Ford Expedition Complaints (2018)

383 consumer complaints on file.

#11664235June 1, 2025
POWER TRAIN
My wife was driving home from a sports class with my kids in the car. She went to make a left turn against oncoming traffic and the car completely lost power. Pressing the gas did not give any power to the car and the car felt like it was in neutral. if the car did not have enough power at the time of the turn to make it through the oncoming lane, it would have been hit by the oncoming car endangering the lives of the occupants of both vehicles. Our vehicle continued to exhibit the same behavior and I drove it to the dealer. While on the way to the dealer it had 2 powertrain failures before I got it there (30 miles away). The dealership ran diagnostics and said it would be best to get a new tranny as opposed to overhaul since the vehicle only has 90,000 miles and is less than 7 years old. We ended up getting it towed to a local transmission shop who confirmed the diagnostic. They said the seal on the CDF drum plate failed and there was nothing that could be done to stop it. The tranny was rebuilt with all new parts, half a dozen of them upgraded parts from Ford. Upon researching the symptoms, I found this vehicle exhibited a neutral out condition and Ford wrote a technical service bulletin because this issue is so common. I'm frustrated because my family could have been seriously injured or killed because of a known issue that Ford knows about yet chooses to not fix even though this issue puts passengers in life threatening situations. I would not have known about this issue prior to my car exhibiting the neutral out behavior. My local transmission shop has all the parts that were taken out of the transmission and they are available for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663259May 27, 2025
ENGINE, ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, there was a loud clanking sound coming from the vehicle with smoke coming from the engine compartment. The vehicle was taken to the dealer where it was diagnosed and determined that the heater hose and cam phaser had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 118,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662806May 23, 2025
POWER TRAIN
The contact owns a 2018 Ford Expedition. The contact stated while the vehicle was parked, the gear shifter was shifted into drive; however, the vehicle failed to respond as intended. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662808May 23, 2025
UNKNOWN OR OTHER, POWER TRAIN
I have had several issues with this vehicle throughout the years I have owned it. The current issues I am writing about include: transmission failure and replacement, rear passenger door no longer opening and continued issues with the Catalytic convertors. When it comes to the transmission it was unsafe to drive as the gears continued to slip while driving and cause the vehicle to temporarily loose power. This could have resulted in an accident. The vehicle is currently having the transmission replaced at a repair shop where they confirmed the issues. They will also be looking at the other two issues as well. The door not opening poses a huge safety concern as we are only able to use one rear door for entering and exiting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662307May 21, 2025
ENGINE AND ENGINE COOLING
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662325May 21, 2025
POWER TRAIN, ENGINE
2018 Ford Expedition Max 4wd; For the last 4 years I have consistently (1-2x a year) brought this car into a ford dealership for the transmission failing to go into gear at random times while driving under normal conditions. Even though multiple TSB's had been sent out, they "couldn't replicate" or "no codes found" or "the transmission tech is 4–6 weeks out"... nothing was done. Twice while merging into on coming traffic the transmission has been stuck in a gear, will not accelerate or go, and the entire dash illuminates with all the flashing symbols. I'm just glad my children were not in the car with me. It was terrifying. Now, the week of May 18, 2025, I'm back for my annual transmission issue as it stalled on 4/26/2025, and I almost was hit by an 18 wheeler, the ford dealership said "you need a transmission overhaul, TCM reprogram, and there is internal failure, the CDF drum comes apart and Ford is aware they have a faulty seal." The total to fix is $8,214.25 and guess what, NONE of it is covered. I have kept my vehical serviced and always taken care of it. But I will have to pay the price to fix it, or worse if there is a car accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662107May 20, 2025
ENGINE
The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, the Check Engine warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660389May 12, 2025
ENGINE
The contact owns a 2018 Ford Expedition. The contact stated that occasionally while driving on the highway at 70 MPH, the vehicle lost motive power and failed to accelerate above 70 MPH. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that there was not fault found with the vehicle. The vehicle was not repaired. The contact referenced Emission Recall: 24E13; as probable cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659933May 9, 2025
ENGINE, POWER TRAIN
1. The issue involves the transmission and camshaft components of the vehicle. Despite the fact that both the transmission and camshaft were replaced by the Ford dealership after purchase in 2018, the vehicle continues to experience problems. These components have been inspected by the dealership, and the vehicle is available for further inspection upon request. 2. The vehicle’s loss of power during highway driving and while attempting to accelerate poses a significant safety risk. On several occasions, the vehicle has lost power while making turns or driving on the highway, nearly causing accidents with other vehicles. This has been a very frightening experience for us, as the sudden loss of power could have led to a collision. 3. Yes, the problem has been confirmed by the Ford dealership, which replaced the transmission and camshaft components. However, the vehicle continues to run roughly, indicating that the issues have not been fully resolved. These repairs were not covered under warranty, and we had to pay for them out of pocket. 4. The vehicle has been inspected by the Ford dealership multiple times. Despite the repairs, the problems persist. The vehicle has been regularly maintained and garage-kept. 5. There were no warning lamps, messages, or error codes indicating the problem before the failure. However, there has been a loud ticking sound when the vehicle is started and running, which started to occur after the initial repairs. The vehicle has had no other prior indicators to suggest the underlying issue. We purchased the vehicle brand new with only 11 miles on it it currently barely has 70k miles on it. We dropped the vehicle off at the beginning of August 2024 and didn't get it back until almost the end of October, with us needing to bring it back to the dealership for more checks/repairs in December of 2024. We have to pay out of pocket and are without a vehicle because of the constant issues and safety concerns. we can provide receipts and more docs
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659732May 8, 2025
ENGINE, POWER TRAIN
Cam phaser failure, yes, available for inspection. This disrupts the engine's timing and can lead to oil pressure issues as well as engine stalling or engine damage. Yes, confirmed by ford dealer. No, not been inspected by manufacturer or others. No warning lamps yet but the noise was the first indicator and it began about 6 weeks ago. My 2018 Ford Expedition is experiencing cam phaser failure. I had an extended warranty that i have not reached the mileage for yet but the date causes me not to be able to have it fixed under warranty. This is a very expensive repair and I am finding out more and more of these vehicles in this age range are having the same problems. I would ask that Ford be required to pay for this repair. I have reported this to Ford and received a case number of [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659470May 7, 2025
EXTERIOR LIGHTING
Defective daytime running light, passenger side, that does not fully illuminate. I’ve noticed this on several of the same make, model, and body style (with the same DTRLs).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658149May 1, 2025
POWER TRAIN
The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted without warning. The transmission also shifted hard, and the vehicle jerked while driving at various speeds. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed the vehicle with transmission failure. The transmission was rebuilt. The following day while driving approximately 65 MPH, the transmission shifted hard, and the contact became aware that transmission fluid was leaking from the vehicle after exiting and inspecting the vehicle. The vehicle was towed to the dealer who diagnosed the vehicle with transmission failure and replaced the transmission. The contact stated that the transmission still shifted hard while driving and the message that the engine was overheating was displayed. The vehicle was returned to the dealer who had rebuilt the new transmission. After having the third repair, the failure recurred. The vehicle was returned to the dealer but was not yet diagnosed or repaired. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656566April 24, 2025
ENGINE
The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle, the engine made an abnormal sound. The check engine warning light was illuminated. Additionally, the vehicle failed to accelerate intermittently while driving. The vehicle was taken to the dealer, who related the failure to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement); however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655666April 20, 2025
ENGINE, POWER TRAIN, SEAT BELTS
Cam phaser and timing chain assembly is beginning to fail. Ford has a CSB out on this problem but is unwilling to repair or replace components. Transmission has had to be replaced be cause of failure at 100000 miles. I’ve had to replace the water pump twice on my Expedition. Driver side seat belt no longer retracts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655491April 18, 2025
POWER TRAIN
I cash purchased a 2018 Ford Expedition on [XXX] - I have a 90 day warranty and purchased an extended 2 year warranty. I've taken the vehicle back twice to Auto Nation in Denver Co for transmission issues. The transmissions slips and makes a horrible nose when it shift. I can't drive it due to it being unsafe to drive. I do not feel safe driving the vehicle. Auto Nation continues to declining to repair the vehicle. I've owned the vehicle for 2months and maybe drove it for only 100 miles due to the unsafety. Ford has know issues with these 10speed transmissions. I was never informed by the dealer of these know issues therefore was sold a lemon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654122April 11, 2025
POWER TRAIN
In January 2025, we had issues with the transmission not shifting smoothly while out of town. While driving on the freeway at around 65MPH, in traffic, the transmission suddenly downshifted from 10th to either 3rd or 4th gear immediately slowing the vehicle. We almost got rear ended and tried to get over to the shoulder. By the time we could get over, which took about a minute, the transmission recovered itself and went back into the correct gear. We arrived home, took the truck in and was told the transmission needed to be rebuilt. There was a known issue with the transmission in these vehicles. We paid to have the transmission rebuilt. In April 2025, we heard rattling in the engine. We took it in and was told the Cam Phasers were bad and needed to be replaced. Another known issue. We have had the cam phasers replaced in 2020 under warranty. We had them reprogrammed again in 2022 for a recall. Now we are having to replace them again out of pocket. We again, paid for the repairs and got the vehicle back. I called Ford customer service and asked about any programs or reimbursement for these known issues. (Ref # [XXX]) I was told there are none at this time, despite Ford knowing they have issues. Ford has done nothing to correct the problems, but is obviously aware of the issues. Our vehicle only has about 50K miles and has had the most repairs on any vehicle that I've ever owned. We have already purchased the vehicle, and I'm having to "purchase" it a second time with the high cost of repairs. At the very least, Ford should repair the defective parts and cover the cost of such repairs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653768April 9, 2025
ENGINE
Cam phasers are making a loud rattling noise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653644April 9, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle on several occasions, there was a fast-banging metallic sound coming from the engine compartment. The vehicle was taken to a dealer, where it was diagnosed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653658April 9, 2025
AIR BAGS, SEAT BELTS
Driver side seat belt air bag popped while driving down the road and now the seat belt will not retract. shows that this is a known issue in my year model but this is not a recall for my specific vin.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653170April 7, 2025
ENGINE, ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, there was a loud clanking sound coming from the vehicle. The check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed with cam phaser failure. The vehicle had been taken to the dealer two previous times for unknown repairs. The vehicle was not repaired for the most recent failure. The vehicle was taken to an independent mechanic and the repair was pending. The manufacturer was made aware of the failure. The failure mileage was approximately 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition