Chevrolet Spark Complaints

529 consumer complaints on file.

#11700935November 22, 2025
POWER TRAIN, FUEL/PROPULSION SYSTEM
Vehicle: 2015 Chevrolet Spark, odometer <79,000 miles Component that failed: Continuously Variable Transmission (CVT) – pulley damage causing complete loss of propulsion.What happened: While driving, the vehicle suddenly lost all motive power with no ability to accelerate. The transmission would not engage in any gear and the car became inoperable in traffic. This is the exact failure described in GM Special Coverage Bulletin N192271110 (pulley damage in 2014–2015 Spark CVT). Safety risk: Complete and unexpected loss of propulsion created an immediate safety hazard. The vehicle could not accelerate from a stop or maintain speed, placing my 15-year-old son and other motorists at risk of rear-end collision or stranding in active traffic lanes.Dealer confirmation: RK Chevrolet in Virginia Beach, VA has inspected the vehicle and confirmed the failure matches N192271110 – full transmission replacement required (quote $6,637.19). Vehicle remains at the dealership and is available for inspection.Warning lamps/symptoms: Check-engine light and reduced-power message appeared at time of failure. No prior warnings before the sudden loss of power event. Failure occurred approximately October 2025 – only four months after GM’s 10-year/120,000-mile Special Coverage N192271110 expired on 06/11/2025.The failed transmission is still in the vehicle and available for inspection upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700241November 19, 2025
ENGINE
This report concerns a known CVT defect and subsequent TCM failure that left the vehicle unsafe and inoperable. The vehicle suffered internal CVT failure consistent with GM Special Coverage N192271110. After the first transmission failed in May 2024 (and the second time October 5 2025), the TCM failed again shortly after the second failure—consistent with GM Preliminary Information Bulletin PIP5525A. Critical Safety Details: Both failures occurred while driving on highways with heavy traffic, where speed limits were 75 mph. On each occasion, the vehicle lost power and became unable to accelerate safely, presenting a serious safety risk to me and other drivers. GM is refusing coverage despite widely documented cases and their own bulletins describing this exact failure chain.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697462November 4, 2025
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The contact owns a 2020 Chevrolet Spark. The contact stated that while driving at 15 MPH and depressing the accelerator pedal, the vehicle lost motive power. The contact exited the vehicle, unlatched the hood, and wiggled the battery cable, and the vehicle worked as intended. No warning light was illuminated. An independent mechanic and the dealer were contacted. The vehicle was taken to the dealer and was inspected, and the contact was informed that the transmission needed to be replaced. The vehicle was then taken to an independent mechanic, where it was diagnosed, and it was determined that the battery cables needed to be replaced. The transmission was replaced; however, the battery was not replaced. The manufacturer was not notified of the failure. The approximate failure mileage was 243,656.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696452October 29, 2025
AIR BAGS
The contact was a passenger in a 2020 Chevrolet Spark. The contact stated that, while the owner was driving at an undisclosed speed through an intersection, another vehicle failed to yield for a red light. As a result, the other vehicle collided with the passenger side front quarter panel of the vehicle. The air bags did deploy, which the contact held responsible for the injuries she sustained. No warning lights were illuminated. The vehicle was towed to a storage facility and deemed a total loss by the owner's insurance provider. A police report was filed, and injuries were reported. Both the driver and the contact were transported to an area hospital by EMT. The driver was treated for whiplash, back pain, and shortness of breath. The contact was treated for an injured sternum, injured left knee, injured left ankle, injured right hip, broken right hand middle finger, and whiplash. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11695334October 23, 2025
ENGINE
Vehicle began slipping out of gear between 1st & 2nd, then started losing power at 74,760 miles. Extended service coverage has been issued for model for CVT transmission pulley system, however only covers 10 years or 100,000 miles, whichever comes first. Mine apparently timed out in February, so they are trying to make me get a new transmission which basically totals out the car I spent a fortune on to buy & in repairs at under 75,000 miles. This is unacceptable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695146October 22, 2025
POWER TRAIN
My 2015 Chevy Spark has had repeated transmission failures related to GM Special Coverage N192271110. The first failure happened in May 2024, I was driving on 1-25 when the transmission went out and I lost all speed and my car was in the shop for five months before I finally got it back in October 2024. Unfortunately, on October 5, 2025, the transmission failed again. I was driving on I-76 speed limit of 75 MPH when my car transmission went out and I lost speed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684117August 30, 2025
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
transmission issues
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679404August 8, 2025
ELECTRICAL SYSTEM, EQUIPMENT
The contact owns a 2015 Chevrolet Spark. The contact received notification of NHTSA Campaign Number: 16V257000 (Equipment, Electrical Systems). The vehicle was taken to the dealer, and the contact was informed that the radio software needed to be updated. The dealer informed the contact that to complete the software upgrade, the dealer had to reprogram the radio USB portion to complete the upgrade. The vehicle was repaired. The contact stated that while driving at an undisclosed speed, the radio image was inoperable. The contact stated that the radio image appeared blank. Additionally, the Bluetooth feature failed to function properly. The dealer was contacted. The vehicle was not diagnosed or repaired. The contact was concerned about the failure of the vehicle and that it was related to the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 129,173.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676086July 25, 2025
ELECTRICAL SYSTEM, POWER TRAIN
When the car reaches a certain speed (50 mph plus) it jerks and jolts. The engine light is on and a P-code is present. Each mechanic says something different.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673154July 13, 2025
POWER TRAIN
transmission recall issued to me on fed. 2020 that extended transmission warranty due to hard shifts. only thing done was a transmission flush.on 07/21/2023. now the car has 83,000 miles on it and is gotten worse over time. the flush just kept the same problem. no power after hitting gas. At Maher Chevy St. Petersburg Florida, they said there was nothing they could do. problem has been throughout vehicles life. And they made us believe they were changing the transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670713July 2, 2025
ENGINE
Transmission issue. During heavy traffic at stop lights car wouldn't shift into drive to move forward. Was stuck in the middle of the road with a passenger. Engine light came on but it's not an engine problem. Car was smoking under the hood. I burned my hand when popping the hood. When the car cooled the engine light went out and car would shift gears and it's drivable again. This has happened 3 times. Mechanic pulled up at P0700 Code on computer. It's the CVT transmission but not sure which part. I can't get the car to the dealership to inspect transmission. It won't drive that far.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11667246June 16, 2025
UNKNOWN OR OTHER
I got the recall done but it still shows not done on the NHTSA website
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663106May 27, 2025
ENGINE, VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
The GM bulletin N19227110 indicates that they are aware of over 10% of Chevrolet Spark models from the years 2014-2015 experiencing transmission problems. Although this bulletin expired last year, it is important to note that they do not provide coverage for vehicles purchased used with fewer than 120,000 miles. This situation poses a significant danger, as the transmission may potentially be contaminated with dirt and debris, leading to unexpected jerking or complete failure, and in some cases, vehicles have caught fire. Furthermore, unless the vehicle is taken to a GM service center, the issue may remain undetected. According to my research, this problem is similar to the one that Nissan faced with their CVT transmissions, which were subject to a recall for the same reason.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660265May 11, 2025
UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM
I am the owner of a 2016 Spark EV, and the driver was my family member. The vehicle was charged and had a remaining driving range of 51 miles when the vehicle suddenly shut down on a major city road without any prior warning or symptoms of a problem. The vehicle did not restart immediately, and other drivers behind had to push the vehicle to the side of the road. The driver experienced the shutdown of the vehicle while driving again on another day. Since the sudden shutdown of the propulsion power while driving happened without any prior warning light, message, or symptom, the incident could put the safety of the driver and others at risk, especially if the shutdown happened at a higher speed on a highway. Failure of a specific component or system has not been identified, but the vehicle is available for inspection upon request. The service department of a Chevrolet dealer initially provided an estimated diagnostic fee of $170, but the service department raised the diagnostic fee by double upon check-in when the vehicle was brought in on the scheduled appointment. I canceled the appointment in frustration.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660237May 11, 2025
AIR BAGS
On 5-3-2025 I rolled my vehicle end over end at least 6 times at a high speed. One of my vehicle safty options was "Advanced SRS airbags" During the crash my vehicles side airbags deployed but my drivers steering wheel air bag did not. As a result of them not deploying I smashed my face into the steering wheel and windshield. I suffered a shattered nose, broken jaw, broken hand and a concussion. It was my fault I crashed my car but if my airbags had gone off I feel like my injuries would be far less severe if not non existent. I would have less medical bills and would still be able to work. My vehicle had no warning lights or indicators that the airbags needed service. My insurance company did make not of the airbags failure to deploy and are doing a thorough investigation of them
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11657335April 28, 2025
AIR BAGS
The contact owned a 2019 Chevrolet Spark. The contact stated that while driving at approximately 50 MPH, the contact had lost consciousness. The contact stated that an emergency services vehicle was behind her and had observed her go through an intersection, crash through and guardrail, and roll down an embankment. The contact was removed from the vehicle, still unconscious, and transported to the hospital by ambulance. The contact stated that she had bruising on her sternum, ribs, and arms. The contact stated she was not advised about why she had lost consciousness. The contact stated that the vehicle had been towed to an impound lot and her insurance provider had written the vehicle off as a total loss. The contact had been advised by a police officer that her driver's side air bags had not deployed. The contact was not sure that a police report had been issued. The manufacturer was not informed of the failure. The failure mileage was approximately 130,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11656556April 24, 2025
ENGINE, STEERING, POWER TRAIN
I lease a car through Carvana, and they informed me that the car was safe and properly inspected. In the first 2 weeks, I took the Chevrolet to a certified dealership for a routine inspection. I was informed that the vehicle has severe mechanical and electrical issues. The engine needs to be replaced entirely because they found shredded metal pieces in the engine oil. The car also requires an entirely new steering and alignment system. It also needs a new heating system. The total cost is 7700, which is close to the current value of the car. I have informed the caravan and Silver Rock third-party insurance. They failed to inspect the vehicle and follow DOT safety requirements. This car should not be available for purchase. This car requires several weeks of repair, which puts me at risk of driving. I could have easily ended up in a deadly accident because of the condition of the vehicle. This company has committed gross negligence while falsely promoting a car as safe. During this initial review of the car, Carvan informed us that it has never been in an accident, has not been resold with parts, and does not show wear and tear on the vehicle. I have documentation outlining the extended warranty coverage, purchase agreement, and diagnosis and analysis done by the Chevrolet dealership. This company is committing consumer fraud and putting its customers at risk. This company is still charging monthly for a car that is legally unsafe to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656467April 24, 2025
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
I lease a car through carvana, and they informed me that the car was safe and properly inspected. In the first 2 weeks, I took the chevrolet to a certified dealership for a routine inspection. I was informed that the vehicle has severe mechanical and electrical issues. The enginee needs to be completed replace they found shred metal pieces in the engine oil. The car also needs a completely new steering and alignment system. It also needs a new heating system. The total cost is 7500, which is close to the current value of the car. I have informed carvan and silver rock third party insurance. They failed to inspect the vehicle and follow DOT safety requirements. This car shouldn't be available or purchased. This car requires several weeks of repair and puts me at risk for driving. I could have easily ended in deadly accident because of the condition of the vehicle. This company has committed gross deglience and promotes a car that is unsafe with false advertising and promises. Carvana is liability however they refuse to follow proper safety guidelines and take responsibility for the issue they created. I am paid for a vehicle I can't legally drive. There gross deglience put all customers at risk; if they were honest about there inspection this issue would never occur. Please help me expose this corrupt company. We the people deserve better. This company needs to be held accountable with an FCC and DOT audit.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655775April 21, 2025
ENGINE
The contact owns a 2020 Chevrolet Spark. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle was able to restart. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 38,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650007March 23, 2025
STRUCTURE:BODY, POWER TRAIN
Ever since I bought the vehicle in 2021, I have had problems with the car jerking and air conditioning problems, mostly during the colder months. I took the car in multiple times on different occasions throughout the years. They would "fix" the problems with the transmission, then a month or two down the line the issues would come back. This last time, the car started stalling on the and turned off completely. The air conditioner never worked because of the transmission as well.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Spark