Ford F-150 Complaints (2021)

1,308 consumer complaints on file.

#11708581January 3, 2026
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
Daytime Driving Lights Are disabled due to an electrical defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708277January 2, 2026
POWER TRAIN, FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Numbers: 23V896000 (Power Train) and 25V455000 (Fuel System, Gasoline). The local dealer was contacted and confirmed that the recall remedy part was not available. The contact was unable to reach the manufacturer due a prerecorded message. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708240January 1, 2026
VEHICLE SPEED CONTROL
This report is being made within 1 1/2 hours after the incident. It has not been inspected by a dealer, service center, nor any other agency. I was stopped at a local fast food restaurant waiting to pay for my purchase. The 2021 Ford F-150 was in drive with my foot on the brake. No warning lights or other indication were present. Without warning, the engine revved to a high rpm and the truck shot forward about 15-20 feet before I could react by putting my full weight on the brake pedal. The engine quickly slowed. I then put the vehicle in reverse and backed up to the window and placed the transmission in park. The truck is equipped with adaptive cruise control but it was not active at the time of the incident. Had there been another vehicle in front of me, I would have rear-ended them. I work from home and use the truck a couple of times per week and it is available for inspection most days.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708116December 31, 2025
POWER TRAIN
Dealer has now had my car for almost 60 days with no resolution Manufacturer Recall Number23S65 NHTSA Recall Number23V896 My asset is basically frozen at this point with zero ETA and any care from FORD. I am willing to trade it in at this point but can’t even do that.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708107December 31, 2025
POWER TRAIN, VEHICLE SPEED CONTROL
Loss of engine power when transmission shifts from 3rd gear to 2nd gear. Truck will unexpectedly loose ability to accelerate, typically until shift to 1st or 3rd gear occurs. Return of power can cause vehicle to accelerate rapidly and unexpectedly. Malfunctions typically happens in parking lots and while yielding to make a turn, but also happens in stop and go traffic. Concerned of loss of acceleration while pulling out in traffic. No warning lamps or error codes when failure occurs. I've been working with the dealer to resolve for 1 year with nothing done. After 11 months the dealer acknowledged there is an issue, but is unsure of cause or how to repair. Now recommending an entire transmission replacement and not sure if that will resolve.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708045December 31, 2025
EXTERIOR LIGHTING
There is a known problem with the DRLs burning out, which poses a safety issue. Many people have had this problem causing an expensive repair out of warranty. The entire headlamp assembly has to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707786December 30, 2025
POWER TRAIN, STRUCTURE
The contact owns a 2021 Ford F-150. The contact stated that while driving 40 MPH, the contact heard an abnormally loud booming sound. The contact pulled over to the right side of the road, exited the vehicle. Upon inspecting underneath the vehicle, the contact noticed that the driveshaft was fractured and damaged. The contact stated that the failure had occurred on several different occasions. The vehicle was towed to a dealer, where it was diagnosed that the heat shield had rubbed on the driveshaft, and the driveshaft needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V986000(Power Train, Structure); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 74,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707615December 29, 2025
PARKING BRAKE
The contact owns a 2021 Ford F-150. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 23V509000 (Parking Brake), but the failure persisted. The contact stated that the failed to respond upon shifting to reverse(R) or drive(D). Additionally, the parking brake had seized. The messages "Parking Brake Fault" and " Parking Brake Service Required" were displayed. The dealer was contacted but refused to repair the vehicle under NHTSA Campaign Number: 23V509000(Parking Brake). The contact stated that the dealer had previously inspected the vehicle but no repair had been performed under the recall. The dealer instructed the contact to check the wiring harness. The contact followed the instructions and found that a wire had rubbed through and was fractured. The contact spliced the wire together with a wiring butt connector as a temporary repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 134,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707110December 26, 2025
POWER TRAIN
The transmission was slipping in 2nd and 10th gear. This was confirmed by the dealer. A full transmission had to be replaced at 66,000 miles. The vehicle had an excellent maintenance record and well kept. Ford did pay half of the cost but I still ended up spending $6k out of pocket and my vehicle was in the shop for 27 days.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706949December 24, 2025
EXTERIOR LIGHTING
Day running lights vertical ones seem to be going out on the F150 and recently mine too.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706853December 23, 2025
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
Description of Incident: The vehicle exhibits a severe and unpredictable transmission "shudder," "stutter," and hesitation during gear synchronization, specifically during 1st–3rd and 8th–10th gear transitions. This manifest as a violent "shaking" sensation and a loss of momentary acceleration while merging into high-speed traffic. This issue was first reported to an authorized Ford dealership on December 17, 2024. At that time, the vehicle exhibited harsh shifting and "shuddering" consistent with Ford Technical Service Bulletin (TSB) 22-2428. Despite being under a 150,000-mile service contract, the dealer misdiagnosed the mechanical transmission defect as an engine misfire, resulting in ineffective repairs. The defect has persisted and worsened. The internal failure has been identified as a defective CDF Clutch Drum (Cylinder) where an internal bushing moves out of place, obstructing fluid flow and causing mechanical "slip." This is a known manufacturing defect documented in multiple Ford TSBs (22-2428, 23-2250, and 24-2101). Safety Risk: The failure causes unpredictable power delivery. On multiple occasions, the vehicle has hesitated or "stuttered" while attempting to merge onto highways or cross intersections, leaving the vehicle vulnerable to side-impact or rear-end collisions. The lack of consistent throttle response and the violent nature of the shifting creates a significant safety hazard for the driver and surrounding motorists. Verification/Inspection: The symptoms were reported to a Ford dealership multiple times. As of December 2025, the dealership has opened a formal case with the manufacturer to verify the internal "cause of failure" by the Shop Foreman. No warning lamps or Diagnostic Trouble Codes (DTCs) appeared on the dashboard, as the failure is a mechanical internal bushing slip that does not always trigger a software sensor until total failure occurs. The vehicle is available for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706723December 23, 2025
FUEL/PROPULSION SYSTEM
Recall #25S75 (Low pressure fuel pump failure) was issued in July of 2025 and has still not been resolved as of this date (12/23/25). I am filing a formal complaint with NHTSA about Ford Motor Company not resolving this issue in a timely manner. This appears to be a pattern with FMC regarding recalls, two previous of which took almost a year to remedy.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706064December 19, 2025
EXTERIOR LIGHTING
LEFT HEADLIGHT BURNT OUT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706037December 19, 2025
ELECTRICAL SYSTEM
The hybrid battery in a 2021 Ford F-150 Powerboost failed due to apparent shorting. (P/N ML3Z-10B690-D) Pictures were taken by service department at the Ford dealership, and can be provided upon request. There is concern that the system could catch fire and spread under the vehicle. There have been other similarly identified failures reported in online communities, but cannot verify the information. Failed component is currently with dealership service department, therefore, cannot verify if there has been further inspection of part. Prior to failure, there were no indicators of problems or faults. As the failed part is not easily accessible and there is no routine maintenance, there is no way to validate when the part failed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705863December 18, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704774December 12, 2025
POWER TRAIN, FUEL SYSTEM, GASOLINE, VISIBILITY
The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 23V896000 (POWER TRAIN), 25V455000 (FUEL SYSTEM, GASOLINE), and 25V729000 (VISIBILITY). The dealer was contacted. However, parts to do the recall repairs were not yet available. The manufacturer was contacted; however, the phone call was dropped five times. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704728December 12, 2025
UNKNOWN OR OTHER
When temperatures hit the teens and below, the driver door will not unlock. I’ve tried numerous times to unlock the door via the manual key and inside latch without success. This traps the driver and prevents a speedy egress if necessary. The inner latch tends to thaw after 40+ minutes of full blast heat within cab but no other solution exists. Passenger and rear doors unaffected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704001December 9, 2025
EXTERIOR LIGHTING
The driver's side Daylight Running Light (DRL) is out and there is not a bulb to repair this, it's a $2000+ repair per the dealership and it's 4 years old with 80,000 miles on it. This needs to be a recall. These lights should last way more than 4 years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703551December 7, 2025
WHEELS, VEHICLE SPEED CONTROL, POWER TRAIN
Ford has refused, on multiple occasions and at multiple dealerships, to address the NHTSA Recall Number 23V896 (MFG. Recall Number 23S65) issue with the Wheel End Hub Bolt in the rear axle. Well, this weekend, the bolt on the passenger side rear axle broke off, rendering the vehicle undriveable. I brought it in to the Lithia Ford Dealership (who's online information said they were open) to get it addressed. They were closed, no one was there, and they won't even give me a loaner vehicle while the F-150 is inoperable. This recall has been out for two years now and they still won't deal with it. Absolute neglect of their obligations and an unsafe practice!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703353December 5, 2025
FUEL SYSTEM, GASOLINE, VISIBILITY
The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (FUEL SYSTEM, GASOLINE) and 25V729000 (VISIBILITY); however, the parts to do the recall repairs were not yet available. The contact stated that while starting the vehicle, the vehicle started then hesitated and stalled. The vehicle failed to restart. The vehicle was towed to a dealer. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact stated that the failure had started since the vehicle was purchased. The failure mileage was 32,962.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150