Ford F-150 Complaints (2007)

488 consumer complaints on file.

#10722605June 1, 2015
FUEL/PROPULSION SYSTEM
UPON SPEEDING UP FROM A STOP THE VEHICLE STUTTERED AND STALLED. I COASTED TO A PARKING LOT AND TRIED TO RESTART. THE ENGINE WOULD CRANK BUT NO ATTEMPT TO START. AFTER SEVERAL TRIES I STOPPED. UPON CHECKING INTERNET FOR PROBLEMS DISCOVERED MANY COMPLAINTS ABOUT THE FUEL PUMP DRIVER MODULE RUSTING AND FAILING SUDDENLY. I CHECKED MODULE AND IT WAS RUSTED THROUGH. I REPLACED MODULE AND TRUCK NOW RUNS FINE. I NOTICED THAT THE MOUNTING BOLTS HAVE CHANGED ALLOWING SPACE BETWEEN MODULE AND CROSS MEMBER. OBVIOUSLY THIS IS AN ISSUE AS THE PART MOUNT HAS CHANGED. IF THIS SUDDEN FAILURE WOULD HAVE OCCURRED AT HIGH SPEED SERIOUS PROBLEMS MAY HAVE RESULTED. THIS IS A FORD ISSUE IN DESIGN THAT SHOULD BE ADDRESSED AND FIXED BY FORD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10722264May 29, 2015
POWER TRAIN:DRIVELINE:DRIVESHAFT
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 3 MPH, THE CONTACT HEARD AN ABNORMAL NOISE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE DRIVESHAFT WAS FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVESHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10717332May 19, 2015
ENGINE, ELECTRICAL SYSTEM
THE ENGINE WAS REPLACED IN 2012 WITH 53,000 MILES ON THE TRUCK DUE TO A SIGNIFICANT KNOCKING COMING FROM THE ENGINE. THE TRUCK WAS STILL UNDER WARRANTY SO IT COST ME NOTHING TO REPLACE. THE ENGINE STARTED TO MAKE THE SAME SOUND IN FEB 2015 (84,000 MILES ON THE TRUCK, 30,000 MILES ON THE ENGINE). I HAD IT TAKEN TO AN AUTO MECH AND THEY TOLD ME ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE AND RIPPED ALL THE THREADING OUT. THEY ALSO FOUND THAT ON E OF THE CYLINDERS BROKE OFF THE CRANK SHAFT AND CEASED. THE ENGINE HAS TO BE REPLACED AGAIN AND THE TRUCK IS NO LONGER UNDER WARRANTY. BOTH THE ORIGINAL DEALERSHIP THAT REPLACED THE ENGINE AND THE AUTO MECH THAT I HAD THE TRUCK TAKEN TO, ARE RESEARCHING IF THE PARTS ARE STILL UNDER WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10706090April 16, 2015
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING
WENT TO HAVE TRUCK TUNED UP--MECHANIC WOULD NOT EVEN TOUCH SPARK PLUGS BECAUSE THEY BREAK OFF AND THE ENTIRE HEAD HAS TO BE REMOVED FOR REPAIR. TOLD US TUNE UP WOULD BE VERY EXPENSIVE AND IF THEY BROKE IT WOULD BE EVEN HIGH. FROM WHAT I WAS TOLD IF SPARK PLUG IS BAD IT CAN RESULT IN FAILURE OF CATALYTIC CONVERT AND RESULT IN A CAR FIRE. WILL IT TAKE A DEATH BEFORE FORD DOES A RECALL HOW DO CONSUMERS MAINTAIN A VEHICLE WHEN AND AUTHORIZED MECHANIC WILL NOT DO THE WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705520April 14, 2015
ELECTRICAL SYSTEM
BROKEN WIRES IN THE WIRING HARNESS GOING TO THE DRIVER'S DOOR. CAUSES AUTOMATIC WINDOWS TO NOT BE ABLE TO ROLL DOWN, RADIO DOES NOT TURN OFF WHEN KEY IS OFF AND DOOR IS OPEN, KEYLESS ENTRY KEYPAD DOESN'T WORK, FOLDING MIRRORS DO NOT WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10701667March 25, 2015
ELECTRICAL SYSTEM
POWER WINDOWS STOPPED WORKING ENTIRELY. AT ALL SWITCHES. NO POWER TO THEM. WIRES IN DOOR JAM FOR POWER WINDOWS RUBBED TILL THEY BROKE. LEAVING NO POWER TO ANY WINDOW AT ANY SWITCH. COST $ 370.00 FOR FORD TO DIAGNOSE AND FIX BROKEN WIRES RIGHT WHERE MECHANIC KNEW THEY WERE BROKE BEFORE LOOKING.. THIS IS A RECURRING PROBLEM IN THESE TRUCKS AND FORD SHOULD OWN UP TO IT AND FIX THEM FREE OF CHARGE. I HAVE ALWAYS OWNED FORDS BUT AFTER THIS EPISODE WITH THE DEALERSHIP. NOT TO HAPPY......CHECKED INTERNET. MANY REPORTS OF THIS EXACTLY AS IT HAPPENED AND IN SAME AREA OF VEHICLE..HAVE SEEN MANY COMPLAINTS SAME PROBLEM, SAME FIX, SAME PLACE, SIMILAR COSTS TO CUSTOMER...NOT RIGHT. FORD IS FULLY AWARE OF THIS AND DOESN'T CARE. COULD HAVE CAUSED A FIRE. HAD A BURNT SMELL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10701468March 24, 2015
ENGINE, POWER TRAIN
TL*THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT AFTER ACCELERATING AT APPROXIMATELY 5 MPH, THE VEHICLE STALLED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10694652March 16, 2015
ENGINE
TRUCK JERKS AND JUMPS BECAUSE THE CYLINDERS AREN'T FIRING. JUST SPENT $1000 FOR NEW PLUGS A FEW MONTHS AGO. I HAVE HAD TO REPLACE SEVERAL COILS IN THE LAST 3 YEARS. PROBLEMS STARTED AROUND 100K MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10691023February 27, 2015
ENGINE
TL* THE CONTACT OWNED A 2007 FORD F-150. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE ENGINE EXPLODED AND CAUGHT FIRE. THE INSURANCE COMPANY INSPECTED THE VEHICLE AND FOUND THAT THE FIRE INITIATED AT THE MOTOR HELI COIL. WHEN FUEL PENETRATED THE HELI COIL, MOTOR, AND SPARK PLUGS, IT CAUSED THE ENGINE TO EXPLODE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT SUFFERED BURNS AND CUTS TO THE LEFT HAND. THE FAILURE MILEAGE WAS 125,000.
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#10684179February 18, 2015
FUEL/PROPULSION SYSTEM, STEERING, ENGINE
WHILE DRIVING ON A NEW YORK INTERSTATE AT APPROXIMATELY 60 MPH IN A SNOW STORM, MY TRUCK STARTED TO MISS. IT THEN SLOWED DOWN AND SHUT OFF. I DID NOT HAVE ENOUGH TIME TO MAKE IT TO THE SIDE OF THE ROAD. A TRUCK STOPPED AND I HAD HIM PUSH MY TRUCK TO THE SIDE OF THE ROAD, CAUSING ME TO HAVE DAMAGE TO MY TRUCK. FOUND OUT THAT THE FUEL PUMP DRIVER MODULE FAILED. IT IS LOCATED ABOVE THE SPARE TIRE AND DUE TO A DESIGN ERROR, WATER AND ROAD SALT GET TRAPPED BETWEEN MODULE AND MOUNTING BRACE. IT ERODES OUT FROM THE BOTTOM SIDE AND THE MOUNTING BRACKET. WHEN REPLACED, WAS INFORMED THAT IT IS A REDESIGNED COMPONENT, LIFTING IT AWAY FROM MOUNTING BRACKET. IF I HAD NOT HAD ENOUGH ROOM BETWEEN ME AND THE TRACTOR TRAILER TRAVELING BEHIND ME, OR IF I HAD ANOTHER VEHICLE TRAVELING NEXT TO ME, IT COULD BE A TOTAL DIFFERENT OUTCOME. I KNOW FOR A FACT, THAT PART COMPONENT IS EXTENDED IN STATES WHERE THERE IS A HIGH RISK OF SALT CORROSION, AND BELIEVE THAT A SAFETY ISSUE LIKE THIS SHOULD BE ONE OF THEM. SITTING ON A HIGHWAY IN A SNOW STORM IS ALWAYS DANGEROUS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10683062February 12, 2015
