Ford Maverick Complaints (2023)

348 consumer complaints on file.

#11739600May 22, 2026
VISIBILITY/WIPER
Recall 24S51 from Ford says that 87,000 Maverick trucks have had the wiper motor fail due to moisture getting into the housing due to a sealant problem with the supplier. The recalled VINs can have a free inspection and replacement. I believe my VIN is also impacted by this problem because 37 months and 31,000 miles into my car, my wipers failed. I was driving in light rain and the wipers would only go up about 6" from their resting position before returning to the resting position, then repeat the same thing. Thankfully the rain wasn't so heavy that I had to stop and could continue driving home (very carefully!). We've had a very dry winter, so I haven't used my wipers in months. The prior week before the failure, we had a big snow/rain storm spanning two days with about 1.5" of moisture coming down. Hence, I think this storm precipitated, literally, my issue. I took my Maverick to the Ford dealership for a hitch recall, asking about this wiper motor recall problem at the same time. I picked up my truck today and after it's been sitting in the sun, my wipers work again. It sure seems that when moisture is getting into the housing, the wipers fail, then the sun dries it out, then the wipers work. Note, my truck is not garaged. I believe my VIN should be part of the 24S51 or 24-594 recall. Since in my almost 60 years of driving, I've never had a failure of a windshield wiper motor in this way, it seems to be a very rare thing to occur. With a recall of this part in other Mavericks similar to mine, I think mine is actually affected as well.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738381May 17, 2026
POWER TRAIN
While driving the vehicle at low speed (roughy 25mph) a loud sqeek was heard. This occured a few more times so I stopped to inspect. I countinued my trip after not finding the source of the noise. When it occured again, I pulled into a parts store and had them run codes. After finding none I purchased a code scanner so that I could monitor while under way. Once on the highway the sound became more frequent, after just a few miles warning lights appeared on my dash and the vehicle had a complete loss of power. I was able to coast to the side of the road. At that time the vehicle did have code P1061. Dealer diagnosted the truck with a failed transmission. I removed the trasmission and disassembled it. The main shaft had been stripped of it's splines on the gear that connects to the engine. I have a video of the gears and shaft here: [XXX] I saved the parts and will be happy to provide them for investigation if needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738209May 15, 2026
VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
infotainment center and modules related to the front-facing display have malfunctions 5x since 9/2024 and have been in the shop 5 times for the same issue, 4 downloads and updates, 3 recalls, and 2 battery and a front-facing module replacement in the last 15 months of issue stsrting
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737841May 14, 2026
ELECTRICAL SYSTEM
My 2023 Ford Maverick Hybrid experienced repeated 12V battery discharge and “Deep Sleep” events associated with Recall 24C01 and SSM 53801. The vehicle repeatedly discharged the 12V battery while parked under normal conditions. In January 2026, after approximately two weeks parked in freezing temperatures, the battery experienced a complete discharge and the vehicle required multiple jump-starts to remain operational. Ford dealer records later confirmed that the corrective action associated with SSM 53801 had not been applied prior to the failure event despite prior complaints and service visits. The repeated discharge events resulted in failure of both: the original factory battery, and a replacement AGM battery installed at owner expense. This condition created repeated stranded events and loss of vehicle reliability. I am submitting this complaint because the issue appears directly related to documented parasitic drain conditions already acknowledged by Ford in Recall 24C01 and SSM 53801, and because the failure condition persisted before corrective action was finally applied.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737537May 13, 2026
VISIBILITY:WINDSHIELD
The contact owns a 2023 Ford Maverick. The contact stated while driving at an undisclosed speed, the contact noticed an abnormal sound coming through the back windshield. The contact stated that the failure was persistent. The vehicle was taken to the dealer, the abnormal sound was confirmed. The contact was informed that there was nothing that can be done to remedy the issue. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736632May 8, 2026
UNKNOWN OR OTHER
CV axles bad, intense shuddering during acceleration and between 25-55mph. Severe enough to shake side to side in my lane on occasion. Serious safety concern and seems to be a ubiquitous issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736287May 7, 2026
SUSPENSION, POWER TRAIN, ENGINE
During acceleration from 40-60 miles per hour, there was a pronounced vibration/shudder through the front end of the vehicle. After taking it to the dealership, they advised both front axles would need to be replaced. The catastrophic failure of an axle is likely to cause a car crash. The problem has been identified by Ford Motor Company and also confirmed by the Ford Dealership where I got it fixed. Ford Motor Company issued Customer Satisfaction Program 25N09 On September 17, 2025. My vehicle is a 2023 model year, but produced at the same plant and in the same time frame as the the ones mentioned in 25N09. There were no warning lamps or messages about the problem. The only indication was the heavy vibration a few thousand miles prior to getting it looked at.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736222May 7, 2026
STRUCTURE:BODY
Driver side door check hinge, rivets that hold the door hinge will break off. Door rivet panel will prevent the window to go down or up. The check hinge will break off during normal closing and opening of door.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736106May 6, 2026
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
The contact owns a 2023 FORD Maverick. The contact stated he noticed a odd sound from the driver side door when closing and opening, the winch on the driver side door is loose and scraping the inside of the door frame. The vehicle was taken to a dealer where it was diagnosed it to need a new driver side door. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 83,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733525April 24, 2026
POWER TRAIN:AXLE ASSEMBLY
The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the steering wheel started shaking, prompting the contact to pull over to the side of the road. The vehicle was pulled over, and a squealing, clicking, and grinding sound started coming from the vehicle. The vehicle was taken to the dealer on three separate occasions and was diagnosed with a CV shaft failure. The manufacturer was not notified of the failure. The approximate failure mileage was 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732289April 19, 2026
POWER TRAIN
