Chevrolet HHR Complaints (2007)

726 consumer complaints on file.

#11463595May 6, 2022
STEERING
The power steering intermittently (but quite regularly) goes out. The "power steering" warning also comes up on the display panel on the dash. If vehicle is restarted, the power steering seems to resolve itself again but only temporarily. This problem is becoming much more frequent. This is a safety issue because without the power steering in working order, the steering wheel becomes difficult to turn and this happens not only on the road but also on the highway as well when the vehicle is going 70 miles per hour. We have not had the vehicle serviced or looked at for this issue. It has been ongoing for several months but seems to be getting worse/more frequent.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443504December 12, 2021
STEERING, ELECTRICAL SYSTEM
While driving the vehicle approximately 45mph, the power steering light came on the dash. While driving straight was not an issue, attempting to pull off the road was difficult. I checked owners manual which told me to take it to a dealer. This in itself was bothersome. I opened the hood and called my mechanic, who told me to check fuses. I replaced the fuse and the vehicle was fine for about 4 weeks, but once again driving 30-35 mph, the light came on the dashboard. I have saved both replaced fuses, I’m wondering after reading other reports whether the fuses are even blown? Either way, this is not a safe situation to be driving any speed without power steering. Mine is a 2007 Chevrolet HHR with approximately 163 k miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11439481November 5, 2021
FUEL/PROPULSION SYSTEM
FUEL LINE ROTTED THRU SPRAYING ON EXHAUST LEFT REAR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11434156September 24, 2021
SERVICE BRAKES
when I went to push on the brake, the brake pedal went to the floor... I had No Brakes? This could have been a terrible accident had I been going faster.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11432041September 7, 2021
FUEL/PROPULSION SYSTEM
My 2007 HHR (I also hve a 2008 with the same issue as this) was being configured with replacement front seats and after completion the mechanic/installer informed me that there was a strong gas leak on the driver's side. Upon looking at the car a very noticeable puddle of gas was on the ground. I had the car moved to my home and it is currently unable to use due to the gas leak. This is ridiculous. Everything I have read points to Chevy cheaping out and not using non-corroding metal lines or nylon and the proximity of the heat shield which traps the moisture and corrodes the fuel lines. This REALLY needs to be recalled at Chevy's expense as it is a manufacturer's error. I have no idea if a prior situation had been addressed by the previous owner (commercial computer repair shop).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11428679August 11, 2021
FUEL SYSTEM, GASOLINE
The contact owns a 2007 Chevrolet HHR. The contact stated that there was an abnormal fuel odor coming from the vehicle while parked in the garage. Upon inspection, the contact stated that the fuel line on the passenger’s side was leaking. The contact called the dealer and the manufacturer and was informed that the vehicle was not under recall. The vehicle had yet to be repaired. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426627July 27, 2021
STEERING
The contact owns a 2007 Chevrolet HHR. The contact stated while reversing out of the driveway, the power steering warning light illuminated, and the vehicle lost power steering functionality. The contact restarted the vehicle however, the power steering functionality did not return. They pulled the vehicle back into the driveway using manual steering and excessive force. The contact reached out to the local dealer to schedule an inspection however, the inspection was not performed due to a scheduling issue. The vehicle was not yet diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422926June 30, 2021
STEERING
The contact owns a 2007 Chevrolet HHR. The contact stated while driving at various speeds, the steering wheel was firm and difficult to turn. The power steering warning light was illuminated and flashing. The vehicle was taken to an independent mechanic where the system was reset. The local dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11418401May 24, 2021
FUEL/PROPULSION SYSTEM
Fuel line corrosion. fuel is leaking from fuel lines under the car in the rear. it appears all HHR are experiencing similar issues why is the 2007 model year excluded from the recall if built the same as other model years. the first occurrence was February 2019 a portion of the line was replaced and now again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11414881May 2, 2021
STEERING
THE POWER STEERING KEEPS GOING OUT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11406450April 5, 2021
FUEL/PROPULSION SYSTEM
THERE IS A RECALL FOR 2008-2009 HHRS FOR FUEL LINE CORROSION. I AM HAVING GAS PUDDLES AND DRIPS FROM LEAKING FUEL LINES NEAR THE LEFT REAR WHEEL WELL, NEAR THE EXHAUST PIPE AND MUFFLER. WHICH IS THE EXACT SAME ISSUE AS DESCRIBED IN THE 2008-2009 HHR RECALL. I HAVE TRIED SPEAKING WITH GMS CUSTOMER ASSISTANCE. ALL THEY DID WAS TELL ME OVER AND OVER AGAIN THAT MY HHR ISN'T INCLUDED IN THE RECALL. 🙄 I KNOW THIS...THAT'S THE PROBLEM. THE DEALERSHIP REFERRED ME TO CHEVY'S CUSTOMER ASSISTANCE...CUSTOMER ASSISTANCE KEPT PUSHING BACK THAT I NEEDED TO TALK TO THE DEALERSHIP'S CEM. NO ONE WANTS TO HELP WITH THIS SITUATION...JUST PUSHING ME TO TALK TO SOMEONE ELSE. SO THAT IS WHY I CAME HERE SO THAT SOMEONE WILL LISTEN TO THIS SAFETY CONCERN THAT THEY KNOW THEY HAVE BASED UPON FUEL LINE RECALLS FOR CERTAIN MODELS. I BELIEVE THEY NEED TO BROADEN THEIR RECALL TO INCLUDE OTHER HHRS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11406459April 5, 2021
AIR BAGS
I HAD AN AUTO ACCIDENT ON FEBRUARY 7, 2021. I LOST CONTROL ON AN ICY HIGHWAY AND FLIPPED MY CAR IN A DITCH FACING THE OPPOSITE DIRECTION. I HIT THE DRIVER'S SIDE IN THE DITCH HARD ENOUGH IT BOUNCED BACK ON ALL FOUR TIRES. MY JAW HIT THE STEERING WHEEL, MY LEFT SHOULDER WENT THROUGH THE DRIVERS WINDOW AND OF COURSE I NOW HAVE ONGOING BACK ISSUES AT THIS TIME. MY CONCERN IS THE AIRBAG NEVER DEPLOYED. I FIND THIS CONCERNING AS THE IMPACT WAS GREAT AND I HOT THE STEERING WHEEL WITH MY FACE.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11397052February 19, 2021
FUEL/PROPULSION SYSTEM
I NOTICE THAT THE TANK HAS BEEN LEAKING FUEL. THIS OCCURS WHEN I FILL UP THE TANK AND/OR THE FUEL SWISHES OR MOVES AROUND. THIS HAPPENS ON THE REAR LEFT TIRE. IT SEEMS TO GET ON THE EXHAUST OR HEAT UP AND SMELL EXCESSIVE FUEL. I NOTICED THIS WHEN I WOULD PARK FOR AT LEAST 20 MINS ON A FULL TANK. I AM A FUEL TANK ENGINEER AND SEE THIS AS A POOR DESIGN POSSIBLY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11384651December 23, 2020
FUEL/PROPULSION SYSTEM
FUEL LEAK IN FUEL SUPPLY LINES NEAR REAR DRIVERS SIDE TIRE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11377113November 30, 2020
STEERING
2007 CHEV HHR..LOST POWER STEERING. THANK GOODNESS ONLY 1 MILE FROM HOME. FORTUNATE NOT TO BE ON HIGHWAY. WHY NO RECALL FROM GM..IS SAME AUTO ON RECALL FOR IGNITION SWITCH..FIXED ON RECALL IN 2014
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11367021October 29, 2020
STEERING
ADD RANDOM SPEEDS 30-80 MPH THE ELECTRIC POWER STEERING PUMP WITH SHUT OFF, RESULTING IN NO POWER STEERING WITH NO WARNING OTHER THAN THE LITTLE CHIME BEEP AFTER IT SHUTS OFF. THE PUMP WAS REPLACED AT MY EXPENSE AND I WANT REIMBURSED BY DEALERSHIP. AT TIMES I WAS DOING OVER 70 MILES AN HOUR GOING AROUND CURVES AND TURNS AND IT WOULD SHUT OFF.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11365656October 21, 2020
POWER TRAIN, VEHICLE SPEED CONTROL
OUT OF NO WHERE, SPEED ODOMETER WENT TO FLASHING AND CAR WOULD NOT SPEED UP EVEN WHEN PUSHING THE GAS... HAD IT CHECKED AND WAS TOLD TO CHECK TO SEE IF THERE WAS A RECALL BECAUSE MECHANIC COULD NOT FIND ANYTHING WRONG WITH IT. IT STOPPED WORKING WHILE ON THE HIGHWAY, HAD TO TOW IT HOME BECAUSE WAS TOO SCARED TO TRY TO MAKE IT HOME. WHEN PUSHING THE GAS, YOU CAN FEEL IT LOSING POWER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11364751October 16, 2020
WHEELS
THE POWER STEERING LIGHT CAME ON AND THE CAR BECAME VERY DIFFICULT TO STEER AS I WAS DRIVING OUT OF A BUSINESS PARKING LOT. I PULLED TO THE SIDE AND TURNED OFF THE CAR. I RESTARTED THE CAR AND IT THE POWER STEERING LIGHT STAYED OFF AND THE POWER STEERING WORKED AGAIN. I CAUTIOUSLY DROVE HOME. THE CAR IS A 2007 CHEVROLET HHR WITH 153,000 MILES ON THE ODOMETER AND WE'VE OWNED THE VEHICLE SINCE IT WAS NEW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11343678August 6, 2020
FUEL/PROPULSION SYSTEM
FUEL LEAKED FROM THE REAR OF THE HHR AND POOLING ON THE FLOOR NEAR THE LEFT REAR WHEEL. THE HHR HAD BEEN PARKED IN A CLOSED GARAGE OVERNIGHT AND THE FUEL PUDDLE WAS FOUND IN THE MORNING. WHEN TAKEN TO A DEALERSHIP FOR REPAIR, THE SERVICE TECHNICIAN STATED THE FUEL LINE HAD RUSTED THROUGH. THE FUEL LINE HAS BEEN REPLACED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11342582July 31, 2020
FUEL/PROPULSION SYSTEM
FUEL LINE CORROSION AND LEAK NEAR DRIVER SIDE REAR TIRE. STARTED OUT AS FUEL VAPOR SMELL WHEN WALKING NEAR CAR. LATER DEVELOPED INTO FUEL LEAK UNDER CAR. VERY CONCERNING TO ME BECAUSE LEAK IS NEAR EXHAUST SYSTEM. EVENTUALLY HAD TO HAVE CAR TOWED (FOR SAFETY) TO REPAIR GARAGE WHERE I HAD TO PAY OVER $600 FOR ALL NEW FUEL LINES. DUE TO GM STRIKE IN 2019 AND RESULTING PARTS SHORTAGES, MY CAR WAS OUT OF SERVICE FOR 4 MONTHS. INTERNET SEARCH SHOWS THAT MANUFACTURER HAD ISOLATED THE FUEL LINES FROM THE EXHAUST COMPONENTS BY USING HIGH TEMPERATURE 'SLEEVE'; THIS SLEEVE APPARENTLY TRAPS WATER THAT CORRODES THE METAL FUEL LINES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet HHR