Ford F-150 Service Bulletins (2019)

332 manufacturer communications on file.

February 19, 2019•Document ID: 10156882
Service Bulletin/Repair Instructions
POWER TRAIN
Mfr Comm. #:
SSM 47812
Date Added:
April 8, 2019
Manufacturer:
FORD
Summary
Some 2017-2019 F-150, 2018-2019 Expedition/Navigator/Mustang, 2019 Ranger vehicles equipped with a 10R80 transmission may exhibit a whine noise. This may occur at idle and while driving coming from the bell housing and front pan area of the transmission. The whine noise may become louder when at operating temperature and increases with higher engine RPM in the PARK position. A small amount of whine noise is considered to be characteristic of the 10R80 transmission due to the offset gear drivetrain in the front support and has no effect on durability.
Associated Products (5)
2019 Ford F-150 2019 Ford Mustang 2018 Ford F-150 2018 Ford Mustang 2017 Ford F-150
Associated Documents
- Download MC-10156882-0001.pdf↗
February 19, 2019•Document ID: 10155571
Service Bulletin/Repair Instructions
SEATS
Mfr Comm. #:
SSM 47814
Date Added:
April 1, 2019
Manufacturer:
FORD
Summary
Some 2016-2019 Explorer, 2016-2018 MKX, 2019 Edge/Nautilus, 2017-2019 Fusion/MKZ, and 2018-2019 F-150/Mustang/Expedition/Navigator vehicles equipped with climate controlled seats may exhibit a buzzing noise from the front seats, front seats too warm, and/or inoperative climate controlled front seats. DTCs B14BA:13, B1154:4B, and/or B14B9:13 may also be present. This may be due to loose terminal pin fit on the driver seat module (DSM) connector C341D (16 pin). If a loose terminal pin fit condition is found during normal diagnostics per Workshop Manual (WSM), Section 501-10, a new service pigtail connector (part number 3U2Z-14S411-BRAB) is available. Refer to Wiring Diagram, Cell 119 to make sure C341D is a 16 pin connector and not a 20 pin connector. Refer to Wiring Diagram, Cell 5 for the recommended splicing procedures.
Associated Products (22)
2019 Ford Edge 2019 Ford Explorer 2019 Ford F-150 2019 Ford Fusion 2019 Ford Mustang 2019 Lincoln MKX 2019 Lincoln MKZ 2019 Lincoln Nautilus 2019 Lincoln Navigator 2018 Ford Explorer 2018 Ford F-150 2018 Ford Fusion 2018 Ford Mustang 2018 Lincoln MKX 2018 Lincoln MKZ 2018 Lincoln Navigator 2017 Ford Explorer 2017 Ford Fusion 2017 Lincoln MKX 2017 Lincoln MKZ+ 2 more
Associated Documents
- Download MC-10155571-0001.pdf↗
February 19, 2019•Document ID: 10155570
Service Bulletin/Repair Instructions
POWER TRAIN
Mfr Comm. #:
SSM 47812
Date Added:
April 1, 2019
Manufacturer:
LINCOLN
Summary
Some 2017-2019 F-150, 2018-2019 Expedition/Navigator/Mustang, 2019 Ranger vehicles equipped with a 10R80 transmission may exhibit a whine noise. This may occur at idle and while driving coming from the bell housing and front pan area of the transmission. The whine noise may become louder when at operating temperature and increases with higher engine RPM in the PARK position. A small amount of whine noise is considered to be characteristic of the 10R80 transmission due to the offset gear drivetrain in the front support and has no effect on durability.
Associated Products (10)
2019 Ford Expedition 2019 Ford F-150 2019 Ford Mustang 2019 Ford Ranger 2019 Lincoln Navigator 2018 Ford Expedition 2018 Ford F-150 2018 Ford Mustang 2018 Lincoln Navigator 2017 Ford F-150
Associated Documents
- Download MC-10155570-0001.pdf↗
February 18, 2019•Document ID: 10156866
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Mfr Comm. #:
TSB 19-2041
Date Added:
April 8, 2019
Manufacturer:
FORD
Summary
Some 2015-2019 F-150 XL/XLT vehicles may exhibit warping/separation of the instrument panel at the defrost vents. To resolve the condition, replace the instrument panel upper section.
Associated Products (5)
2019 Ford F-150 2018 Ford F-150 2017 Ford F-150 2016 Ford F-150 2015 Ford F-150
Associated Documents
- Download MC-10156866-0001.pdf↗
February 18, 2019•Document ID: 10155554
Service Bulletin/Repair Instructions
EQUIPMENT ADAPTIVE/MOBILITY; ELECTRICAL SYSTEM
Mfr Comm. #:
TSB 19-2041
Date Added:
April 1, 2019
Manufacturer:
FORD
Summary
Some 2015-2019 F-150 XL/XLT vehicles may exhibit warping/separation of the instrument panel at the defrost vents. To resolve the condition, replace the instrument panel upper section.
Associated Products (5)
2019 Ford F-150 2018 Ford F-150 2017 Ford F-150 2016 Ford F-150 2015 Ford F-150
Associated Documents
- Download MC-10155554-0001.pdf↗
February 12, 2019•Document ID: 10156857
Service Bulletin/Repair Instructions
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Mfr Comm. #:
TSB 19-2004
Date Added:
April 8, 2019
Manufacturer:
FORD
Summary
Some 2015-2016 F-150 vehicles built on or before 01-Feb-2016, 2019 F-150 vehicles built on 11-Oct-2018 and through 15-Nov-2018 and 2019 F-Super Duty vehicles built on 10-Oct-2018 and through 27-Nov-2018 equipped with adaptive cruise control may exhibit an unintended deceleration event while passing a large object such as a tractor trailer. Follow the Service Procedure steps to correct the condition.
Associated Products (3)
2019 Ford F-150 2016 Ford F-150 2015 Ford F-150
Associated Documents
- Download MC-10156857-0001.pdf↗
February 12, 2019•Document ID: 10155445
Service Bulletin/Repair Instructions
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Mfr Comm. #:
TSB 19-2004
Date Added:
April 1, 2019
Manufacturer:
FORD
Summary
Some 2015-2016 F-150 vehicles built on or before 01-Feb-2016, 2019 F-150 vehicles built on 11-Oct-2018 and through 15-Nov-2018 and 2019 F-Super Duty vehicles built on 10-Oct-2018 and through 27-Nov-2018 equipped with adaptive cruise control may exhibit an unintended deceleration event while passing a large object such as a tractor trailer. Follow the Service Procedure steps to correct the condition.
Associated Products (3)
2019 Ford F-150 2016 Ford F-150 2015 Ford F-150
Associated Documents
- Download MC-10155445-0001.pdf↗
February 6, 2019•Document ID: 10156875
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING:COOLING SYSTEM; ELECTRICAL SYSTEM
Mfr Comm. #:
SSM 47791
Date Added:
April 8, 2019
Manufacturer:
LINCOLN
Summary
Some 2015-2019 F150/Edge, 2016-2018 MKX, 2019 Nautilus and 2017-2019 Fusion/Continental vehicles equipped with a 2.7L engine may exhibit a malfunction indicator lamp (MIL) and/or wrench lamp with diagnostic trouble codes (DTCs) P0116, P0117, P0118, P0119, P0217, P0330, P1026, and/or P130D. This may be due to a engine coolant temperature (ECT) sensor connector which is not fully seated or damaged wiring between connectors C1064 and C1047 for F150 and C1016 and C1168 for Edge/MKX/Nautilus/Fusion/Continental vehicles. ECT sensors should not be replaced if damaged wiring is found at or near these connectors. For claiming, use causal part 12A699 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (20)
2019 Ford Edge 2019 Ford F-150 2019 Ford Fusion 2019 Lincoln Continental 2019 Lincoln MKX 2018 Ford Edge 2018 Ford F-150 2018 Ford Fusion 2018 Lincoln Continental 2018 Lincoln MKX 2017 Ford Edge 2017 Ford F-150 2017 Ford Fusion 2017 Lincoln Continental 2017 Lincoln MKX 2016 Ford Edge 2016 Ford F-150 2016 Lincoln MKX 2015 Ford Edge 2015 Ford F-150
Associated Documents
- Download MC-10156875-0001.pdf↗
February 6, 2019•Document ID: 10155563
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING
Mfr Comm. #:
SSM 47791
Date Added:
April 1, 2019
Manufacturer:
FORD
Summary
Some 2015-2019 F150/Edge, 2016-2018 MKX, 2019 Nautilus and 2017-2019 Fusion/Continental vehicles equipped with a 2.7L engine may exhibit a malfunction indicator lamp (MIL) and/or wrench lamp with diagnostic trouble codes (DTCs) P0116, P0117, P0118, P0119, P0217, P0330, P1026, and/or P130D. This may be due to a engine coolant temperature (ECT) sensor connector which is not fully seated or damaged wiring between connectors C1064 and C1047 for F150 and C1016 and C1168 for Edge/MKX/Nautilus/Fusion/Continental vehicles. ECT sensors should not be replaced if damaged wiring is found at or near these connectors. For claiming, use causal part 12A699 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (20)
2019 Ford Edge 2019 Ford F-150 2019 Ford Fusion 2019 Lincoln Continental 2019 Lincoln MKX 2018 Ford Edge 2018 Ford F-150 2018 Ford Fusion 2018 Lincoln Continental 2018 Lincoln MKX 2017 Ford Edge 2017 Ford F-150 2017 Ford Fusion 2017 Lincoln Continental 2017 Lincoln MKX 2016 Ford Edge 2016 Ford F-150 2016 Lincoln MKX 2015 Ford Edge 2015 Ford F-150
Associated Documents
- Download MC-10155563-0001.pdf↗
February 5, 2019•Document ID: 10156861
Service Bulletin/Repair Instructions
FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM
Mfr Comm. #:
TSB 19-2018
Date Added:
April 8, 2019
Manufacturer:
FORD
Summary
Some 2018-2019 F-150 vehicles equipped with a 3.0L diesel engine built on or before 25-Jan-2019 may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0234, P208E and/or P2201 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
Associated Products (2)
2019 Ford F-150 2018 Ford F-150
Associated Documents
- Download MC-10156861-0001.pdf↗
February 5, 2019•Document ID: 10155549
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING:ENGINE:DIESEL; POWER TRAIN
Mfr Comm. #:
TSB 19-2018
Date Added:
April 1, 2019
Manufacturer:
FORD
Summary
Some 2018-2019 F-150 vehicles equipped with a 3.0L diesel engine built on or before 25-Jan-2019 may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0234, P208E and/or P2201 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
Associated Products (2)
2019 Ford F-150 2018 Ford F-150
Associated Documents
- Download MC-10155549-0001.pdf↗
February 1, 2019•Document ID: 10156870
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL; ELECTRICAL SYSTEM
Mfr Comm. #:
SSM 47782
Date Added:
April 8, 2019
Manufacturer:
FORD
Summary
Some 2019 F-150 vehicles built on or before 4-Jan-2019 may experience difficulty enabling neutral tow mode to allow four-wheel-down towing of the vehicle. To correct this condition, reconfigure the instrument panel cluster (IPC) using As-Built Programming. Make sure you are connected to the internet when entering module programming to obtain the latest data. For claiming, use causal part 10849 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (1)
2019 Ford F-150
Associated Documents
- Download MC-10156870-0001.pdf↗
February 1, 2019•Document ID: 10155558
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM
Mfr Comm. #:
SSM 47782
Date Added:
April 1, 2019
Manufacturer:
FORD
Summary
Some 2019 F-150 vehicles built on or before 4-Jan-2019 may experience difficulty enabling neutral tow mode to allow four-wheel-down towing of the vehicle. To correct this condition, reconfigure the instrument panel cluster (IPC) using As-Built Programming. Make sure you are connected to the internet when entering module programming to obtain the latest data. For claiming, use causal part 10849 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (1)
2019 Ford F-150
Associated Documents
- Download MC-10155558-0001.pdf↗
January 28, 2019•Document ID: 10153979
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM
Mfr Comm. #:
SSM 47775
Date Added:
March 4, 2019
Manufacturer:
FORD
Summary
