Dodge Grand Caravan Complaints (2000)

443 consumer complaints on file.

#10184635March 9, 2007
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
2000 DODGE GRAND CARAVAN SPORT WITH THE 3.3L ENGINE HAS LOST ITS SERPENTINE BELT IN RAIN. THIS RESULTS IN IMMEDIATE LOSS OF POWER STEERING AND LEADS TO SERIOUS OVERHEATING. THIS IS A KNOWN PROBLEM THAT HAS BEEN EXPERIENCED BY MANY OWNERS FOR MANY YEARS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10183236February 22, 2007
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
I WAS DRIVING DOWN 422 AWAY FROM 76. I WAS JUST ABOUT TO TURN OFF ON TO TROOPER ROAD IN NORRISTOWN WHEN I HEARD A CLICKING NOISE. I THEN TURNED THE RADIO OFF AND IT WAS PRETTY LOUD. IT GOT LOUDER THE MORE I PUSHED ONTO THE GAS PEDAL, AND STOPPED WHEN I TOOK MY FOOT OFF. IT WAS SLIGHTLY UPHILL FOR A FEW HUNDRED FEET AND I KNEW IF I JUST MADE IT TO THE TOP AND HOPED FOR 2 GREEN LIGHTS I MAY BE SAFE. I STARTED GOING UP AND MADE IT TO THE SECOND GREEN LIGHT (THANK GOD) BUT MY ENGINE JUST CUT OFF AND I LOST POWER STEERING AND BREAKS. I HAD TO FORCE MY CAR TO TURN AND ALMOST DIDN'T MAKE THE TURN IN TIME. I THEN HAD TO COAST 1/4 MILE TO GET OFF THE ROAD TO PULL INTO A PARKING LOT WHERE MY CAR SAT UNTIL IT WAS TOWED. THIS WAS ALL IN THE MIDDLE OF A SNOW STORM, WHERE I WAS LATER PLOWED IN AND HAD TO DIG MY WAY OUT OF 3 FEET OF SNOW TO GET IT TOWED. IT WENT TO THE SHOP WHERE I WAS TOLD THE TIMING CHAIN BROKE. LUCKILY NOTHING BAD HAPPENED OUT OF THE WHOLE THING, BUT IT COULD HAVE BEEN MUCH WORSE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10182175February 10, 2007
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
I HAVE REPLACED THE SERPENTINE BELT AND PULLEY/TENSIONER ASSEMBLY ON MY 2000 GRAND CARAVAN 4 TIMES IN THE LAST 3 YEARS. THE DESIGN IS FLAWED AND MUST BE FIXED BY DODGE. I HAVE USED BOTH DODGE REPLACEMENT AND NAPA REPLACEMENT PARTS TO NO AVAIL. I CAN NOT TRUST THIS VEHICLE FOR A LONG DISTANCE WHICH IS WHAT I BOUGHT A VAN FOR. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10181067January 30, 2007
POWER TRAIN:AUTOMATIC TRANSMISSION
WHILE DRIVING ON A MAJOR INTERSTATE THE TRANSMISSION IN MY 2000 DODGE GRAND CARAVAN LOCKED UP WITH ONLY 87403 MILES REGISTERED. AFTER HAVING IT TOWED TO A REPUTABLE TRANSMISSION COMPANY I FOUND THAT THE ENTIRE TRANSMISSION WAS DAMAGED FOR NO APPARENT REASON AND HAD TO BE REPLACED. WHILE REPAIRS WERE BEING MADE I INVESTIGATED TO SEE IF THERE WAS A RECALL FOR THIS VEHICLE FOR TRANSMISSION PROBLEMS AND FOUND THAT MANY INDIVIDUALS HAVE HAD PROBLEMS WITH THIS PARTICULAR VEHICLE BUT THERE HAVE BEEN NO RECALLS TO THIS DATE. ALL PARTS INCLUDING GEARS WERE REPLACED AT MY EXPENSE OF $2221.58. IT IS MY UNDERSTANDING THAT THE TRANSMISSIONS IN THIS VEHICLE SHOULD NOT HAVE PROBLEMS AND ESPECIALLY SHOULD NOT HAVE TO BE REPLACED UNTIL AT LEAST OVER 100,000 MILES. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10178630January 13, 2007
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
SERPENTINE BELT IS THROWN WHEN VAN IS DRIVEN IN WET CONDITIONS. CAUSES LOSS OF POWER STEERING AND COOLING SYSTEMS. VAN IS VERY DIFFICULT TO CONTROL AND MUST BE TOWED TO REPAIR FACILITY. THROWN 3 TIMES IN LAST SIX MONTHS WITH 2 OCCURRENCES BEING IN PAST 3 WEEKS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10178593January 12, 2007
ENGINE AND ENGINE COOLING:ENGINE
SERPENTINE BELT CAME OFF WHILE DRIVING DURING RAIN. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10177468January 2, 2007
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
2000 DODGE GRAND CARAVAN - SERPENTINE BELT SLIPS OFF IN THE RAIN CAUSING STEERING AND ELECTRICAL SYSTEM TO QUIT FUNCTIONING. THIS IS VERY VERY DANGEROUS AND HAPPENED LAST TIME IN A VAN FULL OF KIDS. CHRYSLER HAS "FIXED" THIS PROBLEM OVER 7 TIMES IN THE LAST 2 YEARS. TODAY IS THE 8TH TIME IT IS GETTING FIXED YET AGAIN. BRAZIL RECALLED ALL THEIR VANS BETWEEN 1996 AND 2000 FOR THIS VERY PROBLEM - WHY ISN'T THE CAR BEING RECALLED IN THE US? *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10174583November 28, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH UNDER NORMAL ROAD CONDITIONS, THE VEHICLE SUDDENLY ACCELERATED TO 95 MPH. AFTER BEING TAKEN TO THE SERVICE DEALER, IT WAS DETERMINED THAT THE CRUISE CONTROL CABLE BENT, AND CAUSED THE SUDDEN ACCELERATION. THE CONSUMER TRIED USING THE BRAKES WITH NO SUCCESS, THE CONSUMER FINALLY TURNED THE IGNITION OFF AND WAS ABLE TO COAST TO THE EMERGENCY LANE. THE CONSUMER USED THE EMERGENCY BRAKE TO STOP THE VEHICLE AND SHIFTING THE TRANSMISSIONS IN TO LOW. UPDATED 12/28/06. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10174614November 28, 2006
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
SERPENTINE BELT SLIPS OFF TENSIONER PULLEY IN WET CONDITIONS. TOTAL POWER STEERING FAILURE AND VEHICLE IS EXTREMELY DIFFICULT TO CONTROL. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10174419November 27, 2006
STRUCTURE:BODY
WATER LEAKS ONTO THE PASSENGER SIDE FLOOR FROM THE HVAC DURING AC USE AND IN HEAVY RAIN. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10173674November 16, 2006
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
SERPENTINE BELT HAS COME OFF MY 2000 DODGE GRAND CARAVAN 4 TIMES. FIRST TIME, I HIT A POCKET OF WATER ON A SMALL HIGHWAY IN A CONSTRUCTION AREA. DROVE VEHICLE TO A SAFER LOCATION, LEFT MY WIFE AND 3 KIDS ON THE SIDE OF THE ROAD AT NIGHT WHILE I WALKED A MILE HOME IN THE RAIN TO GET MY FORD RANGER TO LOAD ALL 5 OF US IN TO GET HOME SAFELY. HAD IT TOWED TO A REPAIR SHOP WHO REPLACED THE BELT TENSIONER AND BELT. SECOND TIME, ABOUT A YEAR LATER, MY WIFE HIT WATER WHICH ALSO KNOCKED THE BELT OFF AND STRANDED HER AND MY 3 CHILDREN 15 MILES FROM HOME. BROTHER IN LAW WAS ABLE TO COME AND SPENT AN HOUR OF GUT WRENCHING LABOR TO PUT THE BELT BACK ON. THIRD TIME, A MONTH LATER IT CAME OFF AGAIN SHREDDING THE BELT AND LEAVING MY WIFE STRANDED BY HERSELF AFTER DROPPING MY KIDS OFF FOR SCHOOL. I HAD IT TOWED TO A REPUTABLE REPAIR SHOP WHO SAID IT NEEDED ANOTHER BELT TENSIONER AND ASSURED ME THE NAPA PRODUCT WOULD PERFORM BETTER THAN THE PREVIOUS ONE. HE TRIED TO SEE IF A KIT WAS AVAILABLE FOR OUR LARGE 6 CYLINDER ENGINE BUT COULD NOT FIND ONE. FOURTH TIME, ONE MONTH LATER AS MY WIFE WAS DRIVING 2 OF MY CHILDREN TO SCHOOL IN THE RAIN, THE BELT CAME OFF AGAIN BUT THIS TIME SHE DIDN'T HIT ANY WATER. HAD IT TOWED BACK TO THE REPAIR SHOP. THEY CHECKED ALL COMPONETS CONNECTED TO THE SERPENTINE BELT AND TRIED FOR 30 MINUTES TO DUPLICATE THE PROBLEM BY POURING WATER OVER THE BELT, ETC. WITH NO SUCCESS. OWNER SAYS HE DOESN'T KNOW WHAT IS CAUSING THIS PROBLEM EVEN THOUGH HE IS AWARE THAT THIS IS A COMMON PROBLEM FOR DODGE VANS. QUESTION: IF THIS IS SUCH A WIDE SPREAD PROBLEM AS SHOWN BY ALL THE COMPLAINTS FOR THE SAME PROBLEM ON THIS WEBSITE WHY HAS THERE NOT BEEN A RECALL TO CORRECT WHATEVER IS CAUSING THIS PROBLEM? ANSWER: BECAUSE IT WILL COST DODGE/ CHRYSLER TOO MUCH MONEY. SOLUTION: UNLESS YOU CAN ONLY DRIVE A DODGE VAN ON WARM SUNNY DAYS DON'T BOTHER BUYING A DODGE VAN. ESPECIALLY IF YOU VALUE YOUR FAMILY'S SAFETY. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10173167November 10, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
LOST BRAKES ON 2000 DODGE CARAVAN WITH 58K MILES. ALL THE BRAKE LINES WERE BADLY CORRODED AT THE JUNCTURE OF THE FLEX TUBING AND THE SOLID TUBING. IT LOOKS LIKE DISSIMILAR METAL TO ME. THE BRAKE LINES SHOULD NOT RUST OUT IN THAT SHORT OF A TIME AND LOW MILEAGE ALL LINES WERE REPLACED. NOT BY A DODGE DEALER. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10171468October 20, 2006
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
THIS IS THE THIRD TIME IN A YEAR THAT THE SERPENTINE BELT HAS SHREDDED AND/OR FELL OFF. I REPLACED THE TENSIONER THE SECOND TIME. IT LOOKS AS IF THE PULLEYS ARE NOT ALIGNED WITH THE TENSIONER SO THE BELT EVENTUALLY RIDES OFF THE EDGE OF THE TENSIONER. ALL TIMES IT WAS NOT RAINING OR SNOW LIKE SOME OF THE OTHER COMPLAINTS I HAVE RESEARCHED ON THE WEB. DODGE GRAND CARAVAN WITH 107,000 MILES. 3.8L WITH A/C. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10171218October 18, 2006
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
I HAVE A 2000 DODGE GRAND CARAVAN, 3.0 L ENGINE. I HAVE BEEN EXPERIENCING THE BELT SLIPPING OFF THE TENSIONER DURING WET WEATHER. THE FIRST TIME WE HIT A SMALL (1 - 2" DEEP) PUDDLE OF WATER WHEN TURNING A CORNER. WE IMMEDIATELY LOST POWER STEERING. I CONTACTED MY LOCAL, INDEPENDENT MECHANIC, WHO TOLD ME THIS IS AN ON-GOING PROBLEM WITH 1996 - 2000 CARAVANS. HE EVEN WENT SO FAR AS TO PRINT OUT A SERVICE BULLETIN DETAILING THE PROBLEM. THE SECOND TIME IT HAPPENED WAS LESS THAN TWO WEEKS LATER, HIT A SMALL PUDDLE OF WATER ON A RAINY DAY, LOST POWER STEERING AGAIN. LUCKILY, I WAS GOING SLOWLY BOTH TIMES, BUT WORRY ABOUT A SERIOUS SITUATION OF GOING AT HIGHWAY SPEEDS. I HAVE CONTACTED THE DEALERSHIP, WHO ACKNOWLEDGE THAT THEY HAVE HEARD OF SUCH A PROBLEM, BUT THERE IS NO SERVICE ANNOUNCEMENT FROM DODGE/CHRYSLER, AND NO "FIX" - ONLY TO REPLACE BELTS AND TENSIONERS. I THEN RESEARCHED THROUGH INTERNET, FOUND SITUATION AS STATED BY FIRST (INDEPENDENT) MECHANIC LISTED ON MULTIPLE WEBSITES BY MANY OWNERS. CHRYSLER IS AVOIDING ACKNOWLEDGING THE PROBLEM, YET 2 AFTERMARKET PARTS COMPANIES HAVE DEVELOPED PARTS TO FIX THIS ISSUE. BOTH GATES AND GOODYEAR ACKNOWLEDGE A SAFETY ISSUE, SO I BELIEVE CHRYSLER/DODGE SHOULD HAVE TO ENSURE THE SAFETY OF THEIR VEHICLES. THESE ARE MINI-VANS. SOLD PRIMARILY TO FAMILIES. SO, THE TYPICAL SCENARIO IS A MOTHER WITH KIDS STRANDED IN THE RAIN. I NOW FEAR DRIVING MY VAN IN THE RAIN, AND AM PETRIFIED OF DRIVING HIGHWAY SPEEDS IN THE RAIN. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168610September 19, 2006
SUSPENSION:FRONT:MACPHERSON STRUT
DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, A CLUNKING NOISE WAS HEARD COMING FROM THE LEFT FRONT OF THE VEHICLE. IT WAS DRIVEN TO THE DEALER WHO DETERMINED THE LEFT FRONT STRUT TOWER WAS CORRODED AND NEEDED TO BE REPLACED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10166531August 25, 2006
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
SERPENTINE BELT HAS COME OFF DURING HIGHWAY SPEEDS TWICE ON THIS VEHICLE. APPEARS THE TENSIONER PULLEY DESIGN IS NOT ROBUST. SECOND TIME THE ENGINE OVERHEATED DESTROYING 2 CYLINDERS AND THE HEAD STRANDING MY WIFE AND 5 BOYS ON THE INTERSTATE. THE RESULTING FAILURE MODES COULD HAVE VERY SERIOUS CONSEQUENCES - RECOMMEND IMPROVEMENT TO THE DESIGN BY RECALL. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10166195August 22, 2006
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
WAS DRIVING ALONG HIGHWAY WHEN VEHICLE ENGINE TOTALLY SHUT OFF. PULLED VEHICLE OFF ROADWAY. STRONG SMELL OF GASOLINE PRESENT. UPON CHECKING VEHICLE, GASOLINE WAS DRIPPING FROM UNDERCARRIAGE ON RIGHT SIDE. WHEN TOW TRUCK ARRIVED; MECHANIC CHECKED VEHICLE AND SAID THAT GAS LINE HAD CAME OFF. NEXT DAY WHEN RESPONDING TO ALARM WITH FIRE DEPARTMENT - IT WAS FOR A GAS LEAK; THERE WAS ALSO A 2000 DODGE GRAND CARAVAN WITH IDENTICAL PROBLEM. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10165134August 10, 2006
SUSPENSION:FRONT:MACPHERSON STRUT, STRUCTURE
THE PROBLEM DESCRIBED HEREIN IS ABOUT MY 2000 DODGE GRAND CARAVAN. OVER THE PAST YEAR I NOTICED SOME RUSTING AT THE LEFT TOP STRUT TOWER. I QUESTIONED IT AT THE TIME, BUT WAS TOLD IT WAS NOT SERIOUS. DURING THE PAST WEEK I WAS REPLACING THE AIR FILTER AND NOTICED THAT NOW OVER ONE HALF OF THE STRUT AREA WAS HEAVILY RUSTED AND HAD LARGE CRACKS ON ONE SIDE. I TOOK IT TO MY LOCAL CHRYSLER DEALER TO SEE IF THE RUST THROUGH WARRANTY WOULD APPLY, OR IF IT WAS A COMMON PROBLEM. THE MANAGER LOOKED AT IT, LOOKED UP MY WARRANTY AND SAID EVEN THOUGH THE TIME PERIOD IS GOOD UNTIL 12/2006 THE MILEAGE OF 69700 WAS OVER BY 9750 MILES. HE WOULD NOT ADMIT THAT THIS IS A COMMON PROBLEM AND SAID IT COULD BE VERY DANGEROUS, TAKE IT TO A BODY SHOP FOR REPAIR. I SINCE HAVE INVESTIGATED THIS COMPLAINT ON NHTSA, AND FOUND THAT THERE ARE MANY IDENTICAL PROBLEMS, AND CHRYSLER HAS EVEN DEVELOPED A CORROSION KIT FOR THIS PROBLEM. SEE ODI ID: 10147504 CAN YOU ADVICE ME OF MY NEXT STEP. WE ARE NOT DRIVING THE VAN UNTIL IT IS REPAIRED. THIS IS A GARAGED VEHICLE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10165805August 9, 2006
AIR BAGS
2000 DODGE GRAND CARAVAN CLOCKSPRING FAILED. MECHANIC NEVER TOLD CONSUMER OF RECALL. *KB THE CLOCKSPRING IN THE CONSUMER VEHICLE FAILED AND THE CONSUMER HAD IT REPLACED. SEVERAL MONTHS LATER THE CONSUMER READ ABOUT A CLOCKSPRING RECALL ON THE CHRYSLER WEBSITE. THE CONSUMER WAS NEVER NOTIFIED OF ANY RECALL AND HAS BEEN AT THE SAME ADDRESS SINCE PURCHASING THE VEHICLE. THE CONSUMER SUBMITTED THE INVOICE FOR REIMBURSEMENT PER THE MANUFACTURER BUT ONLY RECEIVED PARTIAL REIMBURSEMENT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10163392July 25, 2006
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
DT*: THE CONTACT STATED, THE AIR BAG WARNING LIGHT FAILED TO ILLUMINATE DURING AN EMISSIONS TEST PERFORMED ON 7/21/06. THE LIGHT WORKED UNTIL 6/23/2006, WHEN THE SERVICE DEALER PERFORMED RECALL #04V480000. THE SERVICE DEALER INFORMED THE CONTACT THE WARNING LIGHT WAS NOT PART OF THE RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Dodge Grand Caravan