Ford Expedition Complaints (2019)

526 consumer complaints on file.

#11602278July 15, 2024
AIR BAGS, SEAT BELTS
The contact owns a 2019 Ford Expedition. The contact stated while driving 30 MPH, the passenger’s side front seat belt exploded. There was an abnormal banging noise heard and there was smoke inside the vehicle. While occupying the passenger's side front seat, the seat belt pulled hard, and the passenger was slammed against the seat. The driver was able to pull over safely. The air bag warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V099000 (Seat Belts) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 60,000. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601464July 12, 2024
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING
The contact owns a 2019 Ford Expedition. The contact stated that there was a rattling sound coming from the vehicle while attempting to start the vehicle causing a delay while starting. The vehicle had been taken to a certified mechanic where it was diagnosed that the timing chain and cam phasers had failed and needed to be replaced. The mechanic informed the contact that the failure was related to a TSB: 21B10-S3/NHTSA ID Number: 10201643 (Electrical System). The dealer was contacted and confirmed that the VIN was not included in a recall. The vehicle had not been repaired. The manufacturer was made aware of the failure and informed the contact that the VIN was not included in TSB: 21B10-S3/NHTSA ID Number: 10201643 (Electrical System). The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600996July 10, 2024
ENGINE
Loud knocking from engine. No check engine light came on. Dealer found the cam phasers faulty and could possibly lead to engine failure if not repaired which would put occupants in danger. Banner Ford in Monroe Louisiana performed repair at owners expense.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600222July 8, 2024
ENGINE
Ford issued a recall on the cam phasers for some vehicles this year make and model. Ours was never recalled but obviously faulty as we are having to replace the motor at 80000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11599324July 5, 2024
POWER TRAIN
The contact owns a 2019 Ford Expedition. The contact stated while driving approximately 35 MPH, the transmission failed to shift gear as designed and the vehicle stalled while the accelerator pedal was depressed. The vehicle was taken to a local independent mechanic where it was diagnosed that the transmission needed to be repaired. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The vehicle was not repaired due to the warranty being expired. The manufacturer was made aware of the failure. The failure mileage was approximately 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598252July 2, 2024
ENGINE
The contact owns a 2019 Ford Expedition. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle jerked and the RPM increased quickly, after which the vehicle briefly lost motive power. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598300July 2, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2019 Ford Expedition. The contact stated when the vehicle was started, there was an abnormally loud rattling sound coming from the engine. The contact stated that while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed as a failure with the cam phaser. The contact was informed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 111,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598353July 2, 2024
SUSPENSION, POWER TRAIN, ENGINE
Transmission and shifting problems under 70,000 miles. Also the ac compressor and blower has gone out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598045July 1, 2024
POWER TRAIN
The transmission shifts erratically due to similar issues seen 2014 F-150's that have been recalled. We have seen the transmission jump from 10th to 1st gear and have had the transmission lock out randomly. This issue has caused near miss incidents on the highway and interstate several times. The vehicle is currently parked due to this issue as we try to work with Ford to replace the transmission. Safety was put at risk due to erratic shifting of the transmission. We took the car to the dealer and they named the issue as the CDF clutch pack.the component has not yet been inspected directly as the problem is a known problem for Ford. Yes there were warning lamps when the transmission locked out and would not allow the vehicle to move under it's own power till the power was cycled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597597June 28, 2024
POWER TRAIN
Transmissions are failing. They have a faulty CDF drum. In the 10R80 transmissions. Ford knows it. And they aren't recalling it. Transmissions are failing at low mileage. Some are out of warranty for the age. People are having to pay for 2 and 3 Transmissions. Pay for outrageous extended warranties just to be covered. They are jumping gears and completely dying on highways. I belong to an expedition group. And every day someone is almost in an accident. Or are replacing a transmission. I've had problems since I got mine. Hard shifting. Delayed shifting. 3 times in two weeks I tried passing on a highways. I hit the gas to pass. And it made a loud bang and lost all power to transmission. Was like it's in neutral. I had to try getting to the side of the high way through traffic before it stopped moving. Had to put back in park. Shut car off and restart. I had kids in the car both times. Thousands of people are having this problem. I was going up a hill and almost was rear ended. If my kids had been hurt. Ford would have been sued. They know it's a problem. Same transmission in the expedition. F150s. They just keep making money off people fixing them and the Ford warranty. Many people they completely failed on highways. Someone is going to get hurt because they refuse to acknowledge its a safety issue and just do a repair that needs done again in a year or two. This has been going on for years and still no recall. Something needs to be done already.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596144June 24, 2024
POWER TRAIN
The transmission seems to slip, shudder and sometimes lag or jerk ahead unexpectedly. At times when waiting to cross traffic, the lagging makes it so I almost stall for a second or two and fear getting hit by oncoming traffic. Each time I have asked the dealership to determine the cause, I am told they have to do a software update and reset the adaptive drive to the factory reset. I have had this serviced three times and the problem continues to reoccur a couple months after the reset and software update. Then I get to take it back and pay for the same service all over again. The incorrect timing of the transmission may now have led to a faulty catalytic converter which is now having to be replaced at only 88k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595851June 22, 2024
AIR BAGS, SEAT BELTS
In or around October I reported my Seatbelt tensioner/retractor explosive device deployed almost causing me to have an accident. After really complaining to Ford, they finally fixed it. Now my warning light came on pertaining to my passenger side tensioner. I also received the notice, and went to my dealership. They had the vehicle for a week and could not fix it. They said Ford has to ok it and supply the parts, and it could take all the way to the end of 2024. They gave me the vehicle back, refused a loaner and said their hands were tied. I can tell you first hand that someone may die or cause a serious accident if driving at high speed when the device deploys. It is as loud as a 45 cal or shotgun, inside the cab. The SPL is enormous and the seatbelt tightens 3 to 4 inches, causing disorientation, total fear and loss of control of the vehicle. My incident caused me to have irregular heartbeat and I ended up in the hospital. THEY NEED TO REPLACE THESE DEVICES ASAP, BEFOE SOMEONE DIES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595941June 22, 2024
SEAT BELTS
The contact owns a 2019 Ford Expedition. The contact had not received notification of the recall. The vehicle was taken to the dealer, however, parts for the recall repair were not yet available. The dealer is unable to fix the recall at the moment and they did not have any appointments available in a timely manner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11594448June 14, 2024
POWER TRAIN
Vehicle transmission jerky with hard shifts, has missed gears resulting in vehicle in neutral while in traffic at speed. Could be a major hazard at intersections. Issue appears to be common enough for Ford to issue TSB but only repair available is transmission rebuild or replacement. Local dealer service adviser states issue is happening once a week with vehicles in their shop. This is a known issue with the CDF drum within the transmission that is putting people at risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11594475June 14, 2024
AIR BAGS, SEAT BELTS
The contact owns a 2019 Ford Expedition. The contact stated that while driving at an undisclosed speed, the driver's side air bag inadvertently deployed. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed failures with both the seat belt and driver's side air bags. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V099000 (Seat Belts). The VIN was included, but parts were not yet available. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593690June 11, 2024
STRUCTURE:BODY, UNKNOWN OR OTHER
I am writing to urgently request the initiation of a safety investigation concerning a serious and potentially widespread defect in Ford vehicles, specifically related to the center console’s metal chrome trim on limited models. I own a Ford Expedition, purchased in October 2019, and have encountered a severe issue where the chrome plating on the center console has begun peeling away, forming sharp, dangerous shards that have already caused significant injury to myself and my children. Despite numerous attempts to resolve this issue through Ford’s customer service since first discovering the defect in 2020, the response has been dismissive, labeling the condition as "normal wear and tear." This is despite the fact that the sharp edges of the peeling chrome required medical attention on multiple occasions. The severity of this defect goes far beyond cosmetic degradation and enters the realm of serious safety hazard. Furthermore, this issue does not appear to be isolated. An examination of online consumer forums and resale platforms such as eBay reveals similar complaints from other Ford owners who note identical peeling issues in the same model and in analogous locations on the console. Historical precedence shows that similar defects in past models, like the Ford Explorer, have led to recalls. It is alarming that Ford has not only failed to recognize the defect as a legitimate safety concern but has also continued to sidestep responsibility even after the original factory warranty expired. This lack of accountability for a defect that directly impacts the physical safety of passengers and drivers is unacceptable. Given the potential risk to consumers and the apparent recurrence of this issue across multiple vehicles, I implore the NHTSA to initiate a thorough investigation into this matter. It is imperative that a recall be considered to prevent further injuries and ensure that Ford addresses this serious safety flaw promptly and effectively.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593402June 10, 2024
POWER TRAIN
The contact owns a 2019 Ford Expedition. The contact stated that while driving at various speeds, the transmission malfunctioned, and the vehicle hesitated while accelerating and changing gear. The vehicle was taken to the local mechanic who diagnosed the vehicle and determined that the transmission had overheated. The contact was made aware of an unstated TSB for the failure. The vehicle was later taken to the local dealer who determined that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593434June 10, 2024
SEAT BELTS
I was sitting in the passenger seat unbuckling the seatbelt. A loud noise went off behind me right almost like a gun shot. The seat shot from my hand and tore the leather in the car near the wind. The seatbelt also started smoking and left a smoke residue on the car. The seatbelt in locked in position and cannot be used any more. My right thumb was hit and at this time is in excruciating pain. I cannot make a fist. I’m headed to the doctor for more specifics.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11593499June 10, 2024
SEAT BELTS
The contact owns a 2019 Ford Expedition. The contact stated that while driving at an undisclosed speed, the front driver's seat belt retractor pretensioner was inadvertently deployed. The contact's shoulder was sore from the seat belt deployment but received no medical treatment. The contact pulled over and called her father, who researched and discovered that the VIN was associated with NHTSA Campaign Number: 24V099000 (Seat Belts). The contact had not received notification of the recall. The vehicle was taken to the dealer, where it was determined that the front driver's seat belt retractor needed to be replaced; however, parts for the recall repair were not yet available. The contact was informed that she could pay for the repair and keep the receipt for reimbursement from the manufacturer. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 95,801.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592538June 5, 2024
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
My expedition since I bought it completely turns off on me on roads and highways and throws up a wrench symbol and check engine light. Everytime I bring it in to the dealer they keep clearing codes and never fixing anything even tho I have extended warranty. They have had my car for 5-6 months maybe longer but the last time they had it for over a month said everything is fine for our roadtrip. Well the car turned off on me and died in the middle of the Utah Highway... had to be towed. was told it has 70 plus alerts
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition