General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
THE VEHICLE EXPERIENCES AN INTERMITTENT COMPLETE LOSS OF REARVIEW VISIBILITY WHILE REVERSING, DISPLAYING A BLANK SCREEN AND A RED WARNING TRIANGLE. THIS is a severe safety hazard that violates FMVSS111. The dealership held the vehicle for more than three weeks due to extensive dashboard while wiring harness failures on the communication loop. Yet GM has failed to issue a safety recall.
No injuries · No fire · No crash
Reverse camera and infotainment system glitch, and doesn't work most of the time. This was known by the dealer which tried to repair it at least 3 occasions but problem still occur. Problem showed up after few months of purchase( bought brand new). This a safety concern since you cannot see if there's vehicle or people while reversing.
No injuries · No fire · No crash
Both front wheel drive shaft anti-click washers on my 2023 Bolt EV fractured at 18,269 miles. The failure caused a repeatable click/clunk from the front of the vehicle on torque application — accelerating from a full stop, from a slow roll under 5 mph, or accelerating out of a coast at about 20 mph. A Chevrolet dealer confirmed both anti-click washers were cracked (Repair Order 652900). The repair required removing both front half-shafts, replacing the washers (GM P/N 42754282) and drive shaft nuts (GM P/N 13208079), and reinstalling the axles. The noise was eliminated. This is a safety issue because GM has documented in writing that this exact failure can damage the ABS wheel speed sensor, which sits directly in-line with the washer on the outboard joint of the half shaft. GM TSB 22-NA-089 (Bolt EV) and TSB 19-NA-103 (Volt) both state the fractured washer causes "possible collateral damage to the ABS wheel speed sensor," that ABS, Traction Control, and StabiliTrak lamps may illuminate intermittently, and that those systems "may be deactivated/shut off for that ignition cycle," setting DTCs P215B and C0035-C0051. Loss of anti-lock braking and stability control is a direct safety hazard. My core concern is scope. GM acknowledged this defect in 2019 (Volt, MY2016-2019) and 2022 (Bolt EV, MY2017-2019), but capped the bulletins at model years that exclude my vehicle. My 2023 Bolt EV suffered the identical failure of the identical part, fixed by GM's identical specified procedure and part numbers. Other owners report the same failure on 2020, 2022, and 2023 Bolts. I was charged $737.34 as customer-pay. The dealer submitted a warranty claim and GM rejected it, stating a BEV has no applicable powertrain coverage for this component. I request NHTSA review whether this defect extends to later model year Bolt EV/EUV vehicles and whether a recall is warranted.
No injuries · No fire · No crash
known issue with " anti click washer on Bolt EV " and resulting damage to related components can cause loss of control acceleration, stopping and major damage and cost, no warning lights or TSB other than for previous gen but same design and same defect, inspected by dealer shows broken anti click washer and damage to other components https://gmauthority.com/blog/2022/07/heres-why-your-chevy-bolt-ev-may-have-a-clicking-sound/
No injuries · No fire · No crash
The vehicle suffers from severe, unresolvable electrical failures causing recurring loss of propulsion, shifting lockouts ("No Driving Conditions" / stuck in Park), complete exterior lighting failures, and loss of communication with the Restraints Control Module (RCM) and airbag impact sensors. The primary failure involves short circuits, open circuits, poor terminal contact, and thermal damage with melted, charred wiring and exposed copper in the main harness[cite: 6]. On May 25, 2026, OnStar telematics issued a critical red alert for the Regenerative Braking System[cite: 7]. All damaged components and diagnostic reports are available for inspection upon request[cite: 6, 7]. Safety risks include sudden loss of propulsion at highway speeds, total headlight and tail light loss during night driving, and potential non-deployment or malfunction of airbag restraint systems during a collision. The issues have been repeatedly reproduced and confirmed by an authorized dealership through 7 repair attempts between Sept 2024 and Apr 2025. Diagnostic steps included opening GM TAC Case 9-13634782861, consulting GM engineers, and testing 33 ground points. On Oct 28, 2024, the dealer and an insurance adjuster officially confirmed the failures are covered under GM warranty and unrelated to any accident[cite: 8]. Symptoms first appeared on Sept 10, 2024 (at 5,144 miles) with a "Waiting initialization to shift" message, blown Fuse 58, and loss of power to the ECM. Warning signs prior to subsequent failures included "Service Trans" warnings, "Reduced Propulsion" alerts, dim headlights, Check Engine Lights, SRS/Airbag warning lights, and total shifting lockouts after hitting road bumps. Despite replacing Fuse 58 (multiple times), Fuse 64, IP Fuse 7, the underhood fuse block, ECM connector terminals, headlamp assemblies, the RCM module, and multiple airbag impact sensors, the underlying electrical instability remains unresolved.
No injuries · No fire · No crash