Ford Expedition Complaints (2020)

428 consumer complaints on file.

#11505382February 3, 2023
POWER TRAIN:AUTOMATIC TRANSMISSION
The transmission in the car is not functioning properly. Shifting is not happening correctly and there is slippage. The shift between gears is significantly impacting the car while in motion. The lurch between gears skips the car ahead. Further, Ford Dealers are so backlogged with transmission issues that they are refusing to diagnose and service vehicles due to lack of technicians and parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504952February 1, 2023
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
1) Automatic transmission; Yes 2) Transmission defect causes the vehicle to unexpectedly lose power, increasing the chance vehicles traveling behind could collide with the vehicle (powertrain occasionally does not initially respond to throttle input) 3) Yes 4) The vehicle has been inspected by a Ford dealership; unknown with regard to inspection by others (the vehicle has been serviced by a Ford dealership five times and the problem has not been corrected; early symptoms did not include unexpected loss of power; Ford refuses to replace the trans) 5) October 2021; initial symptom was harsh downshifts; symptoms as of 16 January 2023, are harsh downshifts, harsh reverse engagement when vehicle is cold, erratic upshifts (see above) and burning transmission fluid; an error message appeared while driving on 16 January (see attached)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503925January 27, 2023
POWER TRAIN, VEHICLE SPEED CONTROL
I own the 2020 Expedition. I pressed down on the gas pedal to accelerate into traffic. While the truck should have down shifted and accelerated, instead the powertrain completely disengaged; a total loss of power. The RPM jumped way up to redline, I took my foot of the gas pedal and as the RPM came back down, the transmission slammed back into engagement. At this point, I was finally able to accelerate. This issue has put us in danger as when I am on the road and try to accelerate to my vehicle does go into gear acts if it's in neutral. Also I have been at stop light and light turns green cars are honking as my car won't move. I have had this issue for quite some time, I called for they took it in for inspection the first time and found no issue, took it in again and they said it was the Cadillac converter, they replaced it, and they reprogramed the vehicles gears and now I am expirenceing the same issues, but worst. 2020 Ford Expedition
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503590January 25, 2023
STRUCTURE:BODY, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
Muffler and exhaust pipes have gotten rusted. I only have 37k miles on it. Is this a defect from manufacturer? I have many other cars but not rust over 100k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11501959January 16, 2023
POWER TRAIN
There seems to be an issue with the 10 speed gear shift in my 2020 Ford Expedition. We were driving on the interstate when we attempted to slow down to shift lanes, the gear shift very harshly and then would not respond to pressing the acceleration pedal. It made some very loud clunk noises and after a few minutes, it finally responded to the acceleration but it also was skipping gears and shifting really hard. Upon research, I found out that older models have an issue with the 10 speed shifter as well as others with my same make/model/year. Will bringing my vehicle in for inspection since this can be very dangerous in busy highways.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11499962January 3, 2023
AIR BAGS
I was traveling on the interstate when I was slowing down to get off an exit, got struck from behind at more than 80mph and rear ended a semi trailer that released the emergency brakes of his truck abruptly..my airbags did not deploy. suffered multiple lacerations through my body because of this double impact.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11497851December 17, 2022
POWER TRAIN, FORWARD COLLISION AVOIDANCE: WARNINGS, BACK OVER PREVENTION: WARNINGS
The transmission has now had over 5 shifting stall and power loss events while on the highway when attempting to downshift when accelerating. This loss of power causes a drastic reduction in speed and delay in actions. These events have nearly cause accidents at highway speeds. Additionally the radar sensor for the collision avoidance system went out and the car now shifts harshly in any gear with jerking and clanking. Multiple service lights are now illuminated. This first happened around 20k miles, but is has been increasing in frequency and now the car is not safe or driveable. This is the same transmission that is affecting other ford cars, like the ford 150 which has been subject to recalls. From publicly available information Ford thinks it’s a shifter and transmission disconnect but has not been able to implement a fox.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11496425December 7, 2022
UNKNOWN OR OTHER
Driving on freeway and slowed down due to traffic and trucks ahead. Got over into left lane, accelerated and vehicle stalled then jerked forward. Wrench light came on. Got off the freeway, turned vehicle off and waited 5 minutes. Another time was driving up the grapevine to LA, vehicle stalled and again quickly accelerated forward. I got off the freeway to allow the vehicle to rest. Third incident, driving on freeway, wrench light again appeared. When taking long road trips, I must stop every 2 hours in order for vehicle to not stall and to eliminate having transmission issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11485128September 18, 2022
UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
2020 - Expedition collision avoidance should be investigated. Background: 05-08-21 Traveling south at 6 pm near Oxford Michigan on M-24 (grassy-median 4-lane highway) at the posted 55 MPH limit in clear weather. Ford Co-Pilot360 & 360 Assist active with 360 deg camera. Speed control set to normal mode with “collision avoidance” set to max and auto braking. I am (1st car) in the right lane with a 2nd car following also in my lane. A 3rd car (waiting to enter the highway) stops ahead (on right- from west) at an intersection where left turns (north) are prohibited. That 3rd car safely turns right (south) in front of us quickly crossing both active southbound lanes and over into the short left turn-around lane north. That 3rd driver had cleared the two active lanes quickly and safely. As our vehicles approached him we had an open traffic lane on our left, a clear shoulder to the right and nothing in front of us, no safety issue yet. Issue: When I drive past that 3rd vehicle my Expedition dashboard shouts “collision warning”. My vehicle applies the brakes while my 360 degree cameras ignore that a car is closing fast behind me. I need to accelerate and do it now! I’m shocked to find that flooring my gas pedal or even pumping it has no effect. Ford has taken my throttle away from me, I can’t help that 2nd car behind me. The 2nd car brakes and swerves hard into the open lane barely missing me. It was just luck that the driver was responsive and the lane was open. No, I did not hit or touch the brake by mistake. The 2nd car now angry at me accelerates hard, passes and swerves back into my lane then hits his brakes! My Expedition “collision warning” doesn’t appear, so my “auto brakes” fail to activate and I’m forced to brake hard in response. After successfully avoiding another Ford induced accident, I backed-off a great distance to encourage a justifiably angry citizen to move away. I didn’t want a third attempt at my life if he pulled a weapon
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481613August 28, 2022
UNKNOWN OR OTHER
I was driving my Expedition and the sunroof exploded out of nowhere. I had the screen closed so no one was injured.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481411August 26, 2022
TRAILER HITCHES
Last year (2021), I purchased an Equalizer weight distribution hitch (manufactured by Progress Mfg Inc., Fastway Trailer Products, 353 South 1100 West, Provo, Utah 84601) when I bought my Grand Design Transcend Xplor camper trailer. The dealer sold me the 10,000 lb. hitch which was compatible with the 9,000 lb. GVWR trailer. Recently, (July, 2022) while pulling my camper into a campground site, the shank broke. It broke at the 90 degree joint and the gusset also fractured. Fortunately, I was only creeping into the campsite, so the trailer dropped to the ground, but no damage was done to the vehicle or camper. Upon examining the failure, it appear that one of the welds was defective. In the picture (Broken Trailer Shank - 5) it is clear that the weld on the left side had no weld fusion to the adjoining component. It appears that this was a "cold weld" and was a major contributor to the subsequent failure of the remaining welds and gusset. With the bad weld, the other welds were constantly over-stressed, and subsequently failed during normal use. From the discoloration of this "cold weld" it is evident that this condition existed for some time prior to the final fracture of the remaining welds (which are shinny - final failure) and probably existed since manufacturing. The defective weld also shows signs of "undercut". These are clear signs of poor manufacturing workmanship and should be considered to be a major safety concern. This type of failure should never occur and could have had major safety consequences if the failure occurred while travelling at high speed on the highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481062August 24, 2022
VISIBILITY:SUN/MOON ROOF ASSEMBLY
Panoramic moon roof exploded without warning. No debris or objects hit roof. Glass fell into vehicle from above. Ford denying any manufacturing wrong doing. Glass could have cut or injured children sitting in car seats below.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11480016August 18, 2022
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Driving on a 4-lane highway when a box truck directly ahead stopped quickly due to a stopped car ahead of it. The forward collision warning flashed and beeped, but when forcefully applying the brakes, the brake pedal only pulsed (like anti-lock brakes) but didn't slow the car even enough for the driver or passenger to feel any inertia moving forward in their seats or with their heads. The automatic emergency braking also didn't work, leading to a rear-end collision forceful enough to push the box truck into the car in front of it, apparently injuring the driver of the front car who was transferred by emergency personnel to a nearby hospital to seek medical evaluation/assistance. After impact, a message appeared on the dash stating "Pre-collision assist not available", but the forward collision warning worked, there was no prior warning of issues for the pre-collision assist, and the warning message was after impact, which significantly damaged the front portions of the vehicle (estimated damages exceed $24,000). There was a recall for the same model and year of this vehicle for pre-collision assist features/software not working properly, but it either didn't apply to this specific vehicle or was already addressed by the dealer, and the details aren't quite the same as what was experienced in this collision.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11478969August 12, 2022
POWER TRAIN, ENGINE, ELECTRICAL SYSTEM
The contact owns a 2020 Ford Expedition. The contact stated while driving at 10-20 MPH a week after purchasing the vehicle brand new, the vehicle started jerking. There was no warning light illuminated. The contact continued driving. However, the failure recurred while driving the entire day. The dealer was notified of the failure and informed the contact that the failure was normal as she had just started driving vehicle. The failure persisted. The vehicle was taken to the dealer twice where it was diagnosed that no issues were found. Additionally, the contact stated that there was steam coming through the AC vents. The contact also stated that the check engine warning light illuminated, indicating that the catalytic converter was damaged. The vehicle was taken to the dealer where it was diagnosed that the battery needed to be replaced. However, after the battery replacement, the vehicle shut off while driving and coming to a complete stop. The contact was able to restart the vehicle. However, the failure reoccurred while driving in the highway. The contact was able to restart the vehicle and veered to the side of the road. The vehicle was taken to the dealer where it was diagnosed that the vehicle was lacking unknown computer chips. Additionally, the dealer diagnosed that the transmission, the AC coil and the catalytic converter had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11478323August 9, 2022
POWER TRAIN
Automatic transmission making abrupt and lurching gear changes (even coming out of Park) in addition to mechanical sounds. Safety has not been an issue, so far. The situation has not been inspected by dealer or any other mechanic. Vehicle still under warranty with less than 8,000 miles. No warning messages have surfaced. Never involved in crash or flooding.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11478008August 7, 2022
POWER TRAIN
I own the above listed 2020 Expedition. We were traveling on Interstate 287 yesterday. I was in the right lane and was stuck behind a slow moving semi truck. I put on my blinker and waited for an opening in traffic to move into the middle lane. When an opening presented itself I pressed down on the gas pedal to accelerate into traffic. While the truck should have down shifted and accelerated, instead the powertrain completely disengaged; a total loss of power. The rpm jumped way up to redline, over revving, but the truck was slowing down. I took my foot of the gas pedal and as the rpm came back down the transmission slammed back into engagement with a loud audible clunk that jolted the whole vehicle. At this point I was finally able to accelerate. While this was all happening I had just moved into the middle lane of traffic, which was bearing down on us. All the vehicles behind us wear slamming their brakes and honking their horns. I thought for sure we were going to die. Thank God it wasn't an 80,000 lbs Peterbilt bearing down on us or we would be dead, by the grace of God we're not. Upon returning home I went onto the Ford truck owners website I belonged to. I came to learn this is a known issue with Ford's 10 speed transmission that Ford has failed to address. That there are pending lawsuits and that the NHTSA is aware of the issue. One of the member suggested that I file a complaint with the NHTSA, that was my impetus for writing you today. This is a dangerous condition that Ford needs to remedy. Thank you in advance for your time and attention in this matter
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11473465July 11, 2022
POWER TRAIN
When accellerating in 5th, or6th gear trans slips out hard and car wont accelerate for 1 to 2 seconds. It displays being in 1st while this happens before it goes back into precious gear and starts driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472947July 8, 2022
ELECTRICAL SYSTEM
The Car ELECTRIC 120V 150Watt connector is failing to hold into any plug into the socket thus falling or pulling halfway out and creating a dangerous situation to our children sitting on the back. In trying to plug back in one of our children got an electrical shock. On another instance the electrical plug came halfway out and made contact with some metal and an electrical arc was created and started a small fire with our children sitting on the back. The circuit braker did NOT pop or quit working so we had to dry stop in the middle of traffic to prevent fire from spreading. We took the car to a Ford dealership to be repaired and they dismiss us till I show them our other 2021 F350 same electrical plug exactly the same and how tight it holds the electrical plug! Not till then the Service advisor told us "Yes it needs to be change" we have been waiting for this to happen over 6 months now without resolution.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11471613June 29, 2022
UNKNOWN OR OTHER, STRUCTURE:BODY
While driving down the highway I heard a pop in my vehicle and realized my sunroof had burst. Glass separated and flew into my car and cut myself and my 4 small children. No warning lights were on in my vehicle at this time. When brought to the dealership for repair, the repair shop reported that this will happen with these vehicles and to pursue reimbursement with Ford. Unfortunately, Ford reports that vehicle is not under warranty and the repairs won’t be covered.
Crash:
No
Fire:
No
Injuries:
5
Deaths:
0
#11471317June 28, 2022
POWER TRAIN
The contact owns a 2020 Ford Expedition. The contact stated while driving at various speeds, the vehicle started to decelerate independently. The contact stated the error system failure warning light was illuminated. The contact also started to hear an abnormal noise. The contact stated after a few seconds the failure independently stopped and he was able to continue driving to his destination. The contact took the vehicle to the local dealer, where it was diagnosed with needing an unknown TBS to be completed. The vehicle was serviced for the bulletin but continued to experience the failure. The contact took the vehicle back to the dealer however, the mechanic was unable to duplicate the failure. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition