Ford F-150 Complaints (2007)

488 consumer complaints on file.

#10586153May 2, 2014
AIR BAGS, SEATS
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE AIR BAG CODE- 16 WARNING MESSAGE INTERMITTENTLY FLASHED. THE VEHICLE WAS INSPECTED BY A MECHANIC, WHO DIAGNOSED THAT THE PASSENGER SIDE OCCUPANCY SEAT SWITCH FAILED. AS A RESULT, THE ENTIRE SEAT WOULD NEED REPLACING. THE CONTACT STATED THAT THE REPAIR WAS THE MANUFACTURE WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 48,000 AND THE CURRENT MILEAGE WAS 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10585363April 28, 2014
POWER TRAIN
I HAVE A 2007 F150 SUPERCREW CAB TRUCK. I WAS DRIVING DOWN A PARKING LOT WHEN THE TRUCK MADE A HUGE GRINDING SOUND FROM THE TRANSMISSION. I THEN RECEIVED A TRANSMISSION MALFUNCTION WARNING LIGHT. THE TRUCK SLAMMED INTO A STOP CAUSING DRIVER AND PASSENGER TO BE TOSSED FORWARD. I HAVE READ ONLINE OF SEVERAL OTHERS HAVING THE SAME PROBLEMS WITH THE 2007 F150 TRANSMISSIONS. FORD CLAIMS NO DEFECTS ON THIS MODEL YEAR. YET ON THE INTERNET THERE ARE SEVERAL FORD OWNERS WITH SAME TRANSMISSION ISSUES WITH TRUCK. FORD NEEDS TO RECALL THIS TRANSMISSION ASAP BEFORE SOMEONE GETS HURT BAD. I AM THE ORIGINAL OWNER WITH NO ACCIDENTS WITH TRUCK. TRUCK IS LOW MILEAGE. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583145April 16, 2014
ENGINE
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE CONTACT HEARD A LOUD BANG IN THE ENGINE COMPARTMENT. UPON INSPECTION, IT WAS FOUND THAT THE SPARK PLUG HAD ERRONEOUSLY EJECTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE SPARK PLUG COIL NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 67,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10578134April 7, 2014
ENGINE
WHILE DRIVING THE TRUCK A NOTICEABLE NOISE WAS GENERATED FROM THE ENGINE AND THE TRUCK SHUT OFF. THE LOW OIL SENOR CAME ON DURING OPERATION. SHUT ENGINE OFF AND RESTARTED NOISE STOPPED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10576763April 2, 2014
ENGINE
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, A LOUD KNOCKING NOISE WAS HEARD FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT BOTH THE VTC SENSOR AND THE CAM PHASER WOULD NEED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 45,871.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10576251April 1, 2014
FUEL/PROPULSION SYSTEM
VEHICLE QUIT RUNNING WHILE DRIVING , LEFT ON THE SIDE OF THE RIDE IN VERY COLD WEATHER , THE FUEL CONTROL MODULE WAS SO CORRODED AND BROKE OFF FRAME CAUSE VEHICLE'S ENGINE NOT TO RUN. THERE SHOULD BE A SAFETY RECALL ON THESE MODULES. MY TRUCK IS IN VERY GOOD CONDITION AND YOU SHOULD SEE HOW BAD OF CONDITION THE MODULE LOOKS.. LOOKS LIKE IT WAS IN ACID AND COMPLETELY DISSOLVED THE BACK PANEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10575718March 30, 2014
VEHICLE SPEED CONTROL, FUEL/PROPULSION SYSTEM
THE TRUCK HAS BEEN RUNNING ROUGH AND STALLING OUT AT RANDOM. THIS HAPPENS WHILE DRIVING, WHILE AT THE CAR WASH AND WHILE,SITTING AT THE STOP LIGHT, BUT EVERYTIME IT HAS BEEN WET OUTSIDE. TAKEN TRUCK TO FORD DEALERSHIP, AND HAD LOTS OF WORK DONE, NEW PLUGS, COILPACKS, INJECTOR SERVICE, AND THROTLEBODY CLEANING DONE WITH NO IMPROVEMENT. BROUGHT ISSUE TO A FRIEND AND TO ONE LOOK AT THE FUEL CONTROL MODULE UNDER THE REAR AXEL AND IT WAS SPLIT WIDE OPEN, BAD ENOUGH THE CIRCUIT BOARD WAS JUST HANGING OUT. WHEN ISSUE WAS BROUGHT TO LOCAL FORD DEALER, THE PARTS GUY JUST HAD A LAUGH AND SAID THEY DO AT LEAST THREE A WEEK. "I DIDN'T FIND IT THAT FUNNY" A CONTROL BOX WITH A ALUMINUM BACK PLATE ON A STEEL AXEL WITH NO BUFFER, IS JUST BAD DESIGN AND SHOULD BE RECALLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10575415March 28, 2014
ENGINE
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY STALLED. THE ENGINE WAS RESTARTED AND THE VEHICLE RESUMED NORMALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574640March 25, 2014
ENGINE, POWER TRAIN, SUSPENSION
HAD A BAD MISS AT HIGHWAY SPEEDS AND LIMPED HOME 15 MILES. REPLACED SPARK PLUGS AND IN THE PROCESS BROKE TWO IN THE HEAD. ONE DID NOT BREAK COMPLETELY OFF (#4) AND I NEEDED TO BORROW A PROTOTYPE TOOL FROM LISLE TOOL CORP. REMOVED AND REPLACED PLUGS FOLLOWING FORD PROCEDURES. TRUCK STILL HAD A MISS. REPLACED ALL EIGHT COIL PACKS WHICH FIXED THE PROBLEM. TOTAL COST$380.00. TRUCK DOWN FOR 6 DAYS AWAITING TOOLS AND PARTS. DEVELOPED A VIBRATION AT HIGHWAY SPEEDS. ORIGINAL TIRES(PIRELLI) WERE SEPARATING. REPLACED TIRES(976.00), MUCH BETTER. STILL HAVE SLIGHT VIBRATION AT HIGHWAY SPEEEDS. FOUND LEFT FRONT HUB BEARING SEEPING GREASE AND FEELS STIFF. AWAITING PARTS TO DO REPAIRS. (98.00) HAD A TRANSMISSION SHUDDER AT LIGHT LOAD IN OVERDRIVE. FLUSHED TRANSMISSION WITH BG PRODUCTS AND FLUSH MACHINE. ADDED NEW TRANS FLUID AND CONDITIONER. TRANSMISSION NOW SHUDDERS AT ALL SPEEDS WHEN HOT. WILL ORDER NEW FILTER AND REPLACE. WILL ADD FRICTION MODIFIER AND TRY AGAIN. HAVE TO TOW ANOTHER VEHICLE THIS WEEKEND AND AM AFRAID TO DO SO. I AM COMPLETELY BLOWN AWAY THAT THESE PROBLEMS COULD HAPPEN TO ANY VEHICLE STARTING AT 48,000 MILES. ALL MAINTENANCE HAS BEEN PERFORMED WITH TOP OF THE LINE PRODUCTS. HAVE BEEN A FORD OWNER ALL MY LIFE AND AM COMPLETELY DIS-SATISFIED WITH THE PERFORMANCE OF THIS SUPPOSED NUMBER ONE SELLING TRUCK. THE STICKER PRICES OF THESE TRUCKS SHOULD BE A BUNCH LESS SINCE CHEAPLY PRODUCED CHINESE PARTS ARE SO PREVALENTLY USED. NOT HAPPY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573862March 20, 2014
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC:HOSES, LINES/PIPING, AND FITTINGS, VEHICLE SPEED CONTROL, SERVICE BRAKES
WHEN I STARTED MY ENGINE IT BACKFIRED. FROM THAT POINT ON I HAD TO PRESS EXTREMELY HARD ON THE BRAKE PEDAL JUST TO SLOW DOWN AND EVENTUALLY TO STOP. IN AN EMERGENCY SITUATION IT WOULD WITHOUT A DOUBT HAVE RESULTED IN AN ACCIDENT. THE INCIDENT IS EXACTLY AS INDICATED IN THE RECALL NHTSA CAMPAIGN NUMBER: 08V208000 (FORD RECALL #08S05) FOR THE SAME VEHICLE, EXCEPT MODEL YEAR 2005 AND 2006. WHEN I CONTACTED FORD I WAS TOLD THAT THE VEHICLE WAS MANUFACTURED IN AUGUST OF 2006, BUT THAT IT WAS NOT COVERED UNDER THIS RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10569165March 13, 2014
FUEL/PROPULSION SYSTEM
ENGINE QUIT RUNNING WHILE DRIVING AT 40MPH ON A COUNTRY ROAD. NO SHOULDER ON THIS ROAD SO HAD TO LEAVE IT SIT IN THE ROAD WHILE I WAITED FOR A TOW TRUCK. TOOK IT TO LOCAL FORD DEALER AND THE PROBLEM WAS A CORRODED FUEL PUMP MODULE. $125.00 FOR THE TOW AND $350.00 TO FIX THE TRUCK. NOT A VERY GOOD DAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10566990March 4, 2014
VEHICLE SPEED CONTROL, ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
FIRST WHY WAS" THIS VEHICLE INCLUDED IN THE RECALL OF BAD THROTTLE BODY I HAD THE SAME PROBLEM AS PEOPLE ARE HAVING WITH THE FORD ESCAPE. I REPORTED THIS BACK IN 2012 WHEN IT WAS BROUGHT TO THE ATTENTION OF THE NHTSA I DID NOT RECEIVE A RESPONSE THEN BUT THERE ARE THE SAME PROBLEMS WITH THE F-150 I HAD TO REPLACE MINE @ A COST OF OVER $600.00 AND ALSO DAMAGED MY ALTERNATOR I WAS DRIVING IN TRAFFIC WHEN IT WENT IN LIMP HOME MODE SHOWING A WRENCH SYMBOL WITH LOST OF POWER AND ACCELERATION, I ALMOST WAS HIT BY SEVERAL VEHICLES AS THERE WAS KNOW WHERE TO PULL OVER TIME. THIS IS THE SAME THROTTLE BODY THAT COMES ON THE FORD ESCAPE AND IT SHOULD BE INCLUDED WITH THAT GROUP OF RECALLS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10566275February 27, 2014
ENGINE
TL* THE CONTACT OWNS A 2007 FORD-150. THE CONTACT STATED THAT WHEN HE CAME TO A COMPLETE STOP, HE HEARD A LOUD NOISE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE WAS RECURRING. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10563574February 9, 2014
FUEL/PROPULSION SYSTEM
THE TRUCK SUDDENLY STALLED. UNABLE TO BE RESTARTED. AFTER BEING TOWED HOME, I FOUND THE FUEL PUMP MODULE CORRODED COMPLETELY THROUGH THE BACK SIDE. THE ALUMINUM BACK HOUSING WAS DETERIORATING BAD ENOUGH THAT IT CRUMBLED APART AS I WAS REMOVING IT. MY WIFE AND CHILDREN WERE IN THIS VEHICLE WHEN IT STOPPED. IT WAS 5 DEGREES OUTSIDE AND NOT SAFE TO WALK ANY DISTANCE FOR HELP ESPECIALLY ON OUR SECONDARY ROADS. THIS PART IS AN ENGINEERING FAILURE. THE ALUMINUM DOES NOT MATE WITH THE STEEL ON THE TRUCK FRAME. I HAVE FOUND SEVERAL COMPLAINTS AS TO THIS PART AND NO INVESTIGATION. THIS COULD HAVE BEEN LIFE THREATENING TO MY FAMILY. THE COLD, NO HEAT, AND SMALL CHILDREN ADD UP TO PROBLEMS. A VEHICLE OWNER SHOULD NOT HAVE TO WORRY ABOUT AN ELECTRICAL ISSUE LIKE THIS ESPECIALLY WHEN IT COULD BE RECTIFIED BY CHANGING THE MATERIAL IT IS MADE OF. PLEASE FOR THE SAKE OF THE MANY FAMILIES DRIVING THIS COMMON TRUCK, MAKE THE COMPANY OWN UP TO THE FAILURE OF THIS PART BEFORE IT IS RESPONSIBLE FOR INJURING SOMEBODY OR WORSE YET A CHILD OR INFANT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10563480February 8, 2014
ENGINE
MY 2007 FORD F-150 XLT 5.4 TRITON WAS BROUGHT IN FOR A ROUTINE TUNE UP. WHEN REMOVAL OF THE SPARK PLUGS 6 OF 8 BROKE OFF. THE MECHANICS ATTEMPTED TO REMOVE THE BROKEN PARTS BUT COULD NOT. NOW I AM TOLD I NEED TO HAVE THE HEADS OF THE MOTOR TAKEN OFF AND OR HAVE THE ENGINE REPLACED. THIS MOTOR HAS RUN FINE EXCEPT FOR MIS FIREING SPARK PLUGS. I TALKED TO OTHER MECHANICS AND AUTO PART STORES, PRIOR TO HAVING THIS WORK DONE AND THEY ALL WARNED ME THAT THIS MAY HAPPEN, THE BREAKING OFF OF THE SPARK PLUGS. I CAN`T AFFORD TO HAVE THIS MAJOR WORK DONE AT THIS TIME, AND I FEEL THAT FORD HAS A BAD PRODUCT IN IT`S SPARK PLUG. HAS THERE BEEN ANY OTHER COMPLAINTS IN THIS MATTER [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561292January 24, 2014
ELECTRICAL SYSTEM, POWER TRAIN, FUEL SYSTEM, GASOLINE
I WAS ACCELERATING FROM A STOP AND VEHICLE SHUT OFF. I AM 8MTHS PREGNANT AND WAS STUCK ON THE SIDE OF THE ROAD FOR OVER A 1/2 HOUR IN -45 DEGREE WEATHER WAITING FOR TOW TRUCK, BECAUSE VEHICLE WOULD NOT START. MECHANIC LOOKED AT VEHICLE AND FOUND #9 FUSE FOR FUEL PUMP BLOWN. FUSE REPLACED, AND VEHICLE RAN FOR 30SECONDS AND ELECTRICAL PLUG TO DRIVER CONTROL MODULE BEGAN TO SMOKE AND MELT. DRIVER CONTROL MODULE AND ELECTRICAL PLUG REPLACED, AND VEHICLE RUNS. I WOULD HAVE LIKE TO HAVE BEEN NOTIFIED BY FORD TO AVOID MY STRANDED EXPERIENCE IN -45 DEGREE WEATHER. THIS WAS A HUGE SAFETY RISK AND IT CAN BE AVOIDED. FORD SHOULD HAVE LOCATED THIS DEVICE NEAR THE FUSE BOX OR UNDER HOOD BY FIRE WALL PLENTY OF ROOM AND SAME AMOUNT OF WIRE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10560357January 17, 2014
ENGINE
TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, AN ABNORMAL NOISE WAS HEARD FROM THE ENGINE AS THE VEHICLE SUDDENLY STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED A LACK OF PRESSURE ON THE RIGHT SIDE OF THE ENGINE. IN ADDITION, WATER FROM THE COOLING SYSTEM HAD LEAKED INTO THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10559310January 10, 2014
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
TL* THE CONTACT OWNS A 2007 FORD F -150. THE CONTACT STATED THE INSTRUMENT PANEL FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENTIRE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,000. UPDATED 2/26/14*CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10559211January 9, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE CONTACT LOST CONTROL OF THE VEHICLE DUE TO ICE ON THE HIGHWAY AND FLIPPED THE VEHICLE SEVERAL TIMES. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10557826December 30, 2013
FUEL/PROPULSION SYSTEM
I STARTED MY TRUCK AFTER WASHING IT, IT WAS RUNNING ROUGH SO I SHUT IT OFF AND TRIED TO RESTART IT AND IT WOULD NOT START. AFTER HAVING IT TOWED TO A REPAIR GARAGE THE TECHNICIAN DISCOVERED THE FUEL MODULE WAS BAD, AND HAD TO BE REPLACED IT. AFTER LOOKING ON LINE I FOUND OUT THAT THIS IS A COMMON PROBLEM WITH THESE TRUCKS FROM 2004-2008 MODELS. SOUNDS LIKE A POOR DESIGN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150