Ford F-250 Complaints (2006)

495 consumer complaints on file.

#10714094May 1, 2015
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT THE CAB OF THE TRUCK DID NOT LINE UP WITH THE BED OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT THE BED RAILS FOR THE TRUCK WERE RUSTED AND STARTED TO SEPARATE FROM THE FRAME. THE CONTACT SPOKE WITH THE MANUFACTURER AND THEY WERE TOLD THAT THE FRAME WAS OUT OF WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,000. UPDATED 6/17/15*CN UPDATED 10/12/2017*CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10702141March 27, 2015
SEAT BELTS
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT A VARIOUS SPEEDS, THE FRONT PASSENGER, FRONT MIDDLE AND REAR MIDDLE SEAT BELTS FAILED TO BUCKLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10694333March 15, 2015
FUEL/PROPULSION SYSTEM
TRUCK STALLED AT INTERSECTION. COMPLETE POWER OUTAGE, NO BRAKES, ETC. MANAGES TO RESTART. PROBLEM RECURRED TWO ADDITIONAL TIMES. I LIMPED TO A LOCAL MECHANIC SHOP WHO SCANNED THE ENGINE CODES. HE TOLD ME IT WAS THE THROTTLE BODY AND CHARGED ME $550.00 TO REPLACE IT. TRUCK HAD 47,000 ON IT AT THE TIME. IN MY OPINION THIS PART SHOULD LAST WELL INTO THE 100,000 MILE MARK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679920January 30, 2015
TIRES, TIRES:TREAD/BELT, TIRES:SIDEWALL
I PURCHASED THIS VEHICLE WITH A FULL SET OF THE EXACT SAME TIRE BRAND, TYPE, SIZE, AND LOAD RANGE. THE NEW TIRES WERE TO REPLACE THE DEFECTIVE TIRES WHICH HAD THE EXACT SAME PROBLEM AS THESE: BELT FAILURE. TIRE FAILURE: BELTS BEGAN TO SEPARATE LEADING TO UNEVEN WEAR AND EVENTUALLY FAILURE OF THE SIDEWALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679917January 30, 2015
TIRES, TIRES:TREAD/BELT, TIRES:SIDEWALL
I PURCHASED THIS VEHICLE WITH A FULL SET OF THE EXACT SAME TIRE BRAND, TYPE, SIZE, AND LOAD RANGE. THE NEW TIRES WERE TO REPLACE THE DEFECTIVE TIRES WHICH HAD THE EXACT SAME PROBLEM AS THESE: BELT FAILURE. TIRE FAILURE: BELTS BEGAN TO SEPARATE LEADING TO UNEVEN WEAR AND EVENTUALLY FAILURE OF THE SIDEWALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679921January 30, 2015
TIRES, TIRES:TREAD/BELT, TIRES:SIDEWALL
I PURCHASED THIS VEHICLE WITH A FULL SET OF THE EXACT SAME TIRE BRAND, TYPE, SIZE, AND LOAD RANGE. THE NEW TIRES WERE TO REPLACE THE DEFECTIVE TIRES WHICH HAD THE EXACT SAME PROBLEM AS THESE: BELT FAILURE. TIRE FAILURE: BELTS BEGAN TO SEPARATE LEADING TO UNEVEN WEAR AND EVENTUALLY FAILURE OF THE SIDEWALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679925January 30, 2015
TIRES, TIRES:TREAD/BELT, TIRES:SIDEWALL
I PURCHASED THIS VEHICLE WITH A FULL SET OF THE EXACT SAME TIRE BRAND, TYPE, SIZE, AND LOAD RANGE. THE NEW TIRES WERE TO REPLACE THE DEFECTIVE TIRES WHICH HAD THE EXACT SAME PROBLEM AS THESE: BELT FAILURE. TIRE FAILURE: BELTS BEGAN TO SEPARATE LEADING TO UNEVEN WEAR AND EVENTUALLY FAILURE OF THE SIDEWALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679720January 29, 2015
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM, ENGINE
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 3 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT IT FAILED TO RESPOND. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN STATED THAT THE OIL COOLER, THE EXHAUST BACK PRESSURE SENSOR, THE TURBO AND THE EGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10678993January 26, 2015
ENGINE
TOWED ON SEPT/19/2014 KN MILEAGE DEALER SAID NO PROBLEM FOUND;. 2ND TOW 11/02/2014 MILEAGE 187190 EGR VALVE FAILED WILL NEED ENGINE REPLACED. DEALER WHERE BOUGHT DID NOT DISCLOSE. THE TRUCK HAD THE MOTOR REBUILD IN 2008. AND MANY CLASS ACTION SUITS HAVE BEEN FILED. ON 6.0L ENGINES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679011January 26, 2015
TIRES, WHEELS, STEERING
HELLO, I HAVE A FORD F 250 SUPER DUTY KING RANCH 4X4 DIESEL THAT MY WIFE AND I ALWAYS WANTED. WE BOUGHT FROM A USED CAR/TRUCK LOT. THE RIMS AND TIRES ARE BRAND NEW AS IS ALIGNMENT WAS ALSO HAD DONE TO FIX THE PROBLEM RIGHT OUT OF THE GATE BUT IT DIDN'T.. WHEN THE TRUCK GETS TO 44 MILES AN HOUR AND UP TO 50 MPH MY F 250 HOPS LAND I DON'T KNOW IF ITS FROM THE FRONT OR BACK BUT I THINK ITS HAPPENING IN THE FRONT THE WAY IT FEELS ON THE STEERING WHEEL.. MY TRUCK STEERING WHEEL DOES NOT MOVE BACK AND FORTH LIKE THE TIRES ARE WIGGLING RIGHT AND LEFT , IT IS MORE LIKE WHEN YOU HAVE A BAD RIM OR UNEVEN TIRE HOP, LIKE WHEN I WAS A KID AND COULDN'T AFFORD TIRES AND BOUGHT SOME USED ONES AND GET A BUM TIRE IN THE SET OR MAYBE A RIMS THAT I HAD TRADED FOR AND ONE WAS BAD.. WE LOVE THIS F 250 AND HAVE PUT A LOT OF MONEY INTO IT, NOT KNOWING ANYTHING ABOUT DIESEL TRUCKS, ONLY LOVING THE SOUND AND POWER OF THEM SO THE PROBLEMS THE DEALERSHIP FAILED TO POINT OUT OR MENTION TO US WE HAVE HAD ALL FIXED PROPERLY AND THIS HOP OR BOUNCE THAT MY F 250 IS EXPERIENCING IS REALLY A WORRY TO US SEEING HOW WE BOUGHT IT TO PULL A TRAVEL TRAILER WE PURCHASED TO EXPLORE THIS GREAT U.S.A. SO WE WILL BE CONSTANTLY DRIVING IT ATTACHED TO THE TRAILER OR NOT. I HAVE REPLACED RIMS, TIRES AND HAD AN ALIGNMENT AS STATED BEFORE AND WOULD REALLY LIKE TO SOLVE THIS PROBLEM WHICH IF YOU GOOGLED IT AND SEEING ALOT OFL OTHERS EXPERIENCING THIS SAME PROBLEM AND SOME EVEN LIFE THREATENING WHICH WORRIES ME ALSO IF WHATEVER THE PROBLEM IS, CAUSES SOMETHING TO BREAK OR HAPPEN. I THANK YOU FOR YOUR TIME AND CONCERNS TO REMEDY THIS SAFETY HAZARD ON FORD SUPER DUTY TRUCKS.. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679037January 26, 2015
FUEL/PROPULSION SYSTEM, ENGINE AND ENGINE COOLING
THE TRUCK WAS ON A MAJOR INTERSTATE (I-81 NEAR BLACKSBURG EXIT 118A,B,C) DRIVING UPHILL. WHILE TRYING TO MERGE INTO THE RIGHT LANE FROM THE MIDDLE LANE, WHILE LETTING OF THE ACCELERATOR THE ENGINE DIES. AT THIS POINT LOST ALL POWER INCLUDING BRAKES AND STEERING CONTROL. SINCE THERE WAS NO TRAFFIC IMMEDIATELY BEHIND THE TRUCK THEN WAS ABLE TO PULL OVER TO THE FIRST LANE AND GET OFF THE SHOULDER. THE TRUCK DIED AND FORTUNATELY DUE TO LOW TRAFFIC ABLE TO MANEUVER TO THE SHOULDER. AT THAT POINT, TRIED TO START THE TRUCK AND IT WOULD NOT START SO HAD TO REMAIN ON THE SIDE OF INTERSTATE UNTIL HELP COULD ARRIVE. STRANDED ON THE SIDE OF THE INTERSTATE. TRUCK WAS TOWED TO DEALERSHIP. FORD BLOGS INDICATE THERE IS A KNOWN PROBLEM THAT HAS GONE UNADDRESSED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10678572January 23, 2015
VISIBILITY:SUN/MOON ROOF ASSEMBLY
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE SUN ROOF WINDOW WAS DETACHING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN MADE THE CONTACT AWARE THAT THERE WAS A MANUFACTURER RECALL RELATED TO THE SUN ROOF FAILURE. THE SUN ROOF WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10653120November 6, 2014
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE DECELERATED AND THE SERVICE ENGINE SOON AND THE ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE OIL COOLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10652762November 5, 2014
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
