Ford F-250 Complaints (2001)

508 consumer complaints on file.

#11032550October 9, 2017
ENGINE
SPARK PLUG EJECTIONS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11031820October 4, 2017
ENGINE
THE CYLINDER HEAD GASKETS ARE A MANUFACTURER DEFECT. THEY USED INFERIOR QUALITY GASKETS WHICH RESULT IN ENGINE MALFUNCTION. THIS MANUFACTURER DEFECT PERTAINS TO A 2001 FORD F-250 SUPER DUTY 5.4L V8. I AM AWARE THIS ISSUE BECAME PREVALENT IN 1999 FORD F-250 MODELS AND THIS ISSUE CARRIED FORWARD TO 2001. THERE WAS A RECALL FOR THIS ISSUE FOR 1999 MODELS - $4,500 PER UNIT TO REPLACE COMPLETE ENGINE ASSEMBLIES WHERE THIS MANUFACTURER DEFECT WAS MOST PREVALENT WITH CYLINDER HEAD GASKETS. FORD DID NOT RECTIFY THIS SAFETY ISSUE AS IT PERSISTED IN THEIR 2001 MODELS. A RECALL IS NECESSARY TO RECTIFY THIS MANUFACTURER DEFECT. HTTP://WWW.AUTONEWS.COM/ARTICLE/20020401/SUB/204010753/FORD-HITS-ANOTHER-QUALITY-SNAG
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11020228August 28, 2017
STRUCTURE:BODY, POWER TRAIN
FOR THE R4100 TRANSMISSION. THE EXTERNAL TRANSMISSION FILTER CAME APART AND DESTROYED MY TRANSMISSION (FORD PART # XC3Z-7B155-BA) DEFINITELY NOT A 30,000 MILE FILTER. NOT MANY PEOPLE KNOW ANYTHING ABOUT THIS,OF WHAT I HAVE FOUND. THERE WAS A EASY 80,000 LEFT IN THE TRANS IF LINES AND OIL PORTS WEREN'T PLUGGED FROM FILTER FIBERS. #2 THE PAINT CANCER (WHITE) IS THERE ANY RECALLS OR HELP WITH THAT?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10991926May 27, 2017
SEAT BELTS
THE DRIVER'S SIDE SEAT BELT COMES UNBUCKLED WITHOUT THE LATCH BEING TOUCHED WHILE DRIVING. THIS RESULTS IN AN UNSAFE SITUATION WHERE THE SEAT BELT ISN'T PROVIDING ANY SAFETY AND IT ALSO REQUIRES TWO HANDS TO RE-BUCKLE IT TAKING MY HANDS OFF THE STEERING WHEEL. THIS HAPPENS WHILE DRIVING IN MY DRIVEWAY, ON CITY STREETS AND HIGHWAYS. THE PROBLEM HAS BEEN HAPPENING SOON AFTER I BOUGHT THE TRUCK USED ON NOVEMBER 10, 2004.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10954586February 14, 2017
VEHICLE SPEED CONTROL, SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE CRASHED INTO A PEDESTRIAN BRIDGE. THE DRIVER WAS FATALLY INJURED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE PEDAL WAS BENT AND OVERLAPPED THE ACCELERATOR PEDAL. THIS ISSUE MAY HAVE CAUSED THE CRASH. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000. UPDATED 04/04/17 LJ *CN
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
1
#10903628September 5, 2016
WHEELS
MY RECENTLY PURCHASED VEE RUBBER A/T TIRE BLEW UP WITH A LOUD BANG SUNDAY MORNING PARKED IN THE DRIVEWAY, THANKFULLY, AND NOT ON THE ROAD. I JUST BOUGHT FOUR TIRES FROM SIMPLE TIRE ON 07/07/2016 AND ONLY PUT 200 MILES ON THEM. IT APPEARS TO ME LIKE AN AIR LEAK DEVELOPED NEAR THE TREAD/SIDEWALL AREA AND DELAMINATED THE SIDEWALL FROM THE INNER LINER AND BLEW OUT NEAR THE BEAD. TIRES: VEE RUBBER TAIGA A/T LT285/75R-16 R 126/123R THE ONLY DATE CODE MARKING I SEE IS 0316?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10895338August 12, 2016
