Ford F-150 Complaints (2022)

911 consumer complaints on file.

#11746133June 24, 2026
UNKNOWN OR OTHER
In April 2026 the recall on this truck was done to correct a fault for the Trailer Disconnect. I hooked up my travel trailer for the 1st time here in June and the false warning still came on 5 times during my trip. The software update that was done is not solving the problem. Warning light comes on, says trailer disconnected while the trailer is still connected and all connections are plugged in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745994June 23, 2026
STEERING
While shift gear into drive the gear came loose. And then when attempting to shift gear into park shift wouldnt go into park.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745956June 23, 2026
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated that the rear axle hub bolt had fractured on three separate occasions while driving. The contact stated that there was an abnormal rattling sound coming from the rear hubcap, followed by a rear-end fluid leak prior to each failure. Several unknown warning lights were illuminated. The dealer replaced the driver’s and passenger’s side rear axles under warranty twice. Following the most recent failure, the owner received notification of NHTSA Campaign Number: 23V896000 (Power Train); but was informed that parts for the repair were on back order. The manufacturer was made aware of the failure and provided a case number. The contact attempted to notify the manufacturer several times via phone and email, but received no response. The vehicle was not repaired. The failure mileage was approximately 26,095.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745953June 23, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: ASSIST
Adaptive cruise control applies brakes at varied levels from light to full stop when passing vehicles on the left in an open highway setting when no vehicle is present ahead. Speed range is approx 65-75mph. Other conditions are Interstate highway open road, sunny to partly cloudy, and problem occurs when passing and a longer vehicle (CL8 or other vehicle with trailer is present on the right), no other unusual or notable conditions can be remembered at this time. Other vehicles following in trail were often surprised and required immediate throttle engagement to prevent collision from following vehicles. Not all unexpected brake events produced a warning, however it appears that full brake events a pre-collision warning did appear. 3 attempts were made but dealer was not able (authorized by OEM) to perform extended drive cycles. On 4th attempt claim was stored code was found and multiple components were replaced. However, problem reoccurred in a subsequent highway trip, and there was a clear degradation of the LKA accuracy, as the LKA would no longer keep lane center and would not correct of provide departure warning until on top of after crossing lane line markings. Additionally "hands on wheel" warning would appear even though hands were on the steering wheel at the time. The vehicle is now at the dealer for the 5th attempt at diagnosis and repair. The dealer and OEM claim that installing a data logger is not possible, which I find difficult to agree with as there are clear parameters to measure and tripper a recorded event.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745732June 22, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that parts had been unavailable for a year. The dealer was contacted, and the contact was informed that parts were unavailable. The manufacturer was contacted, and the contact was informed that the parts were unavailable. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744576June 16, 2026
POWER TRAIN
Notified of the Recall 23V-896 remedy/parts availability in May of 2025. Appointment scheduled to inspect and submit photos to ford for parts order on 6/3/2025. Called to follow up 9/2025, 1/2026, 5/2026. As of 6/16/2026 the repair order is still open for the parts and there has been no estimated time of delivery. The rear axle bolt on the passenger side has since broken during the wait for the remedy. Ford is taking an unreasonable amount of time to repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744547June 16, 2026
FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM, EXTERIOR LIGHTING
The contact owns a 2022 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 26V104000 (Electrical System, Exterior Lighting) and 25V455000 (Fuel System, Gasoline); however, parts for the recall repairs were unavailable. The dealer was contacted; and the contact was informed that parts were not yet available. The manufacturer was contacted, and the contact was informed that the parts were unavailable. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744236June 15, 2026
POWER TRAIN
heard rattling sound in right rear wheel, dealer confirmed rear axle bolt was broke.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743936June 13, 2026
EXTERIOR LIGHTING
Daytime led light went out one side
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743589June 11, 2026
UNKNOWN OR OTHER
Preston Automotive Group sold me a used truck that had a replaced odometer and offered and sold as if the vehicles odometer reflected correct mileage. When I brought to their attention they said this is not illegal and should not be a problem and offered no remedy!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743367June 10, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, POWER TRAIN
Highway Incident: While traveling at highway speeds, a sudden evasive braking maneuver caused the truck to drop power. Upon attempting to re-accelerate, the throttle pedal went to the floor with zero response, and the vehicle continued to decelerate on an active highway. Multiple trailing vehicles had to make emergency maneuvers to swerve around the decelerating truck to avoid a high-speed, rear-end collision. Subsequent Incidents: The vehicle repeatedly forces an uncommanded speed limit of 11 mph while attempting to accelerate from a complete stop or merge from stop signs. This severe lack of predictable acceleration creates an immediate risk of being T-boned or rear-ended by cross-traffic, making the vehicle entirely unsafe to operate in normal traffic conditions. An authorized Ford dealership has confirmed the underlying failure of the hybrid system. They kept the vehicle for approximately one month to replace the entire hybrid drive unit. Following that repair, the vehicle was returned to the dealer a second time, where technicians confirmed a software communication failure between the electric and gas systems, attempting to resolve it by flashing/reprogramming the ECU. The vehicle’s hybrid system and software have been extensively inspected and worked on by manufacturer-certified technicians at an authorized Ford dealership. It has not been inspected by police or insurance, as no physical collision has occurred yet. No warning lamps or messages.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741745June 3, 2026
