like a better explanation from Ford besides "We reprogrammed a computer".
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697800November 5, 2025
POWER TRAIN, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS
I had been driving for 2 hours on the interstate when the truck starts losing power and warning lights start flashing. I got the truck to the shoulder before it slammed to a stop. I turned the engine off and waited until all the power turned off before restarting. The truck would only run in limp mode at 35 mph. I drove on the shoulder of the interstate to the next exit. I disconnected the battery and reconnected which allowed me to drive it normally to the dealership. After two days the dealer called to say they didn’t see any codes and there wasn’t anything wrong with it even after I sent pictures of the warning messages. This is the 5th time this has happened under similar circumstances.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696731October 31, 2025
UNKNOWN OR OTHER, ENGINE, FUEL/PROPULSION SYSTEM
The car have a Big vibration when speed up over 45 MPH
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696527October 30, 2025
POWER TRAIN
PREMATURE CV axle failure due to regenerative braking. This cause violent wobble leading to the death wobble
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695713October 26, 2025
POWER TRAIN
At 20k miles the vehicle starts shaking back and forth and rattling while accelerating and I brought it to the dealership and its being serviced under warranty to get both front CV axels replaced. It was shaking so badly and vibrating the whole vehicle, the dealership told me it was unsafe to drive when they saw how badly the axels failed. There were no warnings or check engine lights. Especially dangerous because it doesn't shake at low speeds only when accelerating and at high speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692037October 8, 2025
VEHICLE SPEED CONTROL
Vehicle stopped accelerating while doing an U turn with oncoming traffic. Had to pull over because the vehicle would not move.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick