Ford F-250 Complaints (2015)

296 consumer complaints on file.

#11597331June 27, 2024
STEERING, SUSPENSION
Truck violently shakes (wobbles) when you go over 50 mph.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596660June 26, 2024
FUEL/PROPULSION SYSTEM
my f250 super duty just completely stopped running while driving down the interstate, i then had the vehicle towed to the ford dealer where i purchased it in 2015. after the shop examination they found that the high pressure cp4 fuel pump had came apart and contaminated the fuel system entirely. The shop forman called and advised me of the problem and that it would cost 16,000.00 to have it fixed. he also advised me the this was a ongoing problem that they have had with this particular fuel pump, and that they had recall on the trucks from 2011 to 2018 for this. but he told me that my vin number was not on the recall list. he said that i would have to pay out of pocket to have the repairs done. I THEN CONTACTED FORD MANUFACTORING about this, the service lady that i spoke to said that there was nothing they could do because my truck was not on the recall list. To me this is a big safety measure, because when it quit, if i haven't been in an area where i was able to get out off the road there could have been a very serious accident. i feel that an issue like this that ford knows they have and continue using the same pumps should be there responsibility. I had know visible or any warnings sign of this was going to happen. this truck i purchased new and have put every mile on it and had this truck service very regularly. i have all the service records, just had the fuel filters and oil changed about 2 weeks before this happened. Thank you for your time. PLEASE ADVISE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596607June 25, 2024
POWER TRAIN
Truck has started dropping into 1st gear and losing speed with no warning. Has happened at low and high speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595668June 21, 2024
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Consistent oil leaks. The cars are manufactured poorly and this is a horrible but common issue that Ford has yet to come up with a fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592229June 3, 2024
SUSPENSION
The contact owns a 2015 Ford F-250. The contact stated that while her husband was driving at an undisclosed speed, the vehicle shuddered and hydroplaned. No warning lights were illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle was not under recall and was out of warranty. The failure mileage was approximately 78,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11591670May 31, 2024
STEERING, SUSPENSION
Today my 2015 Ford F250 SD experienced the aptly named Ford “Death Wobble”. It occurred twice today after just having the whole front end rebuilt for the same issue just weeks ago. My truck shakes so violently I am concerned for my safety and that of my wife. To stop the shaking I have to slow to 30 mph or less, typically on the highway where all other vehicles are traveling at 65+. The truck now sits at a dealership waiting for repair. The service writer states parts that were replaced two - three weeks ago are “shot”. How can this be? Ford F250’s have this as a known problem with no real fix. Just keep throwing parts at it with no resolve. I had the truck worked on in July ‘23, May ‘24 and now. I am invested heavily in this truck and have now had to replace parts multiple times because some design flaw keeps wearing them out. I’d love to see some sort of recall that forces some sort of redesign and real repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11591791May 31, 2024
SUSPENSION, STRUCTURE
The contact owns a 2015 Ford F-250. The contact stated while driving at approximately 30 MPH and various speeds, the vehicle rolled over a dip in the road the truck bed shifted, and the vehicle jerked to the right or the left. The contact stated there was no warning light illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the bushings on the suspension needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 176,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11588291May 12, 2024
SUSPENSION, UNKNOWN OR OTHER
I was driving on the Freeway, 65 mph, all of sudden, the steering and truck started to shake violently, lost control of the steering wheel, due to the severe shaking, caused traffic behind me to stop suddenly as they noticed something major was going on. It felt like as if I had 4 flat tires, and it felt like a strong earthquake. I had to reduce speed to 10 mph per hour, it stopped shaking and exited the freeway, Never experience anything like this before.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11583001April 15, 2024
SUSPENSION
When I drive over 50 miles an hour and I hit a small bump, the front end of my truck shakes violently. I also lose control of the truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11580144March 29, 2024
STEERING, SUSPENSION
I experienced the “Ford Death Wobble” when on the highway at 70 MPH. It has happened three times now. It didn’t stop until I pulled off the road and stopped. It was an unsafe situation trying to get across three lanes of traffic and stop in the shoulder of the road. I did not loose control of the truck but it was close to being uncontrollable. From what I’ve read, this needs to be a Recalled item!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579495March 26, 2024
SUSPENSION, STEERING, UNKNOWN OR OTHER
On multiple occasions I have experienced the “F250 death wobble”. When reaching speeds of over 60 mph my front end and steering wheel start shaking violently. The entire truck is uncontrollable. It feels like the vehicle is going to shake apart. It is difficult to even hold onto the steering wheel and keep the vehicle going in a straight line. I have to slow down to about 30 mph on an interstate to make it stop, creating a dangerous situation. Sometimes I have to pull off the road. Often, when hitting a bump in the road it gets triggered. I’ve had it looked at multiple times at ford dealerships and nothing is ever found that is the cause of it. It’s extremely dangerous and there is no recall for this problem. Thankfully I have managed to keep control of the vehicle. I’ve experienced this problem for going on 3-5 years. I have replaced the front tires numerous times as that seems to help, though not eliminate the problem. Ford needs to do something about this with a recall or educating their service departments. There are tons of complaints online
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579241March 25, 2024
POWER TRAIN, STEERING, SUSPENSION
While merging onto an interstate the truck began to violently shake causing me to begin to lose control. I was able to brake hard and pull off the road before I lost complete control. I was extremely upset after this event. After regaining composure on the side of an interstate I pulled back onto the interstate. Within the next 10 min I hit a bump in the middle of the interstate and the truck again began to shake violently. I thought I was going to lose control and crash. We immediately had the vehicle taken to a mechanic. The work they did cost 1300$. Approximately 2 weeks after getting the vehicle back I was driving over a bridge and the seam in the road again caused the truck to violently shake. Again feeling like I was going to lose control. I was able to brake hard and pull over on the side of a bridge. This caused significant trauma to myself and my young son. Since then the truck continues to violently shake anytime it’s driven over a bump or seam in the road even at slow rates of speed. We have taken the vehicle to the mechanic again and they have been unable to solve the issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579313March 25, 2024
ENGINE AND ENGINE COOLING, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
The contact owns a 2015 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. The vehicle was taken to the dealer, who diagnosed a failure with the rear NOx sensor. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N05. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573367February 22, 2024
FUEL SYSTEM, DIESEL
The contact owns a 2015 Ford F-250 The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed diesel particulate filter. The contact was informed that the diesel particulate filter needed to be replaced. The dealer advised the contact that there was a Customer Satisfaction Program for the repair, but the vehicle was not eligible. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573126February 21, 2024
FUEL SYSTEM, DIESEL
The contact owned a 2015 Ford F-250. The contact stated while the driver was driving 70 MPH, the vehicle shut off inadvertently. The contact's fiancé was able to pull to the side of the road. There was no warning light illuminated. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed that the Bosch CP4 high pressure fuel injector pump failure caused metal shavings to enter the fuel filter, causing the vehicle to stall. The mechanic replaced the fuel system assembly. The contact stated that the transmission later failed, and the vehicle was sold. The vehicle was not repaired. An unknown dealer was notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 189,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11571086February 9, 2024
STEERING, SUSPENSION
The truck experienced excessive shaking when it hit a bump in the road while driving on the interstate. The steering wheel rattled so badly that the truck was difficult to control or steer. The shaking was so severe, that it felt like we had been hit by another car or had a blown tire. The violent shaking occurred when driving at speeds over 50 miles per hour.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11570285February 6, 2024
ENGINE
The contact owns a 2015 Ford F-250. The contact stated while driving at various speeds on five separate occasions, the vehicle lost motive power. The vehicle was steered to the side of the road and restarted but remained in idle mode. The vehicle was towed to a dealer three times and was diagnosed and it was determined that the reductant heater, and the front and rear knock sensors, needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 103,654.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11561484December 22, 2023
POWER TRAIN
The contact owns a 2015 Ford F-250. The contact stated that upon coming to a complete stop in a parking area, the vehicle continued to idle, and the vehicle lost motive power. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the reductive heater. The vehicle was repaired, but the failure reoccurred. The vehicle was towed back to the dealer, who then diagnosed a failure with the knock sensors. The vehicle was repaired, but the failure reoccurred. The vehicle was towed back to the dealer, who was unable to diagnose the failure. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 104,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11560153December 14, 2023
TIRES:SIDEWALL, TIRES, TIRES:TREAD/BELT
Driving on Interstate in Illinois. Tire made noise, felt the instability while driving, pulled to shoulder. Very dangerous, fast speeding cars past us, not moving over a lane. Tire had rip in sidewall. LT285/75R18 129/126R
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11556562November 23, 2023
UNKNOWN OR OTHER
At any given moment, if I have the wheel turned a little bit and hit a pot hole or crack in pavement, the drivers wheel will do a horrible wobble until I slam the brakes on and hold tight to the wheel. It will not come out of this wobble until I am at an almost complete stop. This has happened more than 10 times in a few weeks. It has been happening for a few months but is happening more and more now. I have had the tires balanced, changed the shocks, changed stabilizer shock, and replaced the tie rods. None of this has helped. After talking with a mechanic, this is a known Problem with Ford F250’s. This is very dangerous to not only me and my passengers but other drivers on the road as well when my truck swerves into other lanes and I have to slam my brakes on. I am hoping something can be done before injuries happen. Yesterday was the worst and almost caused an accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250