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS PARKED, THE FUEL TANK PARTIALLY DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000. UDATED 09/30/16*LJ *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10893357August 5, 2016
SEAT BELTS
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS BEING OPERATED, THE FRONT DRIVER AND PASSENGER SEAT BELTS UNLATCHED INDEPENDENTLY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10882574July 5, 2016
SERVICE BRAKES, STEERING
WHILE DRIVING BACK HOME FROM SHOPPING MY BRAKES (ANTI-LOCK STYLE) LOCKED UP AND VIOLENTLY SHOOK MY VEHICLE ALL OVER THE ROAD I WAS DRIVING ON. I HAD LIMITED OR NO CONTROL AT ALL OF THIS INCIDENT. WAS DOING ABOUT 40 MPH. TRUCK ACTED AS IF BRAKES WERE APPLIED ON AND OFF 50/60 TIMES SO FAST THAT THERE WAS NOTHING TO DO BUT HANG ON TO THE STEERING WHEEL. AT ONE POINT I THOUGHT I WAS GOING TO FLIP OVER AS THE TRUCK WENT SIDEWAYS. STEERING WENT FROM SIDE TO SIDE AT FIRST, THEN A CONSTANT PULL TO THE RIGHT. I THOUGHT ONE OF MY FRONT TIRES WAS BLOWN OUT. SLOWED DOWN ENOUGH TO GAIN SOME CONTROL BUT IT TOOK MY TRUCK OVER A CURB AND STOPPED ON A SIDEWALK AND SOME GRASS. WHEN I DID APPLY THE BRAKES NOTHING HAPPENED UNTIL I WAS ON THE SIDEWALK AND GOING VERY SLOW BY THIS TIME. GOT OUT AND INSPECTED MY TRUCK FOR DAMAGE BUT SAW NOTHING. WAS ONLY ABOUT .3 MILES FROM HOME SO I STARTED MY VEHICLE AND LIMED IT HOME AT WALKING SPEED. WHEN I TRIED TO GO A LITTLE FASTER IT WOULD START JUMPING AND SHAKING AGAIN. GOT IT HOME AND THAT IS WHEN I NOTICED THE ABS LIGHT WAS ON. IT WAS NOT ON WHEN I STARTED HOME FROM THE STORE. THIS HAPPENED SO FAST THAT I AM GLAD NO ONE WAS IN ANOTHER LANE. THIS HAPPENED ON A 3 LANE EACH DIRECTION ROAD. ALL THIS OCCURRED ON JULY 4TH AT ABOUT 10:47 A.M.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10875692June 21, 2016
ENGINE
DRIVING OUT OF STATE FOR WORK AND SPARK PLUG BLEW OUT OF MY ENGINE. AND FROM THAT RESULTS IT COST ME QUIET A BIT OF EXTRA MONEY THAT I DIDN'T HAVE TO SPEND AND MISSED A DAYS TRYING TO GET THAT PROBLEM FIXED. AND IT RUIN MY FATHERS DAY WEEKEND I WANTED TO SPEND WITH MY KID.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10865278May 16, 2016
ENGINE
I WAS IN THE PROCESS OF RUNNING A MEDICAL IN MY PERSONAL TRUCK WHEN I STARTING THE ENGINE IT POPPED AND WHEN I CHECKED IT OUT I NOTICED THE ENGINE BLEW OUT A SPARK PLUG. SO WHEN I CALLED THE PARTS STORE THEY SAID THE TYPE OF MOTOR I HAVE IN MY TRUCK IS BAD FOR BLOWING THEM LIKE THAT AND TO FIX IT WOULD COST A PRETTY PENNY SO MY QUESTION IS IF YOU ALL AND FORD KNOWS THERES A PROBLEM HOW COME THEY DONT HAVE TO FIX I KNOW SO FAR IT HASNT BEEN AN SAFTEY ISSUE YET WHEN WILL IT BE OR IS IT A CONSUMER ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10862370April 30, 2016
