Ford Expedition Complaints (2019)

526 consumer complaints on file.

#11536777August 6, 2023
SEAT BELTS, AIR BAGS, SEATS
On July 24th 2023, at approximately 2:15pm my wife and I were completely stopped at a red traffic light on 66th St N that crosses Ulmerton Rd in Pinellas County Florida. We were talking and listening to the radio, when all of a sudden, a loud shotgun or explosive sound filled the vehicle. I got hit with something in the chest that felt like a punch or a kick, knocking me out of breath. But my wife only heard the extremely loud noise. I was clutching my chest in pain as I thought I was shot. When the light turned green, I immediately pulled into a Dunkin donuts parking lot, and we exited the vehicle. There was no damage whatsoever on the inside and outside of the vehicle, but we smelled gun powder. My driver's seatbelt was stuck in the retracted position. I slowly drove to my home at 6500 30th Avenue N, St Petersburg, Fl 33710. I immediately called the Pinellas County Sheriff's Department to report the incident, because at the time I thought it was a gunshot. They have a record under my phone number. I had no idea what the loud gun sound was, so I started to research and found the driver's seat belt tensioner charge must have gone off. I called Auto Nation Ford and made an emergency appointment to bring the vehicle in. I explained everything to them, then dropped the vehicle off. Upon doing a full inspection, the Auto Nation Ford mechanic determined there was a factory short in the air bag circuit, which caused the seatbelt tensioner charge to explode. They found the location, under the center console & replaced all necessary wiring, sensors, modules, tensioner & seatbelt. I researched and found recalls for 2020 Expeditions and 2018 F150 pickups, but there was no recall for the 2019 Expedition. I can't imagine what would have happened if we were going fast on an interstate when it happened. Now I get in my 2 Ford vehicles and worry about it happening again. t turned out the kick in the chest was the seatbelt retracting 4 inches pulling me back in the seat.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11535797August 1, 2023
ENGINE
The contact owns a 2019 Ford Expedition. The contact stated while starting the vehicle, there was an abnormal sound coming from the vehicle. The contact stated no warning light was illuminated. The contact took the vehicle to an independent mechanic, and the vehicle was diagnosed with needing the Variable Timing Control (VTC) actuator to be replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with TSB: 21-2119; however, the VIN was not included. A dealer was not contacted. The manufacturer had been notified of the failure. The failure mileage was approximately 77,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11533600July 21, 2023
ENGINE
The contact owns a 2019 Ford Expedition. The contact stated that while starting the vehicle, the vehicle made an abnormal sound. The contact related the failure to Customer Satisfaction Program 21N03: (Cam Phaser). The vehicle was taken to the dealer, who informed the contact that the cam timing unit needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 148,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11532871July 17, 2023
POWER TRAIN
Transmission randomly shifts out of gear while trying to accelerate creating an unsafe driving condition. This usually happens at Highway speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531501July 11, 2023
POWER TRAIN, VEHICLE SPEED CONTROL
I own a 2019 Ford Expedition Max (10R80 trans) & have experienced intermit. issues with the vehicle failing to shift into a higher gear when accelerating rapidly & getting stuck in a high RPM unless the accelerator is released. When releasing the accelerator there is a violent clunk & jerking. I have expressed this issue to Ford’s Service Department at the dealership. When intaking my vehicle the service advisor made a comment to another advisor that we have another Expedition with shifting issues. The advisor stated that this seemed to be a common issue with these vehicles, so I researched the issue online myself & found several threads with the same reported issue to include class action lawsuit websites for this issue. I paid Ford’s Service Department to diagnose the vehicle and they found no issues with the transmission and said it was okay and they weren’t able to replicate the issue (this is because it is an intermit. issue). The advisor stated that the transmission has an adaptive learn system and stated that the adaptive learn could be having issues, so I asked them to keep the vehicle and flash the adaptive learn or do a reset. I had them flash the system and it seemed to resolve the issue for a while, but it later returned. I then attempted contacting Ford Customer Service (Corporate) directly and explained the issue to them however they directed right back to the dealership. Recently I went to West Virginia for vacation and was traveling on the interstate. While traveling on the interstate at about 55 mph I was in a situation where I needed to rapidly accelerate due to an 18-wheeler changing lanes into my lane. The vehicle failed to accelerate/shift into a higher gear and being stuck in high RPMs. We were nearly KILLED in this incident and this is what prompted me to contact the NHTSA. I am also a law enforcement officer of over 15 years. It is my professional and personal opinion that this issue is an EXTREME DANGER to the occupants of these vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530863July 7, 2023
ENGINE
The contact owns a 2019 Ford Expedition. The contact stated that while starting the vehicle, the engine was shuddering. No warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The contact related the failure to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement); however, the VIN was not included. The failure mileage was 67,469.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530065July 3, 2023
SUSPENSION
Rear struts failed at approximately 36, 000 miles - the vehicle was unsafe driving down the interstate at speed due to the bouncing. Independent mechanic confirmed rear strut failure on driver and passenger side. Additionally, front driver side strut failed. In addition to bouncing, this made rear brakes wear out unusually quick. Steering became light due to the front strut. There was no warning lights to indicate an issue. Took to independent mechanic due to unavailability of maintenance appointments at Ford.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11528685June 24, 2023
ENGINE, POWER TRAIN
I own a 2019 Expedition XLT. I was traveling on the highway; I was in the right lane and was stuck behind a slow moving vehicle. I put on my blinker and waited for an opening in traffic, to move into the middle lane. Once there was an opening, I pressed the gas to accelerate into the lane. While the truck should have properly shifted and accelerated; instead the powertrain completely disengaged and I lost all power. The RPM's jumped all the way up. The truck was revving so high, but it was actually slowing down. I took my foot of the gas pedal and as the RPM came back down, the transmission slammed back into place with a horrible loud clunking sound that jolted the entire vehicle. After that, I was finally able to accelerate. This same situation has happened to me on several separate occasions. It is very scary having my 3 children in the vehicle and it losing power as I'm trying to make a move to be safe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527614June 18, 2023
SEAT BELTS:PRETENSIONER
When turning into a parking lot and putting the brakes on, the explosive charge in the seat belt went off with painful compression of the chest by the seat belt in the drivers seat. The air bag did not inflate. I was able to get the seat belt off my chest, but it was fixed by the mechanism and would not extend for use after that.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527339June 16, 2023
ENGINE
The contact owns a 2019 Ford Expedition. The contact stated that while his wife was driving at an undisclosed speed, the vehicle was shaking while idling with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the camshaft phaser needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed a credit $2,500 toward the cost of the repair. The contact related the failure to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement); however, the VIN was not included. The failure mileage was 61,941.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526417June 11, 2023
POWER TRAIN
This vehicle has been to the dealer multiple times to check hard-shifting and shuttering. Could not replicate at dealer. On 5/27/23 500 miles into a 2k mile road trip the vehicle hard shifted- felt like we hit something, then lost all acceleration. Would not accelerate. Narrowly missing being hit by several cars as I moved it from the fast lane into shoulder. Trying to accelerate the whole time. It finally reengaged with another jolt. This vehicle has 76,000 miles on it at the time. It went into a dealer on 5/30. They confirmed the transmission was slipping into neutral on its own. They have had it ever since and now say it will be 2-3 weeks before repaired. Meanwhile - I was stuck 500 miles away from home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524827June 1, 2023
ENGINE, ENGINE AND ENGINE COOLING, ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PUMP
The contact owns a 2019 Ford Expedition. The contact stated that the low oil pressure warning light was illuminated on the instrument panel. The vehicle was taken to the dealer where it was diagnosed with a defective oil pump. Additionally, the contact was also informed that the cam phasers were defective and needed to be replaced. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 77,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524908June 1, 2023
ENGINE
The contact owns a 2019 Ford Expedition. The contact stated that an abnormal rattling sound was coming from the engine. There was no warning light illuminated. The vehicle was taken to the dealer and the contact was informed that the cam phasers where defective and needed to be replaced. The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 58,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524701May 31, 2023
POWER TRAIN
In December 2022, my Expedition had a problem shifting while climbing hills. The transmission fluid was also overheating. We took it into the shop, but they didn’t find any issues. Over the past month, the transmission has been significantly hesitating and clunky. The local dealership have no transmission appointments until July 2023.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11523842May 25, 2023
ENGINE
The contact owns a 2019 Ford Expedition The contact stated while at a stop light, the vehicle started shaking and the contact heard a rattling sound coming from the vehicle. The check engine warning light illuminated. The vehicle was taken to the dealer and the contact was informed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted no assistance was provided. The contact was advised to contact the NHTSA Hotline. The failure mileage was 82,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11523458May 23, 2023
UNKNOWN OR OTHER
In the past year, the horn has gone off several times when car was locked and no one in it. Recently the horn stopped working with the key fob when locking the car and then this past week the horn has completely stopped working. This has been a faulty horn from the beginning and after doing a bit of research I see that others have had the same issue. This can become a safety issue as I realized it when someone cut in front of me and the horn did not work.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11522895May 19, 2023
ENGINE
The contact owns a 2019 Ford Expedition. The contact stated that upon cold starts, there was a loud rattling sound coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the engine cam phasers had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the vehicle was previously service under a Manufacturer Extended Warranty Coverage for the failure. The failure mileage was 77,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521666May 12, 2023
ENGINE
This vehicle with 72,000 miles on it was experiencing a rattle upon start on cold mornings for about two months, it didn't happen every time and only on initial start. Mechanic couldn't get the incident to happen in his presence to diagnose and no codes reported from computer diagnostic equipment. In February 2023, the vehicle lost power while highway driving and seemed to having problems shifting. The check engine and powertrain malfunction indicator both came on. Drove the vehicle immediately to mechanic. Booster sensor replacement was indicated by computer diagnostic and was replaced. On 4/16/2023 the check engine light came on briefly while driving and then went out and did not come back on. On 4/18/2023 while driving on the highway the vehicle started making a loud clanking with black smoke from exhaust pipe. We had the vehicle towed to mechanic. Over 30 diagnostic codes reported and mechanic recommended we take the vehicle to a Ford dealership. We had the vehicle towed to the local Ford dealership and have been informed that this 4 year old, 72,000 mile vehicle needs a complete engine replacement for $18,222. They do not know what caused the problem without pulling the whole engine and opening it up, but recommend a full replacement. We have contacted Ford and opened a case with them, but since the vehicle had a 60,000 mile power train warranty there is nothing that Ford is willing to do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521207May 9, 2023
POWER TRAIN, ENGINE
The contact owns a 2019 Ford Expedition. The contact stated while driving into the driveway and shifting into park, the shift indicator message stated that the vehicle was not in park; however, the contact was still able to turn off the vehicle. On another occasion, while driving 15 MPH and entering the highway, the vehicle lost motive power with the check engine warning light illuminated. The warning light disappeared, and the vehicle operated as intended. The vehicle was taken to the dealer and the contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the contact was informed that the vehicle was not under recall. The manufacturer did not provide any further assistance. The failure mileage was 92,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11520228May 3, 2023
ENGINE
There is an issue with the 3.5L GTDI engine cam phasers, identical to known recall FSA 21N03. This vehicle was not included in the mentioned recall as the manufacture location was other than those listed in recall FSA 21N03.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition