Ford F-150 Complaints (2001)

1,236 consumer complaints on file.

#10442071January 2, 2012
FUEL SYSTEM, GASOLINE
NOT A NEW COMPLAINT, JUST WANTED TO SAY THANKS. FORD MOTOR COMPANY HAS REIMBURSED ME FOR 100% OF MY EXPENSES RELATED TO THE GAS TANK STRAP FAILURE. THANK YOU, AND THANK FORD MOTOR COMPANY. I COULD NOT FIND ANOTHER WAY TO EDIT MY PREVIOUS COMPLAINT. ODI # 10402810. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441779December 30, 2011
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING, FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. WHILE THE VEHICLE WAS BEING SERVICED, THE FUEL TANK WAS FRACTURED AND BEGAN LEAKING GASOLINE. NEITHER THE DEALER NOR THE MANUFACTURER OFFERED ANY ASSISTANCE WITH THE FAILURE SINCE THE RECALL DID NOT INCLUDE REPAIRING THE FUEL TANK. THE CURRENT AND THE FAILURE MILEAGES WERE 129,400. UPDATED 02/03/12*LJ THE TANK WAS REPLACED FREE OF CHARGE ON JAN 17, 2011 AND THE PROBLEM HAS BEEN RESOLVED. UPDATED 02/10/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440558December 20, 2011
SERVICE BRAKES, HYDRAULIC
I HAVE A 2001 FORD F-150 THAT I WAS USING TO DROP MY SON OFF AT HIS FRIEND'S HOUSE. ON THE WAY HOME MY BRAKE PEDAL WENT TO THE FLOOR, I WAS TRAVELING AT ABOUT 35 MPH AND I WAS NOT ABLE TO STOP AT THE INTERSECTION LIKE I WAS SUPPOSED TO. I DID MANAGE TO DRIVE HOME WITH LITTLE TO NO BRAKES. WHEN I GOT HOME I LOOKED IN THE BRAKE FLUID WELL AND THERE WAS NO FLUID IN THERE. I LOOKED AT THE GROUND ON THE DRIVERS SIDE NEAR THE REAR TIRE AND I SAW FLUID DRIPPING ON THE GROUND. I GOT UNDER THE TRUCK AND WAS SURPRISED TO SEE A LOT OF BRAKE FLUID ON THE SIDE OF GAS TANK AND DRIPPING FROM THE FRAME. THIS IS A VERY UNUSUAL AND DANGEROUS SITUATION. NEEDLESS TO SAY, I NO LONGER HAVE THE USE OF MY VEHICLE. I RECENTLY TOOK THE TRUCK IN FOR RECALL SERVICE TO HAVE THE GAS TANK SUPPORT STRAPS REPLACED, IS POSSIBLE THAT THE BRAKE LINE WAS COMPROMISED DURING THE RECALL WORK? I HAVE OWNED MANY VEHICLES AND THIS IS THE FIRST TIME I HAVE SEEN SOMETHING LIKE THIS. I CONTACTED FORD ABOUT THIS UNUSUAL INCIDENT AND THEY STATED THAT BECAUSE MY TRUCK IS NO LONGER UNDER WARRANTY THAT I SHOULD TAKE IT TO A DEALER AND HAVE IT REPAIRED. THE LARGER ISSUE IS THAT SOMETHING LIKE THIS SHOULD NEVER HAPPEN, WARRANTY OR NO. WHAT IF I HAD BEEN TRAVELING AT A FASTER RATE OF SPEED OR ENTERING A BUSY INTERSECTION OR A NERVOUS DRIVER. THIS INCIDENT COULD HAVE ENDED VERY BADLY. THE BRAKE LINES SHOULD NOT RUPTURE. MY CONCERN IS WHETHER THESE WAS AN ISOLATED INCIDENT, OR HAVE OTHER BRAKE LINES RUPTURED CAUSING ACCIDENTS AND HAVE NOT BEEN REPORTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440148December 16, 2011
ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE, VEHICLE SPEED CONTROL
ATTEMPTING TO PARK VEHICLE IN PARKING STALL WITH FOOT ON BRAKE STOPPING THE VEHICLE. THE VEHICLE, FOR NO APPARENT REASON, ABRUPTLY ACCELERATED FORWARD STRIKNIG THE VEHICLE ON THE OTHER SIDE OF THE PARKING STALL. THE RESULTING CRASH CAUSED DAMAGE TO THE FRONT OF THE 2011 GMC SPORT UTILITY VEHICLE AND TO THE FRONT OF THE 2001 FORD F-150. THIS IS THE SECOND TIME AN INCIDENT SIMILAR TO THIS HAS OCCURRED. THE FIRST TIME WAS IN AUGUST 2011. THE FIRST TIME THE VEHICLE DEMONSTRATED A SIMILAR PHENOMENA OCCURRED WHEN THE OWNER WAS PARKING THE VEHICLE IN A PARKING STALL. THE VEHICLE WAS STOPPED IN THE PARKING STALL, THE DRIVER'S FOOT ON THE BRAKE AND THE VEHICLE ABRUPTLY ACCELERATED, FOR NO APPARENT REASON, OVER A CONCRETE PARKING BLOCK. THE VEHICLE CONTINUED INTO THE STREET AS THE DRIVER CONTINUED TO APPLY THE BRAKE, ATTEMPTING TO STOP THE FORD F-150. THE DRIVER WAS UNABLE TO AVOID STRIKING A VEHICLE AFTER ENTERING THE STREET. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10438059December 2, 2011
SEAT BELTS, VISIBILITY
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FRONT DRIVER'S SEAT BELT WOULD NOT ATTACH INTO ITS BUCKLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE CONTACT ALSO STATED THAT THE REAR WINDSHIELD WAS LEAKING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS ADDRESSING THE FAILURES. THE FAILURE MILEAGE WAS 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437751November 29, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE WIRING HARNESS AND COIL PLUG WAS CAUSING THE VEHICLE TO STALL AND DRIVE HARD. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE WIRING HARNESS AND COIL PLUG REPLACED BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER BUT THE DEALER COULD NOT PROPERLY DIAGNOSE THE VEHICLE. THE FAILURE MILEAGE WAS 68,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437532November 28, 2011
FUEL SYSTEM, GASOLINE
A PLASTIC COVER OVER THE REAR PART (TOWARDS THE AXLE) OF THE GAS TANK HAS CAUSED A RUST HOLE IN THE TANK. THE PIECE IS HELD ON WITH 2 STRIPS OF DOUBLE SIDED ADHESIVE AND ATTACHES TO TWO CLIPS ON THE TANK. THE RUST DAMAGE IS UNDER THE ADHESIVE STRIP ON THE BOTTOM CAUSING A VERY SLOW LEAK. I'M NOT SURE WHAT THE FUNCTION IS FOR THIS PLASTIC PIECE AND I CAN'T IMAGINE THAT MY VEHICLE IS THE ONLY ONE AFFECTED BY THIS DESIGN FLAW? *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436760November 22, 2011
VEHICLE SPEED CONTROL:CRUISE CONTROL
TL* THE CONTACT OWNS A 2001 FORD F-150 SUPER CREW. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, HE WAS INFORMED THAT THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED AND ADVISED THAT THE MODULAR OF THE CRUISE CONTROL WAS THE CAUSE OF THE FIRE. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 248,000. ...UPDATE 01/20/12 *BF
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10435343November 12, 2011
FUEL SYSTEM, GASOLINE
ON 11/11/11 I WAS DRIVING HOME FROM WORK IN MY 2001 FORD F150 AND WAS APPROXIMATELY 1 AND A HALF BLOCKS FROM MY HOUSE WHEN I HIT A POTHOLE AND HEARD A LOUD BANG AND THEN SOME METAL GRINDING OR DRAGGING WHICH I INITIALLY THOUGHT WAS MY EXHAUST THE WAY IT SOUNDED, SO I STOPPED THE TRUCK AND LOOKED UNDERNEATH. THIS IS WHEN I REALIZED THE MAGNITUDE OF THE SITUATION, A STRAP THAT HOLDS MY GAS TANK IN PLACE HAD BROKEN OFF FROM WHAT APPEARS TO BE RUSTED AND THE GAS TANK WAS HANGING BY ONE STRAP . AT THIS TIME I WAS ABOUT 100 FEET FROM MY HOUSE SO I HAD MY SON COME OUT AND I PUSHED THE VEHICLE TO IN FRONT OF MY HOUSE. THE TANK IS GRINDING ON SOMETHING WHEN YOU MOVE THE VEHICLE OR WHEN TURNING THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435156November 10, 2011
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH AND HEARD A LOUD, ABNORMAL NOISE OUTSIDE OF THE VEHICLE. THE CONTACT IMMEDIATELY PULLED OVER AND NOTICED THAT THE SPARE TIRE THAT WAS MOUNTED UNDER THE TRUCK HAD DETACHED FROM THE CARRIAGE AS A RESULT OF A FRACTURED CABLE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434996November 9, 2011