ENGINE
5.4 MOTOR SPARK PLUGS KEEP BLOWING OUT. THIS IS A PROBLEM WITH THE OLDER ONES AND NEWER ONES AS WELL FORD SHOULD MAKE IT RIGHT WITH THE CONSUMERS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10853238April 4, 2016
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
THE TRUCK BURST INTO FLAMES WHILE PARKED. IT HAD BEEN SITTING FOR OVER 13 HOURS AT THE TIME OF THE FIRE. IT DESTROYED ONE CAR ON EITHER SIDE OF IT. THE FIRE INVESTIGATOR COULD NOT SAY EXACTLY WHAT CAUSED THE FIRE AT THE TIME, BUT MADE ME AWARE OF A RECALL ON THAT YEAR OF FORD VEHICLES INVOLVING THE SPEED CONTROL SAFETY DEACTIVATION SWITCH. INFORMATION ON THE RECALL SAYS THAT THE WIRE COULD HEAT UP AND CAUSE A FIRE. THE TRUCK ALONG WITH TWO OTHER VEHICLES WERE COMPLETELY DESTROYED IN THE FIRE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10822661January 27, 2016
ENGINE
WHILE TRAVELING AT APPROXIMATELY 35 MPH ON A CITY STREET, THE SPARK PLUG WAS BLOWN OUT OF THE CYLINDER DESTROYING THE THREADS, COIL PACK AND SPARK PLUG.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10820882January 19, 2016
ENGINE
SPARK PLUG BLOWOUT.WHEN DRIVING ON THE HIGHWAY HAD A SPARKPLUG BLOW OUT OF THE ENGINE.LIMPED THE TRUCK HOME SLOWLY WITH GAS FUMES EVERY WERE.VERY DANGEROUS. FORD WONT ADMIT THEY HAVE A PROBLEM BUT THEY DO HAVE A FIX.YOUR DOLLARS NOT THERES.THIS IS ALSO THE SECOND TIME THIS HAS HAPPENED TO ME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10811343December 20, 2015
WHEELS
WIFE WAS DRIVING EAST BOUND ON 580 COMING DOWN WHAT WE CALL THE ALTAMONT PASS ON A SUNDAY AFTERNOON WITH MODERATE TRAFFIC. THE VEHICLE WAS EMPTY SO THE BOUNCING ON THIS FREEWAY IS PRETTY STANDARD. SHE HEARD A LOAD EXPLOSION AND THE TRUCK BEGAN TO SHAKE. SHE IMMEDIATELY PULLED TO THE SHOULDER AND NOTICED THE DRIVER SIDE REAR TIRE WAS SHREDDED ALONG WITH THE SIDE OF THE TRUCK. PRAISE GOD SHE HAD JUST HAD THE TIRES ROTATED OTHERWISE THIS TIRE WOULD HAVE BEEN IN THE FRONT AND PULLED HER ACROSS TRAFFIC. HER SPEED WAS IN THE RANGE OF 55-65 MPH WHICH IS TYPICAL FOR HER AND ON THE FREEWAY THIS TIME OF DAY. CONDITIONS WERE CLEAR AND DRY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10767463September 22, 2015
SEAT BELTS
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT VARIOUS SPEEDS, THE FRONT PASSENGER SIDE SEAT BELT BECAME DETACHED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE HAD ALREADY BEEN THROUGH A RECALL AND THERE WAS NO DEFECT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300,000....UPDATED 01/07/16 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10746794August 6, 2015
SEAT BELTS
TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT ANY SPEED, THE SEAT BELT WOULD INDEPENDENTLY UNLATCH WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS CONFIRMED THAT THERE WAS A MALFUNCTION WITH THE SEAT BELTS. THE TECHNICIAN REFUSED TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN IN TO BE INSPECTED UNDER NHTSA CAMPAIGN NUMBER: 01V227001 (SEAT BELTS) BUT NO FAILURE WAS FOUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10744306July 28, 2015
SERVICE BRAKES
LUCKILY I WAS STOPPED, BUT COULD JUST AS WELL HAVE BEEN ON EXPRESSWAY IN HEAVY TRAFFIC!!! BRAKELINE RUPTURED, MAYBE RUSTED THROUGH IN RONT OF LEFT REAR WHEEL WELL, PEDAL WENTT O THE FLOOR & ONLY HAD SLIGHT AMOUNT OF BRAKES. I CALLED FORD CUSTOMER SATISFACTION, THEY WERE LESS THAN CONCERNED. SEE ON LINE OTHERS HAVE HAD SIMILAR ISSUE. SEEMS MOR OF A PROBLEM THAN THEY WILL ADMIT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10725608June 16, 2015
TIRES
ON SEPTEMBER 12, 2011, A KUMHO ROAD VENTURE AT TIRE, SIZE LT235/85R16, DOT K2ORYD4A3508 (MANUFACTURED AT KUMHO?S BINH DUONG PLANT IN VIETNAM IN THE 35TH WEEK OF 2008) SUFFERED A CATASTROPHIC TREAD SEPARATION, RESULTING IN SEVERE INJURIES TO THE FRONT SEAT PASSENGER OF THE FORD F-250 AND THE DEATH OF HER SON, WHO WAS 32 WEEKS OLD AND STILL IN UTERO. A LAWSUIT HAS BEEN FILED AGAINST KUMHO TIRE CO., INC. AND KUMHO TIRE U.S.A., INC. IN THE UNITED STATES DISTRICT COURT FOR THE DISTRICT OF KANSAS (CASE NO. 2:13-CV-02393-JTM-TJJ). DURING THE DISCOVERY STAGE OF THE CASE, THE PASSENGER RETAINED TROY COTTLES, A RENOWNED TIRE FAILURE EXPERT. AFTER INSPECTING THE SUBJECT TIRE, MR. COTTLES FOUND THE FOLLOWING DEFECTS IN THE SUBJECT TIRE: (1) INADEQUATE BONDING BETWEEN BELTS (TRAPPED AIR/STEAM BLISTER IMPRESSIONS); (2) PREMATURE OXIDATION OF THE BELT SKIMS; (3) BELTING DEFECTS (COINCIDENTAL BELT ENDINGS, IRREGULAR BELT WIRE SPACING, GAPPED BELT SPLICES, DOG-EARED SPLICES, SNAKING, AND SPREAD CABLES); (4) CORD SHADOWS ON THE INNERLINER; (5) LOW TOP BELT WIDTH TO TREAD WIDTH RATIO; AND (6) INADEQUATE APPLICATION OF NYLON CAP PLIES. AS PART OF HIS WORK ON THE CASE, MR. COTTLES TESTED TWO EXEMPLAR KUMHO ROAD VENTURE AT TIRES OF THE SAME SIZE AS THE SUBJECT TIRE THAT WERE ALSO MANUFACTURED AT KUMHO?S VIETNAM PLANT. BOTH OF THOSE TIRES FAILED IN SIDEWALL FAILURE MODE IN APPROXIMATELY 10,000 MILES OR LESS UNDER PROPER LOADS, INFLATIONS, AND SPEEDS THAT WERE MONITORED DAILY. SEE ATTACHED TEST REPORTS AND PHOTOGRAPHS. THIS INFORMATION IS BEING SUBMITTED BY THE ATTORNEYS FOR THE INJURED PASSENGER, AND WITH HER PERMISSION, IN HOPES THAT THIS TIRE (AND THOSE SIMILAR TO IT) WILL BE INVESTIGATED AND RECALLED TO ENSURE NO ONE ELSE IS NEEDLESSLY INJURED OR KILLED AS A RESULT OF THESE DANGEROUS AND DEFECTIVE TIRES....UPDATED 07/30/15 *BF UPDATED 10/23/2017*CN
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
1

← Back to Ford F-250