Ford F-150 Complaints (2002)

821 consumer complaints on file.

#10364691November 3, 2010
SERVICE BRAKES, HYDRAULIC
THE CAR WAS STOPPING TO DROP OFF MAIL AT A MAILBOX. THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. INSPECTION REVEALED BRAKE FLUID ON THE GAS TANK. A RUSTED BRAKE LINE WAS THE CAUSE. DEALER REPLACED THE LINE AT COST OF $511.95 INCLUDING BRAKE FLUID FLUSH. THE REAR BRAKE LINE WAS REPLACED. IT RUNS FROM THE FRONT TO THE BACK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10361826October 22, 2010
ENGINE AND ENGINE COOLING
FORD F150 2002 WAS HAVING WHAT WE THOUGHT WAS A WHEEL BALANCE ISSUE. DAY BEFORE SOUNDED LIKE LIFTERS WE NEEDING ADJUSTMENT (TAPPING) THAT SEEMED TO GET BETTER AS IT DROVE. WAS TURNING ONTO A HIGHWAY TYPE ROAD, ENGINE MADE A BANG THAT SOUNDED LIKE IT THREW A ROD, FOLLOWED BY LOUD POPS. THERE WAS NO SMOKE OR OIL. IMMEDIATELY PULLED OVER AND CUT THE ENGINE. HAD TO TOW TRUCK TO DEALER ($90). FORD DEALER IDENTIFIED BLOWN SPARK PLUG #3, AND USED A KIT TO INSTALL HELICOIL TO ALLOW REPLACEMENT SPARK PLUG. THEY SAID INDUCTION CLEANING WAS ALSO NECESSARY DUE TO THE NON-FIRING CYL, PLUS ALL NEW PLUGS. REPAIR COST $950. LOST USE OF TRUCK FOR TWO DAYS, AND THEN FOUND OUT THIS IS A KNOWN ISSUE WITHOUT A RECALL; AND IT COULD HAPPEN AT ANY TIME ON OTHER SPARK PLUGS. SPARK PLUGS ORIGINAL TO VEHICLE AND NORMAL MAINTENANCE WAS CONDUCTED ON THE TRUCK. WAS ADVISED I COULD HAVE DONE NOTHING DIFFERENT TO PREVENT THIS FROM HAPPENING.. SHOCKED AND APPALLED TO READ OF THOUSANDS OF SIMILAR OCCURRENCE, AND FORD EVEN HAS A KIT TO REPAIR THEIR MANUFACTURING DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10361187October 19, 2010
ENGINE AND ENGINE COOLING
I OWN A 2002 FORD F150 WITH A 5.4 TRITON ENGINE. I JUST HAD AN ISSUE WITH A SPARK PLUG COMING OUT OF THE HEAD. I HAVE READ MANY REPORTS OF PEOPLE HAVING THIS SAME ISSUE WITH NEW FACTORY PLUGS AND REPLACEMENT PLUGS. THIS SEEMS TO BE A DESIGN FLAW THAT FORD HAS YET TO ADMIT IS A DESIGN FLAW. THIS ISSUES CAN RESULT IN A FIRE LUCKILY IT DID NOT HAPPEN WITH MINE. I WORK AT A SALVAGE YARD AND THIS IS ONE OF THE COMMON THINGS WE SEE HAPPEN TO THESE MOTORS. I THOUGHT I HAD ONE THAT WAS NOT PART OF THE ISSUE BUT I GUESS NOT. NOW I WILL HAVE THE COST OF A TOW CALL AND WHAT EVER IT WILL COST TO FIX IT AND FROM WHAT I HAVE SEEN SO FAR AROUND $500-1500 IF HEADS ARE NOT CHANGED. IF HEADS ARE CHANGED THEN IT COULD BE ALOT MORE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10360739October 16, 2010
VEHICLE SPEED CONTROL
OUR 2002 F150 CAUGHT FIRE WHILE PARKED IN THE FRONT OF OUR HOME. AFTER TRYING TO FIGURE OUT WHY OUR TRUCK CAUGHT ON FIRE WE FOUND ONLINE THAT THERE WAS AN OPEN RECALL ON THE CRUISE CONTROL/BRAKE SAFETY SWITCH RECALL FROM FORD. WE CALLED FIRE DEPARTMENT AFTER WE PUT OUT FIRE AND HAVE RECORD THAT THEY CAME TO MAKE SURE ALL HARM WAS OUT OF THE WAY. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10359569October 7, 2010
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT HEARD A LOUD RATTLING NOISE FROM THE ENGINE AREA. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT ONE OF THE SPARK PLUGS HAD BLOWN OUT. THE VEHICLE WAS BEING REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10359000October 4, 2010
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
BLOW SPARK PLUG ON A 2002 FORD F-150 5.4 PICKUP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10358895October 3, 2010
ENGINE AND ENGINE COOLING:ENGINE
EVENTS LEADING UP TO THE FAILURE WOULD HAVE TO BE...EVERYDAY DRIVING.... THE FAILURE - FOR THE THIRD TIME NOW, A SPARK PLUG EJECTED FROM THE CYLINDER HEAD. CONSEQUENCES - $800 FORD DEALERSHIP PARTS/LABOR, PLUS 2 TOW TRUCK SERVICES. NEW PLUG, INSERT, AND COIL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10358140September 28, 2010
FUEL SYSTEM, GASOLINE, SERVICE BRAKES, HYDRAULIC
THE REAR FUEL TANK STRAP ON MY 2002 FORD F 150 RUSTED THROUGH CAUSING THE TANK TO COME LOOSE. THE RUST WAS SO BAD THAT THERE WAS ALSO A SMALL HOLE IN THE FUEL TANK. I HAVE TAKEN THE TRUCK IN FOR REPAIRS AND AFTER THE TANK WAS REMOVED IT WAS DISCOVERED THAT THE BRAKE LINES ABOVE THE TANK WERE ALSO RUSTED WITH ONE STARTING TO LEAK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10358150September 28, 2010
ENGINE AND ENGINE COOLING:ENGINE
ON SEPTEMBER 28TH 2010 I WAS DRIVING FROM INDIANAPOLIS, IN TO LOUISVILLE, KY ON A VERY BUSY I-65 INTERSTATE. AT APPROXIMATELY 4PM I HEARD A VERY LOUD POP AND LOST ALL POWER. I COULD HEAR A VERY LOUD BANGING NOISE AND AT FIRST I THOUGHT I BLEW A TIRE. I IMMEDIATELY TRIED TO GET FROM THE FAST LANE TO THE EMERGENCY LANE BUT WITH AS MANY CARS ON THE ROAD THIS WAS DIFFICULT. I FINALLY MADE IT TO THE EMERGENCY LANE AND TURNED MY FLASHERS ON. WHEN I GOT OUT OF MY VEHICLE I CHECKED FOR A FLAT TIRE BUT THAT WAS NOT THE ISSUE. I RESTARTED THE TRUCK AND LIFTED THE HOOD OF MY ENGINE. I NOTICED THAT ONE OF MY COIL POWER PACKS WAS AT A WEIRD ANGLE. WHEN I WENT TO CHECK IF IT WAS STILL ATTACHED THE COMPRESSION OF MY NUMBER 2 CYLINDER BLEW THE SPARK PLUG THE REST OF THE WAY OUT OF THE ENGINE AND HIT MY HOOD VERY NARROWLY MISSING MY HEAD. THE COIL WAS ALSO DESTROYED BY THE FORCE OF THE SPARK PLUG COMING OUT OF THE CYLINDER. MY TRUCK IS A 2002 FORD F-150 WITH LESS THAN 100K MILES. THIS IS A VERY DANGEROUS ISSUE THAT NEEDS TO BE CORRECTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10355805September 15, 2010
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE ANOTHER DRIVER WAS DRIVING APPROXIMATELY 20 MPH, BOTH STRAPS ON THE FUEL TANK FELL OFF AND THE TANK DROPPED DOWN ON THE GROUND. ANOTHER DRIVER ALERTED HER TO THE FAILURE. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE CONTACT CALLED THE DEALERSHIP WHO REFERRED HIM TO THE MANUFACTURER WHO ASSIGNED HIM A CASE NUMBER. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 241,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10354822September 10, 2010
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE EXITING A PARKWAY TO GET ON THE HIGHWAY WHILE DRIVING 55 MPH HE APPLIED THE BRAKES TO YIELD AND THE VEHICLE ACCELERATED WITHOUT DRIVER INTENT. HE WAS FORCED TO DRIVE THE VEHICLE ON A SIDEWALK IN ORDER TO GET OUT OF TRAFFIC WHICH CAUSED HIM TO LOSE CONTROL OF THE VEHICLE AND CRASHED INTO AN EMBANKMENT. HE TRIED TO PUT THE VEHICLE IN NEUTRAL BUT IT WENT INTO REVERSE INSTEAD. THE VEHICLE ACCELERATED ON IT'S OWN IN REVERSE AND CROSSED A SIX LANE HIGHWAY BEFORE CRASHING INTO A LIGHT POLE, WHICH FINALLY STOPPED THE VEHICLE FROM ACCELERATING. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A STORAGE LOT. THE STATE POLICE RESPONDED TO THE SCENE AND FILED A REPORT WHICH IS AVAILABLE. THE VEHICLE WAS NOT REPAIRED. FORD WAS CONTACTED AND COULD NOT OFFER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 82,200. UPDATED 11/22/10 *BF UPDATED 11/23/10*JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10354782September 9, 2010
VEHICLE SPEED CONTROL
MY 2002 F150 CATCH ON FIRE TODAY. THE FIRE SEEMS TO HAVE COME FROM THE BRAKE MASTER CYLINDER AREA. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10353911September 5, 2010
FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING
I WAS DRIVING IN THE URBAN STREET AND I SUDDENLY HEAR A NOISE COMING FROM THE ENGINE COMPARTMENT, LIKE SOMETHING IS LEAKING FROM THE ENGINE. SO I HAD IT TOWED TO MY HOUSE WHICH IS AROUND 2 KMS AWAY. WE DISCOVERED THAT ONE OF THE SPARK PLUG JUST PULL OUT OF THE ENGINE AND IT WAS THE ONE THAT WAS MAKING THE NOICE AND NO POWER. I BROUGHT IT TO MY FRIEND WHJO IS A MECHANIC AND HE DISCOVERED THAT THE TREAD IS DAMAGED AND HE CANNOT INSERT THE PLUG ANYMORE. I BOUGHT IT USED ON MARCH 2008. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10353689September 3, 2010
STRUCTURE
NUMEROUS FORD PICK-UP TRUCKS TO INCLUDE F SERIES AND RANGER HAVE AN ISSUE WITH THE CROSS BEAMS THAT HOLD THE PICK-UP BED TO THE TRUCK RUSTING OUT. THE POTENTIAL IS THERE THAT THE BED COULD COME LOOSE FROM THE TRUCK AND POSE A SERIOUS SAFETY HAZARD. I HAVE CONTACTED FORD ABOUT IT BUT AS YOU CAN GUESS THEY WERE UNRESPONSIVE. SEVERAL WORKERS AT THE LOCAL FORD DEALER ALSO HAVE THE SAME PROBLEM BUT HAVE BEEN UNABLE TO GET A SATISFACTORY RESPONSE FROM FORD. MY VEHICLE IS A 2002 MODEL BUT I HAVE BEEN TOLD THAT IT OCCURS IN OLDER AS WELL AS NEWER MODELS. I AM GOING TO HAVE TO HAVE THE BED REMOVED AND NEW CROSS BEAMS WELDED ON TO REPLACE THE DEFECTIVE ONES AT MY EXPENSE. I HAVE ONLY 77,000MILES. THE TRUCK IS OPERATED IN NC WITH SOME SALT USED IN THE WINTER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351775August 25, 2010
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING APPROXIMATELY 3 MPH, THE VEHICLE EXHIBITED A LOUD POP FROM THE ENGINE AS THE VEHICLE BEGAN TO LOSE POWER. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT A SPARK PLUG FRACTURED FROM THE ENGINE AND TORE AN ENGINE COIL. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 95,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351351August 23, 2010
AIR BAGS
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE TRAVELING 20 MPH, THE FRONTAL DRIVER AND PASSENGER AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT INVOLVED IN A CRASH. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351363August 23, 2010
ENGINE AND ENGINE COOLING:ENGINE
2002 F-150 FORD 4.6 V-8 SPARK PLUG EJECTION. FIRST TIME HAPPENED ON JUNE 20 2008 IN THE NUMBER 3 CYLINDER TRUCK SHOWING 160,000 KMS. I REMOVED THE HEAD SENT IT TO MACHINE SHOP TO BE REPAIRED. 11 MONTHS LATER(182000) THE HELI-COIL THAT WAS INSTALLED CAME OUT WITH THE SPARK PLUG. REMOVED THE HEAD AND INSTALLED REMAN HEAD (ON RIGHT SIDE) DURING THE SPRING OF 2010 I STARTED TO LOOSE COMPRESSION ON ALL CYLINDERS, RANGING FROM 0-90 LBS AND THE BEST CYLINDER AT 120 LBS) BROUGHT IT TO A FORD DEALER, AND RESULTS SHOWED LEAKING WAS AROUND SPARK PLUGS. FORD DECLARED I NEED A NEW ENGINE. I AM LUCKY ENOUGH TO BE ABLE TO DO MY OWN REPAIRS. I PURCHASED A USED ENGINE FROM A WRECKER AND INSTALLED @ 190000KMS IN JULY 2010. I HAVE SPENT OVER $4000.00 ON THIS PROBLEM, AND I AM NOT DUMB ENOUGH TO CHANGE SPARK PLUGS WHEN THE ENGINE IS HOT, I USE ANTI-SEIZE WHEN INSTALLING, AND TORQUE AS FORD RECOMMENDS! FORD NEEDS TO FESS UP TO THIS ISSUE AND OFFER SOME SORT OF RECALL PROGRAM. I'M SURE THAT MY REPAIR BILLS WOULD HAVE BEEN DOUBLE IF I HAD TO PAY FOR LABOR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351134August 22, 2010
VEHICLE SPEED CONTROL
FORD F150 HAD A RECALLED BACK IN 2005 WITH THE SPEED CONTROL WERE THE DEACTIVATION SWITCH MAY OVERHEAT, SMOKE OR BURN. WAS INSTRUCTED TO TAKE TO DEALER TO DISCONNECT UNTIL PARTS COME IN WAS NOTIFIED ON NEW PARTS WERE AVAILABLE WHICH WERE INSTALL. AUG 21 2010 THE BRAKE PRESSURE SWITCH STARTED LEAKING AND RUNNING FROM MY MASTER CYLINDER BRAKE PRESSURE SWITCH. THIS WAS PART OF THE PROBLEM FROM THE VEHICLE SPEED CONTROL SWITCH PART THAT WAS LEAKING. COULD NOT BUY PART FROM AUTO PART STORE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10350842August 20, 2010
ENGINE AND ENGINE COOLING:ENGINE
STARTING FROM A STOPLIGHT, I HEARD A SUDDEN POP AND SMELLED GAS. LOUD CLICKING OR POPPING NOISE CAUSED ME TO TURN AROUND AND HEAD STRAIGHT TO THE DEALER. THEY SAID A SPARK PLUG BLEW OUT, DAMAGING THE COIL. INITIAL ESTIMATE OF $500 GREW TO $3600 AS THEY SAID THEN THAT THE HEAD WOULD NEED TO BE REPLACED DUE TO DAMAGE THERE AS WELL. RESEARCHING THIS PROBLEM, IT APPEARS THAT THERE ARE QUITE A FEW (MANY MANY MANY) FORD OWNERS WITH THIS PROBLEM! WHY IS THERE NO RECALL? IMMEDIATE SAFETY OR NOT, THIS IS AN OBVIOUS DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10350064August 17, 2010
AIR BAGS:FRONTAL
A 2002 FORD F-150 STRUCK A 1996 CHEVY BLAZER IN THE RIGHT REAR, THERE FOR HAVING DAMAGE TO THE FRONT AND FRONT LEFT QUARTER PANEL OF THE F-150. THE IMPACT WAS HARD ENOUGH TO ROLL THE BLAZER OVER ON TO ITS TOP. MY CONCERN IS THAT THE AIR BAGS IN BOTH VEHICLES DID NOT DEPLOY THE F-150 WAS TRAVELING AT A SPEED OF +40MPH AT THE TIME OF IMPACT, THE BLAZER WAS AT A PARKED STOP. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150