Ford F-150 Complaints (2005)

1,112 consumer complaints on file.

#10154370April 2, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION
JERKING AND BUMPING NOISE IN DRIVE LINE AT LIGHT ACCELERATION JUST BEFORE OR JUST AFTER TRANSMISSION SHIFTS TO THE NEXT GEAR. DEALER ADDED A GEAR FLUID ADDITIVE THAT THEY SAID WAS LEFT OUT AT FACTORY. THIS DID NOT FIX THE PROBLEM. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10152933March 17, 2006
FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING:ENGINE
DT*: THE CONTACT STATED WHILE THE HEATER IS ENGAGED GAS FUMES ARE DETECTED IN THE VEHICLE. IN AN ATTEMPT TO REMEDY THE PROBLEM THE DEALER REPLACED THE FUEL INJECTORS, SPARK PLUGS, STARTER, FLY WHEEL, TRANSFER CASE, AND CATALYTIC CONVERTER WITH NO SUCCESS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10152583March 13, 2006
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
DT*: THE CONTACT STATED WHILE APPLYING THE BRAKE THE PEDAL GOES TO THE FLOOR AND THE CONTACT'S FOOT PRESSES THE ACCELERATOR. THE DEALER INDICATED THE BRAKES OPERATE AS DESIGNED AND BOTH THE BRAKE AND ACCELERATOR PEDALS MEET THE FMVSS. NO REPAIRS HAVE BEEN MADE. UPDATED 3/28/2006 - *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151520March 1, 2006
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
SHUDDERING, SHAKING, ROUGH IDLE, BANGING WHEN RE-APPLYING GAS AFTER COASTING AND STALLING AT INTERSECTIONS. THEN MANUFACTURER HAS REPLACED 5 FUEL INJECTORS SO FAR AND THE TRUCK IS RUNNING ROUGH AGAIN. I HAVE 23K MILES. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151426February 28, 2006
VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM:HORN
DT*: THE CONTACT STATED WHILE STOPPED THE VEHICLE LURCHED FORWARD WITHOUT WARNING. THE ENGINE REVVED TO 5000 RPM AND THE TIRES SPUN AND WERE BURNING RUBBER. THE DEALER COULD NOT DUPLICATE THE PROBLEM AND NO REPAIRS WERE MADE. *JB THE HORN ASSEMBLY WAS REPLACED. UPDATED 03/17/06. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151476February 28, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
WHILE DRIVING MY 2005 F150, THE PASSENGER SIDE REAR TIRE STARTED LOCKING UP AND SMELLING REALLY BAD. I STOPPED TO INVESTIGATE AND FOUND THE RIM TO BE VERY HOT. I DROVE IT A FEW MORE MILES TO A LOCAL FORD DEALER. THEY SAID THEY WERE GOING TO LOAN ME A CAR FOR FREE AND FIX THE PROBLEM. I ASKED WHAT PROBLEM AND THEY SAID THE PROBLEM THEY HAVE STARTED HAVING WITH F150 BRAKE CALIPERS LOCKING UP WHILE CUSTOMERS ARE DRIVING. IT BOTHERS ME THAT I HAD TO FIND OUT ABOUT THE PROBLEM THIS WAY. I THINK FORD SHOULD BE TELLING CUSTOMERS ABOUT THIS PROBLEM RIGHT NOW BEFORE SOMEONE GETS HURT BAD FROM THIS DEFECT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150774February 21, 2006
SEAT BELTS:FRONT
DT*: THE CONTACT STATED WHILE APPLYING THE BRAKES IN EMERGENCY SITUATIONS, THE FRONT SEAT BELTS DO NOT LOCK. THE SEAT BELTS RETRACTED, BUT DO NOT HOLD THE PASSENGERS IN THE SEAT. THE SEAT BELTS LEAVE ENOUGH WEBBING TO WHERE THE PASSENGERS COULD IMPACT THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER FOR INSPECTION. THE DEALER REPLACED THE SEAT BELTS WITH NEW ONES; HOWEVER THE NEW SEAT BELTS HAVE THE SAME PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150543February 17, 2006
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL, SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
DT*: THE CONTACT STATED AFTER ATTEMPTING TO APPLY SUDDEN BRAKE PRESSURE, THE VEHICLE STRUCK ANOTHER VEHICLE IN THE REAR RESULTING IN MINOR DAMAGE. THE BRAKES STOPPED THE VEHICLE, HOWEVER NOT BEFORE THE POINT OF IMPACT. NO INJURIES WERE SUSTAINED AND THE POLICE WERE NOT NOTIFIED. AFTERWARDS, THE CONTACT DISCOVERED THE BRAKE PEDAL WAS TOO CLOSE TO THE ACCELERATOR PEDAL. IT WAS SUSPECTED THAT DUE TO THE DESIGN THIS COULD BE UNSAFE, ALTHOUGH THE PLACEMENT OF THE ACCELERATOR PEDAL WAS NOT A FACTOR IN THE ACCIDENT. THE DEALER WAS NOTIFIED. A MANUFACTURER REPRESENTATIVE INSPECTED THE VEHICLE. IT WAS DETERMINED THE PLACEMENT OF THE ACCELERATOR AND BRAKE PEDAL MET FEDERAL MOTOR VEHICLE SAFETY STANDARDS AND NO CORRECTIONS WERE MADE.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10150274February 14, 2006
ELECTRICAL SYSTEM
2005 FORD F-150 SUPER CREW 4X4, HAVING ELECTRICAL PROBLEMS IN VEHICLE,WITH A BURNING SMELL, LIGHTS COMING ON WITH NO ONE IN VEHICLE, A/C COMING ON BY IT'S SELF AND CAN'T SHUT IT OFF, BATTERY GOING DEAD,4 WAY FLASHERS TURNING CAN'T TURN OFF, RADIO GOING HAYWIRE,INTERIOR LIGHTS COMING ON,BUZZERS RINGING WHEN DRIVING, TURN KEY OFF GAUGES STAY ON. HAD 2,600 MILES ON VEHICLE WHEN IT BURNED. DEALER COULD NEVER FIND ANYTHING??????*JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10149947February 10, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
FRONT ROTORS WARPED WITHIN 9000 MILES AND WHEN BRAKES ARE APPLIED THE STEERING WHEEL JUMPS AND VIBRATES UNCONTROLIBLY ROTORS WERE RESURFACED AT 10,293 MILES THEN REPLACED AT 11,475 MILES AND REPLACED AGAIN AT 17,158 MILES AND AT THIS TIME I WAS TOLD THAT THE WARRANTY WOULD EXPIRE AT 23,475 MILES ON THE ROTORS AND I WOULD HAVE TO PAY FOR REPLACEMENT PARTS AND LABOR AFTER THIS MILEAGE AS OF THIS DATE I HAVE 20,400 MILES ON VEHICLE AND THE ROTORS AGAIN ARE STARTING TO WARP WHICH CAUSES VIBRATION WHEN BRAKES ARE APPLIED *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10149880February 9, 2006
SUSPENSION:FRONT
DT*: THE CONTACT STATED THE FRONT END VIBRATED AT 45MPH AND ABOVE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP FOR INSPECTION NUMEROUS TIMES. THE DEALER REPLACED THE DRIVESHAFT, TRANSMISSION MOUNTS, CUT THE ROTORS AND TIGHTENED THE PINION IN THE REAR END. ALTHOUGH THESE REPAIRS WERE MADE, THIS DID NOT REMEDY THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10149881February 9, 2006
ENGINE AND ENGINE COOLING:ENGINE
DT*: THE CONTACT STATED THERE WERE NOISES THAT RESEMBLED THE SOUND OF BREAKING GLASS. AFTER FINDING THE SOURCE OF THE NOISE IT WAS DISCOVERED THE VEHICLE HAD CAUGHT ON FIRE. THE VEHICLE HAD BEEN PARKED SINCE THE PREVIOUS DAY. THE FIRE SPREAD TO THE CONTACT'S OTHER VEHICLE AND HOME. THE FIRE MARSHAL FILED A REPORT. THE FIRE STARTED IN THE ENGINE COMPARTMENT AND COMPLETELY MELTED. THE VEHICLE IS STILL BEING INSPECTED. THERE WERE NO PREVIOUS PROBLEMS WITH THE VEHICLE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10149179February 1, 2006
AIR BAGS:FRONTAL
DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN A FRONT END COLLISION AT 40 MPH AND THE AIRBAGS DID NOT DEPLOY. THERE WAS NO BRAKING PRIOR TO IMPACT. THERE WERE NO PREVIOUS PROBLEMS WITH THE AIRBAGS. THE CONTACT WAS WEARING A SEAT BELT, BUT SUSTAINED MINOR INJURIES. ALTHOUGH THE VEHICLE SUSTAINED EXTENSIVE DAMAGE, THE VEHICLE WAS NOT TOTALED BY THE INSURANCE ADJUSTOR. THE POLICE WERE ON THE SCENE AND A REPORT WAS TAKEN. UPDATED 02/21/06. *JB
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10148938January 29, 2006
VEHICLE SPEED CONTROL
THE INCIDENT DATE IS THE MOST RECENT. TRUCK HAS ONLY 4200 MILES ON IT. ON ALL FOUR OCCASIONS I WAS BRAKING WHEN IT BEGAN TO ACCELERATED THREE TIMES AT HIGHWAY SPEEDS, ONE TIME ON A GRAVEL ROAD. THE CRUISE WAS NOT ON. I DID NOT HAVE MY FOOT ON BOTH THE BRAKE AND ACCELERATOR. THE BRAKES NOR THE EMERGENCY BRAKE WOULD HOLD IT. ACCELERATION WENT UP TO 3000+ RPMS AND WAS WITNESSED BY THE PASSENGER. I HAD TO SHIFT TO NEUTRAL TO GET IT STOPPED. ALL FOUR TIMES THE DEALER COULD NOT IDENTIFY THE PROBLEM NOR MAKE IT HAPPEN AGAIN. IT IS A VERY UNSAFE AND COULD HAVE CAUSED A FATALITY ACCIDENT. FORD DID REPROGRAM THE PCM MODULE, BUT IT HAPPENED AGAIN AFTER THAT.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147877January 16, 2006
STEERING, POWER TRAIN:AUTOMATIC TRANSMISSION
POPPING FROM REAR-END AT SLOW SPEEDS AND SHUTTERING AT DOWN SHIFT ON HIGHWAY. LOCAL DEALER SAID REAR PINION GEAR OUT OF ALIGNMENT, AND CLUTCH PACKS WERE BAD THEY HAD TO ORDER PARTS TO FIX THE PROBLEMS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147368January 10, 2006
ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE
DT*: THE CONTACT STATED WHILE SITTING INSIDE THE VEHICLE THERE WAS AN ODOR OF GASOLINE. THE VEHICLE WAS INSPECTED BY THE LOCAL DEALERSHIP, AND THEY REPLACED 7 FUEL INJECTORS, 8 SPARK PLUGS, AND ORDERED A FUEL RAIL. THESE ATTEMPTS TO SOLVE THE PROBLEM HAVE BEEN UNSUCCESSFUL. *AK UPDATED 01/25/06. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147006January 5, 2006
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
DT*: THE CONTACT STATED THERE WAS A FEATURE ON THE PASSENGER'S AIR BAG THAT DISABLED THE AIR BAG BASED ON THE WEIGHT OF THE PASSENGER. THE AIR BAG LIGHT ILLUMINATED ONLY WHEN THERE WAS AN OCCUPANT IN THE PASSENGER'S SEAT. THE DEALERSHIP DETERMINED THERE WAS NO ADJUSTMENT TO THIS SENSOR, AND THE MANUFACTURER TOLD THE CONTACT THAT THIS WAS NORMAL. *AK UPDATED 1/25/2006 - THE AIR BAG WAS DISABLED ALTHOUGH A 120 LB OCCUPANT WAS IN THE SEAT. THE CONSUMER CONTACTED THE DEALER. THE DEALER NOTED THE FAILURE BUT CLAIMED THERE WAS NO WAY TO CORRECT THE PROBLEM. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146695January 2, 2006
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
I HAVE EXPERIENCED BRAKE FAILURES ON AT LEAST 5 OCCASIONS. IT HAS OCCURRED AT SLOW SPEED WHEN APPROACHING A STOP AT AN INTERSECTION AND WHEN BEHIND OTHER VEHICLES IN TRAFFIC. THE BRAKES APPEAR TO BE ENGAGING THE ANTI-LOCK BRAKING SYSTEM AND START TO PULSE BUT FAIL TO STOP. ALL OF THE INCIDENTS HAVE OCCURRED WHEN THE PAVEMENT WAS COMPLETELY DRY AND THE ROAD SURFACES WERE CLEAN. ALL INCIDENTS HAVE BEEN NARROW MISSES IN TRAFFIC COLLISIONS. AFTER EACH INCIDENT THE BRAKES APPEAR TO RETURN TO NORMAL FUNCTION AND ONLY ONCE HAVE I BEEN ABLE TO DUPLICATE THE FAILURE WHICH WAS IN A PARKING LOT SHORTLY AFTER THE VERY FIRST INCIDENT. DURING EACH INCIDENT I INITIALLY APPLY AND HOLD THE BRAKE UNTIL I REALIZE COMPLETE FAILURE AND THEN RELEASE AND RE-APPLY. EXCEPT FOR YESTERDAY (01/01/2006) THE BRAKES ENGAGED ON THE SECOND ATTEMPT. YESTERDAY THE VEHICLE CAME TO A STOP ON THE THIRD ATTEMPT BUT ONLY BECAUSE THE INITIAL SPEED WAS SO SLOW THE VEHICLE JUST RAN OUT OF FORWARD MOMENTUM AND THE MINIMAL BRAKING HELD THE VEHICLE. I BACKED OUT OF THE INTERSECTION, BRAKED, TESTED STOPPING AND THE BRAKES APPEARED FINE AT THAT TIME. I PLAN TO TAKE THE VEHICLE BACK TO THE DEALERSHIP TOMORROW. THE DEALERSHIP HAS SEEN THE VEHICLE FOR THIS PROBLEM IN ADDITION TO A CHARGING LIGHT PROBLEM AND HAVE FAILED TO FIX EITHER PROBLEM. THE DEALERSHIP STATED THAT THEY WERE UNABLE TO FIND A BRAKING PROBLEM AND WERE UNABLE TO RE-CREATE THE BRAKING MALFUNCTION. THEIR RESOLUTION WAS TO BLEED THE BRAKING SYSTEM AND RETURN THE VEHICLE TO SERVICE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146241December 28, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP, AIR BAGS:FRONTAL, SEAT BELTS:FRONT
DT: THE CONTACT STATED WHILE TRAVELING ON THE HIGHWAY GOING AT 55 MPH THE VEHICLE HIT SOMETHING IN THE MIDDLE OF THE HIGHWAY WITH THE LEFT FRONT TIRE. THE BRAKES WERE APPLIED BUT THEY DID NOT WORK. THE CONSUMER THEN LOST CONTROL OF THE VEHICLE. THE VEHICLE TRAVELED INTO THE MEDIAN AND COLLIDED WITH THE RETAINING WALL. THIS WAS A FRONTAL IMPACT. THE SEAT BELTS FAILED TO PROPERLY RESTRAIN THE CONSUMER AND THE AIR BAGS FAILED TO DEPLOY WHICH RESULTED IN INJURIES TO THE OCCUPANT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP A COUPLE OF WEEKS PRIOR TO THE ACCIDENT FOR AN ABS PROBLEM. THEY WERE UNABLE TO DUPLICATE THE PROBLEM WITH THE BRAKES. *AK UPDATED 1/25/2006. *NM
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10145922December 22, 2005
STRUCTURE:BODY:DOOR
DT: THE CONTACT STATED THE FRONT AND REAR THIRD DO NOT ALWAYS CLOSE COMPLETELY. THIS SOMETIMES ALLOWED WATER TO LEAK INTO THE VEHICLE WHEN IT RAINED OR WHEN IT WAS WASHED. THERE WAS NO INDICATOR LETTING THE CONTACT KNOW THE DOOR DID NOT CLOSE PROPERLY. THE DEALER WAS NOT CONTACTED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150