Ford Expedition Complaints (2000)

890 consumer complaints on file.

#10223789April 9, 2008
ELECTRICAL SYSTEM
HEAVY RAINS YESTERDAY. ON THE WAY HOME FROM WORK, STOPPED AT A STORE, TURNED OFF THE KEY, BUT THE HEATER BLOWER DID NOT TURN OFF. TURNED THE HEATER CONTROL TO OFF AND HEARD MANY RAPID CLICKS FROM UNDER THE DASHBOARD TO THE RIGHT OF THE STEERING WHEEL. ON ARRIVING HOME, BLOWER DID THE SAME THING. VEHICLE PARKED IN GARAGE OVERNIGHT. NEXT MORNING, SEVERAL SERIES OF FIVE BEEPS CAME FROM UNDER THE DASH. HEATER BLOWER STILL STAYS ON WHEN KEY IS OUT. WE HAD WATER LEAKING AROUND THE WINDSHIELD A COUPLE YEARS AGO THAT CAUSED THE ODOMETER TO GO OUT. HAD THE WINDSHIELD RE-SEALED. ODOMETER INTERMITTENTLY COMES BACK ON SINCE THEN. IT WOULD APPEAR THE LEAK IS HAPPENING AGAIN, AND WATER IS GETTING DOWN INTO THE GEM MODULE AND FUSEBOX. HAVE NOT ATTEMPTED TO REPLACE THESE YET. I'M AFRAID THIS ELECTRICAL PROBLEM WILL CAUSE A FIRE IN THE EXPEDITION, WHICH IN MY ATTACHED GARAGE COULD LIKELY BURN DOWN THE ENTIRE HOUSE AND THREATEN MY FAMILY'S SAFETY. WWW.FORD-FORUMS.COM, TOWNHALL-TALK.EDMUNDS.COM, AND WWW.AUTOMOTIVEFORUMS.COM ALL HAVE MANY POSTS OF SIMILAR WATER-LEAKING-CAUSING-ELECTRICAL-PROBLEMS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10222488March 27, 2008
VEHICLE SPEED CONTROL
TL*- THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CRUISE CONTROL FAILED, AND THE VEHICLE WAS TAKEN THE VEHICLE TO THE DEALER. THE DEALER DIAGNOSED THE FAILURE AS A PROBLEM WITH THE VEHICLE SPEED CONTROL SWITCH. THERE IS A SAFETY RECALL 05V388000 - VEHICLE SPEED CONTROL. THE CONTACT WAS TOLD THAT THE REPAIR HAD ALREADY BEEN MADE TO THE VEHICLE FOR THE PREVIOUS OWNER. THE CURRENT MILEAGE WAS 110,000, AND THE FAILURE MILEAGE WAS 110,000. UPDATED 5/5/08 *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10222319March 25, 2008
STRUCTURE, ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS, ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
RAIN/SNOW CAUSE WATER TO LEAK INTO THE GEM MODULE & FUSE BOX UNDER DRIVER'S SIDE DASHBOARD CAUSING COMPLETE ELECTRICAL FAILURE, WACKY ELECTRICAL THINGS LIKE FAN MOTOR RUNNING WITHOUT KEY IN IGNITION, STRANGE "STUPID LIGHTS" PERIODICALLY ON DASH, ETC. HAVE REPLACED THESE TWICE, VERY EXPENSIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10221869March 20, 2008
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. AFTER BEING PARKED IN THE DRIVEWAY FOR TWO AND A HALF HOURS, THE VEHICLE CAUGHT FIRE IN THE FRONT PASSENGER SIDE WHEEL WELL. SMOKE AND FLAMES BEGAN POURING FROM UNDER THE HOOD. THE CONTACT'S HOME THEN CAUGHT FIRE AND WAS DAMAGED EXTENSIVELY. THE FIRE MARSHALL BELIEVES THAT THE FIRE WAS DIRECTLY RELATED TO NHTSA CAMPAIGN ID NUMBER 05V017000 (VEHICLE SPEED CONTROL:CRUISE CONTROL). THE VEHICLE WAS DESTROYED. A FIRE REPORT WAS FILED AND INVESTIGATIVE NOTES ARE AVAILABLE. THE CONTACT HAS PICTURES. THE PURCHASE DATE AND MILEAGES WERE UNKNOWN. UPDATED 4/22/08 *CN
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10220381March 7, 2008
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE VEHICLE CAUGHT FIRE UNDER THE HOOD. THE FIRE DEPARTMENT SHATTERED A WINDOW IN ORDER TO EXTINGUISH THE FIRE. A FIRE INSPECTOR WAS SENT OUT AND STATED THAT THE FIRE WAS A RESULT OF A RECALL. A POLICE REPORT WAS FILED. THE CONTACT CONSULTED FORD AND SENT ALL THE INFORMATION THEY REQUESTED; HOWEVER, THEY HAVE YET TO CALL HIM BACK. THEY ADVISED HIM TO CALL THEIR LEGAL DEPARTMENT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL). THE PURCHASE DATE AND POWERTRAIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 181,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10220089March 4, 2008
ENGINE AND ENGINE COOLING:ENGINE, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
PURCHASED TRUCK ON 02/15/2008, AND THE BRAKES WENT ON THE TRUCK ON 02/21/2008, WHICH ALMOST CAUSE ME TO GO HEADON WITH A SEMI-TRUCK. TOLD DEALER ABOUT BRAKES GOING OUT BUT DIDN'T CARE ABOUT IT. TOLD HIM ABOUT ME TAKING THE TRUCK TO THE TRANSMISSION SHOP AND THE INDICATED THAT IT WAS THE MOTOR THAT HAVE THE 5 CYLINDER MISSING IN THE ENGINE AND THE ENGINE HAD A LOT OF DEFECTS WITH THE ENGINE. TOOK THE REPORTS TO THE DEALER AND HE SAID HE WOULD TAKE CARE OF IT BUT HE INDICATED TO ME THAT HE WOULD NOT FIX THE PROBLEM WITH THE TRUCK. HE TOLD ME TO FIX IT MYSELF AND PAY HIM THE CAR NOTE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10219268February 27, 2008
ELECTRICAL SYSTEM
I POSTED A COMPLAINT EARLIER AND WOULD LIKE TO FOLLOW UP ON IT. I HAD SEVERAL ELECTRICAL PROBLEMS AFTER THE RAIN. THIS LAST TIME CAUSED MY BATTERY TO COMPLETELY DIE AND ALL OF MY ELECTRICAL STOPPED WORKING. I HAD AAA COME OUT AND JUMP START THE BATTERY AND I LET IT IDLE FOR ABOUT 45 MIN. UNTIL THE ELECTRICAL SHOP OPENED. DURING THE IDLING I HEARD A LOUD NOISE THAT SOUNDED VERY STRANGE AND UNFAMILIAR SO I JUMPED IN AND WHEN I PUT IT IN GEAR TO LEAVE THE NOISE STOPPED AND I CONTINUED TO THE ELECTRICAL SHOP. AS SOON AS I PARKED AND PUT IT IN PARK THE NOISE BEGAN AGAIN. THE GUYS AT THE SHOP HEARD IT AND IMMEDIATELY RECOGNIZED IT AS THE STARTER ENGAGING. THIS WAS A RESULT OF MY ELECTRIC SYSTEM MALFUNCTIONING. AFTER A WHOLE DAY OF DIAGNOSING WHERE THE ELECTRICAL PROBLEM CAME FROM, THEY FOUND THAT THE MAIN FUSE BOX LOCATED INSIDE THE VEHICLE BELOW THE DRIVERS SIDE HAD A LOT OF MOISTURE, RUST AND CORROSION ON THE BACK SIDE. THEY WERE NOT ABLE TO LOCATE WHERE THE WATER IS LEAKING FROM BECAUSE IT STOPPED RAINING. I AM FAMILIAR WITH THE WINDSHIELD SEAL AND THE DRAIN HOLE OF THE WIPER BLADE AS BEING THE SUSPECTED ORIGIN OF THE LEAK, SO AS SOON AS IT RAINS AGAIN I WILL GO BACK TO THE SHOP SO THEY CAN TRY AND FIND THE LEAK. THEY ORDERED A NEW FUSE BOX FROM THE DEALERSHIP AND IT WAS AROUND $145 BUT WILL TAKE 4 DAYS TO SHIP, SO THEY CLEANED THE BACK OF THE FUSE BOX TO HOLD ME OVER. IT RUNS FINE AND SEEMS TO BE BACK TO NORMAL. SO I WOULD CHECK THAT FUSE BOX IF YOU'RE HAVING TROUBLE. THE HIGH POWER FUSE BOX IN THE ENGINE COMPARTMENT WAS NOT DAMAGED. I'LL UPDATE AGAIN IF I FIND OUT WHERE THE LEAK IS COMING FROM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10219013February 24, 2008
ELECTRICAL SYSTEM, EQUIPMENT:ELECTRICAL
I'VE HAD SEVERAL PROBLEMS WITH THE ELECTRICAL SYSTEM OF MY 2000 FORD EXPEDITION AFTER IT RAINS. TODAY MY ALARM WOULD NOT WORK SO I HAD TO USE THE KEYLESS PAD TO UNLOCK MY VEHICLE, BUT IT DOES NOT WORK TO LOCK THE VEHICLE. WHEN I OPEN THE DOOR THERE ARE DINGING NOISES AND YOU CAN HEAR THE FAN RUNNING IN THE MOTOR. THE SUV WILL NOT START, IT TRIES TO TURN OVER BUT ENDS UP FAILING AND ENDING WITH CLICKING NOISE. THE AIR BAG LIGHT WILL STAY LIT AND GIVE ME WARNING CHIMES. THIS HAS HAPPENED SEVERAL TIMES AND I HAVE MANAGED TO START IT ONCE IT DRIES UP . I'VE READ MANY COMPLAINTS ON THIS ISSUE AND IT IS TIME THAT FORD DOES A RECALL........WE CAN NOT ALL BE LYING!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10217544February 9, 2008
ELECTRICAL SYSTEM
I OWN A 2000 FORD EXPEDITION AND AFTER A HARD OVERNIGHT RAIN AN ELECTRICAL PROBLEM BEGAN. WHEN I GOT INTO IT THE NEXT MORNING THE RADIO WAS PLAYING AND THE HEATER DISPLAY WAS ON. WHEN I STARTED IT ALL SEEMED NORMAL UNTIL I PUT IT INTO GEAR AND THE RADIO STOPPED, THE HEATER STOPPED, THE WINDSHIELD WIPERS WOULDN'T WORK, AND THE WINDOWS WOULDN'T LOWER AND WHEN PUT BACK INTO NEUTRAL OR PARK EVERYTHING WENT BACK TO NORMAL. I BROUGHT IT INTO THE FORD DEALER WHO DOES ALL MY REPAIRS AND HE TOLD ME IT WAS THE GEM MODULE AND IT WOULD COST $1000.00 FOR REPAIR. I HAVE NO CHOICE SO I AUTHORIZED THE REPAIR. HE THEN INFORMED ME THAT WHEN I PICK IT UP I NEED TO TAKE IT TO A WINDSHIELD REPAIR SHOP TO GET THE WINDSHIELD RESEALED DUE TO A DEFECTIVE SEAL THAT CAUSED A LEAK THAT CAUSED THE GEM MODULE TO MALFUNCTION. IT SEEMS THAT THIS IS A LARGE BURDEN TO PUT ON THE CONSUMER SINCE IT IS A KNOWN DEFECT AND THERE IS NO ASSURANCE THAT IT WON'T HAPPEN AGAIN. I ALSO BELIEVE THIS COULD BE DANGEROUS CAUSING THE VEHICLE TO STALL WHILE DRIVING OR WIPERS TO MALFUNCTION IN THE RAIN OR ANY NUMBER OF OTHER PROBLEMS SINCE THIS MODULE CONTROLS SO MANY OF THE VEHICLES CONTROLS AND INSTRUMENTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10214910January 15, 2008
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. UPON STARTING THE VEHICLE, THE CONTACT HEARD A LOUD POPPING SOUND COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT A SPARK PLUG BLEW OUT. THE DEALER INSTALLED NEW SPARK PLUGS AND A NEW COIL. WHILE DRIVING 25 MPH, THE FAILURE RECURRED AND THE VEHICLE WAS TOWED BACK TO THE DEALER. THE VEHICLE WAS REPAIRED AGAIN. THE FAILURE MILEAGE WAS 170,000 AND CURRENT MILEAGE WAS 171,000. UPDATED 02/19/08 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10214514January 11, 2008
VISIBILITY:WINDSHIELD, ELECTRICAL SYSTEM:WIRING
WINDSHIELD LEAKS WATER ON TO GEM MODULE AND FUSE BOX. AFTER RAIN OR SNOW VEHICLE WILL TRY TO START WHILE ALREADY RUNNING WIPERS, RADIO, DOOR LOCKS, POWER WINDOWS, LIGHTS FLASHERS WILL NOT WORK. DUMMY LIGHTS ON DASH WILL COME ON THAT WATER LEVEL LOW, NO OIL PRESSURE AND LOW BATTERY. NOW IT WILL NOT SHIFT OUT OF PARK. FILED A FORMAL COMPLAINT THREE MONTHS AGO WITH FORD MOTOR COMPNY AND THEY HAVE YET TO ACKNOWLEDGE THAT I EVER FILED REPORT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10214339January 9, 2008
ELECTRICAL SYSTEM
MY 00 FORD EXPY HAS SEVERAL ELECTRICAL PROBLEMS WHEN EVER THERE'S RAIN THIS LATEST INCIDENT HAPPEN ON 1/6/08 I CAME OUT OF MY HOUSE BECAUSE I KEEP ON HEARING LIKE SOMEONE WAS TRYING TO START THE TRUCK AND YEAH IT HAD BEEN RAINING ALL NIGHT I OPEN THE TRUCK AND THE RADIO WAS ON THE LIGHTS WERE COMING ON I STARTED THE TRUCK AND WHEN IT WAS ON THE STARTER WAS STILL SPINNING HITTING THE FLY WHEEL I HAD TO DISCONNECT THE BATTERY I THINK IF THERE'S WATER LEAKING EVERYTIME IT RAINS IT COULD CREATE A SHORT AND CAUSE A FIRE ON THE TRUCK I WILL LIKE SOMEONE TO LOOK INTO THIS THANKS *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10213329December 31, 2007
ENGINE AND ENGINE COOLING
2000 FORD EXPEDITION SPARK PLUG EJECTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10212908December 27, 2007
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT HE HEARD KNOCKING SOUND COMING FROM THE ENGINE AND THE ENGINE SKIPPED. THE DEALER STATED THAT ONE OF THE COIL PACKS CAUSED THE FAILURE AND THEY MADE THE REPLACEMENT. APPROXIMATELY ELEVEN MONTHS LATER THE FAILURE OCCURRED AGAIN. THE DEALER STATED THAT THE NUMBER THREE AND SIX COIL PACKS NEED TO BE REPLACED. IN ADDITION, THEY NOTICED GUNK ON THE SPARK PLUGS. AS OF DECEMBER 27, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CURRENT MILEAGE WAS 143,000 AND FAILURE MILEAGE WAS 120,000. THE PURCHASE DATE WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10212468December 20, 2007
ENGINE AND ENGINE COOLING
SPARK PLUG # 2 WAS SPIT OUT OF THE ENGINE DUE TO POOR DESIGN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10211323December 10, 2007
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. OCCASIONALLY IN COLD, SNOWY, OR RAINY CONDITIONS, THE VEHICLE WOULD EXPERIENCE ELECTRICAL FAILURE. THE WINDSHIELD WIPERS WOULD NOT WORK, THE RADIO WOULD TURN ON AND OFF RANDOMLY, AND THE HEADLIGHTS FLASHED ON AND OFF. THE CONTACT NEEDED TO DISCONNECT THE BATTERY IN ORDER TO SHUT OFF THE HEADLIGHTS. THE DEALER COULD NOT DUPLICATE THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000 AND CURRENT MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10211236December 8, 2007
ENGINE AND ENGINE COOLING
2000 FORD EXPEDITION V8 4.6L XLT STALLS WHEN GAS IS AT 1/4 TANK AND AT A FORWARD ANGLE (DOWNHILL). THIS HAPPENS WHEN GOING 55 ON THE FREEWAY, COME TO A SLIGHT DECLINE AND VEHICLE STALLS AND DIES. COULD CAUSE AN ACCIDENT. I CAN NOT SELL THIS CAR AND GET A NEW FORD, KNOWING SOME COULD GET HURT. WE DON'T LET OUR KIDS DRIVE IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10208508November 9, 2007
TIRES:TREAD/BELT
WHILE TRAVELING SOUTH ON I-95 AT APPROX 65 MPH, THE PASSENGER RIGHT REAR TIRE FAILED. IT APPEARS THAT THE FAILURE MODE WAS TREAD SEPARATION/DETACHMENT. THE TREAD ENDED UP WRAPPED AROUND THE REAR AXLE. AT THE MOMENT OF THE FAILURE THE 2000 FORD EXPEDITION TORQUED HARD TO THE RIGHT, BUT CONTROL WAS MAINTAINED. FURTHER INFORMATION ON THIS INCIDENT IS THAT THE FAILED TIRE WAS A REPLACEMENT FOR A RECALL (NHTSA CAMPAIGN ID NUMBER: 02T012000) BY CONTINENTAL TIRE CO. AND REPLACED BY A FORD DEALERSHIP. THE FAILURE OF THE REPLACEMENT TIRE FITS THE EXACT DESCRIPTION AS STATED IN THE NHTSA INVESTIGATION REPORT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10208103November 6, 2007
VEHICLE SPEED CONTROL:CRUISE CONTROL
OUR 2000 FORD EXPEDITION CAUGHT ON FIRE AFTER SITTING IN OUR DRIVEWAY FOR APPROXIMATELY 11 HRS. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10207828November 3, 2007
VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH, EQUIPMENT:ELECTRICAL
PRIOR TO OUR 2000 FORD EXPEDITION BEING RECALLED FOR THE CRUISE CONTROL PROBLEMS, WE EXPERIENCED ELECTRICAL PROBLEMS WITH THE INTERIOR LIGHTING GROUP; RADIO, WINDSHIELD WIPERS, ETC. AFTER A RAIN, THE WINDSHIELD WIPERS WOULD NOT WORK AND THE BLOWER MOTOR WOULD REMAIN ON OR BE ON WITHOUT IGNITION ACTIVATION. THE BATTERY HAS RUN DOWN BECAUSE OF THIS! WE RECENTLY EXPERIENCED THE PROBLEMS AGAIN AND TOOK THE VEHICLE TO OUR MECHANIC WHO RECOMMENDED AN ELECTRICAL SPECIALIST. HE DIAGNOSED THE WINDSHIELD SEAL LEAK AS A CONTRIBUTING FACTOR TO THE JUNCTION BOX-GEM MODULE MALFUNCTIONING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition