Ford F-250 Complaints (2012)

323 consumer complaints on file.

#10680146January 31, 2015
FUEL/PROPULSION SYSTEM
WE WERE DRIVING IN THE LEFT LANE OF FOUR LANE HIGHWAY (TWO LANES EACH WAY) WHEN THE SENSOR WARNING CAME ON SAYING STOP SAFELY SOON. MY HUSBAND STARTED TO MOVE TO THE RIGHT. THE TRAFFIC WAS VERY LIGHT. BEFORE WE COULD GET INTO THE RIGHT LANE THE TRUCK DIED. HAD WE BEEN IN HEAVY TRAFFIC WE WOULD HAVE BEEN STALLED IN THE HIGHWAY. I AM REPORTING THIS OUT OF CONCERN FOR OTHER DIESEL TRUCK DRIVERS. FORD DEALER SAID CAUSE WAS BAD EXHAUST GAS TEMPERATURE EGT SENSOR AND WE PAID OVER $1000 TO HAVE ALL 4 SENSORS REPLACED. THIS HAS CAUSED US TO LOSE FAITH IN OUR TRUCK AND WE TRADED IT IN FOR A NEWER MODEL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10680186January 31, 2015
STEERING, SUSPENSION, WHEELS
I WAS DRIVING THE SPEED LIMIT OF 65 MPH ON THE INTERSTATE, WHEN THE TRUCK WENT OVER A ROUGH SPOT IN THE ROAD AND BEGAN TO SHAKE UNCONTROLLABLY. I COULD NOT STEER DO THE STEERING WHEEL AND THE FRONT OF THE TRUCK SHAKING SO VIOLENTLY. I MANAGED TO GET THE TRUCK SLOWED DOWN QUICKLY AND OVER ONTO THE MEDIAN. I STOPPED AND GOT OUT TO CHECK AROUND AND UNDER THE VEHICLE AND FOUND NOTHING. AS I ATTEMPTED TO GET UP TO SPEED AND MERGE BACK ONTO THE HIGHWAY THE TRUCK STARTED SHAKING AGAIN. AFTER GETTING UP TO ABOUT 50 MPH IT SMOOTHED OUT. I TOOK THE TRUCK TO DISCOUNT TIRE AND HAD THE WHEELS REBALANCED AND THE FRONT CHECKED WITH NO PROBLEMS NOTED. THE TRUCK HAS DONE THIS ABOUT 4 OR 5 MORE TIMES SINCE AND IT ALWAYS AFTER YOU GO OVER A ROUGH SPOT IN THE ROAD. THE VEHICLE SHAKES SO BAD THAT YOU CANNOT CONTROL IT AND YOU HAVE TO STAND ON THE BRAKE TO SLOW IT DOWN ENOUGH TO BE ABLE TO STEER IT. THIS CAN RESULT IN A MAJOR ACCIDENT OR DEATH!!! I HAVE ALSO HAD PROBLEMS WITH THE TRANSMISSION SINCE THE TRUCK WAS NEW. WHEN IT SHIFTS FROM 1ST TO 2ND SOMETIMES THERE IS A LONG DELAY WHERE THE THROTTLE IS PUSHED DOWN AND THE TRUCK DOES NOTHING FOR APPROXIMATELY 5 SECONDS, THIS HAS OCCURRED NUMEROUS TIMES IN INTERSECTIONS AND CAN CAUSE YOU TO BE STRUCK IN THE SIDE. I HAVE HAD THE TRUCK TO THE SHOP 3 TIMES AND THEY CHANGED THE TRANSMISSION BODY AND THE TRANSMISSION PUMP AND IT STILL CONTINUES TO HAVE THE PROBLEM... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679092January 27, 2015
ENGINE
TL*THE CONTACT OWNS A 2012 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE "STOP SAFELY NOW" MESSAGE ILLUMINATED AND MINUTES LATER THE ENGINE WOULD STALL. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE EXHAUST GAS TEMPERATURE EGT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10678940January 26, 2015
STEERING
I CURRENTLY OWN A 2012 F-250 LARIAT 6.7 LITER DIESEL AND I STARTED HAVING WHAT SOME MAY CALL A "DEATH WOBBLE" ON MY FRONT END SOMETIMES IT'S NOT THAT BAD BUT AT OTHER TIMES FROM 40-60MPH IT GETS SO BAD I HAVE TO PULL OVER. I'M SO FRUSTRATED WITH IT AND IM EVEN AFRAID TO LET MY WIFE DRIVE IT IN FEAR THAT SOMETHING BAD MAY HAPPEN ONE DAY. FORD DELIBERATELY REFUSES TO RECOGNIZE THE PROBLEM AND TRIES TO OFFER BANDAIDS FOR THE PROBLEM I NEED THIS FIXED BECAUSE I DIDN'T SPEND 70K ON A TRUCK THAT I'M AFRAID TO DRIVE. PLEASE DO SOMETHING BEFORE A LAWSUIT I JOIN A LAWSUIT AND GET THIS MATTER TAKEN ABOVE EVERYONE ELSE'S HEADS. THIS IS SOMETHING THAT THOUSANDS OF PEOPLE ARE EXPERIENCING JUST BY LOOKING ONLINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676921January 21, 2015
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
CAUTION LIGHT CAME ON ADVISING ME TO SAFELY PULL OVER AND STOP. I PULLED OVER INTO A GAS STATION AND THE TRUCK STALLED AS I WAS COMING TO A STOP. ENGINE WOULD NOT RESTART IMMEDIATELY. I CHECKED OIL LEVEL AND EVERYTHING LOOKED FINE. AFTER APPROXIMATELY 10 MINUTES THE TRUCK RESTARTED AND I DROVE STRAIT TO THE FORD DEALERSHIP IN HUNTSVILLE, ALABAMA ABOUT 15 MILES AWAY AND THEY REPLACED AN EGT SENSOR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676929January 21, 2015
ELECTRICAL SYSTEM
ATTEMPTED TO START VEHICLE USING THE REMOTE START FEATURE AND THE TRUCK STARTED FOR ABOUT 10 SECONDS THEN SHUT OFF. AFTER SEVERAL ATTEMPTS TO RESTART THE TRUCK I HAD TO GET THE DEALERSHIP TO TOW IT IN AND PERFORM NECESSARY REPAIRS, WHICH JUST HAPPENED TO BE ANOTHER EGT SENSOR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676508January 19, 2015
STEERING, SUSPENSION
WHILE DRIVING ON THE 400 JUST EAST OF AUGESTA KANSAS THE TRUCK SUDDENLY DEVELOPED A "DEATH WOBBLE". IT IS CALLED BY OTHER NAMES AS WELL, THE STEERING STARTED SHAKING UNCONTROLLABLE AND HAVE TO BRING THE TRUCK TO A STOP. THIS WAS THE SECOND IT IN THREE WEEKS IT HARDENED. IT IS AT THE DEALS HIP NOW AND CAN NOT FIND THE CAUSE. THIS SEEMS TO BE COMMON WITH THE MODEL OF TRUCK. THIS IS VERY DANGEROUS AND NEEDS TO BE ADDRESSED. FORD MUST TAKE ACTION AND NOT WAIT AS LONG AS JEEP TOOK TO ADMIT THEIR IS THE PROBLEM I ORDER TO FIX. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10671832January 12, 2015
SEAT BELTS, POWER TRAIN
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT THE FRONT DRIVER SIDE SEAT BELT MALFUNCTIONED AND FAILED TO RETRACT WHEN UNBUCKLED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN ADJUSTED THE SEAT BELT CLIP; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE CONTACT INDICATED THAT WHILE OPERATING THE CRUISE CONTROL AND DESCENDING DOWN A HILL, THE TRANSMISSION WOULD RAPIDLY DOWNSHIFT, REDUCING THE SPEED AND CAUSING THE PASSENGERS TO LUNGE FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER WHO MADE ADJUSTMENTS TO A COMPUTER, BUT THE FAILURE CONTINUED TO OCCUR. NO FURTHER INFORMATION WAS AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 15,000. UPDATED 03/04/15*LJ THE CONSUMER STATED THE SEATBELT DOESN'T ALWAYS RETRACT CAUSING IT TO BECOME DAMAGED. THE TRANSMISSION WOULD DOWNSHIFT WHILE GOING DOWNHILL. THE RPMS WOULD REACH 2000 WHEN IT SHOULD BE 1250. THE VEHICLE WOULD DOWNSHIFT 8 TIMES IN LESS THAN 7 MILES. UPDATED 10/8/2015*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667388December 19, 2014
ENGINE
THIS IS A DIESEL ENGINE F250. EGT SENSOR FAILED AND ENGINE IMMEDIATELY SHUT DOWN IN THE MIDDLE OF THE ROAD. CEL WAS ON AND MESSAGE SAID " STOP SAFELY NOW". THE FAILURE OF THE EGT SENSOR WAS KNOWN BY DEALER AND HE SHOWED ME 2 TSB S ON THE PROBLEM. PROBLEM WAS FIXED IN 2 DAYS BUT THE SAFETY ASPECT OF THIS FAILURE HAS NOT BEEN ADDRESSED BY FORD. A ALMOST IMMEDIATE SHUTDOWN OF THE ENGINE WITHOUT WARNING IS VERY DANGEROUS. IN OUT CASE WE WERE IN TOWN ON A SIDE STREET BUT WHAT IF THIS HAD OCCURRED ON THE INTERSTATE OR GOING UP OR DOWN ON A MOUNTAIN ROAD OR TOWING A TRAILER, ETC.. WE DO ALL THIS AND NOW THAT WE KNOW WE HAVE A OVER PROTECTIVE COMPUTER WAITING TO KILL THE ENGINE AT ITS WHIM WE FEEL MUCH LESS SECURE. THE COMPUTER SHOULD GIVE ADEQUATE WARNING BEFORE A SHUTDOWN AND PROBABLY SHOULD INCLUDE A LIMP HOME OPTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10663645December 11, 2014
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2012 FORD F-250. WHILE DRIVING APPROXIMATELY 40 MPH, ALL THE WARNING LIGHTS ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS UNABLE TO RESTART AND WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE POWER CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000. UPDATED 02/09/15*LJ UPDATED 6/9/2015 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10663076December 9, 2014
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2012 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 63 MPH, THE REDUCED POWER AND THE CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED TO A SECOND DEALER, WHO DIAGNOSED THAT THERE WAS AN UNKNOWN SUBSTANCE IN THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 18,877. UPDATED 01/23/14*LJ UPDATED 01/26/15*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10662021December 3, 2014
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
WHILE BACKING OUT A PARKING SPACE, THE ENGINE DIED AND A RED WARNING WAS DISPLAYED "PULL OVER SAFELY". THE ENGINE WOULD NOT RESTART. THE ENGINE IS A 6.7 LITER POWERSTROKE DIESEL THE VEHICLE WAS TOWED TO THE DEALER BY A FORD CONTRACT TOWING AGENCY AND TESTED. THE PROBLEM WAS A FAULTY EGT 12 SENSOR. WHEN THIS FAILURE OCCURS, IT IMMEDIATELY SHUTS DOWN THE ENGINE, WHICH "KILLS" THE POWER STEERING AND POWER BRAKES. THE DEALER TOLD ME THAT THE FAILURE IS A KNOWN PROBLEM AND CAN OCCUR AT ANY TIME WITHOUT WARNING, ALTHOUGH UNLIKELY. THEY HAVE HAD SEVERAL OCCURRENCES OF THE PROBLEM AT THIS DEALER ALONE. AS THIS CAN OCCUR AT ANYTIME AND SITUATION, I BELIEVE THAT A RECALL SHOULD BE ISSUED. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10660713November 24, 2014
ENGINE, POWER TRAIN, ELECTRICAL SYSTEM
AFTER DRIVING FOR 5 MINUTES A WARNING LIGHT CAME ON FOR THE REAR LOCKING DIFFERENTIAL- NO CHANGE IN THE DRIVABILITY. ABOUT 5 MINUTES AFTER THAT THE COMPUTER STARTED FLASHING DIFFERENT SYMBOLS INDICATING MANY PROBLEMS- THE ALARMS WERE GOING OFF NON-STOP- THEN THE ENGINE WAS SHUT DOWN BY THE COMPUTER. THIS TRUCK IS HEAVY AND I MAY HAVE CAUSED AN ACCIDENT WHEN IT HAPPENED BECAUSE I HAD TO USE ALL MY STRENGTH TO KEEP IT ON THE ROAD AND WENT INTO THE OTHER LANE! IF THIS HAPPENED WHILE TOWING A LOAD ON ONE OF THE MOUNTAIN PASSES I COULD HAVE BEEN SERIOUSLY INJURED OR KILLED- AND HURT OR KILLED OTHERS! FORD HAS HAD BAD DIESEL ENGINES SINCE THEY DROPPED THE 7.3 YEARS AGO AND ARE RIPPING OFF PEOPLE IN THIS COUNTRY- PLEASE DON'T LET SOMEONE DIE OVER A KNOWN PROBLEM. SEEMS CHEAPER FOR FORD TO PUT US IN DANGER BY SHUTTING DOWN THIS ENGINE AND THEREFORE NOT REPLACING THE ENGINE AND COMPUTER SYSTEM. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10658831November 18, 2014
STEERING, SUSPENSION
TRAVELING ON HIGHWAY APPROXIMATELY 60, HIT A SMALL BLEMISH IN THE ROAD, AND FRONT END STARTED A VIOLENT SHAKE, HAD TO PULL OVER AND STOP FOR SHAKE TO QUIT. HAS HAPPENED MULTIPLE TIMES SINCE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10658643November 17, 2014
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
I HAVE HAD TO REPLACE EGT EXHAUST HEAT SENSORS 4 TIMES IN MY 2012 F-250. THE SAME SENSOR TWICE,FIRST AT 26K AROUND JUNE 2013 AND AGAIN AT 46K, OCT 2014. I'VE BEEN STRANDED 3 TIMES AND HAD TO BE TOWED TO A DEALER. I OCCASIONALLY PULL A 42FT 5TH WHEEL CAMPER AND AM VERY WORRIED IT WILL HAPPEN WHILE PULLING IT WITH NO PLACE TO PULL OVER. FORD NEEDS TO STEP UP TO THE PLATE AND GET A FIX FOR THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654939November 14, 2014
ENGINE
MY TRUCK IS ONE OF MANY THAT HAVE A PRIMARY RADIATOR THAT LEAKS FROM THE DRIVERS SIDE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654807November 13, 2014
STEERING
DRIVING STRAIGHT DOWN THE EXPRESSWAY AND CAR STARTED TO VIOLENTLY SHAKE. SLOWED DOWN AND EXITED HIGHWAY, ONCE TO 20MPH IT STOPPED. PULL OFF AND CHECKED UNDER CARRIAGE FOR ANY SIGNS OF PROBLEMS. NOTING FOUND. DROVE TO DEALERSHIP WHERE I TOLD THEM THE ISSUES. THEY STATED "OH THAT IS CALLED THE DEATH WOBBLE, IT IS ON ALL THE NEW FORD TRUCKS" SPENT $600 TO STABILIZE FRONT END BUT NO GUARANTEE THAT IT WOULD BE FIXED. THIS IS WELL KNOWN PROBLEM ABOUT FORD F-250 AND F-350 TRUCKS YET THEY DO NOTHING ABOUT IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654810November 13, 2014
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
DRIVING 65 DOWN ROAD WITH LIGHT ACCELERATION. TRUCK HAD BEEN RUNNING APPROXIMATELY 20 MINUTES. MESSAGE COMES ON INSTRUMENT PANEL THAT STATES "STOP SAFELY NOW". THERE IS NO OTHER WARNING OR MESSAGE. SLOW DOWN TO PULL OVER AND TRUCK DIES AT 10MPH. NO POWER STEERING OR BRAKES. TOW IT TO THE DEALERSHIP. TOLD THAT IT IS A FAULTY EGT SENSOR AND THEY HAVE SEEN A TON OF THESE. THERE ARE 4 SENSORS ON THE EXHAUST SYSTEM AND IF ONE GOES BAD IT WILL DISABLE THE WHOLE TRUCK. REPLACED SENSOR AND NOT COVERED AS RECALL OR WARRANTY. THIS IS EXTREMELY DANGEROUS AS DEPENDING ON THE SURROUNDINGS IT COULD CAUSE INJURY OR DEATH BEING STRANDED ON ROAD FROM A SENSOR, WHEN THERE ARE 3 OTHER REDUNDANT SENSORS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654813November 13, 2014
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
DRIVING DOWN EXPRESSWAY ABOUT 70MPH DURING RUSH HOUR TRAFFIC. TRUCK HAD BEEN RUNNING ABOUT 30 MINUTES PRIOR. MESSAGE POPS UP ON INSTRUMENT PANEL THAT STATES "STOP SAFELY NOW", NO OTHER MESSAGE GIVEN. ONCE SLOWED TO APPROXIMATELY 10MPH THE ENGINE DIED AND I HAD NO POWER STEERING OR POWER BRAKES. THIS IS IN RUSH HOUR DALLAS TRAFFIC. I PULL OVER TO THE SIDE OF THE ROAD AS MUCH AS POSSIBLE AND TRY TO RESTART IT FOR 40-50 MINUTES WITH NO AVAIL. HAVE IT TOWED TO DEALERSHIP WHICH NOW INFORMS ME THAT I HAVE 3 BAD EGT SENSORS AND THEY NEED TO BE REPLACED FOR THE SAME REASON, NONE. THEY STATE THAT THEY ARE NOT COVERED UNDER WARRANTY AND FORD HAS NOT RECALLED THEM. THIS IS CONCERNING BECAUSE THIS IS THE SECOND TIME THIS HAS HAPPENED AND THIS ONE WAS IN A VERY DANGEROUS SITUATION. I KNOW OF 2 OTHER VERY CLOSE FRIENDS THAT HAVE FORD F-250 TRUCKS THAT THIS EXACT THING HAPPENED TO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10652139November 3, 2014
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
I WAS DRIVING ON I 26 AND A WARNING CAME ON SAYING TO SLOW DOWN AND PULL OVER SAFELY. I DAD NO CHANCE TO DO THIS AS THE COMPUTER PUT THE VEHICLE IN "LIMP MODE". AN 18 WHEELER NARROWLY MISSED HITTING MY TRUCK AS WE MOVED TO THE SHOULDER AND THE ENGINE DIED. THE TRUCK WOULD NOT START FOR ABOUT 45 MINUTES. WE THEN DROVE TO THE DEALER WHO SAID HE COULD FIND NOTHING OTHER THAN A WARNING TO CHANGE THE OIL. IN THE PAST 2 WEEKS, THE TRUCK HAS SHUT DOWN TWICE AGAIN. A TOW TRUCK HAD TO BE CALLED BOTH TIMES. THE FIRST TIME I WAS ON I 77 AND THE TRUCK WENT INTO LIMP MODE AND THE SHUT DOWN AS I PULLED TO THE SHOULDER. THE NEXT TIME I WAS ON US 521 GOING UPHILL WITH NO SHOULDER. THE TRUCK AGAIN WENT INTO LIMP MODE AND THEN STOPPED ON THE HIGHWAY. CARS AND TRUCKS WERE SWERVING TO AVOID US. MY WIFE WAS CRYING BECAUSE SHE WAS CERTAIN THAT AN 18 WHEELER WOULD NOT BE ABLE TO MISS US. I CALLED THE SHERIFF AND FORD AND LATER HAD THE TRUCK TOWED. THESE TWO TIMES, THE CAUSE WAS AN EGT EXHAUST GAS TEMPERATURE SENSOR FAILURE. I BELIEVE #2 FAILED AND THEN #3 (THERE ARE 4 OF THESE SENSORS). DEPENDABILITY IS OF COURSE AN ISSUE HERE. BUT THE REAL ISSUE IS SAFETY. FORD HAS DESIGNED A COMPUTER SYSTEM THAT STOPS THE VEHICLE NO MATTER WHERE YOU ARE TO SAVE THE ENGINE AND/OR THE EMISSIONS SYSTEM. IN DOING SO, THE LIVES OF THE DRIVER AND PASSENGERS ARE PUT AT RISK AND COULD BE KILLED AS A RESULT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250