VEHICLE SPEED CONTROL, SERVICE BRAKES, ENGINE
OVER THE PAST SIX WEEKS, I HAVE ENCOUNTERED THREE EVENTS IN WHICH MY VEHICLE WAS ACCELERATING WHILE I HAD MY FOOT ON THE BRAKE. THE FIRST TIME, THE TRUCK WAS ATTEMPTING TO PULL FORWARD, VIBRATING, AND REVVING THE ENGINE WHILE I WAS STOPPED AT A LIGHT .I THOUGHT IT WAS A FLUKE OR AN ERROR ON MY PART AND DISREGARDED IT. THE SECOND AND THIRD TIME, I WAS TRYING TO SLOW DOWN FOR THE LIGHT WITH VEHICLES AHEAD OF ME. INSTEAD OF STOPPING AS I WAS DEPRESSING THE BRAKE, THE ENGINE BEGAN TO REV AND PULL FORWARD. I DEPRESSED MY BRAKES TO FLOOR AND THE TRUCK STOPPED BUT THE ENGINE CONTINUED TO REV AND ATTEMPT TO PULL FORWARD WITH THE BRAKE ON. FORD COMPANY AND MY DEALERSHIP, OF COURSE, DENIED ANY PROBLEMS EVEN AFTER I CITED SEVERAL CASES IN WHICH THIS OCCURRED WITH OTHER CARS. THEY SAID SOMETIMES SENSORS GO OUT AND THEY SHOULD NOT BE RESPONSIBLE FOR IT BUT WERE HAPPY TO DO A DIAGNOSIS FOR $100. I SEE SEVERAL COMPLAINTS REGARDING THE ELECTRONIC THROTTLE CONTROL SYSTEMS COMPARED TO THE NEW BRAKE OVERRIDE SYSTEMS AND AM TOTALLY UNNERVED THAT FORD WILL NOT TAKE RESPONSIBILITY FOR THIS. I AM CONCERNED ABOUT DRIVING THE TRUCK WITH ONLY 45,000 MILES ON IT. I FEAR THAT ANY MOMENT, MY TRUCK IS GOING TO ACCELERATE INTO ANOTHER VEHICLE WHILE MY FOOT IS ON THE BRAKE. I WILL NEVER BUY A FORD AGAIN--A TOTAL DISREGARD FOR CONSUMER SAFETY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10681735February 6, 2015
ENGINE
TL*THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE DECELERATED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT PHASER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10680369February 1, 2015
STRUCTURE:BODY
CAB CORNER RUST OUT ROCK PALL RUST OUT WHEN I PAY 38000 GRAND FOR A TRUCK NEW OFF THE LOT NOW WITH 30000 MILES SHOULD NOT BE THAT MUCH RUST COME TO FIND OUT ON THE BACK OF THE CAB CORNER THERE A GAP WHERE WATER LEAK IN TO THE ROCKER AND THE WATER LAYS IN THERE AND RUST OUT THE BOTTOM OF THE DOOR AND HOW HARD WOULD OF BEEN TO RUN A BEAD OF SEAM SEALER FOR WATER COULD OF GOT DOWN IN THERE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10680242January 31, 2015
ENGINE
3 OUT OF 8 SPARK PLUGS HAVE BLOWN OUT OF HEAD IH MOTOR. THIS SEEMS TO BE A COMMON PROBLEM AFTER RESEARCHING SEVERAL OTHER MAKES AND MODELS OF ALL FORD VEHICLES. I HAVE SEARCHED FOR RECALL INFORMATION FROM FAULTY DESIGN WITH NO LUCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679537January 28, 2015
FUEL/PROPULSION SYSTEM
TRUCK WOULDN'T START. HAD TO BE TOWED TO DEALER. PROBLEM WAS CORRODED FUEL PUMP DRIVER MODULE. NEW PART COST $195.07 AND LABOR WAS $285.00. GOING ON LINE TO SEE WHAT WAS DONE, THE LABOR CHARGES SEEM VERY EXCESSIVE! THIS ISSUE LOOKS TO BE VERY WIDESPREAD AND SHOULD BE A RECALL BY FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10678589January 23, 2015
AIR BAGS
I WAS STOPPED AT A STOP SIGN AND THE OTHER DRIVER RAN A STOP SIGN AT 55 MPH AND HIT ME ON THE PASSENGER SIDE FRONT FENDER AND MY AIR BAGS NEVER WENT OFF. I HAVE HAD TO GO TO THE HOSPITAL WITH HURT SHOULDER AND BACK AND BRUISED KIDNEYS FRACTURED RIBS AND BRUISED LIVER AND MY ORGANS SWOLLEN AND A DISPLACED HIP. I AM STILL TRYING TO RECOVER FROM THE MAJOR SOFT TISSUE DAMAGE AND THE TRUCK WAS A TOTAL LOSS. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10676779January 20, 2015
SEAT BELTS, AIR BAGS
TL* THE CONTACT OWNED A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 99 MPH, THE VEHICLE STRUCK AN EMBANKMENT AND ROLLED OVER TWO AND A HALF TIMES. THE AIR BAGS DID NOT DEPLOY. THE DRIVER WAS WEARING A SEAT BELT; HOWEVER, HE WAS EJECTED FROM THE VEHICLE THROUGH THE REAR DRIVER SIDE WINDOW. THE DRIVER SUSTAINED FATAL INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. THE VIN WAS UNAVAILABLE.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
1
#10671638January 11, 2015
POWER TRAIN
WHILE DRIVING ON THE FREEWAY AT 75MPH A WARNING LIGHT CAME ON SAYING TRANSMISSION FAULT. THE OVERDRIVE LIGHT WAS FLASHING. THE TRUCK CONTINUED TO DRIVE NORMALLY BUT THE WARNING INDICATORS KEPT GOING ON. THERE WERE NO CODES WHEN IT WAS TAKEN TO THE SHOP ALTHOUGH THE SHOP SAID THEY HAVE A RETAINING CLIP THAT WEARS OUT AND CAUSES ALL THE PARTS TO SHIFT. THIS RESULTED IN HAVING TO REPLACE THE TRANSMISSION. FORD NEEDS TO RECALL THE DEFECTIVE PARTS. MANY OTHER F 150 OWNERS HAVE HAD THE SAME PROBLEM. TRANSMISSION REPLACEMENT COST MORE THAN I BOUGHT THE TRUCK FOR! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668585December 28, 2014
TIRES, TIRES:TREAD/BELT
HANKOOK DYNAPRO AS P235-70-R17S TIRE WITH APPROXIMATELY 60% WEAR (ACCORDING TO FORD DEALERSHIP WHERE VEHICLE WAS PURCHASED AND TIRES REPLACED). DURING NORMAL DRIVING NOTICED ABNORMAL BUMPING THAT APPEARED TO BE ASSOCIATED WITH TIRE OR FRONT END. TOOK VEHICLE TO SHOP TO CHECK BALANCE AND WHEEL ALIGNMENT. TECH FOUND THE ABOVE DESCRIBED TIRE HAD SEPARATED AND THE STEEL BELTING WAS PROTRUDING THROUGH THE TREAD AND TOP OF SIDEWALL. TIRE WAS ABOUT TO FAIL. DRIVER CONTACTED HANKOOK AND FORWARDED A PHOTOGRAPH OF THE TIRE TO THE REPRESENTATIVE. HANKOOK AGREED TO A 40% REFUND OF THE AMOUNT THAT FORD PAID (NOT WHAT I PAID) FOR THE TIRE IF I WOULD RETURN THE TIRE OR A PIECE FROM IT CONTAINING THE DOT NUMBER. FORD TOOK THE TIRE FOR RETURN TO HANKOOK. THREE WEEKS HAVE PASSED AND I HAVE NOT HEARD BACK FROM FORD OR HANKOOK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667831December 23, 2014
POWER TRAIN
STARTED TO ACCELERATE OUT OF A PARKING LOT AND HEARD A LOUD THUMPING SO I PULLED OVER GOT OUT LOOKED AT THE DRIVESHAFT SEEN IT HAD SLID BACK. A BIT OUT OF THE TRANSMISSION ALSO OUT OF THE CARRIER BEARING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150