Ford · Model Report
Showing safety data for the 1989 model year only.
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
A REVISED BRAKE LINING NOISE INSULATOR RESULTED IN A DECREASE IN THE THERMAL INSULATION BETWEEN THE BRAKE LINING AND THE FRONT BRAKE CALIPER PISTON. THIS CAUSED GREATER HEAT TRANSFER TO THE CALIPER PISTONS WITH THE POTENTIAL TO OVERHEAT THE BRAKE FLUID AND DIMINISH BRAKE EFFECTIVENESS DURING SEVERE BRAKING CONDITIONS.
THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP.
UNDER CERTAIN CONDITIONS, THE SNAP RING THAT LOCATES THE PARK GEAR ON THE OUTPUT SHAFT OF THE TRANSMISSION MAY FRACTURE.
SHIELDS ON THE FRONTS OF THE MIDSHIP MOUNTED FUEL TANKS WERE OMITTED DURING ASSEMBLY.
SINCE NOVEMBER 19, 2014 I HAVE BEEN NOTICING A STRONG FUEL VAPOR SMELL FROM MY TRUCK. I REALLY DIDN'T THINK ANYTHING OF IT UNTIL I GOT INTO MY TRUCK AND TURNED THE KEY TO THE ON POSITION. ALL OF A SUDDEN I NOTICED THAT MY REAR GAS TANK WAS EMPTY. I FLIPPED THE SWITCH TO THE FRONT TANK AND IT WAS OVER FULL. AFTER QUITE A PERIOD OF RESEARCHING ONLINE WHEN I HAD TIME TO, I FOUND OUT THAT THERE HAD BEEN A RECALL ON THE DUAL FUEL TANK SELECTOR VALVE. THE 91S39 RECALL LIST 1989 F350 ON IT BUT MY TRUCK DOESN'T APPARENTLY FALL UNDER THE RECALL CAUSE THE BUILD DATE IS 11/88 (NOVEMBER 1988) AND VIN AS A 1989. BUT MY RESEARCH ONLINE GAVE ME THE PART NUMBER THAT WAS RECALLED. PART# E7TA-9B263-AB. WHICH MY VALVE HAS THAT EXACT NUMBER ON IT. I BOUGHT THIS TRUCK FROM THE ORIGINAL OWNER AND EVERYTHING IS ORIGINAL ON IT. YES THIS IS THE ORIGINAL MILEAGE. UNFORTUNATELY NO MAINTENANCE EXCEPT FOR OIL CHANGES AND TUNE UP WERE DONE. UNFORTUNATELY HE ALSO NEVER DID ANY RECALLS. MY TRUCK GOES INTO BELL FORD (602-866-1776) HERE IN PHOENIX, AZ FOR A BRAKE RECALL AND IGNITION SWITCH RECALL. THEY SAID THE DUAL FUEL TANK SELECTOR VALVE WAS NOT A RECALL FOR MY TRUCK. THIS IS A MAJOR ISSUE AND ALL YEARS WITH THIS PART NUMBER SHOULD HAVE BEEN INCLUDED IN THE RECALL. THIS VALVE COST ALMOST $200. IF FORD IS NOT GOING TO FIX ALL THERE TRUCKS WITH THIS VALVE ISSUE THEY SHOULD AT LEAST SEND OUT A HALF OFF COUPON SO THOSE OF US THEY DON'T WANT TO TAKE CARE OF CAN PURCHASE THE NEW UPDATED VALVE AND HAVE IT REPLACED. UNFORTUNATELY I CAN NOT POST THE PICTURE I HAVE OF MY VALVE WITH PART NUMBER IN THIS SECTION. BESIDES MY PERSONAL EMAIL LISTED I CAN BE EMAILED AT MY PLACE OF WORK AT THE CITY OF PHOENIX AT : [XXX]. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1989 FORD F-350 EQUIPPED WITH AN AFTER MARKET FLEX A LITE AUXILIARY COOLING FAN. THE CONTACT STATED THAT AS HE OPENED THE HOOD, HIS FINGERS BECAME CAUGHT IN THE BLADES DUE TO AN INADEQUATE AMOUNT OF GUARDS. THE CONTACT SUSTAINED SEVERE, DEEP LACERATIONS TO HIS FINGERS AND AS A RESULT, HE NO LONGER HAD ANY FEELING LEFT IN HIS FINGERS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000. THE VIN WAS UNAVAILABLE.
I WAS RETURNING HOME FROM PHOENIX. I WAS TRANSITIONING FROM THE 101 FREEWAY,TO THE 60 EASTBOUND. ALMOST WHERE THE CONCRETE BARRIERS COME TO A POINT AND END, MY LEFT FRONT TIRE CUT LOOSE OF IT'S TREAD. I BRIEFLY SAW THAT IT WENT TOWARDS, AND IN BETWEEN THE CONCRETE BARRIERS. THE TIRE DID NOT GO FLAT. WHEN THE TREAD LEFT, IT TORE UP THE INNER FENDER PLASTIC, BENT THE QUARTER PANEL RIGHT BEHIND THE WHEEL WELL, DESTROYED THE FOOTSTEP BOLTED ON UNDERNEATH THE DRIVERS DOOR. THE VEHICLE IS A 1989 F350 4-DOOR LONGBED 4-WHEEL DRIVE TRUCK. THIS EPISODE IS NOT THE FIRST. THE FIRST HAPPENED IN 2003. THE SECOND TIME HAPPENED TO MY 20 YR OLD SON WHILE ON HIS WAY TO SCHOOL. THAT ONE WAS THE LEFT REAR. IT RIPPED OUT BOTH SUPPORTS THAT THE BED HAS IN FRONT AND IN THE REAR OF THE WHEEL WELL. IT SMASHED THE REAR FUEL TANK FILLER TUBE, PULLED IN THE OUTSIDE DOOR TO THE "GAS" CAP,MANGLED THE PORTION OF THE BED THAT IS BEHIND THE WHEEL WELL, INSIDE AND OUT. I WAS IN IRAQ WHEN THAT HAPPENED. THEY SAID THAT I HAD THE WRONG TIRE PRESSURE ON BOTH ACCOUNTS, 1ST AND 2ND TREAD SEPARATIONS. WITH A TRUCK THAT BIG,I DON'T LET MY TIRES GET NEGLECTED FROM HAVING THE PRESSURE CHECKED ON A REGULAR BASIS,AND ADJUSTED ACCORDINGLY. I HAD MY WIFE TELL THEM THAT WAS A BUNCH OF BULL!#*^,AND I WANTED SOMETHING DONE. THEY TOLD MY WIFE THAT I HAD PEPBOYS PUT THE WRONG KIND OF TIRE ON MY TRUCK. THAT IS WHEN I FIRST STARTED TRYING TO FIND SOMETHING OUT ALONG THE LINES OF A LAWSUIT. THEY HAD PLENTY OF LAWSUITS GOING ON CONCERNING TIRES, BUT NONE WERE OF THE TIRE I HAD. I AM NOW LOOKING INTO BUYING ANOTHER BED FOR MY TRUCK BECAUSE OF WHAT COOPERS TIRES HAVE DONE TO IT. I ALSO HAVE TO PURCHASE A NEW STEP TO MOUNT UNDER THE DRIVERS DOOR. THE TIRES I HAD ON MY TRUCK WERE DAKOTA FUTURA RVT,33X12.50R16.5LT. I HAVE WENT AND PURSUED ESTIMATES ON GETTING MY TRUCK FIXED. I AM LOOKING AT ABOUT 3500.00. I NOW HAVE A DIFFERENT BRAND (MANUFACTURER) MADE TIRE S NOW. *NM
No injuries · No fire · No crash
ALMOST DAILY FRONT LEFT WHEEL SHIMMY AT 35-55 MPH. FIRST STARTED ABOUT 1991 AND OCCASIONALLY FIXED BY ALIGNMENT, WHEEL BALANCING, TIRE ROTATION, DUAL FRONT STEERING STABILIZERS, BUT RECENTLY THE PROBLEM HAS WORSENED. I AM UNABLE TO DRIVE THE VEHICLE AT HIGHWAY SPEED FOR FEAR OF THE WHEEL SHIMMY OCCURING AT THE 35-55 MPH RANGE. WHEN SHIMMY STARTS I CAN TURN THE STEERING WHEEL TO THE RIGHT SLIGHTLY AND THE SHIMMY WILL GO AWAY TEMPORARILY. SHIMMY ONLY OCCURS WHILE DRIVING STRAIGHT, OR WHILE TURNING TO THE LEFT. AS A SIDE NOTE THE TRUCK DOES PULL TO THE RIGHT, MAKING ME COUNTER STEER TO THE LEFT, WHICH IS TEMPTING FATE WITH THE SHIMMY.*AK
No injuries · No fire · No crash
CONSUMER STATES THE CHOKE PLATE IN THE INTAKE MANIFOLD GETS SO HOT, IT MELTS THE FUEL LINE AND IGNITES FUEL, BURNING THE ENGINE COMPARTMENT.