Ford C-Max Complaints

510 consumer complaints on file.

#11674198July 17, 2025
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING, BACK OVER PREVENTION: WARNINGS
There has been no accident yet but this is a safety hazard. My vehicle is under 100,000 miles and the part should be replaced by the dealership. The rear cross traffic assistance sensor may be damaged. It just stopped working this week.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672747July 11, 2025
UNKNOWN OR OTHER
Backup camera nonfunctional. Will occasionally work or be upside down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670543July 1, 2025
ELECTRICAL SYSTEM, ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The contact owns a 2016 Ford C-Max Energi. The contact stated that while charging the hybrid battery, the battery stopped charging after 15-16 minutes. The contact stated that the battery could only be charged for 15-16 minutes at a time. The contact stated that there was a red triangle warning light illuminated on the charger but there was no warning light illuminated on the vehicle. Additionally, the contact stated that the mileage range of the vehicle per charge was decreasing continuously. The vehicle was taken to dealer several times to be diagnosed; however, the cause of the failure could not be determined. The vehicle was taken to another dealer, Gator Ford (11780 Tampa Gateway Blvd, Seffner, FL 33584), where it was diagnosed that the hybrid battery had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663221May 27, 2025
EXTERIOR LIGHTING
When I went to the garage, I noticed my brake lights were on, but the ignition was not. I tested the car, it started without me stepping on the brake. I could also move the car out of park without stepping on the brakes. I thought the switch on the brake pedal had failed and so I took it to my mechanic for replacement. The mechanic tested the switch and found it okay. However, he had seen the same problem in other Fords (Recall # 22V-011 or 22S02) and it involved the Pedal Stop Bumper deteriorating. The recall indicated it would replace only the Pedal Stop Bumper. My mechanic said that replacement part wasn't available to them. So, I took it to the dealer hoping that since I had the same problem, I was included in the recall. My C-Max was not listed. They said that that the Pedal Stop Bumper replacement part wasn't available for my car, and that they would have to replace the entire brake pedal system for an outrageous $1400. I had little choice, and so I agreed with the hope that Ford would provide some relief. They didn't. Instead, they said hang onto the receipts and maybe someday there will be a recall, and I'll be reimbursed. So now I'm writing you. Clearly, this was considered to be a safety hazard in the other Ford products, and I believe it to be exactly the same in mine: brake lights always on are a safety hazard as well as being able to shift the car out of park or start the car without depressing the brake. Moreover, the battery will run down unless I disconnect it at night. Basically, my car is unsafe to drive without this repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662849May 23, 2025
STEERING
While driving car, power steering will fail and deactivate leaving the steering extremely heavy and manual. Can happen at any speed, and has happened on the interstate at highway speeds. Information cluster states, "power steering fault - service power steering immediately" When this happens it is highly unsafe and happens instantly without warning. Makes getting the car off the road and stopped safely very difficult and dangerous. Stopping the car, turning it off fully and restarting seems to clear the fault and makes the car power steering operate as normal again. But this has happened many times since owning the car and I can find no reason when or why it gets triggered. Online searches find many other owners of this car describing the exact same issue and they share the same concerns about it being unsafe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654741April 15, 2025
STEERING
The issues that I am having is with the power staring at this. On my way back from dropping off my child I entered the apartment complex and drove over a speed bump and that’s when the fault light came on about the power steering. I noticed that when the light came on my steering wheel started to stiffen however, it’s when I got home and took my car off that the steering wheel became stuck and needed more power to turn the wheel. This is the first time I’m ever seeing this issue, but my ABS tire light is the only light that has remained on since purchasing the vehicle a few months ago. I have already contacted Ford to see about what they could do, and I was instructed that this particular vehicle did not have a recall while others do which highly concerns me. Upon further research, I found out that this is a common occurrence since 2014 with these models.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648591March 16, 2025
VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
WHILE DRIVING the dashboard instrument panel beeps and flashes the word "Put in Park" and "Stop Safely Now", and the speedometer stops working, all kinds of warning lights start flashing on and off on the instrument panel, the heater goes on and off on it's own, then the instrument panel goes black, speedometer shows zero and car goes into shutdown mode. I was put in risk while driving without a speedometer and other vehicles near me were put into risk; when I pull over and stop the vehicle it strands me and I need a tow. This has happened randomly many times; I took it to FORD for repair, they didn't know how to fix the problem, my car was at FORD for 6 weeks! and I was without a car all that time, now 3 months later it's doing the same thing! I have videos of it happening along with the pictures I'm posting here, it is very scary when it's happening while driving and it's scary being stranded in unsafe places having to wait for a tow. This issue is Unresolved and DANGEROUS, I need FORD to get more involved.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643456February 18, 2025
ENGINE
The contact owned a 2016 Ford C-Max. The contact stated that while coming to a stop in a parking lot attempting to obtain mail from a mailbox; the vehicle independently accelerated and it was unknown what gear the vehicle was stationed in. In addition, it was unknown if the brake pedal was depressed or the gear the vehicle was in at the time of the failure. The vehicle had struck and knocked 3 mailboxes down and crashed into the front passenger side corner panel of a Mail Van coming to a stop as it was revving. The vehicle traveled 26 feet from its original stationed position. The vehicle was deemed a total loss. Both front wheels were severely bent outwards after the crash. The air bags did not deploy. The mail delivery employee sought medical attention for cuts and bruises. The contact did not seek medical attention or sustained any injuries. A police report was filed. The vehicle was towed to a tow lot by AAA where it was later taken by the insurance provider for further investigation. The local dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 44,530.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11638212January 24, 2025
STEERING
The contact owns a 2016 Ford C-Max Energi. The contact stated that while operating the vehicle, the message "Service Power Steering" was displayed, and the steering wheel suddenly became difficult to turn in either direction. The vehicle was taken to the local dealer who diagnosed that the steering rack was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer has not yet contacted. The failure mileage was 37,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11636375January 16, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM
Ford 2015 CMax Energi with 41,000 miles. I was driving on a 2 Lane Highway coming to a stoplight and had to press the brakes firmly to avoid an accident at which time my 2015 CMax Energi abruptly stopped w a growling noise,. The dashboard lit up like Christmas. I observed The ABS system/ABS module failure/malfunctioned lights. 2015 C Max Energi was available for inspection when I brought it to the dealership and verified it was ABS Module that had malfunctioned. I was told by the dealership for my safety and others not to drive the car. Sawgrass Ford retained my car for repairs. Sawgrass Ford as well as family and friends stated that my safety and the safety of others were at risk because of the obvious reliability of brake failure. Brake failure could lead to death to me and anyone else on the roads/highway. The problem has been reproduced and confirmed by the dealer@ Sawgrass Ford Sunrise Florida. The vehicle and the component has been inspected by the dealership because it was repaired once the part , which took about 2 1/2 months due to parts being backorder from Ford Corporation. Ford has MANY previous ABS MODULE recalls on several of their MODELS, but the CMax Energi isn’t due to it not being a popular car. I’ve researched through the Internet and forums and found that this is a common problem for the CMax Energi. I retained the damaged parts and have them enclosed w photo of damaged parts and the box that contained the new parts. Additionally, when the brakes were applied the car lurch and jerked, and additionally, there was the “smelling of electrical burning “ Bright red warning lights. AAA was called an immediately was towed to the dealership around mid November. Dealership got in touch with me November 23 and ordered the part FV672C219. At that time I was told that the part would not be available and it was on backorder. Ford corporation 800-392-3673 and confirmed b/o
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634947January 8, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2016 Ford C-Max. The contact stated that while driving at an undisclosed speed, she heard an abnormal sound emanating from the engine compartment, prompting her to discontinue driving the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission would need to be replaced. The vehicle was not repaired. The contact stated that the transmission had previously been replaced 3 years prior. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 49,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628031November 30, 2024
STEERING
Got a “Power steering assist fault” message on the screen. It was very hard to steer the wheel. The case on the wheel was turning around it. Managed to drive 3 more miles to the dealership. A lot of other ford models have same issues, even under 50.000 miles. And many of the are in recall program, but not 2013 ford c-max. Can’t afford 3.400$ price for fixing it at the dealership. I’m a second owner, bought it for 5.000 , 3 years ago. At least it didn’t stuck completely, and I didn’t Die
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617872October 3, 2024
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:THERMAL MANAGEMENT:AIR HANDLING/FILTRATION
The contact owns a 2014 Ford C-MAX. The contact stated while driving at approximately 20 MPH with all four windows closed, there was a strong abnormal odor coming from the rear of the vehicle. The contact then opened all the windows allowing the odor to release, and the abnormal odor was not as potent. The contact later inspected the vehicle and discovered that the original Volvo battery could be emitting a toxic substance that was entering the vehicle; the battery was original equipment. The contact sustained dizziness and difficulty breathing. Medical attention was not sought. This occurred on several different occasions. No warning light was illuminated. The vehicle was drivable and was taken to the place of residence. A dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 131,500.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11616983September 28, 2024
ELECTRICAL SYSTEM
My Stereo/Navigation console went out, just went black and stopped working. I bought it to my local garage and they said it was a costly repair and that there is a recall/service bulletin on it and that i should take it to a Ford Dealer. I did and they acknowledged the issue but said my VIN wasn't covered, but it was a known issue with C-Max of this year. So I didnt have the car services. A few months later, (2 weeks ago) my battery died and could not be jumped, so I had it towed to my Ford Dealer. He informed me that the potential cause of the battery damage was a short in the Console/Radio/Nav/Screen system. I agreed to go forward with the costly repair... They have so far not been able to resolve the issues. This morning I called Ford and explained the issue. They said since there is not a Recall associated with my VIN, there was nothing they could do. I asked them to look up the "issue" not the VIN and they acknowledged that there are issues with 2013 C-Max Energi models associated with the console. I asked for a bulletin number and was given 202363. I believe the recall is associated with the Ford Parts and so my VIN number may not be registered or something to that effect. I'm not sure how to look up the number they provided. While I dont think that not having a Radio or Nav system is a safety issue. The fact that it has caused the car to completely shut down and standing us is an issue. Again, Ford is aware that this type of issue exists, for this model, for this manufacturing year. They say they will only cover the repair if your agency tells them to, UGH Thank you, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614265September 12, 2024
AIR BAGS
Other vehicle impacted our car driver side at front fender/front door joint, continued rearward to rear fender. Airbags deployed, EXCEPT for driver side curtain airbag. Driver injured (fractured left ribs, left shin laceration, right hand laceration/burn, multiple bruised on arms, legs, thighs, left back upper shoulder area).
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11608735August 15, 2024
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2015 Ford C-Max. The contact stated while driving at an undisclosed speed, the contact noticed a failure with the transmission. The contact stated that the vehicle would downshift with the transmission warning light illuminated. The vehicle was towed to the dealer where the vehicle was diagnosed as a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604691July 26, 2024
POWER TRAIN
The contact owns a 2017 Ford C-MAX Hybrid. The contact stated that the vehicle failed to shift as intended and made an abnormal humming sound while driving. There was no warning light illuminated. The vehicle was taken to the dealer, where the transmission was replaced; however, the failure recurred. The contact stated while while driving at various speeds, and while coming to a complete stop, the vehicle made an abnormal humming sound. The vehicle was taken back to the dealer, where it was diagnosed that the transmission needed to be replaced; however, the vehicle was out of warranty. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604390July 24, 2024
STEERING
Steering wheel became loose. Within a week I took it into a Ford dealer who confirmed this was a serious safety concern. They worked on the problem a day later. Steering wheel bolt was damaged and would not retain torque. The steering wheel bolt was replaced by dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603572July 20, 2024
VEHICLE SPEED CONTROL
The wrench 🔧 light came on in my car. and when I put it in drive the car took off without me putting my foot on the gas. and it was like I had no control over the gas pedal. I tried hitting the brakes and it was still wanting to accelerate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11602481July 15, 2024
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Recall Number18S24 My car had 3 recalls so I contacted the Legacy Ford dealer in McDonough on [XXX] and made an appointment on [XXX]. When we brought the car, dealer didn't fix the recall above saying they didn't have parts even though we made an appointment over 2 months before. They told us they will let us know when they gets the parts, but it's been over 2 weeks and they don't contact us or respond any of our email. And since we brought our car to dealer, the car stop charging from charging cord. They said they didn't do anything about that and if we want diagnostic, they will charge for $150. I just wanted to fix all of the recall so I bought the car but feel like I just brought it to break my car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford C-Max