Ford Bronco Sport Complaints (2022)

347 consumer complaints on file.

#11716831February 9, 2026
FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: OTHER
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE). The contact stated that while driving around the neighborhood at slow speeds, the "Forward Collision Warning" system failed to function as intended. The contact stated that the alarm sounded while there were vehicles parked on the street. Occasionally, the vehicle experienced phantom braking. The contact stated that on a separate occasion, while driving on the freeway at an undisclosed speed, the "Forward Collision Warning" alarm sounded, even though no vehicles were nearby. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was not made aware of the issue. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716583February 8, 2026
ENGINE, POWER TRAIN, FUEL/PROPULSION SYSTEM
On 12/22/2025, my fiancé and I purchased a 2022 Ford Bronco Sport from LaFontaine Ford in Lansing, MI. During the initial purchase, we were not aware of any recalls or vehicle defects with the Bronco Sport. Roughly one month later, the check engine light came on, and after a thorough vehicle inspection, we were notified that there was a recall on the vehicle in regards to bad fuel injector(s), and that we needed to bring the vehicle back to the dealership for a computer update. After dropping the vehicle off at the dealership, we were notified that the engine was blown due to a cylinder misfire as a result of a bad fuel injector. We were also advised that the dealership had already completed the computer update prior to our purchase and cleared out the codes (critical misfire). The negligence of the dealership put my fiancé in extreme danger with selling us a vehicle with a critical fault that could cause a vehicle fire! The problem still has not been remedied as Ford is asking up to pay $3,483.00 for a new engine with them covering $4,457.00. I believe all of this should be covered under the recall and/or powertrain warranty since this issue has been well documented with Ford Bronco's prior to us purchasing the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715766February 5, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); and the vehicle was taken to the dealer, where an interim recall repair was performed. The contact expressed safety concerns because the final remedy was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715072February 2, 2026
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM, FUEL SYSTEM, GASOLINE
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714996February 2, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer and provided with paperwork that the recall repair was completed; however, the part for the recall repair was not yet available, and the VIN indicated that the recall was still open. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714603January 30, 2026
ELECTRICAL SYSTEM, POWER TRAIN, UNKNOWN OR OTHER
The car sputters when fuel is added but will drive. Went to get it checked out. Ford said it was spark plugs and a canister purge valve stuck. Got it looked at for a second opinion and they said the plugs were fine and the note saying the canister purge valve was stuck, but the canister purge valve was operating fine. Second opinion said it was throwing a transmission fault code. Possibly solenoid somewhere or an issue with the PCM, TCM or BCM. Then the car started shifting really hard, getting stuck in gears and shutting off. I had to get it towed to my house. I’m thinking there’s a bad PCM, TCM or BCM in this model and it just hasn’t been mentioned yet. Historically, Ford says it’s the spark plugs often and other issues and take several times to fix the issue. Last time it has a shut off problem, they tried two different things before replacing a solenoid somewhere and it lasted for a while up until now. Seems like they can’t really determine what’s wrong with it even after paying for the professional diagnostic fee
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712939January 23, 2026
AIR BAGS
I was driving to work in my 2022 Ford Bronco Sport when traffic ahead of me stopped suddenly. I was able to come to a complete stop. The vehicle behind me did not see the stopped traffic until the last second and rear-ended my vehicle at an estimated speed of approximately 50 mph. The impact was severe enough that my vehicle was pushed forward into the car in front of me, resulting in a multi-vehicle collision. Despite the severity of the impact, none of my airbags deployed. My vehicle sustained significant damage and was declared a total loss. I sustained serious injuries in this crash and continue to experience long-term, life-altering effects. Given the force of the collision and the extent of the damage, I am concerned about why the airbag system did not deploy and whether there may be a defect in the airbag or crash sensor system. I am submitting this complaint so the incident can be reviewed and investigated to determine whether this presents a broader safety issue.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11711596January 17, 2026
SEATS
I was driving the car and had been noticing an aroma, that I couldn't identify all morning. I happened to look over to the passenger side of the car and smoke was coming from the front of the seat. It was just about to catch fire. The seat heater was on and I turned it off. I poured water from a water bottle on the burned spot, that is about the size of your hand, and it sizzled until it cooled down. I contacted my dealer and sent them a photo. They had never heard of this occurring on any vehicle with heated seats ever happening before.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710716January 13, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2022 Ford Bronco Sport. While driving approximately 50 MPH, the contact received an alert indicating that the engine was overheating, with the check engine warning light illuminated. The contact pulled over and became aware that the coolant reservoir was empty. Upon opening the hood, there was white smoke coming from the engine, with a strong coolant odor coming from the vehicle. After adding coolant, the vehicle restarted but only drove a short distance before the coolant leaked out. The vehicle was driven to the residence, where a mobile mechanic inspected the vehicle and determined that it was not repairable and that the engine had cracked from overheating due to the loss of coolant. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710445January 12, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact stated that there were strong exhaust fumes inside the cabin of the vehicle while idling and while driving the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, where the contact was informed that no exhaust fumes were detected. The vehicle was not diagnosed or repaired. Additionally, the contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710414January 12, 2026
POWER TRAIN
At a little over 75,000 miles, I had a warning light come on that basically said there was a problem shifting between 7th & 8th gear and it put my car into safe mode. After getting it to a dealership, I'm told it needs a new transmission and was quoted $10,000. That's incredible excessive for a 3 year old car and reading through many online forums, I'm not the only one this has happened to with this car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709858January 9, 2026
UNKNOWN OR OTHER
Transmission is going out. Costly repair $13,000 Seems to be a known issue but no recall? Let’s do better for your customers
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708784January 5, 2026
STEERING:STEERING WHEEL /HANDLE BAR:HAND HEATER/COOLER
The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the contact turned on the heated steering wheel feature, and 30 seconds later, the steering wheel cover began to catch on fire with a blue flame; the contact discovered smoke coming from the steering wheel cover. The contact disengaged the heated steering wheel feature, where the flame self-extinguished. No warning lights were illuminated. The contact discontinued the usage of the heated steering wheel feature in order to avoid a large fire. A fire department report was not filed. A police report was not filed. The vehicle was not taken to a dealer; however, a dealer was contacted and made aware of the failure and informed that the vehicle caught on fire to resolve the failure with the vehicle's insurance. The vehicle was not repaired, but the contact was advised to buy a new steering wheel. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11705981December 18, 2025
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
The car's OBD (on board diagnostic) is not functional. This means that if a check engine light comes on it's impossible for the mechanic to know why. This means the car can never complete a state inspection and more seriously if there's an electrical problem, could result in a fire. I took the car to a Ford dealership and they verbally told me that lots of Ford cars are having this problem and that it is a manufacturing problem, not a specific problem only with my car. They want anywhere from $1600 - $4000 to repair/reprogram the OBD. They told me that they've done this "repair" for many customers and it's a manufacturing problem. In my opinion this should be a recall, not a repair customers have to pay for, most importantly because it could be dangerous bc mechanics can't access the car info if the check engine light comes on, and also the car can never be inspected which is not the fault of the car owner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703637December 8, 2025
SERVICE BRAKES
Brake booster failed. Lost brake assist while driving. Car became unsafe to drive immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703414December 6, 2025
POWER TRAIN, ELECTRICAL SYSTEM
I am reporting a premature transmission failure on my 2022 Ford Bronco at approximately 85,000 miles. The vehicle required a full transmission replacement after experiencing internal transmission failure described by a Ford service manager as “something came apart inside the transmission.” The dealership quoted $13,000 for transmission replacement. Independent transmission specialists quoted approximately half that amount, indicating the dealership pricing is inflated. A major drivetrain failure at this mileage is abnormal and suggests a manufacturing defect. This issue renders the vehicle unsafe and unreliable and occurred far earlier than the expected life of a transmission. I am concerned this represents a systemic defect in Ford Bronco transmissions and request this complaint be documented and investigated.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703132December 4, 2025
ENGINE
Recurring Safety Defect: Powertrain Cooling System Failure causing Engine Overheating, Coolant Intrusion, and Loss of Motive Power. The vehicle has experienced three catastrophic cooling system failures within a 9-month period, posing a crash and fire risk. Incident 1 (February 2025): Water pump failure caused significant coolant loss. Diagnosed and repaired by authorized dealer under warranty. Incident 2 (June 2025): Vehicle leaked coolant and emitted visible smoke and burning odors from the exhaust. Dealer diagnosed internal turbocharger failure resulting in coolant intrusion into the engine and exhaust system. The catalytic converter was damaged by coolant burn-off and required replacement. This failure kept the vehicle out of service for 38 days. Incident 3 (November 2025): The vehicle engine overheated again while driving, triggering the "Fail-Safe" cooling mode. This resulted in a sudden reduction of motive power (limp mode), creating a collision hazard at highway speeds. The Check Engine light illuminated. Dealer diagnosis confirmed codes P1285 (Cylinder Head Overtemperature) and P05A1 (Active Grille Shutter failure). The manufacturer's dealer has confirmed the current failure but refuses to acknowledge it as part of the recurring powertrain thermal defect. The safety risk involves sudden deceleration in traffic due to overheating protection mode and potential fire risk from repeated coolant leaks onto hot engine components. The vehicle is currently at the dealer and available for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702698December 3, 2025
POWER TRAIN
Transmission failed, Ford diagnosed it as needing the torque converter replaced, however, after this was fixed at a transmission shop, the problem persisted and that mechanic said the transmission needs to be rebuilt. My safety was out at risk when my vehicle stalled at an intersection and would not accelerate. Also, on two occasions, when the vehicle was put into reverse, it jerked forward and did not go backwards. Luckily nothing was hit in front of my vehicle, although it could have due to being in a parking spot when theirs happened. Ford confirmed an issue on 11/3/25 and another independent mechanic replaced the converter, but stayed the transmission needs to be rebuilt after that did not correct the problem. He states that the torque converter would not cause the reverse issues. Initially, no warning lamps came on, but now the wrench light and check engine light are on. Ford app gave two errors, one on 11/13/25: Powertrain malfunction/reduced power What Is Happening? The transmission control module has detected a concern when trying to shift to 8th gear. A failsafe logic disables 7th gear for the remainder of this key cycle. What Should I Do? Have your vehicle checked by an authorized dealer as soon as possible And one on 11/21/25 Powertrain Malfunction/Reduced Power: What Is Happening? The powertrain control system has detected one of the transmission clutches did not apply within the expected time as expected. Some transmission gears may not being available resulting in delayed or harsh shifts into another gear. Additional alerts that may provide additional information may accompany this alert. What Should I Do? Have your vehicle checked by an authorized dealer as soon as possible. Vehicle already had Powertrain issues last year when transaxle assembly was replaced and there was an issue with the exhaust, which ended up falling off the engine after Ford worked on it. Also, had to replace vacuum pump the year before that.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702399December 2, 2025
UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: BLIND SPOT DETECTION
Dash Panel Display blanked out while driving in the morning and was dark out. It happened at least 4 times during a 45min drive into work. Could not see the speed I was going or any gauges which I don't think any of the Safety stuff was working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700760November 21, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco Sport