SMELLED SOMETHING AS TRAVELING DOWN THE ROAD AT 55 MPH. STOP THE VEHICLE ALONG SIDE THE ROAD. CHECKED THE TRAILER. CAME BACK TO THE TRUCK AND SMOKE WAS ROLLING OUT OF THE DASH VENTS, RIGHT REAR PASSENGER SIDE OF THE HOOD WAS BURNING THE PAINT, THEN FLAMES CAME OUT FROM UNER THE HOOD. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10648898October 20, 2014
TIRES
TL* THE CONTACT OWNS A 2006 FORD F-250 EQUIPPED WITH CONTINENTAL CONTITRAC TR TIRES, SIZES LT275/70R/ 18, DOT NUMBER P515 46XB. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THERE WAS VIBRATION AND THE LEFT REAR TIRE BLEW OUT. ALSO, THE TIRE EXHIBITED TREAD SEPARATION. THE TIRE HAD NOT BEEN REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. ..UPDATED12/11/14 *BF UPDATED 12/19/14*CN THE CONSUMER STATED SOME OF THE VEHICLE'S FAILURES WERE REPAIRED PRIOR TO HAVING KNOWLEDGE OF THE RECALL. UPDATED 11/10/2015*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10638130September 22, 2014
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
DASHBOARD INSTRUMENT PANEL GAUGES AND LIGHTS STOP FUNCTIONING ALSO LOW FUEL LIGHT COMES ON WITH FULL TANK OF FUEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10638199September 22, 2014
SERVICE BRAKES
WHILE DRIVING I NOTICED THAT THE VEHICLE WAS SLUGGISH AND WHEN ENGAGING THE CLUTCH IN ORDER TO SHIFT THERE WAS A NOTICEABLE BRAKING FEELING EVEN THOUGH I WAS NOT TOUCHING THE BRAKE PEDAL. UPON REACHING HOME I SAW MY FRONT WHEELS/ROTORS/CALIPERS SMOKING AND THE HEAT FROM THE WHEELS COULD BE FELT ALMOST 3 FEET FROM THE VEHICLE. I TOOK MY PICK-UP TO THE DEALER AND WAS TOLD THAT MY FRONT CALIPERS HAD FROZEN AS WELL AS THE RIGHT REAR AND THE LEFT REAR WAS JUST AS BAD BUT HAD NOT FROZEN YET AND PROBABLY WOULD. THIS REPAIR REQUIRED FOUR (4) NEW CALIPERS, BRAKE PADS AND REQUIRED THE ROTORS TO BE RESURFACED. THE DEALER SAID THAT NO RECALL HAD BEEN MADE FOR THIS ITEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10615287July 22, 2014
VEHICLE SPEED CONTROL
AS I PULLED AWAY FROM A STOP SIGN I THROTTLED UP TO REACH THE APPROPRIATE SPEED LIMIT AND MY 2006 FORD F250 6.0 WENT WIDE OPEN THROTTLE OUT OF NOWHERE. I MASHED ON MY BRAKES TO TRY TO SLOW THE TRUCK DOWN, TO NO SUCCESS. I FLASHED MY LIGHTS AND STROBE LIGHTS AT ON COMING TRAFFIC AS WELL AS BLEW THE HORN TO MAKE OTHER DRIVERS AWARE THAT I COULD NOT STOP. LUCK BEING AGAINST ME THIS DAY THE FIRST VEHICLE I APPROACHED WAS A NC STATE TROOPER. I HAD TO TURN OFF MY IGNITION TO STOP THE TRUCK BUT THE ENGINE KEPT RUNNING AT 4500 RPM SO I SLAMMED IT IN PARK. THE STATE TROOPER GAVE ME A TICKET FOR PASSING HIM AT 80MPH IN A 45. KEEP IN MIND THAT MY TRUCK IS EQUIPPED WITH AN SCT LIVEWIRE TUNER, SO WHEN IT OPENED UP IT LAUNCHED LIKE A ROCKET. THIS IS THE SECOND TIME I'VE HAD THE THROTTLE ISSUE, THE FIRST TIME WAS THE SAME CASE EXCEPT I DID NOT HAD A TUNE ON THE VEHICLE. THERE HAS BEEN SEVERAL REPORTED CASES OF THIS HAPPENING, WITH AND WITHOUT TUNERS ON THE VEHICLE. PLEASE SHARE YOUR INSIGHT IF ANY ONE KNOWS THE CAUSE OF THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10611014July 16, 2014
ENGINE, SUSPENSION, EXTERIOR LIGHTING
GOING 55MPH THE TRUCK STARTS SHAKING AND SHIMMING. ALL LIGHTS GO IN AND OUT AND BLOWS WHENEVER ANYTHING IS HOOKED UP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10605754June 24, 2014
STEERING, SUSPENSION
THE DEATH WOBBLES OR SHIMMY BEEN.GOING ON SINCE 2010. THE WHOLE TRUCK WOULD SHAKE AND SHAKE HARD. UNTIL I SLOW DOWN TO 30MPH. THEN FORD SENT ME A LITTER (09L02) SAYING IT'S CALLED THE SHIMMY AND ITS MY TIRE PRESSURE. I CHECKED TIRE STILL KEPT HAPPENING. YESTERDAY 6/23/2014 MY WIFE AN TWO SONS WHERE ON THE FREEWAY WHEN IT HAPPEN AND THE STEERING DAMPER BROKE OFF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250