Ford Bronco Sport Complaints (2022)

347 consumer complaints on file.

#11700758November 21, 2025
FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING
The contact owns a 2022 Ford Bronco Sport. The contact stated that on every occasion while entering the vehicle, there was a fuel odor coming through the vents. The check engine warning light illuminated briefly during one occasion. The vehicle was taken to the same dealer twice and was diagnosed with a cracked coolant pump. The dealer determined that the coolant pump and the purge valve needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was then taken to an independent mechanic, where it was diagnosed and determined that there was fluid leaking nearby the catalytic converter; however, the mechanic was unable to take the catalytic converter apart. The mechanic also determined that the fuel injectors, the exhaust clamps and gaskets, and Oxygen sensors needed to be replaced, and the turbo charger required coolant and oil feed lines replacements. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700506November 20, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue and confirmed that the part for the recall repair was not yet available. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700429November 19, 2025
FUEL/PROPULSION SYSTEM
There has been a recall on this issue for 4 months with no options to have it fixed. The recall clearly states that a fire may start under your hood due to the issue, which seems like an issue that should be addressed asap.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700337November 19, 2025
BACK OVER PREVENTION: WARNINGS
At approximately 7:00 p.m., it was already dark, and I relied on my vehicle’s rear parking-aid sensor to assist me while backing out of my driveway. However, the rear collision/parking-aid sensor did not activate and provided no audible or visual warnings. Because the sensor failed to operate, I continued reversing and unintentionally collided with a vehicle parked across the street. The malfunctioning sensor is still installed on the vehicle and is available for inspection upon request. The absence of any warning put my safety and the safety of others at risk, as I had no indication that another vehicle was behind me. There were no warning lamps, messages, or symptoms before the incident, and the failure was first noticed when the expected alert did not occur. After the accident, I contacted a Ford dealership and confirmed that the sensor had not activated at the time of the incident. I also verified afterward, in daylight conditions, that the sensor does work normally and provides warnings when objects are behind the vehicle. The issue has not yet been reproduced or inspected in person by a dealer or an independent service center, and the manufacturer has not examined the component. My insurance company has been notified of the collision.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11699146November 13, 2025
POWER TRAIN
All of a sudden, when I would shift the gear to neutral or reverse the car would only drive forward. While there are other recalls related to this issue for other models, there isn’t a recall for this 2022 model. The ford dealership said it needs a new transmission and that would cost around $10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698649November 10, 2025
STRUCTURE:BODY
The firewall on the passenger side was not sealed correctly causing water to enter behind the glove box affecting the blower motor and causing water to enter the vehicle. Causing mold under the carpet. The leak was confirmed at the Ford dealership
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697604November 5, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer and two other dealers were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696303October 29, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694027October 17, 2025
UNKNOWN OR OTHER
Car shutters and makes a lot of noise in low gears and speed. Car still has issues after repairs. Local shop unable to make final repairs due to tools needed... Ford dealer will not cover due to mileage even with TSB- 25-2351
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693134October 13, 2025
SERVICE BRAKES, SEAT BELTS, POWER TRAIN
Along with the current unable to be fixed PCM recall, the customer service satisfaction program regarding the drivers side buckle replacement and the replacement of high-pressure fuel injectors that I was told they will only replace if there is an issue because it is not considered a recall. I have had multiple other recalls that were done and several issues that weren't related to recalls. In the first year the bushings were replaced to ease the loud noise when backing up. At 36,0000 miles I had no heat. The water pump failed and was fixed under powertrain warranty. At 41000 miles (just over warranty) the AC stopped working. The condenser failed and was my responsibility to pay. Ford did work out a deal with me on that repair due to all of the other issues I had previously. Currently, my drivers side back seatbelt does not work, the car shudders when driving and recently my forward collision indicator goes off for no reason. I have not reached out to have these items checked yet as I have spent far to much time dealing with Ford. I bought this car to feel safe and confident on the road and I have never felt that. The lack of compassion from Ford for all the money wasted in missed work and repairs because they cannot produce a quality vehicle is abhorrent.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692726October 11, 2025
SEAT BELTS
They sent me 2 papers about recalls and refused to fix it. Whatsoever, they tell me the fuel injection has to go out so they would fix it before even though they know it's bad. The second is a seat belt that click sometimes so basically they won't fix that either until it breaks completely. So what they're saying is basically the car can one be set on fire and 2 when I'm in a car crash, and I go through the window and If it fails, then they'll fix the problems.Is my understanding of it even though they're admitting there's a recall and they're refusing.To fix ithen, they said.Then when you've been at the software to fix the feeling injection problem.So why they selling cars?They don't have the software to fix the car.So I want something done about it.[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691511October 5, 2025
UNKNOWN OR OTHER
I own a 2022 Ford Bronco Sport (VIN: [XXX] ) that experienced a premature and unsafe transmission failure at about 75,000 miles. The issue began earlier with jerking and hesitation after stops and worsened until the vehicle displayed “Transmission Not in Park” and would not start. This created a dangerous situation at intersections and parking areas. Sioux City Ford diagnosed the issue and replaced the valve body under partial goodwill in July 2025, but the problem persisted. My service advisor said the new valve needed to “relearn” after 700 miles, but symptoms continued and the vehicle eventually became undriveable. I contacted Ford multiple times and was assigned case numbers, but received no resolution. The transmission was later confirmed failed by an independent certified shop, which replaced it at my expense ($7,711.96) along with towing ($246.10) and rental costs ($511.63). The defective parts remain available for inspection. This is a 2022 vehicle with less than 80,000 miles, and a complete transmission failure at this mileage is unreasonable and unsafe. Many other Bronco Sport owners have reported similar failures, jerking, and “Transmission Not in Park” errors linked to Ford’s 8F35 transmission. Ford has also issued Recall 24V-267000 and TSB 22B38 for related issues. This failure is not isolated and poses a significant safety concern for drivers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690883October 1, 2025
ELECTRICAL SYSTEM, ENGINE
I went to start my car it did not start but repeatedly kept trying to start itself over and over the car locked up completely i couldn't push the brake or anything it wouldn't stop it disappeared from my app..the car cranked itself repeatedly until it caught fire and electrical smoke was rolling i had to call the fire department i was parked at a dayhab for special needs had to run and have them to remove all of the special needs people in wheelchairs and or with other adaptive equipment had to run into another office building and tell them to remove their vehicles i had a serious worry that this could have hurt or even killed people they at the ford dealer that has had my car 21 days said it's the starter no way the starter just went nuts for no reason we had to call the fire department and everything they replaced the battery which my understanding has recall 24s24 which says causes glitches either someone is blaming a starter for something other than that
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11690821October 1, 2025
FUEL SYSTEM, GASOLINE, SUSPENSION:REAR:SHOCK ABSORBER
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The contact called the local dealer several times but was informed that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact had taken the vehicle to the same dealer for an oil change and was advised that the rear shock absorbers were leaking and needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690217September 28, 2025
ENGINE, FUEL/PROPULSION SYSTEM
As you may know, my Ford Bronco 2022 is under NHTSA Recall 25V467 as of July 2025. October is approaching, and so far, Ford Motor Company has not found any remedy for this problem, which can not only cause a spontaneous engine fire, but can also cause the death of those inside the vehicle or a serious accident if it occurs while driving. My vehicle is for daily use, and I have to transport my son to school every day, risking his life and mine, with the uncertainty of the vehicle catching fire. I ask that you consider requiring Ford Motor Company to collect these vehicles or exchange them for others of the same value that are not at risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689606September 25, 2025
FUEL/PROPULSION SYSTEM
My car has a recall since 07/16 and manufacture has not resolved the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689358September 24, 2025
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential systemic issue: I purchased the 2022 Ford Bronco Sport on 06Aug2025 which is still within its warranty period. During the test drive I identified the Pre-Collision Assist with Automatic Emergency Braking (AEB) wasn't operable. The dealership stated yes that model does have it and that it is not working. All safety settings were verified on and that it should be functioning but isn't. The dealership troubleshot but couldn't identify the issue. The dealership then contacted the Ford maintenance headquarters twice and received responses to the effect of "Where looking into it" with no path forward or timeline to correct the issue. Important considerations and information: 1. This is an important safety feature that people assume is working if turned on. This is no alarm or error code showing that it has malfunctioned. 2. While driving the Pre-Collision Assist with Automatic Emergency Braking (AEB) alarms went on twice at different times. There was no vehicle in front of me, and it didn't attempt to brake. If it did auto-brake this could've caused someone to rear end me. 3. I was given loaner Ford Bronco sport, and the same safety feature and others didn't work in that one either. This leads me to think this is a systemic malfunction and not a one-off. 4. All other safety features work 5. Ford Headquarters customer service opened case# CXH-XXX. Phone: [XXX] ext. 79202. Case owner is [XXX] 6. There are two versions of Ford Co-pilot 360 which most customers don't know of. One has dynamic cruise control, and the other doesn't. It's assumed by the customer that it is equipped with dynamic cruise control. This isn't clearly stated to the customer. This assumption could be a potential safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688038September 18, 2025
ENGINE
I am filing this complaint regarding a recall affecting my 2022 Ford Bronco Sport. I received a recall notice concerning the possibility of the vehicle catching fire. Despite numerous attempts to resolve the issue, Ford continues to ignore the warnings and say "we are working on fixing the issue." I feel unsafe and will not drive this vehicle until there is a resolution. Ford has taking months/years to fix this issue with no resolution in sight.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687408September 15, 2025
FUEL SYSTEM, GASOLINE, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The contact stated that while turning and depressing the accelerator pedal, the vehicle was slow to respond. There was a lag before the vehicle accelerated. There were no warning lights illuminated. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was taken to another local dealer, Fairway Ford (1350 E Yorba Linda Blvd, Placentia, CA 92870); where it was diagnosed and determined that an unknown part needed to be cleaned. The vehicle was repaired, but the failure recurred. The contact called the same local dealer, who confirmed that parts were not yet available. The manufacturer was called, but the phone call was disconnected several times. The approximate failure mileage was 36,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686636September 11, 2025
POWER TRAIN
My 2022 Ford Bronco Sport started making grinding noises when I would back up at an angle earlier this summer. I made an appointment and took the car to the dealership. They took it apart and determined it was the transaxle. The tech said this was a known problem, but not a recall. Luckily, I was within the 36-month warranty. However, due to trouble getting parts, the dealership has had my car for seven weeks now. The parts arrived, but they said they didn't have the right tool because this was a "fairly extensive rebuild." This vehicle has just over 28,000 miles on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco Sport