ELECTRICAL SYSTEM
THE VEHICLE HAD NOT BEEN DRIVEN FOR SEVERAL DAYS. IT CAUGHT FIRE WHILE NO ONE WAS HOME. THERE HAD BEEN NO PROBLEMS BEFORE AS FAR AS RUNNING. THE FIRE STARTED IN THE ENGINE COMPARTMENT. EXACT CAUSE WAS NOT DETERMINED. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10434897November 8, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE NOTICED A FUEL SPILL. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AS THE REAR FUEL TANK STRAP BEING CORRODED AND CAUSED A HOLE ON THE FUEL TANK. THE FUEL TANK AND STRAPS WERE REPLACED. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE MANUFACTURER DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE BECAUSE THE FUEL TANK DID NOT DETACH. THE FAILURE MILEAGE WAS 101,340 AND THE CURRENT MILEAGE WAS 102,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434495November 3, 2011
VEHICLE SPEED CONTROL
2001 FORD F150. ATTORNEY WRITES ON BEHALF OF CLIENT REGARDING VEHICLE FIRE *TGW AN EXPERT EXAMINED THE VEHICLE AND DETERMINED THE CAUSE OF THE FIRE WAS THE FACTORY-INSTALLED SPEED CONTROL DEACTIVATION SWITCH. A RECALL WAS ISSUED REGARDING THE SAME PROBLEM TARGETING THE CONTROL SWITCHES. HOWEVER, THE CONSUMER WAS NEVER NOTIFIED. *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10433983November 2, 2011
SEAT BELTS
TL* THE CONTACT OWNS A 2001 FORD F150. WHILE DRIVING APPROXIMATELY 25 MPH, THE FRONT PASSENGER SEAT BELT BUCKLE RELEASED AND FAILED TO CLOSE IN A SECURED POSITION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE SEAT BELT ASSEMBLY WOULD NEED TO BE REPLACED DUE TO A DEFECTIVE SPRING IN THE SEAT BELT BUCKLE. THE VEHICLE HAD BEEN PREVIOUSLY REPAIRED FOR THE SAME FAILURE IN JULY OF 2003 UNDER NHTSA CAMPAIGN ID NUMBER: 01V227001 (SEAT BELTS: FRONT: BUCKLE ASSEMBLY). THE FAILURE RECURRED BUT THE PART NEEDED FOR REPAIRS WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433772November 1, 2011
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE FUEL TANK WAS LEAKING FUEL DUE TO THE CORRODED STRAPS. THE CONTACT WAS ALSO INFORMED THAT REPAIRS TO THE FUEL TANK WERE NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432880October 26, 2011
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE PARKED, THE VEHICLE BECAME ENGULFED IN FLAMES. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. THE CONTACT NOTICED THE FIRE HAD ORIGINATED FROM THE CRUISE CONTROL SYSTEM. THE FIRE DEPARTMENT REPORTED TO THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. THE DEALER WAS WAITING FOR THE MANUFACTURER AND THE INSURANCE COMPANY TO COMMUNICATE IN ORDER TO INSPECT THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10430453October 17, 2011
FUEL SYSTEM, GASOLINE
I HAVE NOT SEEN THIS POSTED ANYWHERE. I HAVE RECEIVED THE FORD RECALL FOR THE FUEL TANK STRAPS. MY LOCAL DEALERSHIP CALLED ME WHEN I TOOK THE TRUCK IN FOR THE REPAIRS AND SAID MY FUEL TANK IS LEAKING. THE FUEL LEAK IS RIGHT BEHIND OR AROUND THE REAR TANK STRAP. I DO HAVE PICTURES IF ANYONE WANTS TO SEE IT. THE FORD DEALERSHIP DIDN'T HESITATE TO TELL ME THAT IT WAS NOT PART OF THE RECALL AND GAVE ME A QUOTE TO REPLACE IT. I FEEL IT SHOULD BE ADDED TO THE RECALL PROCEDURE. IT SURE SEEMS LIKELY THAT THE RUSTED STRAP CAUSED THE RUST AND EVENTUALLY CAUSED THE