Ford F-150 Complaints (2004)

2,029 consumer complaints on file.

#10457913May 9, 2012
SUSPENSION
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING APPROXIMATELY 42 MPH, THE CONTACT NOTICED THE FRONT END OF THE VEHICLE BEGAN TO SHAKE ABNORMALLY. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE FRONT COIL SPRINGS WERE FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10456729April 27, 2012
ENGINE AND ENGINE COOLING
SINCE APPROXIMATELY 120,000 MILES, THIS VEHICLE HAS EXPERIENCED SPARK PLUG FAILURE AT A RATE OF ABOUT TWO EACH 5,000 MILES. PRIOR TO THIS PERIOD, THE VEHICLE HAD NO HISTORY OF SPARK PLUG FAILURE. THE PLUGS WERE CHANGED IN ACCORDANCE WITH THE MANUFACTURER'S RECOMMENDED SERVICE SCHEDULE AROUND 101,000 MILES. BETWEEN 120,000 AND 142,000 MILES, EIGHT SPARK PLUGS AND TWO COILS FAILED DURING NORMAL DRIVING CONDITIONS. AN ADDITIONAL TUNEUP AND COMPLETE SPARK PLUG REPLACEMENT WAS PERFORMED AT 142,000 MILES AFTER TWO FAILED DURING NORMAL FREEWAY DRIVING CONDITIONS. ANOTHER SPARK PLUG BLEW OUT AND WAS REPLACED AT 148,000 MILES. IN ADDITION TO SPARK PLUG FAILURE, SEVERAL OF THESE PLUGS HAVE BROKEN WHILE BEING EXTRACTED, CAUSING NEEDLESSLY EXPENSIVE REPAIRS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10455060April 13, 2012
POWER TRAIN
WAITING AT A STOP LIGHT THAN PROCEEDED TO GO WHEN LIGHT TURNED GREEN ALL OF A SUDDEN BIG BANGING AND GRINDING NOISE COMING FROM UNDER TRUCK LOOKED UNDER AND SEES DRIVE SHAFT BROKE IN HALF POLICE WERE CALLED TO HELP DIRECT TRAFFIC AND CALLED TOW TRUCK! MECHANIC OF THE REPAIR SHOP TOLD ME WHY IN HIS REPORT THAT THE DRIVE SHAFT BROKE HE SAID THE DRIVE SHAFT HAD RUSTED IN THE MIDDLE TO CAUSE IT TO BREAK IN HALF!! MY SAFETY ISSUE IS I BOUGHT THE TRUCK BECAUSE ITS BIG I DRIVE MY GRAND KIDS IN IT NOW CAN YOU IMAGINE WHAT WOULD HAPPEN ON A HIGHWAY AT 55 MPH!!! EVERYONE I SPOKE TOLD ME THEY NEVER HEARD OF A DRIVE SHAFT BREAK AND RUST LIKE THAT ESPECIALLY ITS ONLY A 2004 MODEL!! CAN YOU HELP ME ON THIS ISSUE I HAVE WITH FORD! THANK YOU....... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10455004April 12, 2012
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2004 FORD F150. WHILE DRIVING APPROXIMATELY 40 MPH, A LOUD CLICKING NOISE EMITTED FROM UNDER THE VEHICLE. THE FAILURE PROGRESSED AND COULD BE HEARD WHENEVER THE VEHICLE WAS IN OPERATION. THE NOISE WOULD INCREASE AS THE SPEED WAS INCREASED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED THE CONTACT THAT THE EXHAUST MANIFOLD WOULD NEED TO BE REPLACED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10453274March 27, 2012
POWER TRAIN
TRANSMISSION FAILED AND WAS REPLACED. REAR DIFFERENTIAL NEEDS TO BE REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10453003March 26, 2012
ELECTRICAL SYSTEM, VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
I HAVE A 2004 F150 WITH 22,000 MILES ON IT AND EVERY WINDOW REGULATOR IN THE TRUCK HAS GONE OUT AND SEND THE WINDOW CRASHING DOWN. THIS IS THE FOURTH ONE. FORD WILL NOT RECALL IT, IT IS A KNOW ISSUE. THE DEALERSHIP TOLD ME, "LADY ITS YOU AND THOUSANDS LIKE YOU." *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10452416March 20, 2012
ENGINE AND ENGINE COOLING
I PURCHASED THE TRUCK USED WITH AN ODOMETER READING OF 86,782 MILES. I WAS NOT TOLD THAT I NEEDED TO REPLACE THE SPARKPLUGS OR THAT THERE IS A MAJOR ISSUE WITH THE SPARKPLUGS BREAKING. I ASSUMED THAT IF THERE WAS ANY ISSUE OF THIS NATURE THE DEALERSHIP WOULD HAVE TO DISCLOSE THIS PROBLEM ON THE PURCHASING AGREEMENT. I WENT TO THE DEALERSHIP LAST WEEK DUE TO THE WINDOW MOTOR SEIZING/BREAKING. I PAID FOR THE SERVICE TO REPAIR THAT ISSUE, WHICH IS ANOTHER PROBLEM AS WELL. DURING THAT VISIT I WAS INFORMED ABOUT THE SPARK PLUG PROBLEM, WHICH FORD HAS ISSUED A TSB REPORT ABOUT. THE PLUGS BECOME FUSED TO THE ENGINE BLOCK AT 100,000 MILES, AND I AM NOW AT 105,000 AND JUST FINDING OUT ABOUT THIS! THE PROBLEM THAT I AM EXPERIENCING IS THAT THE DEALERSHIP WANTS TO CHARGE AN ABSORBENT AMOUNT OF MONEY TO CHANGE THE SPARK PLUGS, AND IF ANY BREAK, ITS AN EXTRA $100 TO REMOVE EACH BROKEN PLUG. THAT COULD POTENTIALLY BE AN ADDITIONAL $800 EXTRA TO CHANGE THE SPARK PLUGS. THAT IS ABSOLUTELY LUDICROUS FOR FORD TO CHARGE AN OWNER FOR SUCH A TASK! ALSO IT IS IMPORTANT TO NOTE THAT THE DEALERSHIP THAT I PURCHASED THE TRUCK FROM OBVIOUSLY KNEW ABOUT THIS ISSUE AND NEGLECTED TO INFORM ME IN ANY FASHION. I AM CONSIDERING TAKING LEGAL ACTION AS I BELIEVE THE DEALER SHOULD BE LIABLE TO COVER THE COST OF THIS TASK, AS THEY DID NOT DISCLOSE THESE PROBLEMS THAT ACCORDING TO THE DEALER HAD TO BE ADDRESSED WITHIN 10,000 ADDITIONAL MILES. THAT IS A VERY SHORT AMOUNT OF MILES TO DRIVE FOR SUCH A MAJOR EXPENDITURE. I DO BELIEVE THAT I SHOULD HAVE TO PAY A TYPICAL FEE FOR PARTS AND SERVICE TO REPLACE THE SPARKPLUGS AS THEY ARE A MAINTENANCE ITEM. HOWEVER, I BELIEVE THAT IF THE DEALER HAS ANY PROBLEM CHANGING THE SPARKPLUGS, IT SHOULD REST ON THEIR SHOULDERS TO COVER THOSE COSTS. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10452445March 20, 2012
POWER TRAIN:AUTOMATIC TRANSMISSION, VEHICLE SPEED CONTROL
AT 50,000 MILES , AND EARLIER, THE ENGINE WARNING LIGHT CAME ON, THE TRUCK LOST ALL POWER, AND THE POWER STEERING FAILED. UPON TAKING THE TRUCK TO THE DEALER, IT WAS DETERMINED THAT THE THROTTLE BODY WAS DEFECTIVE, AND NEEDED REPLACING. NEEDLESS TO SAY, I THINK THAT THIS SHOULD NOT HAVE HAPPENED AT SUCH A LOW MILEAGE AND SHOULD BE COVERED UNDER A RECALL. THANKS FOR ALLOWING ME TO VENT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450691March 7, 2012
VISIBILITY
I WAS DRIVING ON THE INTERSTATE AT 65 MPH WHEN ALL OF A SUDDEN MY WINDOW DISAPPEARED STARTLING ME. I HAD MY KIDS IN THE CAR WHO WERE FRIGHTENED BY THE GUSH OF WIND. IT SURPRISED ME AND I WAS NOT CERTAIN WHAT HAPPENED MY WINDOW WAS JUST GONE ON THE DRIVERS SIDE.THE WINDOW HAD FALLEN INTO THE DOOR. APPARENTLY AFTER MY RESEARCH I LEARNED THAT FORD HAS HAD MANY PROBLEMS WITH ITS WINDOW REGULATORS FAILING CAUSING THIS ISSUE. THIS IS EXTREMELY DANGEROUS AND COULD CAUSE A SERIOUS ACCIDENT. I HOPE FOR BEFORE IT IS TOO LATE AND HARM IS DONE THAT FORD WILL OWN UP TO THIS PROBLEM AND HAVE RECALL TO REPAIR THE WINDOW MECHANISM THAT FAILS. IF FORD DOES NOT DO ANYTHING THAN NHTSA SHOULD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450276March 5, 2012
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
IN MY SUPER-CAB - WITHOUT WARNING THE DRIVER'S SIDE WINDOW FELL COMPLETELY DOWN TO THE BOTTOM OF THE DOOR AND WOULD NOT RAISE BACK UP WHILE IN ROUTE ON THE INTERSTATE. IT WAS LOUD AND SHOCKING! THIS OCCURRED OUT OF WARRANTY THE FIRST TIME AT 53,354 MILES. YESTERDAY (3/4/12), THE PASSENGER WINDOW DID EXACTLY THE SAME THING AND STARTLED MYSELF AND MY WIFE. THIS PRESENTS AN EXTREMELY UNSAFE AND UNSECURED SITUATION, ESPECIALLY IN THE WINTER CONDITIONS WE EXPERIENCE HERE IN THE NORTHWEST. THERE ARE HUNDREDS IF NOT THOUSANDS OF SIMILAR INCIDENTS POSTED ON THE INTERNET FOR THIS MODEL, 2004-2008. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450070March 2, 2012
VISIBILITY
TL* THE CONTACT OWNS A 2004 FORD F-150 SUPER CREW LARIAT. THE CONTACT WAS DRIVING 5 MPH WHEN THE FRONT DRIVER'S SIDE POWER WINDOW FAILED AND FELL INTO THE DOOR PANEL. THE FAILURE REPEATED ON SEVERAL OCCASIONS WITH BOTH THE FRONT AND PASSENGER SIDE REAR WINDOWS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 108,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450011March 1, 2012
STRUCTURE, ELECTRICAL SYSTEM
I HAVE OWNED THIS TRUCK SINCE 2004, NO SERIOUS ISSUES. THIS PAST FRIDAY I NOTICED POWER WAS STILL GOING TO MY TRUCK WHEN IT WAS TURNED OFF. THE POWER ACCESSORY RELAY WAS CLICKING VIGOROUSLY THEN STOPPED, NO POWER INSIDE MY VEHICLE. I STARTED THE TRUCK AND EVERYTHING WORKED EXCEPT FOR THE RADIO. I WENT FOR A DRIVE THAN AND THEN THE REVERSE LIGHTS CAME ON THE DOOR BUZZER WAS GOING OFF, AS I WENT TO STOP I HEARD A GRINDING NOISE OCCUR THAN STOPPED. WAS ABLE TO GET IT HOME. I HAVE 30 YEARS OF MECHANIC EXPERIENCE AND TRIED TO FIND A POSSIBLE SHORT. WHEN I REMOVED THE PASSENGER SIDE ROCKER PANEL I FOUND THE HARNESS COVERED IN RUSTY WATER. NOW DOING RESEARCH ON THE INTERNET, I HAVE SEEN HUNDREDS OF PEOPLE COMPLAINING ABOUT THIS ISSUE, THAT FORD WONT COVER. IT TURNS OUT MANY PEOPLE HAD TO HAVE WIRING HARNESS REPLACED COSTING THOUSANDS. WHILE CONDUCTING MY RESEARCH I HAVE FOUND OUT WATER IS LEAKING THROUGH THE WINDSHIELD THE REAR WINDOW AND WIRING HARNESS THAT TRAVELS THROUGH THE FIREWALL. PLEASE HELP, FORD WILL NOT ADMIT TO THEIR MISTAKE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10449747February 29, 2012
ELECTRICAL SYSTEM
THIS TRUCK HAS ONLY BEEN USED THREE TIMES IN FIVE MONTHS. IT WAS PARKED ON A PARKING PAD UNATTENDED FOR THREE DAYS AN 10 HOURS. THE MAIN ELECTRICAL WIRING STARTED A FIRE INSIDE OF THE TRUCK ON ITS OWN. IF IT HAD NOT BEEN FOUND AT 3:00 AM IT WOULD HAVE MOST LIKELY KILL TWO PEOPLE IN THEIR BEDS. UPDATED 03/12/12 *BF *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10449229February 24, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC WHERE THE MECHANIC STATED TO THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 69,000. UPDATED 03/23/12*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10449048February 23, 2012
POWER TRAIN
THE CLUTCH PACK IN THE DRIVEN TRAIN REAR DIFFERENTIALS LOCK UP WHEN TURNING CORNERS AND HOWLS WHEN GOING DOWN THE ROAD. THESE FAILURES ARE SO COMMON ON FORD TRUCK THAT FORD IS NOW ADDING FRICTION MODIFIERS TO THE REAR DIFFERENTIALS TO REAR THE PROBLEM AND AFTERMARKET SUPPLIERS ARE MAKING REPLACEMENTS FOR THE CLUTCH PACK LIKE DETROIT LOCKER TO ELIMINATE THE PROBLEM. THIS LOCK UP ON WINTER SURFACES CAUSE THE WHEELS TO LOOSE TRACTION INCREASING THE POTENTIAL FOR ACCIDENTS. THE HOWLING SOUND IS ALSO A DRAG ON THE DRIVE TRAIN COMPONENTS, REDUCING MPG AND CAPABILITY OF THE VEHICLE TO HANDLE ADVERSE CONDITIONS. FORD HAS KNOWN ABOUT THIS PROBLEM FOR SEVERAL YEARS AND HAS DONE NOTHING TO FIX THE PROBLEM OR REIMBURSE OWNERS FOR THE COST OF REPAIR. ON MY TRUCK, TOTAL REAR END REPAIR COSTS HAVE EXCEEDED $3700. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10449106February 23, 2012
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THERE WAS AN ABNORMAL INCREASE OF ACCELERATION TO 80 MPH FOR A BRIEF MOMENT. THE VEHICLE THEN RESUMED NORMAL OPERATION. ON A SEPARATE OCCASION WHILE DRIVING, THE BRAKE PEDAL WAS ENGAGED WITH A RAPID INCREASE IN RPMS, FOLLOWED BY AN UNEXPECTED INCREASE IN SPEED. THE GEAR WAS SHIFTED INTO PARK IN ORDER TO STOP THE VEHICLE. THE FAILURE RECURRED FIFTEEN TIMES AND WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT PLANNED TO TAKE THE VEHICLE BACK TO THE DEALER FOR A SECOND DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 24,000. ..UPDATED 04/16/12 *BF THE CONSUMER ALSO STATED THERE WERE TIMES WHEN HE STARTED THE VEHICLE AND THE ENGINE RACED AT HIGH RPM'S AND IT WAS NOT RELATED TO THE ENGAGEMENT OF THE CHOKE IN COOL OR COLD WEATHER. ALSO IN RELATION TO INCREASED RPM'S ABOVE AFTER THE VEHICLE WAS SHIFTED INTO PAR, THE ENGINE CONTINUED TO RACE AT 5,000 RPM'S.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448457February 19, 2012
ENGINE AND ENGINE COOLING
2 1/2 YEARS AGO MY HUSBAND PURCHASED A USED 2004 F-150 FX4 WITH THE 5.4 TRITAN ENGINE (WITH A 5 FOR THE 8TH DIGIT IN THE VIN) ALONG WITH A 2 YEAR EXTENDED WARRANTY (THAT COVERED THE ENGINE AMONG OTHER THINGS), FROM A FORD DEALERSHIP. IT HAD JUST UNDER 50,000 MILES. OVER TIME, WE HAD THE SUGGESTED OIL CHANGES, PUT NEW TIRES ON, NEW BATTERY AND HAD THE SPARK PLUGS CHANGED. THE PROBLEM I AM MOST UPSET ABOUT IS THE ??TICKING?? SOUND I HEARD THE DAY MY HUSBAND BROUGHT THE TRUCK HOME. WHEN I ASKED ABOUT IT HE SAID HE ALREADY ASKED THE DEALERSHIP WHAT THE SOUND WAS AND THEY SAID IT WAS JUST HOW ??THIS ENGINE SOUNDS??. IT WAS SUCH A STRANGE SOUND, WE ASKED TWO OTHER FORD DEALERSHIP AND THEY STATED THE SAME THING, BUT THEY NEVER LOOKED INTO IT. ONE MORNING IN OCTOBER, MY HUSBAND WAS DRIVING TO WORK AND THE TRUCK STARTED SHAKING SEVERELY. IT WAS SO BAD HE HAD DIFFICULTY CONTROLLING THE VEHICLE. IF IT WASN'T ON A BACK ROAD, WE KNOW HE WOULD HAVE BEEN IN AN ACCIDENT. WE TOOK IT TO COURT STREET FORD AND THEY SAID THEY HAD TO RUN DIAGNOSTICS ON IT. THEY RECEIVED A CODE OF 340, BUT COULDN'T FIND ANYTHING WRONG. THE FORD DEALERSHIP BROUGHT FORD ENGINEERS IN TO HELP IDENTIFY WHAT WAS WRONG WITH THE VEHICLE. PER THE ENGINEERS?? SUGGESTION, THE MECHANIC WOULD ASK FOR PERMISSION TO RUN A TEST. EACH TIME, WE WERE TOLD, THIS TEST WILL TELL US IF IT IS THIS REPAIR OR THAT. AFTER 2 WEEKS AND ALMOST $700 IN TESTS, IMAGINE OUR SURPRISE AT THE FINAL DIAGNOSIS "CATASTROPHIC ENGINE FAILURE" DUE TO CLOGGED OIL PASSAGES. NOW WE FIND THAT THIS PARTICULAR SOUND IS A SYMPTOM FOR THIS ENGINE THAT HAS NOTHING BUT PROBLEMS AND EVEN HAS A TSB FOR IT (06-19-08). THIS TSB REPLACES PARTS THAT WOULD PREVENT THIS PROBLEM, BUT WAS NEVER PART OF A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448474February 19, 2012
SERVICE BRAKES, HYDRAULIC
TRUCK VIBRATING. SLOWED DOWN, APPLIED BRAKES SEVERAL TIMES, VIBRATING STOPPED. AFTER GETTING HOME, STATED CHECKING THINGS. FOUND EMERGENCY BRAKE CABLE OFF. THIS HAS HAPPENED SEVERAL TIMES. POOR DESIGN. I HAVEN'T FOUND OF ANY RECALL ON THIS. THIS IS UNSAFE AND SHOULD BE RECALLED BY FORD. IF SOMEONE WHO DOESN'T HAVE ANY MECHANICAL ABILITY COULD GET "BURNED" BY UNNECESSARY COST BY FORD OR REPAIR SHOPS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448141February 16, 2012
VISIBILITY
F150 2004 WINDOWS DRIVER SIDE AND PASSENGER SIDE WINDOW BOTH FELL ON THE SAME DAY. I HAVE THEM PROPPED UP AT THIS TIME. I CAN NOT BELIEVE THERE IS NOT A RECALL ON THIS DANGER. BOTH WINDOWS SAME DAY! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448162February 16, 2012
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE DRIVER, PASSENGER, AND REAR PASSENGER WINDOWS WOULD OPEN AND FALL INTO THE DOOR PANEL UNEXPECTEDLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE WINDOW REGULATORS FAILED AND WOULD NEED REPLACING. THE WINDOW REGULATORS WERE REPLACED. THE MANUFACTURER WAS CONTACTED AND THE CONTACT ADVISED THEM OF THE FAILURE, STATING THAT HE HAD BEEN A VITIM OF THEFT AS A RESULT OF THE FAILURE. THE MANUFACTURER OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150