Ford F-150 Complaints (2022)

911 consumer complaints on file.

#11658943May 5, 2025
ELECTRICAL SYSTEM, SUSPENSION, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
This vehicle has random bursts and loss of power due to the transmission not shifting properly. There is a noise coming from the passenger front that may be tied to transmission failure. Pre collision assist isn’t working due to ECM problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658111May 1, 2025
POWER TRAIN
The pre 2023 10R80 transmission needs to be recalled. The transmission surges, jerks, and has even downshifted so roughly in a low speed hard right turn that the tires slipped. Gears 3-5 are incredibly bad, but downshifts from 3rd to 1st when coming to a stop interferes with the braking and can cause drivers to misjudge the stopping distance required. Coming to a stop is rarely smooth, and the problem isnt me because this doesnt happen with my other three vehicles. It also vibrates at certain speeds and Groove Ford, now purchased by Autonation, refuses replacement or rebuild. Ford needs to recall these for the CDF drum, which was redesigned, and for the F clutch cyl, which is now a hardened anodized unit. Both were updated for the 2023 model year. Worse than that, my transmission and many others were underfilled from the factory. The dealer added 3.5 qts and refused to replace the transmission even after shuddering and a valvebody replacement which was necessitated by the low fluid conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657605April 29, 2025
STEERING
Electric portion of rack and pinion faults while driving causing loss of power steering Safety factor is loss of power steering Ford dealership has confirmed the issue and the truck only only has 37,000 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657536April 29, 2025
STRUCTURE:INTERIOR PANELS:DASHBOARD
The contact owns a 2022 Ford F-150. The contact stated while the vehicle was parked, there was rainwater entering the interior of the vehicle on the front driver's side. The contact noticed the rainwater entering from behind the dashboard onto the front driver's side floor mat. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 66,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656948April 26, 2025
ELECTRICAL SYSTEM
Unbearably loud ear piercing static from speakers. Unable to turn it off or lower volume. Volume controls didn’t work. Ears in major pain from the noise. I have video of the noise but don’t seem able to upload.
Crash:
No
Fire:
No
Injuries:
2
Deaths:
0
#11656798April 25, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655845April 21, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
2022 Ford F-150. The vehicle displays a warning message that reads, "Trailer Disconnected" continuously. It comes on as soon as the engine is started and comes back on as quickly as I can press the "OK" button to make it go away. I have taken the truck to the dealer for repairs four times so far and it still comes back. I have paid to have the trailer break control module reprogrammed as well as having a new one installed. The Ford web site lists this as a recall for the '22 F-150 but not for my specific VIN so it would appear the problem is larger than they know. Here is the link to Ford's description of the recall: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655798April 21, 2025
POWER TRAIN, ENGINE
Issue: Some 2021-2023 F-150 vehicles equipped with a 3.3L engine may exhibit an illuminated MIL in the instrument panel cluster (IPC) with OTC P0171 stored in the powertrain control module (PCM). This may be due to the software level of the PCM. To correct this issue, follow the Service Procedure to reprogram the PCM to the latest software level using the Ford Diagnosis and Repair System (FORS). Description: 2021-2023 F-150 3.3L: Reprogram The Appropriate Modules As Required By The Software Update And Service Procedure (Do Not Use With Any Other Labbr Operations) Ford has current recalls for this issue but my vehicle was not included.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655386April 18, 2025
EXTERIOR LIGHTING
Rear tail light/bar was recalled a couple of years ago for small micro cracks that water got in. My truck tail light had water in it and was replaced under recall. Less than 2 years later it has happened again. Ford denied covering it under warranty per the dealer who replaced it originally. . Others have posted that their tail light has failed and the leds stay on. Mine as far as I know, has not failed yet. No warning lamps. I feel ford should replace it again since they have had it recalled previously.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655534April 18, 2025
EXTERIOR LIGHTING
This letter serves as formal notification of a persistent and unresolvable defect in my 2022 Ford F-150 Lightning. The defect concerns the tailgate light, which continues to leak water despite multiple repair attempts. I purchased/leased this vehicle on [XXX] from Galpin Ford on 15505 Roscoe Blvd, North Hills, CA 91343. The vehicle is currently under the original manufacturer's warranty. The tailgate light has exhibited a recurring issue of water intrusion, leading to condensation, malfunction, potential for electrical damage. This problem significantly impairs the vehicle's safety due to Inoperative reverse lamps. This may reduce the awareness of other motorists or road users of the driver’s intention to operate the vehicle in reverse gear, increasing the risk of injury or crash. It has also in the past caused electrical shorting that caused other lamps to fail, potentially resulting in the risk of injury or crash due to failed communication with other drivers. The following repair attempts have been made to address this defect, once under the recall: 1. March 14, 2023: Autonation Ford performed the repair for the first time. 2. March 18, 2024: Autonation Ford performed the repair for the second time. 3. March 24, 2025: Autonation Ford performed the repair for the third time. Despite these attempts, the defect persists. I have also become aware that numerous other Ford F-150 Lightning owners across the country are experiencing the same or a similar tailgate light issue. This is evidenced by discussions on the Ford Lightning Owners Forum, reports on social media platforms such as Facebook. This widespread problem indicates a potential design or manufacturing defect that Ford has failed to adequately address. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655178April 17, 2025
EXTERIOR LIGHTING
Under recall 23S30 in 2023 my rear light bar assembly which included brake light, back up camera, and white reverse lights for illumination the area behind the vehicle when backing up. There was a new rear lightbar part issued as part of that recall. After almost 2 years the same issue has occurred again to my vehicle. I'm concerned the new part # has not resolved this original issue and a new recall needs to be put in place.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655072April 16, 2025
EXTERIOR LIGHTING
My truck was "repaired" for recall 23S30. The light bar gets microcracks that leet water in and short out the lights. The "repair" was to replace the light bar with another light bar that does the exact same thing. It lasted just over a year before it went out. It didn't even last as long as the original that was recalled and replaced
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655008April 16, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, there was an abnormal rattling sound coming from the vehicle. The vehicle was taken to the dealer and was diagnosed with a fractured axle and bolts. The contact was informed that the axle and bolts needed to be replaced. The vehicle was repaired. In addition, the contact was informed that the parts used for the repair were the original parts. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure; however, the manufacturer was unable to confirm when parts would become available. The failure mileage was 15,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654581April 14, 2025
POWER TRAIN
Rear axle bolt broke while 1,300 miles from home. Recall has been in place for at least 17 months now and still NO repair available from Ford. THIS IS A HAZARD. While driving when the bolt breaks you will lose power which if you were passing in the left lane on a highway at 70MPH it would result in a catastrophic situation. RECALL INFO - Dec 22,2023 Manufacturer Recall Number23S65 / NHTSA Recall Number23V896
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654309April 13, 2025
ELECTRICAL SYSTEM
Recall remedy not available. Battery issue which could cause a fire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653881April 10, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact stated that while the vehicle was stationary or down-shifting, there was a clicking sound coming from the vehicle. There were no warning lights illuminated. The contact stated that while depressing the brake pedal there was a clicking sound coming from the rear-end of the vehicle. The vehicle was taken to a dealer and was diagnosed, and a repair was performed on the axle shaft and bolt assembly. Additionally, the rear-end of the vehicle was rebuilt. The contact stated that the failure re-occurred four months after the repair and the vehicle was repaired. The failure mileage was approximately 15,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653735April 9, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653616April 9, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653567April 8, 2025
POWER TRAIN
I have had the rear axle bolts break 2 times now. ford has had 2 years to come up with a fix and they have not as of today. the recall was issued over 2 years ago and the temporary fix is all they have come up with. dealers are not wanting to take the trucks in trade, I have had to spend time and money for the temporary fix. Ford has had more than enough time to come up with a permanent fix and they have failed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653043April 6, 2025
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
No warning lamps but this could cause injury due to not having working tailgate lamps. Lamps started flickering like it was shorting and then just stopped turning on. Item that is not working. 2022-2024 Ford F-150 Lightning EV LED Center Tail Light Bar OEM NL34-13N466-AC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150