Both front CV axles on my 2023 Ford Maverick Hybrid are failing at approximately 60,000 miles. The vehicle experiences violent shaking and vibration during acceleration, most noticeably at speeds above 30 mph and on inclines. The shaking is severe enough to affect steering control and reduce driver confidence, particularly during highway merging and uphill acceleration. The problem was diagnosed and confirmed by San Leandro Ford dealership, which identified both front CV axles as defective and in need of replacement. No warning lamps or message appeared prior to or during the issue. The vehicle is available for inspection upon request. This appears to be a widespread manufacturing defect. Numerous owners of 2022-2023 Ford Mavericks have reported identical premature CV axle failures at mileages ranging from 10,000 to 60,000 miles, as documented in online forums and prior NHTSA complaints. Some owners have had axles replaced multiple times. The defective CV axles pose a safety risk as the severe vibration compromises vehicle control during normal driving conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731420April 15, 2026
POWER TRAIN
Vehicle started to have a shake under acceleration. Reported it to multiple dealerships and requested them to specifically observe the CV axles. Finally secured an appointment on 11-24-2025 while vehicle was under factory warranty. Tenvoorde Ford informed me (the owner) that the CV axles were “fine” and a non issue. Shake was still present. Kept driving the vehicle and now, five months later with no factory warranty left on the vehicle, shake still present, and received a second opinion today. CV axle needs replacement. ~68,000 miles on the odometer. I exclusively commute on interstate 94 in central Minnesota, hardly drive in cities. There is no justifiable reason when the vehicle was at the dealership that the CV axle went from being just fine to needing replacement. This is a very common concern with these Ford Mavericks and Ford needs to conduct a recall before people get injured on the public roadways.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728328March 31, 2026
STRUCTURE:BODY
The vehicle was at the dealer for a loud noise on the hinge area of the driver side door. I was contacted by the dealer and told That the door has cracked spot welds and needs to be replaced. The dealer contacted Ford and for opening offered to pay for a portion of the repair leaving me with over $1000 dollars out of pocket.This is a common problem with this vehicle and the Ford escape see Ford TSB 2356B. The vehicle is still under warranty but this is a defective item and should be covered 100% by Ford.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726645March 24, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the brake lights and turn signals failed to function as intended. In addition, the message “Brake Light Failure” was displayed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure, and the contact was informed that the parts were not available to repair the vehicle. The contact received notification of NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting); however, parts were unavailable for the recall repair. The contact's husband purchased and replaced the light bulbs lights. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that there was no assistance available. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726541March 23, 2026
POWER TRAIN
CV axle fails prematurely, causing vehicle shaking under acceleration, and potentially unsettling vehicle stability at speed. First noticed the shaking at 49K miles. I have not had an opportunity to schedule an appointment with the dealer to have it replaced yet. This is a known issue on these vehicles that Ford has not acknowledged, with many drivers reporting they need the CV axles replaced ever 30k miles or so.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725852March 20, 2026
POWER TRAIN
The contact owns a 2023 Ford Maverick. The contact stated that while driving 5 MPH and making a right turn, the vehicle lost power, and the transmission slipped into neutral(N). While driving 25 - 30 MPH and approaching a red light, the transmission slipped into neutral. The contact associated the failure with NHTSA Campaign Number: 24V330000 (Power Train) and 25V133000 (Power Train). The local dealer was contacted and confirmed that the VIN was included in the recalls. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 17,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725681March 19, 2026
POWER TRAIN
CV axles are covered under the Ford Powertrain Warranty. I am experiencing a driveline vibration consistent with axle failure. I would like a warranty diagnosis and documentation explaining why this is not considered a warrantable defect. Dealerships are refusing to evaluate a powertrain warranty issue involving driveline vibration consistent with axle failure. The vehicle exhibits driveline vibration under normal operation. That is not normal function and indicates a defect under warranty terms. Powertrain issues with axles present a safety concern. I see Ford has superseded the original NZ6Z axle part numbers to SZ6Z and now PZ6Z revisions. That indicates a known issue with earlier components. My vehicle is exhibiting the exact failure symptoms—this should be evaluated under powertrain warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725203March 18, 2026
ENGINE
The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was a fuel odor on the exterior and interior of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured fuel seal. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact was informed that a diagnostic test was needed to determine the cause of the failure. The dealer declined to provide a free diagnostic test. The contact referenced the notification of NHTSA Campaign Number: 23V380000 (Engine); however, the VIN was not associated. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 45,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724855March 17, 2026
ENGINE
Per the dealership my vehicle is throwing the same codes P1061 and P032F as the recall that is less than a month from when my vehicle was built. My vehicle knocks and then the speed drops to less than 35 miles and it happened to me in traffic. It is very dangerous and again this is the same issue as the recall for my 2023 that is for other 2023 vehicles. I have called Ford to get help and file a complaint but am getting zero help. Again this is a very dangerous event that is happening and could cause damage not only to my vehicle but to others. I have to work so driving the vehicle is my only option right now and I can't afford the $9,000 to fix something that is a Ford issue. Please review and have Ford pay for the safety issue they already know they have. Thanks
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719477February 20, 2026
ELECTRICAL SYSTEM
Hybrid Ford Maverick electrical system began to go into a save battery mode -no interior lights, only driver side door operated, and other system failures. Dealer replaced battery under warranty and general recall for this issue. A few months later same characteristics started showing up -interior lights not working, only driver's side door operational, etc. This time the warranty had expired and the dealer, along with Ford Motor, told me any repairs would be at my expense, 100%. I feel problem was never resolved, even with replacement battery. Ford and dealer should address this problem. I'm sure I'm not the only one with this battery and electrical issue. After all, there was a full recall for the battery failure. Having no interior lights, unable to enter except driver's side, and other manifestations are inherently unsafe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick