Ford F-150 Complaints (2006)

585 consumer complaints on file.

#10214592January 12, 2008
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS
BRAKES WORKED FINE UPON ARRIVING AT STORE. UPON LEAVING PARKING LOT AS I APPROACHED STREET, I APPLIED BRAKES TO LEARN THAT THE VEHICLE HAD NO BRAKES. I PRESSED THE BRAKES VERY HARD AND WAS ABLE TO SLOWLY STOP. I WAS PROBABLY TRAVELING AT LESS THAN 5-10 MPH LEAVING PARKING. I CHECKED BRAKE FLUID AND ANY ENGINE CODES, ALL WERE NORMAL. I PROCEEDED TO THE HOUSE CAREFULLY ALLOWING FOR MAXIMUM DISTANCE. BY PRESSING VERY HARD ON BRAKE PEDAL, I WAS ABLE GRADUALLY COME TO A STOP. ON MONDAY, 11/19/2007, I TOOK THE VEHICLE TO THE LOCAL FORD DEALERSHIP. THE VEHICLE THIS MORNING HAD A CHECK ENGINE LIGHT VISIBLE. THE TROUBLE WAS QUICKLY DIAGNOSE BY SERVICE MECHANIC AS A BROKEN VACUUM LINE BEHIND THE ENGINE. THE SMALL COUNTRY DEALERSHIP RELATED THAT THEY REPLACED THE SAME LINE ON A SIMILAR VEHICLE THE WEEK BEFORE. THE DEALERSHIP WAS IN SOUTHEAST GEORGIA AND THE NEAREST PART WAS IN MEMPHIS, TN AND WOULD TAKE 2 DAYS TO ARRIVE. PLUS, THE MANIFOLD AND OTHER PARTS HAD TO BE REMOVED TO GET TO LINE. IT TOOK SOME 6 HOURS OF LABOR TO REPLACE. THE PARTS AND LABOR WAS $767.80 AND THE RENTAL CAR WAS $112.19. THE SERVICE ON THE VEHICLE WAS COMPLETED IN THE AFTERNOON OF 11/21/2007. THE MILEAGE ON THE TRUCK WAS 43996 MILES WHEN TAKEN IN FOR SERVICE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10214093January 7, 2008
STEERING
TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT AT 395 MILES, THE PASSENGER SIDE FRONT BUMPER WAS BENT AND THE BED WAS ALIGNED IMPROPERLY. THE FORD DEALER REPAIRED THE VEHICLE FOR FREE. THE INSIDE OF THE FRONT TIRES HAD SEVERE EDGE WEAR BECAUSE OF AN ISSUE WITH THE ALIGNMENT ONCE AGAIN AT 4,076 MILES. THE DEALER PERFORMED A 4-WHEEL ROTATION AND ALIGNED THE VEHICLE. THE CONTACT TOOK THE VEHICLE BACK AT 11,000 MILES FOR THE SAME FAILURE. HE ALSO STATED THAT THE STEERING WHEEL VIBRATED WHEN DRIVING 70 MPH. THE DEALER CHANGED THE DRIVER SIDE FRONT TIRE, FRONT SHOCK ABSORBER, AND PERFORMED ANOTHER WHEEL ALIGNMENT. THE CONTACT TOOK THE VEHICLE BACK AND THE DEALER CALLED FORD MOTOR COMPANY. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO MISSION VALLEY FORD FOR A WHEEL ALIGNMENT. THEY PERFORMED A WHEEL ALIGNMENT AND INFORMED HIM TO COME BACK FOR A FOLLOW-UP VISIT AFTER 1,000 MILES. THE CONTACT OBEYED AND THE VEHICLE WAS FOUND TO BE OUT OF ALIGNMENT ONCE AGAIN. MISSION VALLEY FORD CALLED FORD MOTOR COMPANY AND THE CONTACT WAS THEN ADVISED TO TAKE THE VEHICLE TO SUNNYVILLE FORD. FORD AUTHORIZED FOUR NEW TIRES AND AN ALIGNMENT AT 18,456 MILES. HE WAS ADVISED ONCE AGAIN TO TAKE THE VEHICLE BACK AFTER 1,000 MILES FOR A FOLLOW-UP VISIT. THE FRONT TIRES WERE FOUND TO HAVE INSIDE EDGE WEAR AND THE DEALER ROTATED THEM AND PERFORMED ANOTHER ALIGNMENT. THE CONTACT TOOK THE VEHICLE BACK AT 19,640 MILES AND THEY ROTATED THE TIRES ONCE MORE. THE CONTACT TOOK THE VEHICLE BACK AFTER 1,000 MILES. AFTER THAT, HE WAS INFORMED THAT NOTHING ELSE COULD BE DONE. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 21,056 AND FAILURE MILEAGE WAS 4,076.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10214124January 7, 2008
ENGINE AND ENGINE COOLING
RANDOM STALLING, LOOSES POWER AND COMPLETELY SHUTS DOWN EVERYTHING. 2006 FORD F150. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10212669December 24, 2007
ENGINE AND ENGINE COOLING:ENGINE
VEHICLES MISFIRING AND STUBBLING DURING MODERATE ACCELERATIONS AND CRUISING WHEN A LOAD IS PUT ON MOTOR. ( GOING UP A HILL, SLIGHT INCLINE AND PASSING). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10210789December 4, 2007
SERVICE BRAKES, HYDRAULIC
WHILE DRIVING 40MPH POWER BRAKES FAILED WITHOUT WARNING. I WAS ABLE TO STOP & PULL OVER WITH COMBINATION OF E BRAKE AND COASTING. FORTUNATELY THIS HAPPENED ON A SIDE STREET WITH ONLY LIGHT TRAFFIC. THE VEHICLE WAS TOWED TO FORD DEALER WHO DETERMINED THAT A VACUUM BOOST HOSE WAS DETACHED FROM THE MANIFOLD. THE DEALER REPLACED THE HOSE AND ADDED A CLAMP TO THE CONNECTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10207573October 31, 2007
EQUIPMENT:APPLIANCE:AIR CONDITIONER, EXTERIOR LIGHTING:HEADLIGHTS, TIRES
CONTACT: CRYSTAL SHAW, FORD MOTOR COMPANY, 5700 GRANITE PKWY, STE 1000, PLANO, TX 75024-6640 HER FAX NUMBER: 972-334-1832 GO TO : HTTP://WWW.CONSUMERAFFAIRS.COM/NEWS04/2006/11/FORD_LEMON_LINEUP.HTML I OWN 2006 FORD F-150 LEMON. THE LEMON AIR CONDITIONER WAS COMING-APART WITHIN TWO WEEKS OF PURCHASED. THE TRUCKS REQUIRES NUMEROUS JUMPS. THE LIGHTS FAIL NEARLY KILLING US . THEY STILL HAVE NOT GOTTEN MY REPLACEMENT VEHICLE, PAY FOR MY RENTALS, OTHER EXPENSES. THIS IS LEMON PRESENTS SERIOUS SAFETY HAZARDS. I HAVE A 74 YEAR-OLD HANDICAPPED MOTHER. I NEED YOUR ASSISTANCE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10207421October 30, 2007
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC:HOSES, LINES/PIPING, AND FITTINGS
TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT HEARD A POPPING SOUND AND NOTICED SMOKE UNDER THE HOOD AND DASHBOARD WHEN THE VEHICLE WAS STARTED. THE NOISE SOUNDED AS IF THE VEHICLE BACKFIRED. WHILE DRIVING 55 MPH, THE POWER BRAKES FAILED WITHOUT WARNING. THE CONTACT APPLIED THE EMERGENCY BRAKE TO STOP THE VEHICLE AND PULLED OFF THE ROAD. HE NOTICED THAT THE VACUUM HOSE WAS DETACHED FROM THE MANIFOLD, WHICH SUPPLIES VACUUM POWER TO THE BRAKE BOOSTER. THE VEHICLE WAS TOWED TO A FORD DEALER. THE DEALER PLACED THE VACUUM HOSE BACK ON THE ENGINE AND INFORMED THE CONTACT THAT IT SHOULD BE REPLACED. THE WEATHER WAS NOT A FACTOR. THE CURRENT MILEAGE WAS 23,000 AND FAILURE MILEAGE WAS 22,000. UPDATED 11/15/07 *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10204432September 29, 2007
UNKNOWN OR OTHER, STRUCTURE
I HAVE A 2006 FORD F-150 THAT HAS PAINT PEELING OFF THE FRONT CAP JUST BELOW THE GRILL. WHAT REALLY CONCERNS ME IS THAT I WORK FOR A LARGE COMPANY THAT HAS HUNDREDS OF FORD VEHICLES AND MOST OF THE 2004, 2005, & 2006 MODELS ARE PEELING AS WELL. WHAT IS FORD GOING TO DO ABOUT THIS.. I FIND THIS VERY UN-ACCEPTABLE.. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10203927September 24, 2007
ENGINE AND ENGINE COOLING, EQUIPMENT:APPLIANCE:AIR CONDITIONER
TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 40 MPH, THE CONTACT HEARD A RATTLING NOISE UNDERNEATH THE VEHICLE. THE DEALER STATED THAT THE A/C COMPRESSOR WAS SEPARATING. THE DEALER MADE THE REPLACEMENT, HOWEVER, THE NOISE CONTINUED. THE CONTACT TOOK THE VEHICLE TO THE DEALER, BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF FAILURE. IN ADDITION, THE VEHICLE FAILED TO START. AS OF SEPTEMBER 24, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 495 AND CURRENT MILEAGE WAS 23,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10203831September 19, 2007
SERVICE BRAKES, HYDRAULIC
2006 FORD F-150 WITH BRAKE FAILURE. CUSTOMER STATES THAT THE BRAKE PEDAL FELL ALMOST ALL THE WAY TO FLOOR LEVEL. HE STATES THAT THE DEALER IS UNABLE OR UNWILLING TO FIX THE PROBLEM. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10202513September 11, 2007
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
INSTRUMENT CLUSTER HAS A SHORT. PART COST WILL BE $500. PLUS LABOR. THIS MEANS CLUSTER WILL START A FIRE. EVENTUALLY. RIGHT NOW THE DASH IS INTERMITTENT. SOMETIMES THERE IS NO SPEEDOMETER, AC, ENGINE TEMPERATURE,CRUISE CONTROL, OIL PRESSURE, FAN, DEFROST. THESE GO ON AND OFF WHILE DRIVING. SINCE TRUCK IS ONLY ONE YEAR OLD, THIS MEANS FORD WANTS YOU TO PAY UP TO A THOUSAND DOLLARS A YEAR FOR AN INSTRUMENT CLUSTER. THIS SHOULD BE A RECALL. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201932September 5, 2007
SERVICE BRAKES, HYDRAULIC, FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP
ACCELERATION WHEN APPLYING THE BRAKES. THIS HAS OCCURRED SEVERAL TIME THE MOST RECENT BEING TODAY. I ALMOST RAN INTO A BUILDING PULLING INTO A PARKING SPACE. THE TIME BEFORE WAS AT A RED LIGHT, NO ONE WAS IN FRONT OF ME AND THE TIME BEFORE THAT I WAS HAULING AN ANTIQUE CAR ON A TRAILER WITH TRAILER BRAKES THAT ACTUALLY KEPT ME FROM HITTING ANYONE WHEN THE TRUCK BRAKES CAUSED AN ACCELERATION. I AM AFRAID TO DRIVE THIS TRUCK. I ALSO HAD A PROBLEM WITH THE FUEL PUMP POURING FUEL OUT OF THE TRUCK ONTO THE EXHAUST SYSTEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201652September 1, 2007
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
INSTRUMENT PANEL GOES OFF AND ON. TOOK TO DEALER FOR RECALL ON THIS PROBLEM #06C11. 24 HOURS LATER TRUCK DASH STILL INTERMITTENT. NO ODOMETER READING AT ALL NOW. SPEEDOMETER, AC, CRUISE CONTROL, TACHOMETER AND WATER TEMPERATURE GAUGE GO OFF AND ON WHILE DRIVING. TIME LENGTH RANDOM. VERY DISCONCERTING NOT TO KNOW HOW FAST YOU ARE DRIVING. PROBLEM IS INCREASING-ANYWHERE FROM 1 TO 5 TIMES IN AN HOUR OF DRIVING. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10200903August 27, 2007
TIRES
ON AUGUST 26, 2007 I WAS TRAVELING EAST ON HIGHWAY 190 BETWEEN KEMPNER, TX AND COPPERAS COVE, TX AT ABOUT 10:30 A.M. IN A 2006 FORD F-150 SUPER CREW WITH ABOUT 25,000 MILES ON IT. ROAD CONDITIONS WERE DRY AND THE ROADWAY WAS RECENTLY REDONE. MY SPEED WAS ABOUT 65 MPH IN A 70 ZONE. FOR NO REASONS THAT I CAN DETERMINE THE RIGHT REAR TIRE RAPIDLY DEFLATED. I MANAGED TO KEEP THE VEHICLE UNDER CONTROL AND PULLED ONTO THE SHOULDER. THE TIRE WAS DESTROYED WITH EVIDENT DAMAGE TO THE OUTER SIDEWALL. I PUT THE SPARE TIRE ON AND CONTINUED. MONDAY, 27 AUGUST I VISITED AUTOMAX FORD AND ASKED THEM TO REPLACE ALL THE TIRES ON THE VEHICLE. THE SERVICE MANAGER TOLD ME THAT TIRE DEFECTS WERE THE RESPONSIBILITY OF THE MANUFACTURER. I MADE THE DECISION AT THAT TIME TO REPLACE ALL THE TIRES WITH ANOTHER BRAND. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10200016August 18, 2007
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT, SERVICE BRAKES, HYDRAULIC:POWER ASSIST, SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP, SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC:HOSES, LINES/PIPING, AND FITTINGS
COMPLETE POWER BRAKE FAILURE.I TURNED ON MY ENGINE, HEARD A LOUD POPPING SOUND, DROVE FORWARD A FEW FEET AND DISCOVERED THE POWER BRAKES INOPERABLE. NO WARNING LIGHTS CAME ON BEFORE OR AFTER THE INCIDENT. I TOOK THE VEHICLE TO THE NEAREST FORD DEALERSHIP --OLYMPIC LINCOLN MERCURY SEATTLE-- AND THEY REPAIRED IT UNDER WARRANTY. THEY SAID A POOR CONNECTION OF A PRESSURE LINE UNDER THE FUEL RAIL CAUSED THE PROBLEM. THEY SAID NO RECALLS HAD BEEN ISSUED. THEY HAD NO EXPLANATION FOR WHY THE WARNING LIGHTS DID NOT COME ON. THIS INCIDENT HAPPENED APPROXIMATELY 4 MONTHS AGO. I DON'T HAVE THE PAPERWORK IN HAND. IF NEEDED I CAN PROVIDE THE EXACT DATE. THE DATE ABOVE IS A QUESTIONED. OLYMPIC LINCOLN MERCURY HAS CHANGED HANDS, IT IS NOW JACK CARROLS LINCOLN MERCURY. THIS SUDDEN LOSS OF BRAKES WITHOUT WARNING COULD HAVE BEEN DISASTROUS. MY SON WAS WITH ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10199761August 16, 2007
TIRES
TL*THE CONTACT OWNS A 2006 FORD F-150. THE VEHICLE HAS HANKOOK DYNAPRO AS TIRES, SIZE P235/75R17. IN JULY OF 2007, THE CONTACT NOTICED THAT ONE OF HIS TIRES WAS FLAT. FORD STATED THAT HIS NEGLIGENCE CAUSED THE FLAT TIRE. THE TIRE FAILURE MILEAGE WAS 3,000. THE CURRENT VEHICLE MILEAGE WAS 3,200 AND FAILURE MILEAGE WAS 3,000. UPDATED 02-01-08. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10195595July 9, 2007
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 60 MPH, THE CONTACT SMELLED SMOKE COMING FROM THE VEHICLE. SHE WAS THEN ALERTED BY A MOTORIST THAT HER VEHICLE WAS ON FIRE. THERE WERE NO WARNING INDICATORS. SHE PULLED OVER AND EXITED THE VEHICLE BEFORE IT BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE VEHICLE WAS TOWED AWAY. THE VEHICLE HAD AN OIL CHANGE TWO DAYS BEFORE THE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 36,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10195167July 2, 2007
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
TL*THE CONTACT OWNS A 2006 FORD F150. EVER SINCE THE VEHICLE WAS PURCHASED, IT HAS BEEN TO THE DEALER ON FOUR OCCASIONS. THE CONTACT STATED THAT HIS BRAKES FEEL SPONGY AT ALL SPEEDS AND WHEN IDLING. HE STATED THAT THE BRAKE PEDAL STOPS THE VEHICLE, BUT IT IS NOT FIRM AND EXTENDS ALL THE WAY TO THE FLOORBOARD AT ANY GIVEN MOMENT. DURING ONE OF THE FOUR TRIPS TO THE DEALER, THE MECHANIC BLED THE BRAKE LINE, BUT THIS DID NOT RESOLVE THE FAILURE. THE CONTACT RECEIVED A LETTER FROM FORD IN FEBRUARY OF 2006, WHICH STATED THAT THE VEHICLE FAILED TO CONFORM TO BOTH STANDARD #105 AND #135. THE CURRENT MILEAGE IS 6,888 AND FAILURE MILEAGE WAS 100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10194814June 27, 2007
TIRES:TREAD/BELT
2006 FORD F150 WITH 34000 MILES, CONTINENTAL CONTITRAC TIRES ARE WORE OUT IRREGULARLY AND PREMATURELY. REPLACED TIRES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10193344June 14, 2007
SUSPENSION:FRONT
TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 70 MPH, THE CONTACT DROVE OVER A SERIES OF BUMPS IN THE ROAD AND HIS VEHICLE BEGAN TO JUMP AND SHAKE VIOLENTLY. AS TIME PROGRESSED, HE COULD DRIVE 55 MPH AND RIDE OVER A POTHOLE OR EVEN THE SLIGHTEST OF BUMPS. AS A RESULT, THE VEHICLE BEGAN TO SHAKE AND VIBRATE SIMILAR TO HOW A FLAT TIRE WOULD FEEL. THE DEALER STATED THAT HE NEEDED SHOCKS AND TIRES. AFTER SPENDING $1,600 DOLLARS ON WHAT THE DEALER RECOMMENDED, HIS VEHICLE IS STILL VIBRATING AND SHAKING UNCONTROLLABLY. THE CURRENT MILEAGE IS 41,132 AND FAILURE MILEAGE WAS 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150