Some 2019 Mustang/Fusion/Edge/F-150/Continental/MKZ/Nautilus with SYNC 3 may show a pop-up message every key cycle that states Network Connection Needed - To complete the system updates your vehicle should connect to a Wi-Fi network or through the FordPass/LincolnWay app. Until the update is completed, some features may not be available. Would you like to attempt to connect to a Wi-Fi network now? This message may occur, even if SYNC has been connected to a trusted Wi-Fi source. To temporarily remove the inconvenience of this pop-up message, advise the customer from SYNC to select Settings > Automatic Updates > System Wi-Fi and turn off System Wi-Fi, then turn off automatic system updates. Engineering is investigating, monitor OASIS for updates
Associated Products (6)
2019 Ford Edge 2019 Ford F-150 2019 Ford Fusion 2019 Ford Mustang 2019 Lincoln Continental 2019 Lincoln MKZ
Associated Documents
- Download MC-10153979-0001.pdf↗
January 18, 2019•Document ID: 10153920
Service Bulletin/Repair Instructions
EQUIPMENT; LATCHES/LOCKS/LINKAGES:DOORS:LATCH; STRUCTURE:BODY:DOOR
Mfr Comm. #:
TSB 19-2007
Date Added:
March 4, 2019
Manufacturer:
FORD
Summary
Some 2018-2019 F-150 vehicles built at Kansas City Assembly Plant on or after 4-Apr-2018 and Dearborn Truck Plant on or after 13-Apr-2018 and some F-Super Duty vehicles built at Kentucky Truck Plant on or after 22-Apr-2018 and Ohio Assembly Plant on or after 18-Apr-2018 may exhibit doors that are difficult to unlatch or latch in temperatures at or below freezing. Follow the Service Procedure steps to correct the condition.
Associated Products (26)
2019 Ford F-150 2019 Ford F-250 2019 Ford F-350 2019 Ford F-450 2019 Ford F-550 2019 Ford F-650 2019 Ford F-750 2018 Ford F-150 2018 Ford F-250 2018 Ford F-350 2018 Ford F-450 2018 Ford F-550 2018 Ford F-650 2018 Ford F-750 2017 Ford F-250 2017 Ford F-350 2017 Ford F-450 2017 Ford F-550 2017 Ford F-650 2017 Ford F-750+ 6 more
Associated Documents
- Download MC-10153920-0001.pdf↗
January 17, 2019•Document ID: 10153970
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Mfr Comm. #:
SSM 47750
Date Added:
March 4, 2019
Manufacturer:
FORD
Summary
Some 2018-2019 Ford and Lincoln vehicles equipped with a TCU may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization and/or accessory protocol interface module (APIM) DTC U0198 or no modem electronic serial number (ESN) displayed. To correct this condition prior to programing remove the TCU fuse for 5 minutes then reinstall. Delete all previous session files for the vehicle. Verify that the electronic serial number (ESN) is now displayed. Start a new IDS/FDRS session. Program the TCU to the latest IDS/FDRS version level. Make sure you are connected to the internet before retesting. If the concern is still present, follow normal diagnostics in Workshop Manual(WSM), Section 415-00. Refer to PTS OASIS home page for TCU version identification. For claiming, use causal part 14G229.
Associated Products (18)
2019 Ford Ecosport 2019 Ford Escape 2019 Ford Explorer 2019 Ford F-150 2019 Ford Mustang 2019 Lincoln Continental 2019 Lincoln MKC 2019 Lincoln MKX 2019 Lincoln MKZ 2018 Ford Ecosport 2018 Ford Escape 2018 Ford Explorer 2018 Ford F-150 2018 Ford Mustang 2018 Lincoln Continental 2018 Lincoln MKC 2018 Lincoln MKX 2018 Lincoln MKZ
Associated Documents
- Download MC-10153970-0001.pdf↗
January 17, 2019•Document ID: 10153969
Service Bulletin/Repair Instructions
EQUIPMENT
Mfr Comm. #:
SSM 47749
Date Added:
March 4, 2019
Manufacturer:
LINCOLN
Summary
Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford are not reimbursable through the Ford Motor Company warranty system. Please see the Warranty and Policy Manual for further information on Ford Licensed Accessories.
Associated Products (142)
2019 Ford Ecosport 2019 Ford Edge 2019 Ford Escape 2019 Ford Explorer 2019 Ford F-150 2019 Ford Fiesta 2019 Ford Flex 2019 Ford Fusion 2019 Ford Mustang 2019 Ford Taurus 2019 Ford Transit 2019 Ford Transit Connect 2019 Lincoln Continental 2019 Lincoln MKC 2019 Lincoln MKT 2019 Lincoln MKX 2019 Lincoln MKZ 2018 Ford C-Max 2018 Ford Ecosport 2018 Ford Edge+ 122 more
Associated Documents
- Download MC-10153969-0001.pdf↗
January 11, 2019•Document ID: 10153926
Service Bulletin/Repair Instructions
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA; BACK OVER PREVENTION
Mfr Comm. #:
SSM 47741
Date Added:
March 4, 2019
Manufacturer:
FORD
Summary
Some 2019 Mustang, Continental, Fusion, MKZ, F150, Edge or Nautilus with SYNC 3 may have a symptom of a rear view camera that remain on the screen when moving forward above 5MPH or a solid blue screen once the vehicle is at cruising speed. Some vehicles may experience inoperative infotainment applications such as Apple CarPlay. To eliminate these symptoms from occurring, it is recommended to disable the Wi-Fi in the settings menu by selecting Automatic updates. Shut off system WIFI and then disable automatic updates. If the vehicle is stuck in the rear camera state you can exit this state by shutting the vehicle off and powering the system down for at least three minutes. Engineering is investigating, monitor OASIS for updates.
Associated Products (7)
2019 Ford Edge 2019 Ford F-150 2019 Ford Fusion 2019 Ford Mustang 2019 Lincoln Continental 2019 Lincoln MKZ 2019 Lincoln Nautilus
Associated Documents
- Download MC-10153926-0001.pdf↗
January 10, 2019•Document ID: 10153925
Service Bulletin/Repair Instructions
EQUIPMENT ADAPTIVE/MOBILITY; ENGINE AND ENGINE COOLING
Mfr Comm. #:
SSM 47740
Date Added:
March 4, 2019
Manufacturer:
FORD
Summary
2018 Expedition/Navigator, 2018-2019 F-Super Duty and 2019 E-Series/F-650/F-750 vehicles built on or after 9-Jul-2018 and 2019 F-150/Transit vehicles built on or after 2-Jan-2019 are filled with the new Motorcraft Yellow Antifreeze/Coolant. When servicing the cooling system(s) on these vehicles, use Motorcraft Yellow Antifreeze/Coolant VC-13-G (CVC-13-G for Canada). Do not mix different colors or types of coolant. NOTE: The Motorcraft Yellow Antifreeze/Coolant may appear green in color due to the florescent dye used.
Associated Products (17)
2019 Ford E-350 2019 Ford F-150 2019 Ford F-250 2019 Ford F-350 2019 Ford F-450 2019 Ford F-550 2019 Ford F-650 2019 Ford F-750 2019 Ford Transit 2018 Ford Expedition 2018 Ford F-250 2018 Ford F-350 2018 Ford F-450 2018 Ford F-550 2018 Ford F-650 2018 Ford F-750 2018 Lincoln Navigator
Associated Documents
- Download MC-10153925-0001.pdf↗
January 8, 2019•Document ID: 10153915
Service Bulletin/Repair Instructions
EQUIPMENT
Mfr Comm. #:
TSB 18-2364
Date Added:
March 4, 2019
Manufacturer:
FORD
Summary
Some 2015-2019 F-150 vehicles may exhibit a console media bin door that will not open or is binding. This may be due to the console media bin door inertia switch being stuck in the active position. Follow the Service Procedure steps to correct the condition.
Associated Products (5)
2019 Ford F-150 2018 Ford F-150 2017 Ford F-150 2016 Ford F-150 2015 Ford F-150
Associated Documents
- Download MC-10153915-0001.pdf↗

← Back to Ford F-150