Ford Explorer Complaints

917 consumer complaints on file.

#11676588July 28, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2022 Ford Explorer. The contact’s son started the vehicle and became aware that the "Cylinder Head Temperature Overheated" message was displayed on the instrument panel while the vehicle was parked in the driveway. The vehicle was towed to the dealer, who diagnosed that the engine and engine cooling system had failed due to water leaking into the turbo. The dealer stated that the sensor failed to identify and inform the driver that the engine was running hot. The contact became aware that the failure had occurred with the previous owner of the vehicle approximately 2 - 3 years ago. The contact was informed that the engine needed to be replaced, or the turbocharger could be replaced as a temporary repair. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 105,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676271July 25, 2025
BACK OVER PREVENTION
The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was parked, the rearview became inoperable. The contact stated that the rearview camera image was blank. The vehicle was taken to the dealer, where it was diagnosed that the processing module console had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 76,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676040July 24, 2025
STEERING, SUSPENSION
I noticed a loud squeak when driving over bumps at lower speeds. Almost sounds like a bad shock or spring. I am not sure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675704July 23, 2025
ELECTRICAL SYSTEM
The contact owns a 2023 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. There were several unknown warning lights illuminated. The vehicle was taken to the dealer, where the vehicle was diagnosed and determined that the wiring harness located on the passenger’s side of the vehicle needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 44,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675083July 21, 2025
UNKNOWN OR OTHER
Panoramic sunroof fail for 2nd time repair is close to 2000$ I’m not going to paid again this is a ford design issue not a owner fault Panoramic roof have some plastic click that hold the shade and they got brake or damage by itself causing the shade felt, ford rapair is close to 1.8k$ I paid one when I first bought the car now after the Texas freeze when I was closing the system I heard the clicks braking and then we have the same issue with the panoramic shade got weak and there is no way to fixed just the deal and the price is close to 2000$ for a internal design there is several people with this same issue this is a internal fault design not a owner fault
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674872July 20, 2025
SEAT BELTS, ENGINE, ELECTRICAL SYSTEM
Recall Action Soon Issue Since 06-20-2025 Unrequested second-row seat movement For More Information Telematics Generated Issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674796July 19, 2025
ENGINE, FUEL/PROPULSION SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS
Recall Action Soon Issue Since 06-20-2025 Unrequested second-row seat movement Unrequested second-row seat movement Recall incomplete Recall service not available right now. We have a remedy but parts are not available right now. We will inform you when the service is available. Or, you can contact your dealer. Contact Dealer Issue Date 2025-06-13 Campaign 25S67/25V393 Description On your vehicle, it is possible that the easy entry seat fold switch on the second-row outboard seats may bind or stick if its surrounding trim bezel was installed incorrectly. If the button is stuck in the down position, the seat may unlatch, fold and or slide unexpectedly, potentially while driving. Safety Risk A seat that unexpectedly folds or slides while driving could increase the risk of injury, particularly in a crash. Remedy Ford Motor Company is working to provide parts for this repair. When the remedy becomes available, Ford Motor Company will notify you via mail to schedule a service appointment with your dealer for repairs to be completed free of charge.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674669July 18, 2025
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS
Brakes failed while coming to a red light. Turned to the right and into rock landscaping and pushed the ebrake to stop. Antilock brake failure came up and pre collision assist said was no longer available. Had to have it taken to Ford dealership. They replaced brake booster and brake lines and tried to reprogram computer but brakes keep locking up . So there are keeping for now to figure out the problems
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674188July 17, 2025
ENGINE, FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford Explorer. The contact stated that while driving approximately 20-30 MPH, the vehicle stalled, with the check engine warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was towed to an independent mechanic. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673960July 16, 2025
STRUCTURE:BODY
My 2025 Ford Explorer has a wind noise that Ford has admitted to having an issue with. My case number is CXH04811376. In the upper corner of both the drivers and passenger side front window there is a loud wind noise that begins at speeds of 40 mph and more. A Customer Experience Specialist admitted there is a problem but they will not fix it until there is a recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673816July 15, 2025
POWER TRAIN, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
my explorer has a 10 speed transmission, and its REALLY heavy on shifting like it is missing shifts or slipping, it will shoot up in rpms to the 7-8k mark and jerk forward, this will happen every few minutes when varying speed, driving through residential areas or normal trafficways not including the highway, however on the highway it has a tendency to feel as if it loses power and regains it, dropping rpms and shooting back up to 4-5k rpm, and dropping back down to around 2k. today i had the incident where the car jerked hard after a shift, gave me prompts on the dash about seeing the manual, and that drive modes are not available. this has happened in the past month before multiple times, however this time i lost all power to acceleration going down the road, ended up just coasting to a stop on a road that speed limit is 55 mph. this made me panic, because i could have possibly been rear ended, or in any other case could have been hit if my car would not have properly been able to accelerate. the car has had similar problems reported from previous owners and they have been taken into a dealership for repairs of which did not fix the problem or the problem is reoccurring. there are no warning lamps prior to the jerkiness of shifting and loss of acceleration because of it. it will jerk a handful of times and eventually give me the "see manual" prompt after the initial problem was noticed, i decided to look online for answers as to what was wrong and it seems like this is a reoccurring problem with vehicles similar to mine. Hopefully it hasnt caused and injuries, but it definitely has the possibility to from what i have experienced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673644July 15, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford Explorer. The contact stated that while depressing the accelerator pedal, the vehicle hesitated while accelerating and decelerated unintendedly. The contact stated that the failure mostly occurred during the warmer weather months. The cause of the failure was not determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673636July 15, 2025
VEHICLE SPEED CONTROL
The contact owns a 2023 Ford Explorer. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning lights were illuminated. The vehicle was taken to an independent mechanic; however, a diagnostic test was not performed. The dealer was made aware of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the vehicle had been scheduled for a diagnostic test. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 44,100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673550July 15, 2025
VISIBILITY/WIPER
Fabric for sunroof shade sags making the rearview mirror un usable due to the fabric sag obstruction.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673262July 14, 2025
SERVICE BRAKES, ENGINE, UNKNOWN OR OTHER
I was stoped at a red light with cars in front of me and behind me when with my foot on the break the car accelerated forward like my foot was on the gas pedal but my foot was not on pedal, the car surged forward and came close to hitting the car in front of me I pressed the break and got stopped didn’t happen again but sometimes I can feel the car wanting to keep surging forward when breaking. If there is a problem this could cause me to hit someone in the rear or even worse could hit a pedestrian in the crosswalk please check this out
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672932July 11, 2025
POWER TRAIN
The contact owns a 2021 Ford Explorer. The contact stated that while her fiancé was driving 76 MPH, the vehicle inadvertently lost motive power. The driver was able to pull over to the shoulder of the roadway, where the vehicle was able to be restarted. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 39,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672572July 10, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Ford Explorer. The contact stated while driving 75 MPH on the interstate, the vehicle lost motive power. The contact stated that while depressing the accelerator pedal, the vehicle responded as intended. No warning light was illuminated. A dealer was contacted. The vehicle was taken to a dealer however, the dealer was unable to retrieve a diagnostic trouble code, and informed the contact that there was no failure. No assistance was provided. The vehicle was not repaired. The manufacturer was notified of the failure, and informed the contact that the repair would have to be out-of-pocket with the possibility of being reimbursed. The contact related the failure to NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 17,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672566July 10, 2025
LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
The contact owns a 2025 Ford Explorer. The contact stated while driving approximately 1 MPH and pulling into the garage, the liftgate opened unintendedly, scraping the garage door. The contact worked on the vehicle and temporarily repaired the liftgate. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed that the VIN was not under recall. The manufacturer opened a case due to the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 1,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672511July 10, 2025
LANE DEPARTURE: BLIND SPOT DETECTION
2021 Ford Explorer •Problem: Blind Spot Detection / Sensor Malfunction •Description to copLeft-side blind spot sensor fails intermittently. It shows no warning when vehicles are in the blind spot, creating a risk during lane changes. I found Ford TSB 23-2048 confirms the issue. Dealer quoted $1,200 but this is a known factory problem and safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672494July 10, 2025
AIR BAGS
restrains indicator lamp warning air bag warning issue with vehicle impact sensor. this can prevent that the air bag system from deploying properly
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Explorer