STEERING, SUSPENSION
Component Failed & Inspection Status: The front-left upper and lower control arms, ball joints, wheel hub assembly, steering knuckle, and front axle shaft have failed. Severe environmental corrosion has completely seized and fused the steering knuckle inside the wheel hub. All original failed components are currently intact and are fully available for physical inspection upon request. Safety Risk: This severe structural corrosion causes the steering knuckle and axle to seize, creating an imminent risk of primary steering component separation while driving. A steering separation on a heavy electric vehicle (over 6,000 lbs curb weight) causes a sudden, complete loss of directional control, creating an immediate life-threatening hazard to the occupants and surrounding traffic. Confirmation & Testing:The failure and severe structural corrosion were officially diagnosed and confirmed by a certified technician at an authorized Ford dealership service center. Warning Signs & Symptoms: The symptom appeared as a very noisy, distinct creaking sound coming from the front-left suspension. This noise occurred specifically when turning the steering wheel and when operating the vehicle at speeds below 40 mph. The sounds may have been present but obscured by road noise at higher speeds. There were no dashboard warning lamps or error messages prior to the diagnostic inspection. Systemic Concerns: This 2022 model is experiencing a severe vulnerability to premature environmental corrosion that causes the steering knuckle, axle, and control arms to seize to the point of failure. This demonstrates a critical structural durability issue under heavy EV loads in road-salt regions that warrants federal safety tracking for the 2022 model year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741778June 3, 2026
POWER TRAIN
The contact own a 2022 Ford F-150. The contact stated while at an stop the contact herd a a snapping coming the vehicle and the vehicle failed to ilthe contact stated that the headlights and both turn signals were inoperable and failed to to illuminate. The vehicle was taken to the dealer where it was not diagnosed or repaired. The contact was informed that the failure could not be duplicated. The contact also stated that the failure peristed after taking the vehicle to the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 66,000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741532June 2, 2026
EXTERIOR LIGHTING
The driver-side integrated factory LED headlight assembly experienced a sudden, complete failure of the vertical LED Daytime Running Light (DRL) / parking lamp strip. The vehicle is completely stock, and the electrical system has never been modified or altered. The component failed suddenly with no prior warning lights, dashboard messages, or symptoms. Safety Risk: The failure of the LED DRL significantly reduces the vehicle’s forward visibility and conspicuity to oncoming traffic, pedestrians, and cyclists, particularly during daytime hours, dusk, dawn, and inclement weather. Because only one side is illuminated, oncoming drivers may misjudge the width, position, or presence of the truck, significantly increasing the risk of a front-end or sideswipe collision. Inspection Status: The failed component is currently intact and installed on the vehicle, making it available for inspection upon request. At this time, the problem has not yet been inspected or confirmed by a dealer, independent service center, manufacturer, insurance, or law enforcement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741475June 2, 2026
FUEL/PROPULSION SYSTEM
Recall has been out for 11 months and still no fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741352June 1, 2026
BACK OVER PREVENTION
The contact owns a 2022 Ford F-150. The contact stated that when reversing the vehicle, the backup camera no longer operated, and the display showed only a blank blue screen. The contact referenced NHTSA Campaign Number: 23V342000 (Back Over Prevention) to be the cause of the failure however, the VIN was not included in the recall notice. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer not notified of the failure. The failure mileage was 40.000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741299June 1, 2026
VISIBILITY/WIPER
The panoramic moonroof glass shattered while the vehicle was parked and stationary in my driveway. There was no known impact from another object and no occupants were in the vehicle at the time of the incident. I had the moonroof sunshade closed when the glass shattered. The upper surface of the sunshade contained the shattered glass fragments, including both large and small pieces. Upon inspection, I did not observe any foreign object resting on the sunshade, inside the vehicle, or on the ground surrounding the truck that would indicate an object had struck the moonroof. Based on my observations, I am unaware of any external event that caused the glass to shatter. Vehicle mileage was approximately 54,500 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740686May 28, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle was sluggish. The contact stated that the failure occured intermittently. There was no warning light illuminated. The dealer was contacted, but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 34,824.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740552May 28, 2026
EXTERIOR LIGHTING
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740328May 27, 2026
UNKNOWN OR OTHER
Based on publicly available reports and similar complaints, multiple F-150 vehicles with the 10-speed automatic transmission appear to experience similar transmission failures at relatively low mileage under normal driving conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150