LEAK. NOW I HAVE A TRUCK THAT SHOULDN'T BE DRIVEN, WON'T PASS STATE INSPECTION AND FORD SAYS I'M ON THE HOOK FOR A NEW FUEL TANK. THEY KNOW THEY HAVE A PROBLEM AND SHOULD STEP UP TO THE PLATE AND LOOK INTO THIS SOME MORE. I'M NOT THE ONLY GUY THAT HAS THIS SAME PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430496October 17, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS WERE FRACTURED AS A RESULT OF CORROSION. THE CONTACT MENTIONED THAT THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 11V385000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) . THE VEHICLE WAS TOWED TO THE DEALER WHO VERIFIED THE FAILURE AND DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE FUEL TANK WAS NOT PART OF THE RECALL. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430094October 13, 2011
VEHICLE SPEED CONTROL
I HAD NOTICED A SLIGHT RESTRICTION IN THE ACCELERATOR PEDDLE FOR AN EXTENDED PERIOD. ON THE DATE ABOVE, I PRESSED DOWN ON THE PEDDLE. WHEN I TOOK MY FOOT OFF THE PEDDLE IT STAYED DOWN AND THE VEHICLE BEGAN ACCELERATING RAPIDLY. TO GAIN CONTROL I TURNED SLIGHTLY TO THE RIGHT AND TURNED OFF THE KEY TO SLOW TO A STOP. I REMOVED THE PLASTIC COVER THAT ENCLOSES THE THROTTLE BODY. IT WAS SECURELY IN PLACE. WHEN I TOOK THE COVER OFF THE THROTTLE SNAPPED CLOSED. IT NOW OPERATES NORMALLY WITH THE THROTTLE BODY COVER REMOVED. ALL PARTS ARE IN GOOD CONDITION AND EXHIBIT NO WEAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430112October 13, 2011
ENGINE AND ENGINE COOLING
I WAS DRIVING TO WORK AND HEARD A LOUD POP AND STOPPED THE TRUCK AND CALLED THE TOW TRUCK. THE MECHANIC INFORMED ME THAT A SPARK PLUG BLEW OUT OF THE HEAD OF THE ENGINE AND IT WAS GOING TO COST $550.00 TO FIX, HE ALSO SAID THAT IT WOULD BE A TEMPORARY FIX AND THAT I WOULD NEED A NEW ENGINE BECAUSE OF THE DAMAGE. I DID SOME RESEARCH AND FOUND THAT THIS HAS BEEN A PROBLEM FOR SOME TIME WITH THESE ENGINES BECAUSE OF THE ALUMINUM HEADS AND THERE WERE ONLY 3-4 THREADS ACTUALLY HOLDING THE SPARK PLUG. A FORD MOTOR CO. WARRANTY INSPECTOR SAYS THE FORD TRITON V-8 ENGINES ARE "DROPPING LIKE FLIES" BECAUSE OF BLOWN SPARK PLUGS. I WOULD LIKE TO ADDRESS THE FORD SPARK PLUG BLOWOUT ISSUE. FORD TRITON ENGINES FROM 1997 TO 2003 HAD A PROBLEM WHERE SPARK PLUGS WOULD RANDOMLY FLY OUT THE CYLINDER HEAD. THIS APPEARS TO BE DUE TO A FEW ISSUES (ENGINEERING DESIGN FLAW), FIRST THERE ARE INSUFFICIENT THREADS (3-4) IN THE HEAD TO PROPERLY HOLD THE SPARK PLUG. SECOND THE THREADS IN THE HEAD ARE NOT INSERTED, IN OTHER WORDS THE THREADS ARE IN THE ALUMINUM AND ARE NOT VERY STRONG. SPARK PLUG EJECTION IS DANGEROUS BECAUSE FUEL VAPOR STARTS COMING OUT THE SPARK PLUG HOLE, WHICH IS CLEARLY A SERIOUS SAFETY ISSUE. THE FUEL VAPOR CAN BE IGNITED BY THE LOOSE SPARK PLUG - AND IN FACT THERE HAVE BEEN A SMALL NUMBER OF CASES REPORTED OF ENGINE FIRES DUE TO SPARK PLUG EJECTION/BLOWOUT. FORD NEEDS TO BE HELD RESPONSIBLE FOR THE REPAIRS OF SPARK PLUG BLOW OUT AND SHOULD EXTEND THE WARRANTY REGARDLESS OF AGE ON THE SPARK PLUG BLOW OUT ISSUE, THEY ALSO SHOULD BE FORCED TO PAY A FAIR AMOUNT OF LABOR TIME, BECAUSE MOST OF THE REPAIRS COST THOUSANDS OF DOLLARS. FORD HAS BEEN AWARE OF THIS SERIOUS ISSUE OF AN ENGINEERING-DESIGN FLAW AND NEEDS TO RECALL 17 MILLION VEHICLES FROM 1997-2003. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150